Comparison of coagulation performance and floc properties of a novel zirconium-glycine complex coagulant with traditional coagulants

A new inorganic-organic hybrid material zirconium-glycine complex (ZGC) was firstly used as a coagulant in a coagulation process to treat Pearl River raw water. Its coagulation performance was compared with commonly used aluminum (Al) coagulants such as aluminum sulfate (Al₂(SO₄)₃) and polyaluminum chloride (PAC), in terms of water quality parameters and floc properties. ZGC coagulation achieved higher removal of turbidity (93.8 %) than other traditional coagulants. Charge neutralization was proven to act as a dominant mechanism during ZGC coagulation. The aggregated flocs with ZGC showed the fastest growth rate and good recovery ability compared with the other coagulants and achieved the largest floc size within 5 min. The ZGC coagulant can decrease the hydraulic retention time and increase removal efficiency.     

絮体性质对纳滤膜污染的影响

混凝过程产生的絮体会对后续膜过滤性能产生一定的影响。实验中利用激光粒度仪研究2种混凝剂(AlCl3和PAC)在不同投加量下的絮体性质,混凝出水(不经过沉淀)直接进入纳滤膜(NF270)装置进行过滤实验。研究表明,投加量低(<0.20 mmol/L)的情况下,混凝出水反而使纳滤通量衰减发生恶化,随着投加量的增加,纳滤膜通量衰减得到有效的减缓。直接过滤腐殖酸(HA)的膜通量衰减(J/J0)为0.65,投加量为0.50 mmol/L时,AlCl3和PAC 2种混凝剂产生的通量衰减(J/J0)分别为0.78和0.75。滤饼层阻力受到絮体尺寸的影响较大,絮体尺寸越大,形成的滤饼层透水性更好。通过污染模型分析,混凝出水的纳滤膜污染机理主要是滤饼层阻力。     

高效聚合氯化铝对超滤膜污染影响的中试研究

针对某水厂以超滤为核心的短流程水处理工艺,在通过聚氯乙烯(PVC)超滤膜之前选择不同投加量(5、10、15和20 mg/L)的高效聚合氯化铝(HPAC)对长江下游原水进行混凝处理。通过跨膜压差(TMP)增长趋势、CODMn的去除率以及混凝后的水质,可知HPAC的最优投加量为15 mg/L。在此投加量下,运用体积排阻色谱法分析原水、膜前水、膜后水中各相对分子质量有机物的变化,可以发现混凝去除有机物的效果要优于超滤截留的。继而将HPAC与另外4种常用混凝剂:硫酸铝(分析纯)、氯化铁(化学纯)、聚合氯化铝(PAC)、聚合硫酸铁进行对比,结果表明,在它们各自最优投加量下,HPAC能够更有效地减缓超滤膜TMP的增长率,从而降低膜污染。因此,认为HPAC是与PVC超滤合金膜契合效果最佳的混凝剂。     

Use of chemical coagulants to control fouling potential for wastewater membrane bioreactor processes.

Chemical coagulation with ferric chloride, alum, and an organic polymer were used to control the fouling potential of mixed liquors for submerged membrane bioreactor (MBR) processes in treating municipal wastewater. Their filterability was evaluated using a submerged hollow fiber ultrafiltration apparatus operated in constant permeate flux mode. The collected transmembrane pressures over filtration time were used to calculate the membrane fouling rates. The results showed that coagulation pretreatment can reduce fouling rates when MBRs were operated above the critical flux. Even though coagulation with the organic polymer formed larger mixed liquor suspended solids particles and had shorter time-to-filtration than those with ferric chloride and alum, the filterability for membrane filtration were similar, indicating that the membrane fouling in MBR systems was mainly controlled by the concentration of smaller colloidal particles.     

Comparison of hydrolysis/coagulation behavior of polymeric and monomeric iron coagulants in humic acid solution

Fluorescence quenching is commonly used to study the extent of metal binding to humic acid or fulvic acid. By studying this phenomenon, the hydrolysis and precipitation behaviors of polymeric and monomeric iron coagulants in the coagulation of humic acid were evaluated. Combined measurements of fluorescence intensity and dissolved organic carbon were performed to distinguish the hydrolysis and organic matter binding of polymeric and monomeric iron salts in coagulating high molecular weight organic compounds. Experimental results showed that ferric chloride had lower fluorescence quenching than polyferric sulfate (PFS), indicating more rapid hydrolysis of the monomeric ferric ion in the coagulation and dilution process. The less fluorescence quenching was caused by the lower residual concentration of Fe-humic acid complexes in the filtrate. There was no clear difference in adsorption ability and fluorescence quenching, which indicated that the physical and chemical properties of Fe(OH)3 flocs formed from PFS and FeCl3 coagulation were similar. From the pH study, we found that sludge formed from PFS coagulation was more stable than that from FeCl3 coagulation.     

聚合氯化铝铁的形态分布对微污染源水混凝效果的影响

针对微污染源水中浊度、叶绿素a等的强化去除问题,研究了碱化度、铝铁比和加碱方式等对聚合氯化铝铁形态分布的影响,并考察了形态分布与混凝除污效率和混凝沉淀出水中残铝浓度的关系.结果表明:在铁摩尔分数一定时,混凝剂中单体、中等聚合物和无定形凝胶含量与碱化度存在线性相关性,并推导出中等聚合物含量的计算公式;在碱化度一定时,混凝剂中单体、中等聚合物和无定形凝胶含量与铁摩尔分数也存在线性相关性;增加碱化度或降低铁摩尔分数,可以增加中等聚合物含量、降低单体含量,从而影响混凝除污效率和混凝沉淀后出水中残铝浓度.混凝实验结果表明,混凝过程中叶绿素a去除率和浊度去除率均与混凝剂中中等聚合物含量存在线性相关性,但两者相关系数不同.混凝沉淀后出水中残铝浓度与混凝剂中单体含量存在线性相关性.因此,预聚合的无机高分子混凝剂对提高混凝过程中的除浊、除藻效率,降低混凝沉淀后出水中残铝浓度具有重要的意义.     

地表水中隐孢子虫和贾第鞭毛虫微球的混凝去除

以向地表水中投加的隐孢子虫微球和贾第鞭毛虫微球为对象,研究通过对给水混凝工艺对其的去除效果进行比较,着重考察了不同混凝剂种类、投加量及水样pH值对去除效果的影响.结果表明,混凝工艺可较为有效地去除地表水中的两虫微球,去除率最高可达4 lg.相比常规的金属盐类混凝剂,高分子的PAC、PAFC混凝剂对两虫微球的混凝去除率更...     

混凝剂品种对混凝-超滤联合工艺膜污染的影响

本实验以工业化学合成聚合硫酸铁混凝剂和自制生物聚合硫酸铁为例,考察了铁系混凝剂品种对地表水浊度、TOC和UV254的去除效果,混凝剂品种对混凝-超滤联合工艺处理地表水过程中超滤膜污染的影响。混凝实验结果表明,在10 mg/L(以Fe3+计)最佳投加量下,两类混凝剂对浊度、TOC和UV254的去除率基本相同。超滤膜污染实验结果表明,生物聚合铁预处理水样通量衰减速度略大于化学聚合铁预处理水样;膜污染阻力分析结果显示,随着循环次数的增加,工业化学合成聚合铁预处理水样造成的不可逆污染阻力逐渐增加,而生物聚合铁预处理水样造成的不可逆污染阻力却略有下降;膜污染机理分析表明,2组过滤过程的膜污染类型基本相似,由最初的膜孔堵塞过渡到最终的滤饼层污染。SEM分析表明,生物聚合铁预处理水样的膜污染较为严重。     

制浆造纸废水生化出水的混凝处理研究

研究了硫酸铝和三氯化铁对制浆造纸废水生化出水的处理效果.研究发现,不调节原水pH值,硫酸铝投加量为600 mg/L或三氯化铁投加量为300mg/L时,混凝后废水的COD＜150 mg/L,色度＜50倍,出水均符合现阶段排放标准.混凝剂比较发现,在最佳反应条件下,2种混凝剂的处理效果相当,但硫酸铝混凝的成本低于三氯化铁....     

Coagulation and precipitation as post-treatment of anaerobically treated primary municipal wastewater.

The main objective of this study was to investigate the feasibility of coagulation as a post-treatment method of anaerobically treated primary municipal wastewater. Both mesophilic and ambient (20 degrees C) temperature conditions were investigated in a laboratory-scale upflow anaerobic sludge bed (UASB) reactor. In addition, optimization of the coagulant, both in terms of type and dose, was performed. Finally, phosphorus removal by means of aluminum and iron coagulation and phosphorus and ammonia nitrogen removal by means of struvite precipitation were studied. Anaerobic treatment of primary effluent at low hydraulic retention times (less than 15 hours) resulted in mean chemical oxygen demand (COD) removals ranging from 50 to 70%, while, based on the filtered treated effluent, the mean removals increased to 65 to 80%. Alum coagulation of the UASB effluent gave suspended solids removals ranging from approximately 35 to 65%. Turbidity removal reached up to 80%. Remaining COD values after coagulation and settling were below 100 mg/L, while remaining total organic carbon (TOC) levels were below 50 mg/L. Filterable COD levels were generally below 60 mg/L, while filterable TOC levels were below 40 mg/L. All coagulants tested, including prepolymerized aluminum and iron coagulants, demonstrated similar efficiency compared with alum for the removal of suspended solids, COD, and TOC. Regarding struvite precipitation, optimal conditions for phosphorus and nitrogen removal were pH 10 and molar ratio of magnesium: ammonia-nitrogen: phosphate-phosphorus close to the stoichiometric ratio (1:1:1). During struvite precipitation, removal of suspended solids reached 40%, while turbidity removal reached values up to 80%. The removal of COD was approximately 30 to 35%; yet, when removal of organic matter was based on the treated filterable COD, the removal increased to approximately 65%. In addition, nitrogen was removed by approximately 70%, while phosphorus removal ranged between approximately 30 and 45% on the basis of the initial phosphorus concentration. Finally, size fractionation of the organic matter (COD) showed that the various treatment methods were capable of removing different fractions of the organic matter.     

铁铝复配混凝剂处理低温低浊水

针对北京某水库水在冬季呈现低温低浊特性,以此为原水的某水厂在该期间常会出现出水余铝超标现象的问题,通过烧杯实验研究不同投药量下聚合氯化铝(PAC)以及它与三氯化铁(FeCl3)不同复配比形成混凝剂对冬季北京某水库水的处理效果。结果表明,复配药剂存在最佳的Fe/Al摩尔复配比为1/5,此时余铝、有机物去除效果较其他配比混凝剂高。在此配比下,当PAC投药量为0.03 mmol/L时,水中残余铝量取得最低值0.0063 mg/L。相同投药量复配药剂的浊度去除效果比单独使用PAC的浊度去除效果略弱。当投药量为0.06 mmol/L时,Fe/Al摩尔比为1/5的复配混凝剂,能使浊度降至0.4 NTU左右。此外,复配药剂的投药量小,投药范围更宽,易于实际投药操作;同时复配药剂还适于常温及偏中性水源水的处理。规模为5 m3/h中试实验也证明,采用铁铝复配混凝剂连续运行,可获得良好的浊度、余铝去除效果。     

微絮凝-直接过滤工艺用于东江流域典型印染废水回用的实验研究

以东莞地区某典型印染企业尾水为研究对象,针对东江流域饮用水源河流水质污染现状及纳污河流水质改善目标要求与企业对尾水回用的实际需求,进行了印染废水深度处理回用工艺的适用性研究.通过混凝烧杯实验,选用工业PACl、FeSO4、HPAC 3种药剂,对微絮凝-直接过滤集成工艺用于印染废水尾水深度处理后水质回用的可行性,进行了实...     

PAC与粘土矿物混凝去除颤藻及残余铝形态研究

研究了PAC与不同粒径的天然粘土矿物复合混凝去除给水中的颤藻。结果表明，两者复合除藻效果显著优于单加PAC。当PAC浓度为12 mg/L，矿物浓度为24 mg/L，粒径为160目时，除藻效果最好，浊度和叶绿素a去除率分别为98.2%和100%。两者复合后PAC形态含量都发生了变化，悬浮态铝含量相对增加，溶解态铝含量相对减少，总残余铝量减小。     

Optimization of circular plate separators with cross flow for removal of oil droplets and solid particles

A circular gravity-phase separator using coalescing medium with cross flow was developed to remove oil and suspended solids from wastewaters. Coalescence medium in the form of inclined plates promotes rising of oil droplets through coalescence and settling of solid particles through coagulation. It exhibits 22.67% higher removal of total suspended solids (TSS) compared to separators without coalescing medium. Moreover, it removed more than 70% of oil compared to conventional American Petroleum Institute separators, which exhibit an average of 33% oil removal. The flowrate required to attain an effluent oil concentration of 10 mg/L (Q(o10)) at different influent oil concentrations (C(io)) can be represented by Q(o10) x 10(-5) = -0.0012C(io) + 0.352. The flowrate required to attain an effluent TSS concentration of 50 mg/L (Q(ss50)) at different influent TSS concentrations (C(iss)) can be represented by Q(ss50) x 10(-5) = 1.0 x 10(6) C(iss)(-2.9576). The smallest removable solid particle size was 4.87 microm.     

两种不同形态的铝盐混凝剂的吸附电中和特征

通过吸附历时过程,饱和吸附量,吸附过程Ｎａ＾＋离子交换释放,絮凝前后高岭土微粒的ζ电位测定等实验考察ＡｌＣｌ３（ＡＣ）和聚合铝两种不同形态的铝盐对高岭土悬浮水样的吸附电中和特征,并探讨了其作用机理。     

The effect of coagulation on the toxicity and mutagenicity of reclaimed municipal effluents

The objectives of this work were the assessment of the effectiveness of coagulation on the reclamation of secondary effluents and the evaluation of the quality of reclaimed waters by the examination of their ecotoxic and mutagenic properties. Aluminum coagulants resulted in higher removal of organic content, than iron coagulant, reaching up to 40%; the removal of heavy metals, such as zinc and copper was enhanced by the addition of a low strength anionic flocculant. The toxicity of pre-concentrated samples to the bacteria Vibrio fischerii was related to the heavy metal content, especially zinc and copper, indicating the significance of the metals bioavailability and their potential interactive effects. The secondary effluents exhibited mutagenic effects on strain TA 98; these effects were increased during coagulation with ferric chloride (both in absence and presence of flocculant). However, the addition of aluminum coagulants resulted in a decrease of mutagenic potential of secondary effluents, due to the extended removal of organic matter.     

氯化镁复配硫酸铝混凝性能及絮体特性

在研究氢氧化镁混凝特性的基础上,复配氯化镁和硫酸铝作为混凝剂,以高岭土配水水样为研究对象,运用iPDA在线监测技术对混凝过程絮体形成进行监测,探讨了单独使用氯化镁和硫酸铝以及二者复配使用的混凝效果和絮体特性,确定复配使用的各种条件。结果表明,对于浊度20 NTU,pH 11.5的高岭土配水水样,氯化镁、硫酸铝最佳投加量分别为7.2 mg/L(Mg2+计)和3 mg/L(Al3+计);硫酸铝跟氯化镁复配使用时,先投加硫酸铝,间隔30 s后投加氯化镁,混凝效果较好;在镁离子最佳投加量7.2 mg/L时,铝和镁最佳质量比在1∶3~1∶2之间;镁铝复配时其FI值明显大于单独作用时,即絮体尺寸大小:二者复配硫酸铝氯化镁,而且复配条件下Zeta电位值在零电势左右浮动,浮动范围小,更利于聚集沉淀;镁铝复配时发生了协同效应,弥补了单独使用氯化镁混凝过程的不足。     

溶气气浮过程动力学模型的分形观

凝聚/絮凝过程中形成的絮体通常具有分形几何结构,导致絮体的密度、渗透性发生了变化,从而对于固液分离过程(沉淀、气浮和过滤)带来很大的影响。本文基于前人对于絮体分形的研究成果,建立了絮体与微气泡之间接触碰撞的动力学方程、絮体/微气泡聚集体在水中上升的分形速率方程。絮体与微气泡间的相对尺度和流态的不同会有不同的碰撞机制,相应的动力学方程式与絮体的分形维数也有不同的关系。     

改性硅藻土复合混凝剂处理深度采油废水

某油田深度采油废水中含有大量残油,粘度大、乳化程度高、油水分离困难,本实验采用改性硅藻土吸附和无机混凝剂混凝相结合以处理深度采油废水.结果表明,对于含油浓度为250～ 350 mg/L的石油废水,用强化吸附方法,吸附剂投加量为1.5 g/L,优化实验条件下除油率可达到75％；采用强化混凝的方法,PAC在投药量为200 mg/L的情况下除油率可达到87％；采用强化吸附-混凝联合处理的优化方法,投加0.7 g/L吸附剂+PAC 200 mg/L,除油率＞95％,明显高于吸附和混凝单独处理效果,大大改善了出水水质.     

优化混凝处理低温低浊黄河水及对余铝的控制

考察了4种混凝剂，高效聚合氯化铝（HPAC），聚合氯化铝（PACl），硫酸铝（Al2（SO4）3），混合PACl和氯化铁（FeCl3），对低温低浊黄河原水的混凝效果与沉后水残留铝含量的关系。结果表明，当采用Al2（SO4）3或PACl做混凝剂时，在取得较好浊度去除的投药量下，水中余铝浓度会超过国家标准（0．2131g／L）。而采用HPAC或FeCl3和PACl复配药剂，在取得与Al2（SO4）3或PACl类似的浊度去除效果的同时，也能较好地控制水中的余铝含量。当HPAC投加量为21mg／L时，沉后水浊度降至1．3NTU，残留铝含量为0．147mg／L。复配投加PACl 15mg／L和FeCl3 12mg／L后，沉后水浊度为1．18NTU，残留铝含量为0．074mg／L。PACl和氯化铁的复配比例需要精确的调控，否则容易导致出水余铁余铝含量增加。而HPAC投加量小于21mtg／L时出水余铝浓度均低于国家标准。因此，在这4种混凝剂中，就混凝效果及余铝控制而言，HPAC更适合充当低温低浊水源水的混凝处理药剂。