Investigation of organic matter dynamics during in-vessel composting of an aged coal-tar contaminated soil using fluorescence excitation-emission spectroscopy

In-vessel composting of an aged coal-tar contaminated soil from a manufactured gas plant site was investigated over 98days using laboratory-scale in-vessel composting reactors. The composting reactors were operated at 18 different operational conditions using a logistic three-factor factorial design with three temperatures (T=38, 55 and 70 degrees C), four soil to green waste ratios (S:GW; 0.6:1, 0.7:1, 0.8:1 and 0.9:1 on a dry weight basis) and three moisture contents (MC; 40%, 60% and 80%). Excitation-emission matrix (EEM) fluorescence spectroscopy was used to investigate organic matter dynamics in the composting mixture. The results of this investigation indicated that formation of humic substances can be monitored by fluorescence excitation-emission matrix, and provided evidence of progressive mineralization or humification of the composting mixture. Peak excitation wavelength shifts and peak fluorescence intensity can both be used as indicators to monitor the humification or maturation of compost. Finally, the fluorescence index can be applied to investigate the origin of humic substances and fulvic acids, and the humification or maturation of compost.     

猪粪堆肥中铜锌与腐殖质组分的结合竞争

为研究猪粪堆肥中铜锌与腐殖质组分的结合竞争,以猪粪和秸秆为堆腐原料,进行了为期36 d的好氧堆肥实验,研究猪粪堆肥过程中腐殖质组分(胡敏酸和富里酸)、胡敏酸结合态铜锌、富里酸结合态铜锌含量的变化。结果表明,堆肥结束后,腐殖化程度提高,胡敏酸碳含量增加394.4%,富里酸碳含量降低64.9%,腐殖化指数从0.24增加到3.33;随着堆肥的进行,胡敏酸结合态铜锌含量分别增加394.3%和56%,而富里酸结合态铜锌含量分别下降17.5%和28.4%;相关分析表明,胡敏酸结合态铜、富里酸结合态锌与胡敏酸、富里酸碳含量及腐殖化指数均成显著相关(P<0.01);堆肥过程中,胡敏酸结合态铜与富里酸结合态铜之比大于1,而胡敏酸结合态锌与富里酸结合态锌小于1,另外,胡敏酸中的Cu/Zn大于1,而富里酸中的Cu/Zn小于1,表明在腐殖质中铜主要与胡敏酸结合,而锌主要与富里酸结合。研究揭示了猪粪堆肥中重金属铜锌与不同腐殖质组分的结合竞争关系,为畜禽粪便堆肥土地利用的风险评估和风险控制提供科学依据。     

Changes in the chemical composition of water-extractable organic matter during composting: distribution between stable and labile organic matter pools

Aerobic decomposition and stabilization of organic matter during the composting of waste materials is primarily due to the biochemical transformation of water-soluble compounds in the liquid phase by the microbial biomass. For this reason water-soluble organic matter represents the most active fraction of compost, both biologically and chemically, and thus should directly reflect the biochemical alteration of organic matter. This work aims to elucidate the microbial-mediated processes responsible for the distribution of soluble organic matter between stable and labile pools with composting time. Accordingly, chemical analysis as well as UV absorption, and ¹H and ¹³C-NMR spectroscopy of samples collected during the industrial composting of urban waste revealed microbial induced transformation of water-extractable organic matter over time. The chemical composition changed from labile, hydrophilic, plant-derived organic compounds in the beginning to predominately stable, hydrophobic moieties comprising lignin-derived phenols and microbially-derived carbohydrates at later stages of composting.     

Formation of chloromethoxybenzaldehyde during composting of organic household waste

Standardized household waste was mixed with different litter amendments, straw, leaves, hardwood shavings, softwood shavings, paper, and sphagnum peat, resulting in six compost mixtures. In addition non-amended household waste was composted. Composting was done in small rotatable bins and compost samples were taken on a regular basis until day 590. Extraction and analysis of wet compost samples showed no evidence for the presence of chloroorganic compounds. Drying and re-wetting of compost samples, however, revealed that chloromethoxybenzaldehyde (CMBA) was formed in all composts at concentrations varying between 5.6 and 73.4 microg kg(-1) dry matter. CMBA was not present in the original materials. During composting, there was a clear positive relation between formation of CMBA and microbial activity, as indicated by C losses and temperature. Formation took place during the most intensive phase of composting when C losses were highest. Under anaerobic conditions, however, which prevailed initially in the non-amended compost, no CMBA was formed. Calculation of total amounts of CMBA in composts revealed that there was a small decrease during storage in the hardwood, peat, and softwood composts. However, all composts contained CMBA after 590 days. The mean concentration was 33.4 microg kg(-1) dry matter (s.d. = 21.9). Possible biocidal effects of composts when used in cultivation may be explainable by the presence of natural toxic compounds formed during composting.     

Co-composting of distillery wastes with animal manures: carbon and nitrogen transformations in the evaluation of compost stability

The aim of this work was to study the viability of recycling the solid wastes generated by the winery and distillery industry by means of co-composting with animal manures, as well as to evaluate the quality of the composts obtained. Two piles, using exhausted grape marc and cattle manure or poultry manure, respectively (at ratios, on a fresh weight basis, of 70:30), were composted by the Rutgers static pile composting system. Throughout the composting process, a number of parameters were monitored, such as pH, electrical conductivity, organic matter, water-soluble carbon, water-soluble polyphenols, different forms of nitrogen (organic nitrogen, ammonium and nitrate) and humification indices (humification ratio, humification index, percentage of humic acid-like C, polymerisation ratio and cation exchange capacity), as well as the germination index. Organic matter losses followed first-order kinetics equation in both piles, the highest organic matter mineralisation rate being observed with exhausted grape marc and cow manure. On the other hand, the mixture with the lowest C/N ratio, using exhausted grape marc and poultry manure, showed the highest initial ammonium contents, probably due to the higher and more labile N content of poultry manure. The increase in the cation exchange capacity revealed the organic matter humification during composting. In contrast, other humification parameters, such as the humification ratio and the humification index, did not show the expected evolution and, thus, could not be used to assess compost maturity. Composting produced a degradation of the phytotoxic compounds, such as polyphenols, to give composts without a phytotoxic character. Therefore, composting can be considered as an efficient treatment to recycle this type of wastes, due to composts presented a stable and humified organic matter and without phytotoxic effects, which makes them suitable for their agronomic use.     

Effect of inoculating microbes in municipal solid waste composting on characteristics of humic acid

Municipal solid waste (MSW) compost contains a significant amount of humic substances. In this study, the compost consisted of residual MSW with the metal, plastic and glass removed. In order to enhance degradation processes and the degree of composting humification, complex microorganisms (Bacillus casei, Lactobacillus buchneri and Candida rugopelliculosa) and ligno-cellulolytic (Trichoderma and White-rot fungi) microorganisms were respectively inoculated in the composting process. During the MSW composting, humic acid (HA) was extracted and purified. Elements (C, N, H, O) and spectroscopic characteristics of the HA were determined using elementary analyzer, UV, Fourier transform infrared (FTIR), and fluorescence spectroscopy. The elements analysis, UV, FTIR and fluorescence spectra all led to the same conclusion, that is inoculations with microbes led to a greater degree of aromatization of HA than in the control process (CK) with no inoculation microbes. This indicated that inoculation with microbes in composting would improve the degree humification and maturation processes, in the following order: lingo-cellulolytic>complex microorganisms>CK. And mixed inoculation of MSW with complex microorganisms and lingo-cellulolytic during composting gave a greater degree of HA aromatization than inoculation with complex microorganisms or lingo-cellulolytic alone. But comparing with the HA of soil, the HA of MSW compost revealed a lower degree of aromatization.     

Oxidative biodegradation of dissolved organic matter during composting

Dissolved organic matter (DOM) plays an important role in the microbial degradation of compost since it represents the most active organic fraction, both biologically and chemically. The detailed evaluation of the changes in the chemical and biochemical characteristics of DOM induced by oxidative biodegradation, presented in this work highlights the mechanisms involved in the degradation of soluble organic matter during composting. In fact, the results show that during the initial stages of composting, DOM is highly degradable under aerobic conditions, particularly due to the predominance of labile, hydrophilic compounds such as carbohydrates, amino acids and proteins. As such compounds are degraded more resistant aromatic moieties accumulate in solution resulting in a reduction in the degradability of DOM with composting time. This decrease in degradability was found to be highly correlated with microbial oxygen demand, and could have important implications in the evaluation of the composting process.     

复合微生物菌剂强化堆肥技术研究

采用复合微生物菌剂对生活垃圾的接种堆肥技术进行了实验研究。通过测定堆肥过程中反应器出口O2、CO2与H2S气体浓度及对堆肥样品扫描电镜照片分析，比较了3个接种组与1个对照组中堆料中微生物总数变化、种群结构演替及堆肥腐熟速度。试验结果表明，在原料成分为：生活垃圾／成熟堆肥=80／20，有机物约为60％，初始含水率为55％，初始C／N-30时，对于不同接种量的复合微生物接种系统堆料中分别接种0．2％、0．3％、0．5％(质量百分含量)，与加入0．3％灭活菌的对照组进行对比实验，接种复合微生物菌剂堆肥系统不仅微生物总数高于对照组，而且其种群结构合理，能明显提高堆肥效率，有效控制臭气的产生，提高堆肥腐熟度。     

Microbial activity during composting of anthracene-contaminated soil

Microbial activity of an anthracene-spiked soil mixed with kitchen waste during laboratory composting at 56-59 degrees C was studied using an in-vessel technology. The effect of old compost containing acclimated microorganisms on the composting efficiency was also investigated. Microbial succession, microbial enzyme activity, microbial diversity and anthracene removal rate were analyzed during 42 days of composting. The results demonstrated that inoculating with old compost increased the amounts of thermophilic microorganisms, but did not significantly increase anthracene removal. A microbial succession from mesophilic bacteria to thermophilic bacteria and thermophilic actinomycetes was observed during composting. Polyphenol oxidase activity decreased while catalase activity varied irregularly. Microbial diversity increased drastically when temperature elevated from 35 to 56 degrees C, but decreased when temperature maintained at 56-59 degrees C.     

Co-composting of spent coffee ground with olive mill wastewater sludge and poultry manure and effect of Trametes versicolor inoculation on the compost maturity

The co-composting of spent coffee grounds, olive mill wastewater sludge and poultry manure was investigated on a semi-industrial scale. In order to reduce the toxicity of the phenolic fraction and to improve the degree of composting humification, composts were inoculated with the white-rot fungus Trametes versicolor in the early stages of the maturation phase.During composting, a range of physico-chemical parameters (temperature and both organic matter and C/N reduction), total organic carbon, total nitrogen, elemental composition, lignin degradation and spectroscopic characteristics of the humic acids (HAs) were determined; impacts of the composting process on germination index of Hordeum vulgare and Lactuca sativa were assessed. The coffee waste proved to be a highly compostable feedstock, resulting in mature final compost with a germination index of 120% in less than 5 months composting. In addition, inoculation with T. versicolor led to a greater degree of aromatization of HA than in the control pile. Moreover, in the inoculated mixture, lignin degradation was three times greater and HA increased by 30% (P < 0.05), compared to the control pile. In the T. versicolor inoculated mixture, the averages of C and N were significantly enhanced in the HA molecules (P < 0.05), by 26% and 22%, respectively. This improvement in the degree of humification was confirmed by the ratio of optical densities of HA solutions at 465 and 665 nm which was lower for HA from the treated mixture (4.5) than that from the control pile (5.4).     

牛粪堆肥腐殖质的动态变化研究

牛粪堆肥实质是有机物质分解的同时形成腐殖质的过程。本研究通过向牛粪中接种发酵微生物进行堆肥,研究分析了总有机碳含量、总腐殖酸、游离腐殖酸和水溶性腐殖酸等的腐殖质物质含量的动态变化。研究结果表明：在牛粪发酵过程中,总有机碳含量呈明显降低趋势,发酵微生物处理下的下降幅度明显大于不接种发酵微生物的处理;总腐殖酸、游离腐殖酸和水溶性腐殖酸含量在发酵前期呈明显的降低趋势,但至发酵腐熟期又逐渐升高。发酵前期,外源微生物的处理,使其下降幅度明显大于不接种外源微生物的处理,但在发酵腐熟期变化不大。     

Concentrations of monosaccharides in humic substances in the early stages of humification.

Deteriorated liquid packaging board (LPB) and biowaste compost are matrices, mainly consisting of cellulose, in the early stages of humification. Degradative studies on these matrices allow an examination of the role of carbohydrates in the synthesis of humic substances. Samples of different age were collected and divided by extraction into hot water extract (HWE), bitumen, humic acid (HA), fulvic acid (FA) and humin or residual fibre fractions. The following monosaccharides were identified in these fractions: L-arabinose, D-ribose, D-xylose, L-fucose, D-mannose, D-fructose, D-galactose, D-glucose, L-rhamnose and xylitol. The main component in all fractions was glucose. The concentrations of monosaccharides in humic acids (HAs) of LPB ranged from 67 to 503 mg/g of organic matter, and the concentrations in HAs of compost from 52 to 101 mg/g. As a general trend, the concentrations of monosaccharides decreased during LPB degradation and composting in all fractions. At the same time the relative amounts of D-xylose, D-mannose and D-galactose increased in HAs of compost samples.     

Advantages and risks of using steel slag in preparing composts from raw organic waste

It had been reported that iron and manganese oxides in steel slag enhanced the production of humic acid (HA) from low-molecular-weight compounds, such as phenolic acids, amino acids, and saccharides. In the present study, this function of steel slag was applied to the composting of raw organic wastes (ROWs). The degree of humification of HAs is an important factor in evaluating compost quality. Thus, HAs were extracted from the prepared composts and the humification parameters were determined, in terms of elemental compositions, acidic functional group contents, molecular weights, spectroscopic parameters from UV–vis absorption and ¹³C NMR spectra. The timing for adding steel slag affected the degree of humification of HAs in the composts. The weight average molecular weight of a HA when slag was added initially (29 kDa) was significantly higher than when slag was added after elevating the temperature of the compost pile (17–18 kDa). These results show that ROWs are decomposed to low-molecular-weight compounds after the pile temperature is elevated and the presence of slag enhances the polycondensation of these compounds to produce HAs with a higher degree of humification. Because the slag used in the present study contained several-tens ng g^?1 to several μg g^?1 of toxic elements (B, Cu, Cr, and Zn), leaching tests for these elements from the prepared composts were carried out. Levels for leaching boron from composts prepared by adding slag (0.2–0.4 mg L^?1) were obviously higher than the corresponding levels without slag (0.05 mg L^?1).     

Effect of inoculating flower stalks and vegetable waste with ligno-cellulolytic microorganisms on the composting process

A lab-scale composting experiment was carried out using vegetable and flower stalks waste to study the effectiveness of ligno-cellulolytic microorganisms (LCMs) obtained from the previous isolation on composting process, especially on enhancement of biodegradation rate of these organic materials. The addition of LCMs to compost showed promised to be a valuable asset by rendering timely benefits in efficiency, maturity, and quality of the composting. This was evidenced by a significant increase of temperature, O2 consumption and CO2 emission, and population density of LCMs in compost mass compared with that of biotic (addition of culture of horse feces) and abiotic (1% molasses amendment) treatments, as well as control trial. The phytotoxicity assay showed that the substrate became mature after 60 days' composting. The LCMs inoculation enhanced the biodegradation of the composting materials as evidenced by an increasing screening ratio (1.2 cm sieve pore) of 34.5% in the treated trail, compared with that of control, which elucidated that big advantage of adding selected inoculants over other treatment, and screening ratio is a reasonable index to compare the quality of different compost. However, the inoculation seemed to have no significant effect on the moisture content, pH, and the final organic carbon of the composting materials.     

Effect of Inoculating Flower Stalks and Vegetable Waste with Ligno-cellulolytic Microorganisms on the Composting Process

Abstract

A lab-scale composting experiment was carried out using vegetable and flower stalks waste to study the effectiveness of ligno-cellulolytic microorganisms (LCMs) obtained from the previous isolation on composting process, especially on enhancement of biodegradation rate of these organic materials. The addition of LCMs to compost showed promised to be a valuable asset by rendering timely benefits in efficiency, maturity, and quality of the composting. This was evidenced by a significant increase of temperature, O₂ consumption and CO₂ emission, and population density of LCMs in compost mass compared with that of biotic (addition of culture of horse feces) and abiotic (1% molasses amendment) treatments, as well as control trial. The phytotoxicity assay showed that the substrate became mature after 60 days’ composting. The LCMs inoculation enhanced the biodegradation of the composting materials as evidenced by an increasing screening ratio (1.2 cm sieve pore) of 34.5% in the treated trail, compared with that of control, which elucidated that big advantage of adding selected inoculants over other treatment, and screening ratio is a reasonable index to compare the quality of different compost. However, the inoculation seemed to have no significant effect on the moisture content, pH, and the final organic carbon of the composting materials.     

Role of biochar on composting of organic wastes and remediation of contaminated soils—a review

Biochar is produced by pyrolysis of biomass residues under limited oxygen conditions. In recent years, biochar as an amendment has received increasing attention on composting and soil remediation, due to its unique properties such as chemical recalcitrance, high porosity and sorption capacity, and large surface area. This paper provides an overview on the impact of biochar on the chemical characteristics (greenhouse gas emissions, nitrogen loss, decomposition and humification of organic matter) and microbial community structure during composting of organic wastes. This review also discusses the use of biochar for remediation of soils contaminated with organic pollutants and heavy metals as well as related mechanisms. Besides its aging, the effects of biochar on the environment fate and efficacy of pesticides deserve special attention. Moreover, the combined application of biochar and compost affects synergistically on soil remediation and plant growth. Future research needs are identified to ensure a wide application of biochar in composting and soil remediation.

Open image in new window

Graphical abstract ?

     

Ammonia emissions from the composting of different organic wastes. Dependency on process temperature

Ammonia emissions were quantified for the laboratory-scale composting of three typical organic wastes with medium nitrogen content: organic fraction of municipal solid wastes, raw sludge and anaerobically digested sludge; and the composting of two wastes with high nitrogen content: animal by-products from slaughterhouses and partially hydrolysed hair from the leather industry. All the wastes were mixed with the proper amount of bulking agent. Ammonia emitted in the composting of the five wastes investigated revealed a strong dependence on temperature, with a distinct pattern found in ammonia emissions for each waste in the thermophilic first stage of composting (exponential increase of ammonia emitted when increasing temperature) than that of the mesophilic final stage (linear increase of ammonia emissions when increasing temperature). As composting needs high temperatures to ensure the sanitisation of compost and ammonia emissions are one of the main environmental impacts associated to composting and responsible for obtaining compost with a low agronomical quality, it is proposed that sanitisation is conducted after the first stage in large-scale composting facilities by a proper temperature control. CAPSULE: Ammonia emission pattern and correlation with process temperature are presented for the composting process of different organic wastes.     

Effect of bulking agents on maturity and gaseous emissions during kitchen waste composting

This study investigated the effect of bulking agents on the maturity and gaseous emissions of composting kitchen waste. Three different bulking agents (cornstalks, sawdust, and spent mushroom substrate) were used to compost kitchen waste under aerobic conditions in 60-L reactors for a 28-d period. A control treatment was also studied using kitchen waste without a bulking agent. During the experiment, maturity indexes such as temperature, pH value, C/N ratio, and germination index were determined, and continuous measurements of leachate and gaseous emissions (CH₄, N₂O, and NH₃) were taken. The results showed that all of the composts with bulking agents reached the required maturity standard, and the addition of spent mushroom substrate gave the highest maturity (C/N ratio decreased from 23 to 16 and germination index increased from 53% to 111%). The bulking agents also reduced leachate production and CH₄ and N₂O emissions, but had little impact on NH₃ emissions. Composting with sawdust as a bulking agent was found to emit less total greenhouse gas (33 kg CO₂-eq t⁻¹ dry matter) than the other treatments.     

水葫芦与厨余垃圾混合好氧堆肥中氮素变化及对腐熟度的影响

通过采用间歇式好氧动态堆肥工艺，对厨余垃圾与添加水葫芦的厨余垃圾进行堆肥实验，探讨堆肥进程中全氮、氨基酸态氮、蛋白质的变化及对腐熟度的影响。结果表明，全氮含量在堆肥后期有所提高，分别由1.76%和2.23%提高到3.64%和2.67%；氨基酸态氮含量与微生物活性显著负相关；添加水葫芦使堆体温度提高，促进了蛋白质的快速降解；堆肥中N素是影响种子发芽的主要因素；添加水葫芦能够促进堆肥的腐熟。     

Comparative effectiveness of mixed organic substrates to mushroom compost for treatment of mine drainage in passive bioreactors

Bioreactors are one possible best sustainable technology to address the mine-impacted water problems. Several prospective substrates (mushroom compost, cow manure, sawdust, wood chips, and cut rice straw) were characterized for their ability to serve as a source of food and energy for sulfate-reducing bacteria. Twenty bench-scale batch bioreactors were then designed and set up to investigate relative effectiveness of various mixtures of substrates to that of mushroom compost, the most commonly used substrate in field bioreactors, for treating mine drainage with acidic (pH 3) and moderate pH (pH 6). Overall, reactive mixtures showed satisfactory performances in generating alkalinity, reducing sulfate and removing metals (Al>Fe>Mn) (up to 100%) at both pH conditions, for all substrates. The mixture of sawdust and cow manure was found as the most effective whereas the mixture containing 40% cut rice straw gave limited efficiency, suggesting organic carbon released from this substrate is not readily available for biodegradation under anaerobic conditions. The mushroom compost-based bioreactors released significant amount of sulfate, which may raise a more concern upon the start-up of field-scale bioreactors. The correlation between the extent of sulfate reduction and dissolved organic carbon/SO(4)(2-) ratio was weak and this indicates that the type of dissolved organic carbon plays a more important role in sulfate reduction than the absolute concentration and that the ratio is not sensitive enough to properly describe the relative effectiveness of substrate mixtures.