三效汽车净化催化剂性能研究

以汽车尾气模拟装置中产生的气体作为模拟废气,对JFG型催化剂处理汽车排气中CO、HC和NO_x的三效性能进行了研究。结果表明,该催化剂具有低起燃温度,良好的三效性能和热稳定性。利用TPD-MS测定了催化剂表面氧数目及脱附性能。通过汽车发动机怠速试验和初步行车30000km,证明该催化剂具有较好的应用开发前景。     

资源型催化剂净化柴油机尾气

本文使用含有稀土金属和过渡金属元素以及只含有过渡金属元素的矿石制备了多种资源型催化剂,并在柴油机台架上进行筛选和活性评价.结果表明,含有稀土金属和过渡金属复合氧化物的ZC-1号催化剂和只含有过渡金属氧化物,但添加助催化剂的ZC-4号催化剂具有较好的温度特性、空速特性、热稳定性和抗积碳性能,其中ZC-1号催化剂的性能最优.对ZC-1号催化剂进行了700h的使用寿命考察,未见其活性降低。     

制备条件对低温NH_3-SCR脱硝催化剂Mn-Ce/TiO_2结构与性能的影响

采用溶胶凝胶法制备了Mn-Ce/TiO2催化剂,以NH3为还原剂,通过程序升温反应考察其选择性催化还原NO的催化性能.同时,着重探讨了焙烧温度、焙烧时间、活性物质负载量及Mn、Ce负载比例对催化剂结构和性能的影响,并用BET、XRD等对催化剂进行了表征.结果表明,活性组分负载量由0增至20%时,NO转化率随着负载量的增加而提高,当(Mn+Ce)质量分数为20%,催化剂活性最高,此后随着活性组分负载量的增加,NO转化率明显下降;Mn与Ce的负载比例为0.85∶0.15时,催化剂比表面积最大,为112.31m2·g-1;焙烧温度500℃时催化剂晶相均为TiO2锐钛矿型结构,焙烧温度升高至600℃,催化剂晶相为TiO2锐钛矿型和金红石型混合结构,且催化剂比表面积急剧减小;焙烧时间对催化剂晶相结构影响不大,焙烧时间为5h时,Mn-Ce/TiO2的脱硝性能最好.     

氮掺杂二氧化钛负载钒磷氧催化氧化NO的实验研究

以VPO为活性组分,N掺杂TiO 2为载体,采用浸渍法制备了VPO/TiN催化剂,基于单因素实验研究了其对NO的选择性催化氧化(SCO)性能以及抗硫抗水性能。研究表明:当P/V为1/5、N/Ti为1、活性组分负载量为10%、焙烧温度为350℃时,催化剂的SCO活性最好,NO氧化率达到61%;光致发光光谱(PL)表征显示N掺杂TiO 2在催化剂表面形成的氧空位可增强催化剂对O 2的吸附;VPO/TiN催化剂抗硫抗水性能较强,反应后的催化剂表面未发现硫酸根的特征峰,水蒸气主要通过与NO竞争吸附占据活性位点来抑制催化剂的SCO活性。     

地下水脱硝催化剂的制备及其性能研究

以Al2O3为载体制备了负载型催化剂,通过甲酸催化还原脱除地下水中硝酸盐对该催化剂进行了活性评价,并研究了催化剂制备条件对催化性能的影响,发现催化剂种类、配比及其含量不同,催化剂的催化性能也相应发生变化,其中4%Pd-1%Cu/Al2O3催化剂可以在45min内将100mg/L的NO3-被完全去除。     

含砷SCR脱硝催化剂再生处理实验研究

通过空气清灰、筛分、碱浸、酸洗、活性组分补充等方式对砷中毒的SCR脱硝催化剂进行再生处理。采用BET、XRD、XRF、ICP等检测方法对再生催化剂进行了表征,对再生后催化剂的脱硝性能进行测试并与新鲜催化剂对比。结果表明:再生催化剂的砷去除率可达99%,脱硝效率在150℃～450℃范围内与新鲜催化剂脱硝效率基本一致;中毒和再生均不改变催化剂的载体结构,经再生后其活性组分负载均匀。     

K、Ce掺杂LaMnO3四效催化性能研究

文章采用柠檬酸络合法制备了钙钛矿型催化剂,研究K、Ce部分掺杂取代LaMnO_3中的A、B位后对柴油车尾气净化催化剂四效催化性能的影响。并通过X射线衍射、扫描电子显微镜、傅里叶红外光谱以及活性评价实验,对催化剂的活性进行评价。结果显示,优选出的La_(0.5)K_(0.5)Mn_(0.7)Ce_(0.3)O_3四效催化性能最佳。分析表明,K和Ce成功掺入钙钛矿的晶格内;K的掺入有效改善了催化剂的团聚现象,使催化剂变得疏松多孔,增大了与反应烟气的接触,进而提高了催化剂的催化活性,大大降低了碳烟的起燃温度;Ce部分取代La_(0.5)K_(0.5)MnO_3中的Mn,进一步改善催化剂的团聚现象的同时,使催化剂中存在CeO_2,有利于提高CO的去除率。     

制备参数对Mn-Ce/TiO2催化剂脱硝性能的影响

以锐钛矿型TiO₂为载体,采用分步共混法制备了Mn-Ce/TiO₂催化剂,通过考察不同活性组分前驱体、焙烧温度以及活性组分负载量对催化剂样品脱硝性能的影响,以确定最佳制备参数;结合XRD（X射线衍射）、XPS（X射线光电子能谱分析）、BET比表积等表征手段研究制备参数对催化剂性能的影响.结果表明:无定型态MnO₂含量越多,越有利于提高催化剂的脱硝活性;催化剂样品表面原子浓度比Mn/Ti[或（Mn+Ce）/Ti]越高,催化剂表面有效活性组分越多,催化剂脱硝活性越好.以自制Mn盐（MX）为前驱体,在Mn-Ce活性组分负载量为16%时,经500℃焙烧的催化剂样品脱硝活性最高;反应空速为10000 h-1,反应温度为80℃时,其脱硝效率可达80%,150℃时脱硝效效率可达99%.      

用于乙醇水蒸气重整的负载型金属催化剂失活的研究进展

负载型金属催化剂的发展直接影响着乙醇水蒸气重整的研究,而造成负载型金属催化剂失活的原因有很多。重点论述了催化剂活性金属烧结和催化剂表面积碳的问题,并对目前所采用的解决办法进行阐述。同时对今后制备抗积碳性能强的负载型金属催化剂的研究方向进行展望。     

微波加热下苯的催化氧化性能研究

研究考察了微波加热与传统电炉加热两种不同加热方式下苯的催化氧化性能,同时考察了微波加热下铜锰质量比,铈掺杂量及焙烧温度变化对铜-锰-铈/分子筛催化剂催化氧化苯性能的影响,并对催化剂进行了SEM和XRD表征.结果表明,微波加热下苯的催化氧化性能优于电炉加热,微波的"局部热点"效应、偶极极化作用与稳定的床层反应温度保证了苯的高效催化氧化;铜∶锰∶铈质量比1∶1∶0.33和焙烧温度500℃下催化剂的活性最高,苯的起燃温度与完全燃烧温度分别为165℃和230℃.催化剂表征分析可知,铜、锰氧化物及铜锰尖晶石固溶物等活性相的存在保证了催化剂的高活性;稀土元素铈的掺杂促进了活性组分在催化剂表面的分散与规整化;高温焙烧可导致催化剂表面的烧结与活性组分的团聚,从而降低其催化氧化苯的活性.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...