利用硫铁矿烧渣和硫酸铵废液制备铵铁蓝

将氨法制铁黄所产生的硫酸铵废液净化后,加入硫铁矿烧渣制备得到的硫酸亚铁得到硫酸亚铁和硫酸铵混合溶液,其硫酸亚铁和硫酸铵Ё浓度分别为0.346和0.173 mol·L-1.按照硫酸亚铁与亚铁氰化钠物质的量比为1.15:1,将硫酸亚铁和硫酸铵混合溶液加入浓度为0.200 mol·L-1的亚铁氰化钠溶液中,80℃下反应10 min得到白浆.将所得白浆在100℃下热煮1 h,加入质量分数为50%的硫酸溶液酸煮2 h,降温至70℃后加入质量分数为10%的氯酸钠溶液氧化3 h得到铁蓝.将铁蓝过滤、洗涤、干燥、研磨得到铵铁蓝粉末.实验所得铵铁蓝质量优于国家标准GB 1860-88及HG/T 3001-1999行业标准.SEM实验表明,铵铁蓝颗粒大小均匀、粒径约为20 nm;XRD实验表明,铵铁蓝具有与Fe4[Fe(CN)6]3相同的立方晶体结构.     

利用硫铁矿烧渣生产铁精粉的研究与探讨

针对辰溪县硫铁矿烧渣的利用现状,以硫铁矿烧渣为原料,制取铁精粉的新工艺进行探讨。通过对硫铁矿烧渣的筛选与理化处理,所得到的铁精粉其各相关指标均达到钢铁生产行业对铁精粉的质量要求。     

硫铁矿废水资源化制备纳米铁黑颜料

硫铁矿废水预处理除铝后作为二价铁源,添加一定量的氯化高铁作为三价铁源,以化学共沉淀法制备纳米铁黑颜料.通过考察nFe3+/nFe2+( 1.8～2.1)、反应温度(30～70℃)、反应溶液初始pH值(7.5～12.5)和反应时间(0～60 min),探索了资源化利用硫铁矿废水制备纳米铁黑颜料的较优工艺条件.结果表明:在...     

天然有机高分子絮凝剂壳聚糖制备工艺的改进

在壳聚糖的制备过程中,通过在稀酸脱钙阶段加入少量的助剂A,改过去室温浸泡16h～24h为30℃下搅拌3h,反应物质量比为10%HCl:助剂A:蟹(虾)壳=3.5:0.5:1;在浓碱脱乙酰基阶段加入少量助剂B,改过去115℃下反应6h为105℃下反应2h,反应物质量比为40%NaOH:助剂B:甲壳素=4:0.2:1,使壳聚糖的制备成本较原工艺下降了49%,制备时间缩短了1半,产品的主要性能参数(脱乙酰度、粘度、分子量等)均达到或超过美国Sigma公司同类产品(Chitosan,C-3646)的水平.     

硫酸渣制备高纯度硫酸亚铁

以高铁硫酸渣为原料,采用酸浸-还原-除杂-结晶一重结晶-干燥工艺,合成高纯度硫酸亚铁。通过反应温度、反应时间对硫酸渣中铁的浸出率的影响,以及结晶温度、干燥温度、干燥时间对硫酸亚铁产品纯度的影响做分析实验,得出最佳酸浸条件：硫酸渣与硫酸的固液比为1：3,硫酸质量分数为20％～25％,反应温度为80℃,反应时间为6h,搅拌强度为200r／min;最佳结晶精制条件：结晶溶液pH值为1-3,温度为60℃;除杂最佳条件：pH值约为4．5;冷却结晶温度控制在20℃,结晶干燥过程为30℃,干燥6h。     

冷热联用对市政脱水污泥低温干燥的影响

为探究冷热联用干燥市政脱水污泥的可行性,明确冷冻对市政脱水污泥低温干燥的影响,以市政脱水污泥为试验材料,利用扫描电镜（SEM）及流式细胞仪研究了冷冻对污泥的作用.考察了不同冷冻温度和冷冻时间对脱水污泥干燥特性的影响,并对不同含水率和厚度的脱水污泥冷热联用低温干燥效果进行了分析.结果表明：冷冻使污泥的内部微小孔隙增多.当冷冻温度降到-30℃时,细胞死亡率达到15.5%,是未冷冻时的9.7倍.当干燥温度为60℃,冷冻温度分别为-10℃、-20℃和-30℃时,脱水污泥完成干燥的时间分别缩短了25.0%、33.3%和29.2%.质量为5g±0.1g,厚度为3mm,直径为50mm的污泥样品冷冻6h后达到最大强化效果.污泥含水率的下降会导致强化效果减弱,当含水率降至45%时强化效果消失.增加泥饼厚度使强化效果小幅下降,5mm、10mm和15mm厚的泥饼强化效果分别为33.3%、31.3%和30.4%.     

硫铁矿烧渣制备PFS、PFPS及其除浊效果比较

以硫铁矿烧渣为原料，采用胶体分散法新工艺制备得到聚合硫酸铁（PFS），然后在PFS溶液中加入磷酸钠得到聚磷硫酸铁（PFPS）。研究了影响PFPS盐基度的因素，以及PFS、PFPS的除浊效果。结果表明，采用胶体分散法制备PFS的工艺独特，无污染物氮氧化物的产生。实验还表明，PFPS的絮凝效果明显好于PFS。PFPS投放量以及盐基度适宜时可达到最佳除浊效果。     

用硫铁矿烧渣制备的硫酸亚铁研制软磁用α-Fe_2O_3

介绍了利用硫铁矿烧渣制备的硫酸亚铁为原料制备高纯软磁用α Fe2 O3的基本原理、制备工艺 ,以及对工艺过程的影响因素进行了探讨 ,得到了制备高纯软磁用α Fe2 O3的适合条件 ,并对高纯软磁用α Fe2 O3的工业化生产做了经济估算     

电石渣和石灰对污泥的改性效果比较

在含水率为86.1%的脱水污泥中分别添加10%的电石渣和工业生石灰,其搅拌30min后及自然晾晒24,48,72,96,120 h后的含水率持续线性下降,自然晾晒120 h后可达到填埋标准;添加电石渣及石灰的污泥,其单位质量水分蒸发速率与原污泥有本质差异;两种改性剂均可使污泥比阻降低50%左右;经板框压滤机压滤出的泥饼...     

硫酸工业含砷污水处理试验研究

硫铁矿烧渣(俗称"红砂")是硫酸工业的固体废弃物,一般出售给钢厂。将红砂与硫酸混合后,通入氨水,得到氢氧化铁沉淀,氢氧化铁和硫酸反应生成硫酸亚铁。本试验证明了制取的硫酸亚铁可以作为很好的除砷剂,不仅具有良好的混凝除砷效果,而且使固体废物得到了综合利用。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.