Application of Klebsiella oxytoca immobilized cells on the treatment of cyanide wastewater

Klebsiella oxytoca, isolated from cyanide-containing industrial wastewater, has been shown to be able to biodegrade cyanide to non-toxic end products. The technology of immobilized cells can be applied in biological treatment to enhance the efficiency and effectiveness of biodegradation. In this study, potassium cyanide was used as the target compound and both alginate and cellulose triacetate techniques were applied for the preparation of immobilized cells. Results from this study show that KCN can be utilized as the sole nitrogen source by K. oxytoca. The free suspension systems reveal that the cell viability was highly affected by initial KCN concentration and pH. Results show that immobilized cell systems could tolerate a higher level of KCN concentration and wider ranges of pH. In the batch experiments, the maximum KCN removal efficiencies using alginate and cellulose triacetate immobilized beads were 0.108 and 0.101mM h(-1) at pH 7, respectively. Results also indicate that immobilized system can support a higher biomass concentration. Complete KCN degradation was observed after the operation of four consecutive degradation experiments with the same batch of immobilized cells. This suggests that the activity of immobilized cells can be maintained and KCN can be used as the nitrogen source throughout KCN degradation experiments. The maximum KCN removal rates using alginate and cellulose triacetate immobilized beads in continuous-column system were 0.224 and 0.192mMh(-1) with initial KCN concentration of 3mM, respectively. Results indicate that the immobilized cells of K. oxytoca would be applicable to the treatment of cyanide-containing wastewaters.     

固定化降解菌Q5去除喹啉的性能研究

为了研究固定化微生物在土壤生物修复中的应用,以实验室筛选出来的高效降解菌 Q5 为生物活性物质,利用生物大分子仿生合成出的纳米多孔氧化硅为载体,通过表面吸附同定化方法将其固定,制备出固定化微生物.考察固定化微牛物初始 pH 值、温度、摇床转速和菌种的接种量对喹啉去除的影响,得到适宜的去除条件,在相同条件下比较固定化微生物与游离菌种对底物的去除情况,研究单一固定化菌种对不同浓度的喹啉的去除情况,考察固定化微生物的稳定性.实验结果表明,菌株 Q5 经固定化后,对喹啉的去除能力大大增强,在 500 mg/L 浓度下,40 h 固定化 Q5 对底物去除率达96.6%,远高于未固定化 Q5 的去除率 56.1%;对于高底物浓度,固定化微生物的去除效果明显,初始底物浓度为1 500 mg/L,反应 70 h 后去除率为 91.6%,且这种固定化微生物的重复使用性能良好.     

Alginate immobilized enrichment culture for atrazine degradation in soil and water system

An atrazine degrading enrichment culture, a consortium of bacteria of genus Bacillus along with Pseudomonas and Burkholderia, was immobilized in sodium alginate and was used to study atrazine degradation in mineral salts medium (MSM), soil and wastewater effluent. Sodium alginate immobilized consortium, when stored at room temperature (24 ± 5°C), was effective in degrading atrazine in MSM up to 90 days of storage. The survival of bacteria in alginate beads, based on colony formation unit (CFU) counts, suggested survival up to 90 days and population counts decreased to 1/5^th on 120 days. Comparison of atrazine degrading ability of the freely suspended enrichment culture and immobilized culture suggested that the immobilized culture took longer time for complete degradation of atrazine as a lag phase of 2 days was observed in the MSM inoculated with alginate immobilized culture. The free cells resulted in complete degradation of atrazine within 6 days, while immobilized cells took 10 days for 100% atrazine degradation. Further, immobilized cultures were able to degrade atrazine in soil and wastewater effluent. Alginate beads were stable and effective in degrading atrazine till 3rd transfer and disintegrated thereafter. The study suggested that immobilized enrichment culture, due to its better storage and application, can be used to degrade atrazine in soil water system.     

Enhanced degradation of 2-nitrotoluene by immobilized cells of Micrococcus sp. strain SMN-1

Nitrotoluenes are the toxic pollutants of the environment because of their large scale use in the production of explosives. Biodegradation of such chemicals by microorganisms may provide an effective method for their detoxification. We have studied the degradation of 2-nitrotoluene by cells of Micrococcus sp. strain SMN-1 immobilized in various matrices such as polyurethane foam (PUF), sodium alginate (SA), sodium alginate–polyvinyl alcohol (SA–PVA), agar and polyacrylamide. The rate of degradation of 15 and 30 mM 2-nitrotoluene by freely suspended cells and immobilized cells in batches and fed-batch with shaken cultures were compared. The PUF-immobilized cells achieved higher degradation of 15 and 30 mM 2-nitrotoluene than freely suspended cells and the cells immobilized in SA–PVA, polyacrylamide, SA and agar. The PUF-immobilized cells could be reused more than 24 cycles without loosing their degradation capacity and showed more tolerance to pH and temperature changes than freely suspended cells. These results revealed the enhanced rate of degradation of 2-nitrotoluene by PUF-immobilized cells of Micrococcus sp. strain SMN-1.     

Biosorption of Cr(VI) by free and immobilized Pediastrum boryanum biomass: equilibrium, kinetic, and thermodynamic studies

Background and purpose

The biosorption of Cr(VI) from aqueous solution has been studied using free and immobilized Pediastrum boryanum cells in a batch system. The algal cells were immobilized in alginate and alginate?Cgelatin beads via entrapment, and their algal cell free counterparts were used as control systems during biosorption studies of Cr(VI).

Methods

The changes in the functional groups of the biosorbents formulations were confirmed by Fourier transform infrared spectra. The effect of pH, equilibrium time, initial concentration of metal ions, and temperature on the biosorption of Cr(VI) ion was investigated.

Results

The maximum Cr(VI) biosorption capacities were found to be 17.3, 6.73, 14.0, 23.8, and 29.6?mg/g for the free algal cells, and alginate, alginate?Cgelatin, alginate?Ccells, and alginate?Cgelatin?Ccells at pH?2.0, which are corresponding to an initial Cr(VI) concentration of 400?mg/L. The biosorption of Cr(VI) on all the tested biosorbents (P. boryanum cells, alginate, alginate?Cgelatin, and alginate?Ccells, alginate?Cgelatin?Ccells) followed Langmuir adsorption isotherm model.

Conclusion

The thermodynamic studies indicated that the biosorption process was spontaneous and endothermic in nature under studied conditions. For all the tested biosorbents, biosorption kinetic was best described by the pseudo-second-order model.     

内循环管式光催化反应器降解水中喹啉的动力学研究

采用内循环管式光催化反应器,考察不同的温度、有机物底物浓度、光照强度、曝气强度等因素对水中喹啉的降解效果影响,在此基础上进行降解动力学研究。实验结果表明:温度、喹啉初始浓度、光照强度、曝气强度等因素与喹啉的催化降解呈现良好的相关关系,喹啉的表观吸附平衡常数为0.0244 L/mg,溶解氧表观吸附平衡常数为2.11,反应活化能为16.734 kJ/mol,光照强度修正指数为0.525。     

固定化菌藻微球的制备、表征及其对富营养化湖水的修复

以聚乙烯醇(PVA)和海藻酸钠(SA)为主要包埋材料,以活性炭、SiO2和CaCO3作添加剂,采用普通小球藻(Chlorella vulgaris)和活性污泥制备固定化菌藻微球。采用正交实验对微球的制备条件进行了优化,并对最优化条件下制得的微球进行了表征,还考察了固定化菌藻微球对某富营养化湖水的修复效果。结果表明,固定化菌藻微球的最优化制备条件为:PVA用量10%(m/v),微生物包埋量15 mL,海藻酸钠用量0.6%(m/v),氯化钙浓度2.0%(m/v)。制得的微球具有较大的比表面积,内部呈网状结构,孔径分布均匀,中孔居多,适合小球藻和微生物生长。采用固定化菌藻微球可有效修复上述湖泊的实际富营养化湖水,微球可重复使用3~4个循环,在前4个循环中,每个循环历时96 h,TN平均去除率达80%以上;TP平均去除率达90%以上;COD平均去除率达85%以上,表明固定化菌藻微球在富营养化湖水的修复方面具有潜在的应用价值。     

Repeated batch and continuous degradation of chlorpyrifos by Pseudomonas putida

The present study was undertaken with the objective of studying repeated batch and continuous degradation of chlorpyrifos (O,O-diethyl O-3,5,6-trichloropyridin-2-yl phosphorothioate) using Ca-alginate immobilized cells of Pseudomonas putida isolated from an agricultural soil, and to study the genes and enzymes involved in degradation. The study was carried out to reduce the toxicity of chlorpyrifos by degrading it to less toxic metabolites. Long-term stability of pesticide degradation was studied during repeated batch degradation of chlorpyrifos, which was carried out over a period of 50 days. Immobilized cells were able to show 65% degradation of chlorpyrifos at the end of the 50th cycle with a cell leakage of 112 × 10³ cfu mL^?1. During continuous treatment, 100% degradation was observed at 100 mL h^?1 flow rate with 2% chlorpyrifos, and with 10% concentration of chlorpyrifos 98% and 80% degradation was recorded at 20 mL h^?1 and 100 mL h^?1 flow rate respectively. The products of degradation detected by liquid chromatography–mass spectrometry analysis were 3,5,6-trichloro-2-pyridinol and chlorpyrifos oxon. Plasmid curing experiments with ethidium bromide indicated that genes responsible for the degradation of chlorpyrifos are present on the chromosome and not on the plasmid. The results of Polymerase chain reaction indicate that a ~890-bp product expected for mpd gene was present in Ps. putida. Enzymatic degradation studies indicated that the enzymes involved in the degradation of chlorpyrifos are membrane-bound. The study indicates that immobilized cells of Ps. putida have the potential to be used in bioremediation of water contaminated with chlorpyrifos.     

Kinetics of quinoline degradation by O3/UV in aqueous phase

The kinetics of quinoline degradation by O3/UV in aqueous phase was studied in this paper. It was found that the stoichiometric factor for the number of ozone molecule consumed by per quinoline molecule was 1. The second-order rate constants at 15 degrees C for the direct reaction of quinoline with ozone and that for the reaction of quinoline with *OH were determined to be 51.0 and 7.24 x 10(9) M(-1)s(-1), respectively. In O3/UV reaction system, *OH was the more important oxidant to degrade quinoline than ozone. For a comparison, in O3 reaction system, the relative importance of the two oxidants depended on the pH value greatly. To make the degradation of quinoline more practical, improvement of the concentration of *OH is more feasible.     

4种固定化藻类对污水中氮的净化能力研究

取培养至对数末期的藻，采用海藻酸钙凝胶包埋固定，对人工污水进行静态模拟净化试验，研究了蛋白核小球藻、鱼腥藻、双对栅藻和突变衣藻4种藻在固定和悬浮状态下，对污水中的氨氮和硝酸氮的净化效率以及藻类的生长特性。结果表明：固定化藻细胞比悬浮态藻细胞具有生长更趋于稳定、藻类的活性保持时间更长的优势。4种藻类中，小球藻和鱼腥藻在污水中的生长状况更好，较适宜采用海藻酸钙凝胶包埋固定化技术。实验第5 d时，固定化小球藻、鱼腥藻、双对栅藻和衣藻对NH₃-N去除率分别为91.9%、84.8%、68.3%和51.2%；对NO^-₃-N的去除率分别为85.1%、100%、96.9%和65.9%。固定化小球藻对NH₃-N的去除效果最好，而固定化鱼腥藻对NO^-₃-N的去除效果最好。因此，小球藻和鱼腥藻更适用于去除污水中的氮，具有很好的应用前景。     

Bioaugmentation with a Bacillus sp. to reduce the phytoavailable Cd of an agricultural soil: comparison of free and immobilized microbial inocula

In order to reduce the cadmium potentially available for plants, soil bioaugmentation was performed by using a Bacillus sp. In a pot experimentation, sterilized and non-sterilized soils were inoculated using free or immobilized cells entrapped in alginate beads. This test was carried out with different inoculum sizes (2 x 10(10) and 2 x 10(11)CFU kg(-1) dw of soil) and alginate bead compositions (10 and 15 g of both alginate and CaCl(2) l(-1)). Then, the soil pots were incubated at 20 degrees C and the soil humidity was kept at a level of 20%. After 3 weeks of a batch incubation, the potentially phytoavailable Cd was reduced up to a factor of 14. The bioaugmentation resulted in the soil colonization by Bacillus sp. thanks to an increase of the cell concentration up to 1.8 log units. However, in comparison to the cells being inoculated in a free mode, the immobilization of the cells did not significantly improve the survival of the cells in the soil. Although the resulting effect not being highly pronounced, the potentially phytoavailable Cd correlated with the cell concentration in a surprisingly positive way. What is more, the Bacillus concentrations in the soil were positively correlated with the inoculum, too.     

固定化原油降解菌的制备及其性能研究

从石油污染土壤中筛选出的石油降解菌Y-13对石油的降解率为57.45%,经初步鉴定为芽孢杆菌属,以Y-13为固定化对象,选择聚乙烯醇(PVA)、海藻酸钠(SA)为主要载体材料,以胜利原油为反应底物,研究了固定化微球的制备和运行条件对微球性能的影响,实验确定了PVA-H3BO3包埋法制备固定化微球的最佳条件,最高降解率为79.04%;对PVA-H3BO3微球的性能测定结果表明:这种固定化微球具有良好的机械强度、弹性和渗透性、较高的比表面积和孔容;固定化微球比游离细菌对外界的适应性要强,适宜pH值、接种量和活化时间分别为7.5、1∶10和21 h。     

Treatment of phenol-containing wastewater by photoelectro-Fenton method using supported nanoscale zero-valent iron

This study presents the degradation of phenol by the photoelectro-Fenton method using nano zero-valent iron (nZVI) immobilized in polyvinyl alcohol–alginate beads. The effect of nZVI loading, H₂O₂ concentration, pH, and initial phenol concentration on phenol degradation and chemical oxygen demand reduction was studied. The scanning electron microscope images of the nZVI beads were used to analyze their morphology, and their diameters were in the range of 500–600 μm. The concentration of nZVI in the beads was varied from 0.1 to 0.6 g/L. Fe²⁺ leakage of 1 and 3 % was observed with 0.5 and 0.6 g/L of nZVI, respectively, and the observed beads' fracture frequency was 2 %, which confirmed the stability of the beads. The optimum operating conditions that arrived for better degradation were 0.5 g/L of nZVI, pH 6.2, and 400 mg H₂O₂/L. The treatment of effluent by this method increased the biodegradability index of the effluent, and the degradation data were found to follow pseudo first-order kinetics.     

聚乙烯醇-海藻酸钠固定铜绿微囊藻对磷的吸附

利用聚乙烯醇与海藻酸钠固定包埋铜绿微囊藻,通过正交实验获得聚乙烯醇溶液浓度、海藻酸钠溶液浓度及铜绿微囊藻液量去除磷的最佳配比,研究溶液起始pH值、反应时间、磷初始浓度对固定化小球吸附磷的影响。结果表明,固定化小球的最佳制备条件为聚乙烯醇质量分数6%,海藻酸钠质量分数0.5%及铜绿微囊藻浓度2×107个/mL;固定化小球吸附磷的最适起始pH值为6～8,吸附达到平衡的时间为9～12 d,初始磷浓度为1.00 mg/L时去除率最高,达到79.19%。     

Optimisation of decolourisation and degradation of Reactive Black 5 dye under electro-Fenton process using Fe alginate gel beads

The aim of this work was to improve the ability of the electro-Fenton process using Fe alginate gel beads for the remediation of wastewater contaminated with synthetic dyes and using a model diazo dye such as Reactive Black 5 (RB5). Batch experiments were conducted to study the effects of main parameters, such as voltage, pH and iron concentration. Dye decolourisation, reduction of chemical oxygen demand (COD) and energy consumption were studied. Central composite face-centred experimental design matrix and response surface methodology were applied to design the experiments and to evaluate the interactive effects of the three studied parameters. A total of 20 experimental runs were set, and the kinetic data were analysed using first-order and second-order models. In all cases, the experimental data were fitted to the empirical second-order model with a suitable degree for the maximum decolourisation of RB5, COD reduction and energy consumption by electro-Fenton–Fe alginate gel beads treatment. Working with the obtained empirical model, the optimisation of the process was carried out. The second-order polynomial regression model suggests that the optimum conditions for attaining maximum decolourisation, COD reduction and energy consumption are voltage, 5.69 V; pH 2.24 and iron concentration, 2.68 mM. Moreover, the fixation of iron on alginate beads suggests that the degradation process can be developed under this electro-Fenton process in repeated batches and in a continuous mode.     

固定化解脂耶氏酵母间歇式处理油脂废水研究

固定化解脂耶氏酵母菌(Yarrowia lipolytica)在气升式反应器中处理色拉油浓度为2 000 mg/L、COD为3 000 mg/L的高COD油脂废水。结果表明,固定化菌对废水的最佳处理时间为6 d,可间歇式处理9批次高COD油脂废水,重复处理废水后,其对油脂的降解均在85%以上,对COD的降解在70%以上,降解后的排出水pH稳定在3.6~3.8。且处理动力学方程属于一级生化方程。结果进一步表明,固定化解脂耶氏酵母菌在气升式反应器中适于处理高COD含油脂的污水。     

同分异构体喹啉和异喹啉的缺氧降解性能比较

研究了同分异构体的含氮杂环化合物喹啉和异喹啉在缺氧条件下的降解情况,发现两者表现出不同的缺氧降解特性。喹啉可以在缺氧条件下得到有效降解,其缺氧降解的最佳碳氮比为8。在最佳碳氮比条件下,喹啉的缺氧降解过程符合一级动力学规律,在其降解过程中首先以硝酸盐为电子受体,当硝酸盐氮浓度为零时,亚硝酸盐氮浓度达到最高,此后喹啉的降解主要以亚硝酸盐为电子受体,并和亚硝酸盐氮同时达到最低浓度。异喹啉对硝酸盐的利用甚微,其降解主要表现为厌氧降解特征,降解过程符合零级动力学规律。     

Effect of immobilized microalgal bead concentrations on wastewater nutrient removal

A unicellular green microalga, Chlorella vulgaris, entrapped in calcium alginate as algal beads were employed to remove nutrients (N and P) from simulated settled domestic wastewater. A significantly higher nutrient reduction was found in bioreactors containing algal beads (at concentrations ranging from 4 to 20 beads ml(-1) wastewater) than the blank alginate beads (without algae). A complete removal of NH(4)(+)-N and around 95% reduction of PO(4)(3-)-P was achieved within 24 h of treatment in bioreactors having the optimal algal bead concentration (12 beads ml(-1), equivalent to 1:3 algal beads:wastewater, v/v). The NH(4)(+)-N removal was significantly lower at low (around 4 beads ml(-1)) and high (>15 beads ml(-1)) algal bead concentrations. On the other hand, the effect of bead concentration on phosphate removal was less obvious, and bead concentrations ranging from 8 to 20 beads ml(-1) showed comparable percentages of phosphate reduction. Algal uptake and adsorption on alginate gels were found to be the major processes involved in the removal of N and phosphate in the present study. In addition, NH(4)(+)-N could be lost via ammonia volatilization while PO(4)(3-)-P was removed by chemical precipitation, as alkaline pH was recorded in the immobilized microalgal treatment system.     

Bio-beads with immobilized anaerobic bacteria,zero-valent iron,and active carbon for the removal of trichloroethane from groundwater

Chlorinated hydrocarbons are the most common organic pollutants in groundwater systems worldwide. In this study, we developed bio-beads with immobilized anaerobic bacteria, zero-valent iron (ZVI), and activated carbon (AC) powder and evaluated their efficacy in removing 1,1,1-trichloroethane (TCA) from groundwater. Bio-beads were produced by polyvinyl alcohol, alginate, and AC powder. We found that the concentration of AC powder used significantly affected the mechanical properties of immobilized bio-beads and that 1.0 % (w/v) was the optimal concentration. The bio-beads effectively degraded TCA (160 mg L^?1) in the anaerobic medium and could be reused up to six times. The TCA degradation rate of bio-beads was 1.5 and 2.3 times greater, respectively, than ZVI + AC treatment or microbes + AC treatment. Measuring FeS produced by microbial reactions indicated that TCA removal occurred via FeS-catalyzed dechlorination. Analysis of clonal libraries derived from bio-beads demonstrated that the dominant species in the community were Betaproteobacteria and Gammaproteobacteria, which may contribute to the long-term stability of ZVI reactivity during TCA dechlorination. This study shows that the combined use of immobilized anaerobic bacteria, ZVI, and AC in bio-beads is effective and practical for TCA dechlorination and suggests they may be applicable towards developing a groundwater treatment system for the removal of TCA.     

Fe3+(NTA)还原菌的固定化小球制备及还原特性

采用海藻酸钠包埋驯化得到的优势铁还原菌，用于还原络合吸收法脱除NOx过程中形成的中间副产物Fe³⁺(NTA)。结果表明，最佳包埋条件为海藻酸钠质量浓度4%，菌体质量浓度0.2%，CaCl₂质量浓度3%，此条件下制备的小球还原性能好，在微生物用量为20 g（湿重）/L时还原10 mmol/L Fe³⁺(NTA)，经12 h反应后还原率达到96.1％，而相同条件下游离微生物的还原率仅为11.8％，但反应16 h后游离微生物与固定化小球的还原率相近，均为97％左右。但此法制备的小球机械强度不高，溶胀、破裂现象严重。通过添加聚乙烯醇和硅藻土改良固定化小球，可强化小球的机械强度、降低小球的溶胀及破裂现象，对Fe³⁺(NTA)的还原效果也较改良前的小球有所提高，两者最佳添加量均为20 g/L。改良后的小球与游离微生物相比，耐酸性增强，在pH=5的条件下，仍具有79.8％的还原效率，远高于相同条件下游离微生物的39.5％，但对温度的适应范围两者基本一致。