20钢超塑性的获取

本文研究了20钢的超塑性。通过三次热循环处理,将供应状态热轧钢管坯料组织细化成4.43um,在(?)=1.25×10~(-4)S~(-1),T=750℃时,已获取最高延伸率δ=210.5％,否定了Marder认为亚共折钢不具有超塑性的观点,进一步扩大了Fe—C合金的超塑区域,并确定了最佳应变速率范围(?)=1×10(-1)S~(-1)～1.25×10~(-4)S~(-1),最佳超塑变形温度区域为740℃～750℃,同时研究了晶粒度对延伸率的影响。     

5CrMnMo钢的组织超塑性

5CrMnMo钢经热处理组织超细化后,在660～720℃、初始应变速率为(0.6～3.0)×10~(-2)分~(-1)的变形条件下,具有良好的超塑性:最终延伸率δ_T可达300～480％,最大流变应力σ_(max)仅40～50MPa,m值为0.4左右,成功地实现了铜触指热锻模型腔的超塑成形。     

工业用防锈铝合金板材的超塑性能研究

此文主要对工业牌号防锈铝合金板LF3、LF21进行了组织超塑性研究.结果表明,LF3防锈铝合金,在变形温度为470～510℃、ε_0=(5.56～11.1)×10~(-4)s~(-1)的试验条件下可实现超塑性;LF21防锈铝合金,在变形温度为510～540℃、ε_0=(5.56～8.83)×10~(-4)s~(-1)的试验条件下具有超塑性.     

循环热处理对高速钢超塑性的影响

此文研究了循环热处理工艺对W6Mo5Cr4V2钢超塑性的影响.结果表明:该钢在1040℃两次循环淬火是实现其超塑性的最佳热处理工艺;按此工艺进行预处理后,在810℃、初始应变速率为5.56×10~(-1)s~(-1)的条件下,该钢的超塑延伸率可达187%.     

高应变速率反挤压超塑Zn-Al_(22)合金管材

此文简要地叙述了工业性试生产Zn-Al_(22)超塑性管材的工艺流程。采用慢速等液面浇注法和几次均匀化处理实现晶粒细化。在ε=2×10~(-2)S~(-1)的高应变速率下进行反挤压Φ49×2.25×250mm管材1200只,超塑性能最高值δ=1620％,流变应力σ_b=2.36MPa。     

长江口及毗邻海区水中悬浮颗粒汞的形态分布

本文报道了1986年1月和7月份长江口海区水体悬浮颗粒态汞化学形态分析结果。长江口毗邻海区悬浮颗粒态汞含量范围1月份4.0～37.7ng·L-1,7月份0.04-14.8ng·L-1。长江有潮河段和冲淡水主轴一带水中悬浮颗粒汞的化学形态分布,其浓度和百分含量分别是:水溶态(0.003-0.008)×10～6,百分含量0.9-7.4％;可交换态(0.001-0.017)×10～6;百分含量0.4-8.0％;碳酸盐结合态(0.005-0.026)×10-6,百分含量2.4-19.5％;腐殖酸结合态(0.039-0.179)×10～6,百分含量42.1～69.3％;氧化有机结合态(0.016-0.127)×10-6,百分含量14.1-38.3％;残渣态(0.008-0.045)×10-5,百分含量4.2-18.0％。腐殖酸结合态是悬浮颗粒态汞的主体。百分含量顺序是腐殖酸结合态>氧化有机结合态>残渣态>碳酸盐结合态>可交换态>水溶态。     

变形镁合金晶粒细化及热处理后的组织和性能

通过变形方法细化晶粒提高镁合金塑性。大挤压比(100:1)可获得细晶镁合金挤压薄板,其晶粒尺寸为2.5～12.5μm;大挤压比+轧制确保合金获得平均晶粒尺寸小于5μm的细晶镁合金薄板。通过优化再结晶退火制度使合金具有最佳的组织结构和良好的力学性能。在523K保温20min后细晶(晶粒尺寸小于12.5μm)镁合金板材具有良好的热拉深性能,能成功拉深出质量完好的筒形件,而晶粒尺寸大于25μm,出现不良的热拉深现象。     

蜂窝陶瓷催化臭氧化降解水中微量硝基苯的动力学研究

实验表明单独臭氧氧化和臭氧/蜂窝陶瓷氧化在温度20℃、初始pH值6.87条件下对硝基苯的降解均遵循一级反应动力学模型,该条件下单独臭氧氧化和臭氧/蜂窝陶瓷氧化工艺对硝基苯的降解主要来源于高活性羟基自由基的氧化作用,同时证明了不同体系温度（10～40℃）和溶液初始pH值（3.00～10.96）下硝基苯的降解同样符合一级反应动力学.2种工艺对硝基苯的降解反应速率都随着温度的升高而增加,单独臭氧氧化的反应速率常数由0.37×10^-3 s^-1升高到1.49×10^-3 s^-1,臭氧/蜂窝陶瓷氧化的反应速率常数由0.56×10^-3 s^-1升高到2.46×10^-3 s^-1,温度越高反应速率提高的幅度却越小.随着pH的升高,单独臭氧氧化对硝基苯降解的反应速率常数从0.15×10^-3 s^-1增加到2.69×10^-3 s^-1,在pH值3.00～9.23范围内,臭氧/蜂窝陶瓷氧化工艺反应速率常数从0.17×10^-3 s^-1增加到1.90×10^-3 s^-1,在pH为10.96时反应速率常数下降到1.64×10^-3 s^-1.     

废水中乙醛的化学发光法测定

乙醛发光分析法的检出限为8×10~(-11)g/ml,线性范围为5×10~(-10)g/ml-1×10~(-6)g/ml.对近30种常见无机物和有机物对乙醛测定的影响进行了试验,表明该方法具有良好的选择性.用于有机化工和印染废水中乙醛的测定,其回收率为94％～100％,变异系数为1.6％—6.4％。     

大别山东南麓韧性剪切构造带

广济县四望、松山咀和黄梅县大河、苦竹及宿松县界岭、二郎河一线存在一条规模较大的平移—推覆型韧性剪切带,其延60余公里,宽约5—15km。该带中糜棱岩岩石的斑晶及眼球体压力影不对称、重结晶石英斜列方式及微褶皱形态特征反映出以左旋剪切作用为主。有限应变沿x方向最大拉伸量为170％,沿z方向最大缩短量为57％。中心部位的糜棱岩明显经历了热加工—恢复作用阶段,是深层次韧性剪切的产物,古差异应力平均值为158.76MPa,应变速率为3.67×10~(-11)～6.17×10~(-12)sec~(-1)。晚期又遭受了脆性薄皮冲断作用。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.