Effect of the alkyl chain length on the anaerobic biodegradability and toxicity of quaternary ammonium based surfactants

The anaerobic biodegradability and toxicity to methanogenic gas production of different alkyl chain length homologs of quaternary ammonium based surfactants were examinated. Two series of these cationic surfactants were selected: alkyl trimethyl ammonium and alkyl benzyl dimethyl ammonium compounds. A simple anaerobic gas production test containing municipal digester solids as a source of anaerobic bacteria was used. Under the applied methanogenic conditions, the cationic surfactants tested showed a very poor primary biodegradation and no evidence of any extent of ultimate biodegradation was observed. The toxicity of quaternary ammonium based surfactants to methanogenic gas production decreased with increasing the alkyl chain length.     

Protocol for early detection and evaluation of inhibitory wastewater using combined aerobic respirometric and anaerobic batch techniques.

Faced with the task of treating significant volumes of complex industrial wastewaters, the biological components of municipal wastewater treatment plants are operating under the risk of toxic or inhibitory contaminants from the industrial effluents that may be detrimental to their operation. This might lead to undesirable effluent toxicity and/or result in permit violations. Therefore, there is a need for upset early warning systems that can protect full-scale plants from toxic or inhibitory constituents in the incoming wastewaters. This study focused on the development of a protocol for rapid detection of potentially toxic inhibitory or toxic wastewaters using combined aerobic respirometric and anaerobic batch techniques. Aerobic respirometers equipped with automated data acquisition systems were used as potential early warning devices. The inhibition effect on carbon and nitrogen oxidation was assessed. The degree of inhibition was evaluated as the concentration causing 50% reduction in microbial activity, which was estimated by an inhibition model. Anaerobic toxicity assays were also conducted to evaluate the inhibitory effects of the toxic compounds to anaerobic inocula obtained from a master culture reactor fed with ethanol. The developed protocol for early detection of toxicity was validated using wastewater samples from a biotechnology industry and a food processing industry, and pure chemicals such as furfural and phenol. Varying degrees of sensitivity were observed in the study when different groups of microorganisms, wastewater samples, and chemicals were tested. The comparison of aerobic and anaerobic inhibition suggested the importance of using both aerobic and anaerobic cultures to maximize the necessary sensitivity of the protocol.     

Anaerobic degradation and toxicity of commercial cationic surfactants in anaerobic screening tests

Anaerobic biodegradability and toxicity on anaerobic bacteria of di(hydrogenated tallow) dimethyl ammonium chloride (DHTDMAC) and two esterquats have been investigated. A batch test system containing municipal digester solids as a source of anaerobic bacteria, based on the method proposed by the ECETOC, has been applied. To evaluate the potential toxicity of such surfactants on anaerobic sludge, a co-substrate, an easily biodegradable compound in anaerobic conditions, has been added to the samples to test and the effects on biogas production have been determined. For the esterquats studied high biodegradation levels were obtained and no toxic effects on anaerobic bacteria were observed even at the highest concentrations tested, 100 and 200 mg C/l, respectively. On the contrary, DHTDMAC was not degradated at the same test conditions. However, no inhibitory effects on the biogas production were detected for this surfactant at concentrations <100 mg C/l.     

Biodegradability and ecotoxicity of amine oxide based surfactants

The aerobic and anaerobic biodegradability as well as the aquatic toxicity of two fatty amine oxides and one fatty amido amine oxide were investigated. Aerobic biodegradation was evaluated using the CO(2) headspace test (ISO 14593) and biodegradation under anaerobic conditions was assessed employing a standardised batch test. The three amine oxide based surfactants tested were readily biodegradable under aerobic conditions but only the alkyl amido amine oxide was found to be easily biodegradable under anaerobic conditions. Toxicity to Photobacterium phosphoreum and Daphnia magna was evaluated. Bacteria (EC(50) from 0.11 to 11 mg l(-1)) proved to be more sensitive to the toxic effects of the amine oxide based surfactants than crustacea (IC(50) from 6.8 to 45 mg l(-1)). The fatty amido amine oxide showed the lowest aquatic toxicity.     

Performance Evaluation of Waste Activated Carbon on Atrazine Removal from Contaminated Water

Abstract

In this study, the potential of spent activated carbon from water purifier (Aqua Guard, India) for the removal of atrazine (2 chloro-4 ethylamino-6-isopropylamino-1, 3, 5 triazine) from wastewaters was evaluated. Different grades of spent activated carbon were prepared by various pretreatments. Based on kinetic and equilibrium study results, spent activated carbon with a grain size of 0.3–0.5 mm and washed with distilled water (designated as WAC) was selected for fixed column studies. Batch adsorption equilibrium data followed both Freundlich and Langmuir isotherm. Fixed bed adsorption column with spent activated carbon as adsorbent was used as a polishing unit for the removal of atrazine from the effluent of an upflow anaerobic sludge blanket (UASB) reactor treating atrazine bearing domestic wastewater. Growth of bacteria on the surface of WAC was observed during column study and bacterial activity enhanced the effectiveness of adsorbent on atrazine removal from wastewater.     

Performance evaluation of waste activated carbon on atrazine removal from contaminated water

In this study, the potential of spent activated carbon from water purifier (Aqua Guard, India) for the removal of atrazine (2 chloro-4 ethylamino-6-isopropylamino-1, 3, 5 triazine) from wastewaters was evaluated. Different grades of spent activated carbon were prepared by various pretreatments. Based on kinetic and equilibrium study results, spent activated carbon with a grain size of 0.3-0.5 mm and washed with distilled water (designated as WAC) was selected for fixed column studies. Batch adsorption equilibrium data followed both Freundlich and Langmuir isotherm. Fixed bed adsorption column with spent activated carbon as adsorbent was used as a polishing unit for the removal of atrazine from the effluent of an upflow anaerobic sludge blanket (UASB) reactor treating atrazine bearing domestic wastewater. Growth of bacteria on the surface of WAC was observed during column study and bacterial activity enhanced the effectiveness of adsorbent on atrazine removal from wastewater.     

生物降解实验中的接种物标准化研究

针对降解实验中接种物采集困难、活性差异大、实验可重复性及结果可比性差的问题展开接种物标准化研究。对多来源的接种物在实验室可控条件下进行驯养,驯养后生长状态良好的活性污泥分别固定于灭菌麸皮和藻酸钙凝胶等2种微生物载体上,形成2种固定化接种物(分别简称为Bran及Ball)。对上述固定化接种物进行微生物活性、适应性、降解能力以及稳定性研究:通过2种固定化接种物与商品化接种物Polyseed对葡萄糖-谷氨酸(GGA)五日生化需氧量(BOD5)的结果与活菌细胞数的关系,确认3种接种物在降解实验中的用量可控制在相同数量级;比较不同批次及保存时间的2种固定化接种物、相同批次不同保存时间的Polyseed以及污水处理厂曝气池污泥为接种物对苯胺及二甘醇的快速生物降解实验(OECD301F)结果,发现Ball及Bran较Polyseed及新鲜采集活性污泥的微生物适应性及降解能力更佳。此外,在较长保存期内2种固定化接种物活性相对稳定。2种固定化接种物初具成为标准化接种物的必要条件。     

Characterization and modeling of nutrient-deficient tomato-processing wastewater treatment using an anaerobic/aerobic system

Tomato-processing wastewaters are typical of slowly biodegradable high strength wastewaters generated from the food canning industry. Three different samples of influent and three samples of anaerobic effluents corresponding to the three influents collected from an on-site pilot-scale anaerobic/aerobic system were characterized using respirometric methods. Respirometric studies demonstrated that the pretreatment in the anaerobic reactor of the pilot-scale system increased the readily biodegradable fraction from an average of 40% of the SCOD in the influent to 50% of the SCOD in the anaerobic effluent, improved kinetics from an average micro(max) of 1.5d(-1) in the influent to 3.5d(-1) in the anaerobic effluent, and eliminated nutrient deficiency. Furthermore, the system was calibrated and simulated by application of wastewater characterization and biokinetic data derived form respirometric tests of influent and anaerobic effluent in Activated Sludge Model no.1 (ASM1).     

芳香类污染物的厌氧生物降解研究

综述了国内外芳香类污染物厌氧降解的研究进展,详细阐述了含氮芳香类、氯代芳香类和酚类污染物厌氧降解的微生物类群与机理.提出了芳香类污染物生物降解今后发展方向的重点是共基质条件下生物降解性研究、厌氧-好氧条件下的生物降解性研究、高效工程菌和固定化细胞技术应用研究、构建基因工程菌和遗传学研究等技术领域.     

The biodegradability and microbial toxicity testing of lubricants--some recommendations

In recent years there has been a growing demand for information on the biodegradability (fate) and microbial toxicity (effects) of lubricants. This has been driven by the need to comply with environmental legislation and to meet the requirements of ecolabelling schemes, standards and customer specifications for 'environmentally acceptable' lubricants. This paper describes suitable approaches for generating this information under a variety of environmental conditions (e.g. aerobic, anaerobic, freshwater, marine), gives examples of the results obtained and discusses their interpretation. Recommendations on the use of each test are made.     

Evaluation of laboratory-made sludge for an anaerobic biodegradability test and its use for assessment of 13 chemicals

Laboratory-made sludge for a biogas based anaerobic biodegradability test was prepared as an alternative for digested sludge from wastewater treatment plants (WWTPs). Biodegradation activities and background gas productions of digested sludge from various WWTPs were found to vary significantly depending on the source, which adversely affected test reliability. Subsequently, test conditions such as sludge concentration and sludge washing were examined with the laboratory-made sludge and a sludge concentration of 1.0 g-SS/L without washing was determined to be most suitable. Under these conditions, biodegradability tests were conducted for 13 select chemicals and their relative toxicities to methanogenic bacteria were evaluated. The results of biodegradability tests showed that chemicals with -OH and -CH2OH radicals were readily biodegraded and those with -Cl, -NO2, -NH2, -SO3H and -CH3 had inhibited degradation responses m-nitriphenol and 2,4,6-trichlorophenol were highly toxic to methanogenic bacteria, with m-nitrophenol completely inhibiting methane fermentation as low as 20 mg/L.     

Evaluation of a serum bottle technique for assessing the anaerobic biodegradability of organic chemicals under methanogenic conditions

The serum bottle method of Shelton and Tiedje (1984), for assessing the potential of an organic chemical to undergo anaerobic biodegradation, was evaluated using U.K. primary digesting sludges. The method was modified by using the sludge at a known solids content and employing sterile (autoclaved) controls to correct for abiotic gas production. Gas production was measured with a compact hand-held pressure meter, which represented an improvement over previously described techniques. Results obtained confirmed the reliability and precision of this type of simple, screening test for assessing anaerobic biodegradability. However, the test is only applicable to low-sulphate, methanogenic environments and evidence is presented of interference from sulphate-reducing bacteria (SRB) when testing sulphate-containing chemicals.     

Treatment of pharmaceutical wastewater containing antibiotics by O3 and O3/H2O2 processes

Ozonation of three different synthetic pharmaceutical formulation wastewater containing two human antibiotics and a veterinary antibiotic has been studied to enhance the their biodegradability. The effects of pH and initial chemical oxygen demand (COD) value as well as addition of hydrogen peroxide on ozonation process were investigated. Total organic carbon (TOC), COD, biochemical oxygen demand (BOD), and aromatic content (UV254) were the parameters followed to evaluate the performance of ozonation process. Comparison of the biodegradability of selected wastewaters containing different antibiotics confirmed that the variation of biodegradability was associated with the target compound. While BOD5/COD ratio of veterinary antibiotic formulation wastewater was increased from 0.077 to 0.38 with an applied ozone dosage of 2.96 g/l, this ratio for human antibiotic I and human antibiotic II was increased from 0 to 0.1 and 0.27 respectively. Moreover the results of this investigation showed that the ozonation process is capable of achieving high levels of COD and aromaticity removals at about their natural pH values.     

脂肪酰基氨基酸对矿物润滑油生物降解性的影响研究

通过生物降解试验研究了N-月桂酰基谷氨酸、N-月桂酰基甘氨酸、N-月桂酰基丙氨酸和N-油酰基甘氨酸4种脂肪酰基氨基酸对HVI 350矿物润滑油生物降解性的影响，采用高倍电子显微镜分析了生物降解过程中微生物数量和形态变化。结果表明，在矿物润滑油中添加少量脂肪酰基氨基酸后，矿物润滑油的生物降解性能明显改善，且生物降解过程中微生物数量增多、形态发生变化，这可能是脂肪酰基氨基酸增加了微生物的营养，且具有表面活性，有利于细胞的吸收，从而促进了矿物润滑油生物降解。     

Evaluation of the toxicity of substances to be assessed for biodegradability

The ability to distinguish between true non-biodegradability, and inhibition of biodegradability due to the toxic effects of the compound tested present problems. It results in possible false identification of substances as non-biodegradable.Six chemicals were evaluated in a variety of tests to assess their toxicity to aerobic sludge organisms. The tests employed were: BOD₅ and Closed Bottle inhibition tests, inhibition of respiration of activated sludge, growth inhibition of activated sludge, light emission from (MICROTOX test) and the repetitive die-away test (RDA). Results from these tests were compared with results obtained from a number of ready biodegradability tests using the compounds listed above at anticipated non-toxic and toxic concentrations.No test method evaluated consistently forecast toxicity due to the chemicals tested. The MICROTOX and nitrification inhibition tests were too sensitive. A combination of sludge respiration rate and/or growth tests seem most appropriate. To avoid toxicity to the sludge, biodegradability testing should be made at 10% of the EC₅₀ value. Compounds with an EC₅₀ value greater than 300 mg/l are unlikely to be toxic in ready biodegradability tests. Compounds with an EC₅₀ value of less than 20 mg/l may pose problems necessitating the use of the stringent closed bottle test, or the use of C¹⁴ labelled test materials. Compounds with an intermediate EC₅₀ that is between 20–300 mg/l, need to be evaluated at a range of concentrations in biodegradability tests, or may need to be evaluated carefully to define the precise no-effect level. Procedure recommendations to distinguish between the inhibition of biodegradability and inertness of the test substance are made.     

Improving ready biodegradability testing of fatty amine derivatives

This study assesses the biodegradation potential of a number of fatty amine derivatives in tests following the OECD guidelines for ready biodegradability. A number of methods are used to reduce toxicity and improve the bioavailability of the fatty amine derivatives in these tests. Alkyl-1,3-diaminopropanes and octadecyltrimethylammonium chloride are toxic to microorganisms at concentrations used in OECD ready biodegradability tests. The concentration of these fatty amine derivatives in the aqueous phase can be reduced by reacting humic, or lignosulphonic acids with the derivatives or through the addition of silica gel to the test bottles. Using these non-biodegradable substances, ready biodegradability test results were obtained with tallow-1,3-diaminopropane and octadecyltrimethylammonium chloride. Demonstration of the ready biodegradability of the water-insoluble dioctadecylamine under the prescribed standard conditions is almost impossible due to the limited bioavailability of this compound. However, ready biodegradability results were achieved by using very low initial test substance concentrations and by introducing an organic phase. The contents of the bottles used to assess the biodegradability of dioctadecylamine were always mixed. False negative biodegradability results obtained with the fatty amine derivatives studied are the result of toxic effects and/or limited bioavailability. The aids investigated therefore improve ready biodegradability testing.     

Kinetic study of the anaerobic biodegradation of alkyl polyglucosides and the influence of their structural parameters

This paper reports a study of the anaerobic biodegradation of non-ionic surfactants alkyl polyglucosides applying the method by measurement of the biogas production in digested sludge. Three alkyl polyglucosides with different length alkyl chain and degree of polymerization of the glucose units were tested. The influence of their structural parameters was evaluated, and the characteristics parameters of the anaerobic biodegradation were determined. Results show that alkyl polyglucosides, at the standard initial concentration of 100 mgC L^?1, are not completely biodegradable in anaerobic conditions because they inhibit the biogas production. The alkyl polyglucoside having the shortest alkyl chain showed the fastest biodegradability and reached the higher percentage of final mineralization. The anaerobic process was well adjusted to a pseudo first-order equation using the carbon produced as gas during the test; also, kinetics parameters and a global rate constant for all the involved metabolic process were determined. This modeling is helpful to evaluate the biodegradation or the persistence of alkyl polyglucosides under anaerobic conditions in the environment and in the wastewater treatment.     

Ionic liquids as lubricants or lubrication additives: An ecotoxicity and biodegradability assessment

This paper reports on the (eco)toxicity and biodegradability of ionic liquids considered for application as lubricants or lubrication additives. Ammonium- and pyrrolidinium-based cations combined with methylsulphate, methylsulphonate and/or (CF₃SO₂)₂N⁻ anions were investigated in tests to determine their aquatic toxicity using water fleas Daphnia magna, green algae Selenastrum capricornutum and marine bacteria (Vibrio fischeri). Additional test systems with an isolated enzyme (acetylcholinesterase) and isolated leukaemia cells from rats (IPC-81) were used to assess the biological activity of the ionic liquids. These compounds generally exhibit low acute toxicity and biological activity. Their biodegradability was screened according to OECD test procedures 301 B and 301 F. For choline and methoxy-choline ionic liquids ready biodegradability was observed within 5 or 10 d, respectively. Some of the compounds selected have a considerable potential to contribute to the development of more sustainable products and processes.     

Comparison of bioluminescence and nitrification inhibition methods for assessing toxicity to municipal activated sludge

The aim of this study was to compare two alternative toxicity assessment methods to determine wastewater toxicity and predict treatment plant process upsets. The toxicity of two synthetic organic compounds (triclosan and 4-n-nonylphenol), which are commonly detected in municipal wastewater, and municipal and industrial wastewaters with different heavy metals content were evaluated by the nitrification inhibition assay and bioluminescence toxicity test. Comparison between both assays confirmed that Vibrio fischeri is generally more sensitive than autotrophic bacteria, and, if not calibrated, the bioluminescence method tends to overestimate toxic effects on activated sludge biomass. The nitrification inhibition assay appears to predict plant process upsets more accurately. Both methods showed a significant toxicity decrease through treatment that could be partially attributed to the significant heavy metals removal obtained by primary and secondary treatment. A good correlation for the two assays was obtained, as indicated by a high correlation coefficient (r2 = 0.80).     

Biodegradability of some antibiotics, elimination of the genotoxicity and affection of wastewater bacteria in a simple test

Most antibiotics and their metabolites are excreted by humans after administration and therefore reach the municipal sewage with the excretions. Only little is known about their biodegradability in aquatic environments. It was recognised that genotoxic substances may represent a health hazard to humans but also may affect organisms in the environment. Therefore, the biodegradability of some clinically important antibiotic drugs (ciprofloxacin, ofloxacin, metronidazole) and hereby the elimination of their genotoxicity was investigated as the first step of an environmental risk assessment using the Closed Bottle test (CBT) (OECD 301 D) and the SOS chromotest. Additionally, to assess toxicity of the antibiotics tested against aquatic bacteria (i) a growth inhibition test (GIT) with Pseudomonas putida was conducted, (ii) a toxicity control was used in the CBT and (iii) the colony forming units (CFUs) were monitored in the test vessels. Worst case concentrations of the antibiotics in hospital effluents were estimated and compared with minimum inhibitory concentrations for susceptible pathogenic bacteria and with the genotoxic potency in the SOS chromotest. Both the concentrations calculated for hospital effluents and the adverse effects in bacteria were in the same order of magnitude. None of the test compounds were biodegraded. The genotoxicity was not eliminated.