Effectiveness of a cooling jacket with reference to physiological responses in iron foundry workers

Personal cooling garments (PCGs) have gained increased attention in recent years due to heat stress and strain in the working environment. The present study was conducted in hot environments of an iron foundry to evaluate the efficacy of a battery-operated PCG. Twenty-four workers were exposed to climatic conditions of 35.89?±?1.25?°C, 35% relative humidity during 90-min work with PCG and habitual clothing (HC). Mean weighted skin temperature was significantly lower by 4.84?±?1.05?°C compared with HC 0.38?±?1.02?°C (p?p?相似文献   

Human Adaptation to Work in Two Different Climates

The processes of acclimation to hot-dry and to warm-humid climates were studied using two approaches: a quantitative analysis of literature data and an experimental study in the laboratory concerning the physiological parameters of heart rate, rectal temperature, sweat loss, and subjective assessment.

Analysis o f literature data: Data from 62 experiments with a total of 813 participants were pooled and recalculated. The experiments ranged from 6 to 24 days, air temperatures from 30.4 to 50.0°C, water vapor pressures from 1.5 to 6.5 kPa, and wet bulb globe temperatures (WBGT) from 27.4 to 38.6°C.

Laboratory studies: In the laboratory, 8 participants were acclimated during 15 consecutive days to a hot-dry climate and to a warm-humid climate, which were equivalent in terms of the WBGT (33.5 and 33.6°C, respectively). The participants walked four times for 25 min on a treadmill at a speed of 4 km/h. The hot-dry climate caused somewhat greater strain than the warm-humid condition. In the course of acclimation to the hot-dry climate, heart rate and rectal temperature started at higher levels, decreased slightly steeper but remained on a higher level throughout. Nevertheless, the differences between both thermal conditions were small, and both physiologic functions reached the point of acclimation almost at the same time under warm-humid and under hot-dry exposure. Sweat loss, which is not regarded as a valid predictor for acclimation, was considerably higher but increased less in the hot-dry than in the warm-humid climate.     

Effects of workplace thermal conditions on safe work behavior

The effect of workplace thermal conditions on worker safety has not previously been adequately investigated, due in part to the difficulty of defining a suitable safety performance measure. This report describes a study conducted in two industrial plants to determine if a correlation exists between the safety-related behavior of workers and workplace thermal conditions. Both heat exposure measurements and behavioral observations were taken over a 14-month period, for a total of over 17,000 observations. The results indicate that temperatures below and above those typically preferred by most people have a significantly detrimental effect on the safety-related behavior of workers. This is demonstrated by an index based on the ratio of observed unsafe behaviors to the total number of observed behaviors. The relationship between this index of unsafe behavior and the ambient temperature formed a U-shaped curve. The minimum unsafe behavior index occurred within the zone of preferred temperature (approximately 17°C to 23°C, WBGT). Other factors such as metabolic workload and time during the shift also had significant effects on worker safety-related behavior.     

Ergonomics in Practice: Physical Workload and Heat Stress in Thailand

This study consists of assessments of the thermal environment and physio-logical strain in tasks associated with airport, construction, and metal jobs. The number of male and female participants was 108. Environmental heat stress was evaluated with the WBGT index. Physiological strain was evaluated by the relative cardiovascular load (%CVL) based on the measurements of heart rate. Also the increase of body temperature, weight loss, and perceived discomfort were determinated. At work sites the assessments lasted for 2 to 4 hrs for each participant. The mean physiological strain exceeded the level of 30%CVL. Severe peaks (over 60%CVL) were observed in specific tasks being in agreement with perceived discomfort ratings. The increase of body temperature and weight loss in most cases remained within acceptable limits. For the most strenuous tasks, various ergonomic improvements were developed in consultation with workers and managers.     

Physiological and perceptual strain of firefighters during graded exercise to exhaustion at 40 and 10 °C

Purpose. To study whether perceptual identification should be included as a measure to evaluate physiological stress. Methods. Physiological variables oxygen uptake (V_O2), ventilation, heart rate, blood lactate concentration, rectal temperature (T_rec) and mean skin temperature, and perceptual variables rate of perceived exertion, thermal sensation and time to exhaustion, were measured at submaximal and maximal intensities during graded exercise on a treadmill to exhaustion in 12 firefighters wearing protective clothing and extra mass at 40 and 10 °C. Physiological strain index (PhSI) and perceptual strain index (PeSI) were calculated. Results. Apart from T_rec, all physiological and perceptual variables were higher at submaximal intensities of 40 °C. Time to exhaustion was 16% shorter and the corresponding V_O2 was reduced by 7% in the heat. A high correlation (r?=?89) between PhSI and PeSI was found at both temperatures. PeSI scores were equal to PhSI at both ambient temperatures, except at the two highest intensities in the heat, where PeSI was higher. Conclusions. These findings support use of perceptual identification to evaluate physiological stress. However, at very high intensities under hot conditions the perceptual strain was estimated higher than the physiological strain. More precise indexes are needed to include perceptual measures in safety standard.     

Multiple dimensions of work-related risk factors and their relationship to work ability among industrial workers in Iran

Objectives. The present study was designed to investigate the simultaneous effects of physical, psychosocial and other work-related risk factors on the work ability index (WAI) score among industrial workers. Methods. This study used a cross-sectional design with a questionnaire survey. A total of 280 workers were included in the study. Data were collected using three questionnaires including the Persian version of the WAI, the Persian version of the job content questionnaire and an author-developed measure (to assess work-related factors, health-related factors and socio-demographic characteristics). Results. The majority of the participants were young, but they had poor WAI scores (mean 37.3?±?6.4) and 44.3% of them had poor or moderate work ability. Occupational accidents and injuries were found to be the strongest predictors of WAI scores. Additionally, there was a strong association between WAI scores and supervisor support, skill discretion, occupational training, sleep quality, work nature and educational level. Conclusions. Intervention programs should focus on improving supervisor support, sleep quality, job skills and knowledge and on decreasing physical and mental work demands. Additionally, implementing a comprehensive occupational health and ergonomics program for controlling and reducing hazardous working environments and occupational injury rates should be considered.     

Effects of physical exercise on musculoskeletal disorders,stress and quality of life in workers

Background. The effect of physical exercise in the workplace (PEW) on health promotion of workers is contradictory. Objective. To evaluate the effects of the PEW in musculoskeletal disorders (MSDs), perception of stress and quality of life in workers. Methods. The participants were divided into two groups: control group (n?=?46) including non-participant workers of the PEW program, and PEW group (n?=?50) including workers who regularly participate in the exercise program. All workers answered the Nordic general questionnaire, the perceived stress scale and the quality-of-life questionnaire. Results. The PEW group reported a lower prevalence of MSDs for the trunk in the last 7 days and 12 months (p?=?0.021 and p?=?0.001, respectively), and for the upper limbs in the last 12 months (p?=?0.001) compared with the control group. The results for the perception of stress and quality of life showed no significant differences between the groups. Conclusion. PEW is a potential method to reduce MSDs in workers, but it was not efficient in reducing stress levels or improving the quality of life of the workers.     

高温户外环境电网作业人员热应激预测评价*

为了预测分析户外高温环境下电网作业人员热安全风险,采用预测热应激（Predicted Heat Strain,PHS）模型,考虑人体基础代谢率个体差异性和人体移动与风速对服装热阻和湿阻的影响,应用改进后的预测热应激模型对多种户外高温作业环境工况和不同劳动强度下电网作业人员的核心体温、出汗量等生理参数和最大允许暴露时长进行计算分析。结果表明:在户外高温环境中,随着环境温度、相对湿度和新陈代谢率的升高,电网作业人员的核心体温也随之升高,湿热环境中风速的增加会加剧电网作业人员的热应激;当电网作业人员从事代谢率为240 W/m2高劳动强度工作时,可接受的最大工作时长相比代谢率为190 W/m2中度劳动强度工作时长减小50%以上。研究结果可为电网公司夏季户外工作组织策略制定和作业人员热安全防护提供参考支持。     

CAERvest® – a novel endothermic hypothermic device for core temperature cooling: safety and efficacy testing

Introduction. Cooling of the body is used to treat hyperthermic individuals with heatstroke or to depress core temperature below normal for neuroprotection. A novel, chemically activated, unpowered cooling device, CAERvest®, was investigated for safety and efficacy. Methods. Eight healthy male participants (body mass 79.9?±?1.9?kg and body fat percentage 16.1?±?3.8%) visited the laboratory (20 °C, 40% relative humidity) on four occasions. Following 30-min rest, physiological and perceptual measures were recorded. Participants were then fitted with the CAERvest® proof of concept (PoC) or prototype 1 (P1), 2 (P2) or 3 (P3) for 60 min. Temperature, cardiovascular and perceptual measures were recorded every 5 min. After cooling, the CAERvest® was removed and the torso checked for cold-related injuries. Results. Temperature measures significantly (p?Conclusion. This study demonstrates that the CAERvest® is an effective device for reducing body temperature in healthy normothermic individuals without presence of cold injury. Further research in healthy and clinical populations is warranted.     

Infrared thermography reveals effect of working posture on skin temperature in office workers

Introduction. Musculoskeletal symptoms related to using traditional computer workstations are common. Quantitative methods for measuring muscle stress and strain are needed to improve ergonomics of workstations. We hypothesize that infrared thermography (IRT) is suited for this purpose. Methods. This hypothesis was evaluated by estimating muscle activity in upright and traditional working postures with IRT and surface electromyography (sEMG). IRT and sEMG measurements were conducted in 14 female participants with both working postures. First, measurements with the traditional posture were performed. Later, participants had 1?month to adjust to the upright working posture before repeating the measurements. IRT images were acquired before and after a full working day, with sEMG recordings being conducted throughout the measurement days. Participants evaluated their neck pain severity using neck disability index (NDI) questionnaires before the first and after the second measurement day. Results. Spatial variation in upper back temperature was higher (p?=?0.008) when working in traditional posture and the upright working posture reduced (p?p?=?0.003) after working in the upright posture. Conclusion. IRT was found suitable for evaluating muscle activity and upright working posture to reduce the NDI and muscle activity in the upper back.     

A ventilation cooling shirt worn during office work in a hot climate: cool or not?

The aim of the study was to identify whether a ventilation cooling shirt was effective in reducing heat strain in a hot climate. Eight female volunteers were exposed to heat (38?°C, 45% relative humidity) for 2?h with simulated office work. In the first hour they were in normal summer clothes (total thermal insulation 0.8?clo); in the second hour a ventilation cooling shirt was worn on top. After the shirt was introduced for 1?h, the skin temperatures at the scapula and the chest were significantly reduced (p?<?0.05). The mean skin and core temperatures were not reduced. The subjects felt cooler and more comfortable by wearing the shirt, but the cooling effect was most conspicuous only during the initial 10?min. The cooling efficiency of the ventilation shirt was not very effective under the low physical activity in this hot climate.     

Impact of posture and upper-limb muscle activity on grip strength

Purpose. The current research was carried out to determine grip strength (GS) with change in posture and upper-limb muscle activity of manual workers and investigate the impacts of these changes. Methods. For the current research, 120 male and 80 female participants were selected and GS was assessed using a digital hand grip dynamometer in various conditions. Results. The outcomes showed that male participants had higher GS as compared to female participants. Maximum GS was found in a standing posture with the fixed forward shoulder at 45°, elbow at 90° and a neutral position of the wrist and forearm for all participants. Conclusions. Higher values of GS were attained in standing postures which may result in attainment of higher performance levels by the workers. The outcomes justify the importance of correct postures during manual work in industries employing traditional methods.     

Age-related thermal strain in men while wearing radiation protective clothing during short-term exercise in the heat.

The aim of the study was to compare heat strain among different age groups of men in protective clothing during short-term physical work. Eight young (20-29 years), 6 middle-aged (41-55 years), and 6 older (58-65 years) men exercised for 30 min on a cycle ergometer (40% V(O2 max)) in 2 hot environments with a similar WBGT (ca. 26 degrees C): once with minimal clothing without infrared radiation (E1), and once with aluminized protective clothing under infrared radiation (E2). All subjects had sedentary jobs, but only the older subjects were physically active in their leisure-time. Body temperatures, heart rate, sweat rate, and subjective feelings were determined during the tests. Higher thermal strain was observed in E2 than in E1. No age-related differences in thermal strain were observed in either experiment indicating that active older men can tolerate short work periods with protective clothing in the heat as well as younger sedentary men.     

Model for predicting peak expiratory flow rate of Nigerian workers in a cement factory in Itori,Ogun State,Nigeria

The main aim of the study was to propose a model for predicting the peak expiratory flow rate (PEFR) of Nigerian workers in a cement factory. Sixty randomly selected non-smoker and healthy workers (30 in production sections, 30 in the administrative section of the factory) participated in the study. Their physical characteristics and PEFR were measured. Multiple correlations using SPSS version 16.0 were performed on the data. The values of PEFR, using the obtained model, were compared with the measured values using a two-tailed t test. There were positive correlations among age, height and PEFR. A prediction equation for PEFR based on age, height, weight and years of exposure (experience) was obtained with R²?=?.843 (p?<?0.001). The developed model will be useful for the management in determining PEFR of workers in the cement industry for possible medical attention.     

Evaluating the usability of a commercial cooling vest in the Hong Kong industries

Objective. The provision of appropriate personal cooling vests is recognized as an effective measure to combat heat stress. However, personal cooling vests are not widely implemented in the Hong Kong industries. The current study aims to evaluate the usability of a hybrid cooling vest that is associated with the success of its application in industrial settings. Methods. A self-administrated questionnaire focusing on 10 subjective attributes of cooling effect, ergonomic design and usability of a hybrid cooling vest was administered with 232 occupational workers in the construction, horticultural and cleaning, airport apron services and kitchen and catering industries. Results. A structural equation model estimated by analysis of moment structures was constructed to evaluate the usability of the cooling vest, as influenced by cooling effect and ergonomic design. Results showed that cooling effect (path coefficient?=?0.69, p?p?Conclusions. The structural equation model is feasible to examine the complex nature of the structural relationships among the subjective perceptions of personal cooling vests. The empirical findings furnish sound evidence for further optimization of the hybrid cooling vest in terms of cooling effect and ergonomic design for occupational workers.     

人体热应变预测方法标准在热安全评价中的应用

工业生产中存在着大量的高温工作环境,如高温生产车间或夏季露天作业环境等。高温工作环境可能导致人体体温升高、出汗脱水,对人体安全造成危害。建立人体热生理响应模型,通过计算得出人体生理指标变化,从而判断人体安全状态,是有效的人体安全评价方法。ISO 7933是人体热应变计算方法的国际标准。在考虑了环境和人体的多种情况下,给出人体相关生理参数的计算方法。基于此方法,与人体热安全阈值相结合,建立人体热安全评价方法,并给出了典型热环境下的算例。该方法也可用于评价热防护服的有效性。     

井下高温作业场所危害程度分级标准研究

对我国热害分级相关标准进行了简要总结分析,表明我国尚未制定综合考虑温湿度条件和体力劳动强度从而对井下高温作业场所的热害程度实施有效分级的相关标准.由井下现场管理人员、企业劳资(人事)管理人员、研究人员等3类共30名相关专家对井下62类主要工种劳动强度进行主观分级,通过对其结果的统计分析,研究制定了井下高温作业场所不同工种最高体力劳动强度级别建议表.通过定性和定量分析,确定了井下作业场所不同劳动强度级别下 WBGT指数限值,将结果与南非井下热害分级标准限值进行了对比.最终制订了基于井下高温作业场所最高体力劳动强度级别和WBGT指数的井下高温作业场所危害程度分级标准,提出了标准的宣传贯彻建议及分级监管策略.     

Knowledge,attitudes and practices of occupational risks in Colombian taxi drivers

Objective. The objective of this study was to learn about the health and safety strategies in a sample of taxi drivers in Bucaramanga, Colombia. Methods. A cross-sectional study was conducted among 138 taxi drivers. A survey was used to identify the socio-demographic and working characteristics, knowledge, attitudes and practices according to their occupational risk. Results. Eighty-five percent of the workers labored 9–15?h/day. Of those who suffered accidents, 27% were not affiliated to an occupational risk administrator (p = 0.028). Of the workers who had a work-related accident, 58% considered that the use of a cell phone while driving would not always reduce their attention, 50% always used their seat belt and 7% took active breaks and wore their seat belt (p = 0.01). Conclusions. Within this group of taxi drivers, having or believing to possess knowledge regarding an occupational risk did not ensure that they had a safe attitude or safe working practices.     

Relationships between certain individual characteristics and occupational accidents

Background. Work accidents and injuries are an occupational health and safety problem. Methods. This cross-sectional study was conducted for 404 frontline workers who were randomly selected from the Arya Sasol Petrochemical Company in Bushehr, Iran, during 2016. A statistical analysis was performed using the χ² test and the logistic regression model with SPSS version 18. Results. The overall occupational accident rate among the participants was found to be 9.2%. Statistically significant differences were observed for body mass index, education, job experience, smoking habit, consumption of sedative pills and presence of sleep disorders. Three factors had significant adjusted odds ratios (ORs): body mass index (OR 2.41, 95% confidence interval [CI] [1.16, 5.04]), education (OR 0.25, 95% CI [0.07, 0.85]) and job experience (OR 0.29, 95% CI [0.15, 0.57]). Conclusions. Preventive programs should be implemented for industrial workers, especially young workers, workers who smoke, overweight workers and workers with psychosomatic disease.     

Repeatability of electromyography normalization of the neck and shoulder muscles in symptomatic office workers

Purpose. The purpose of the study was to examine the repeatability of electromyography (EMG) normalization in office workers with neck and shoulder symptoms. Methods. Fifteen female office workers with neck/shoulder symptoms were recruited to participate in two separate days of testing. Maximum voluntary isometric contraction (MVIC) was used for the normalization of EMG data on the following muscles: cervical erector spinae, upper trapezius, lower trapezius and anterior deltoid. Repeatability was calculated using the intra-class correlation (ICC), relative standard error of measurement (%SEM) and relative coefficient of variation (%CV). Results. Peak root mean square (rms) and median frequency (MF) showed good to high repeatability in the UT, AD and CES (ICC?=?0.87–0.95, %SEM=?2.65–9.48, %CV=?0.2–5.9). The repeatability of peak rms was good (ICC?=?0.87, %SEM?=?12.56, %CV?=?3.3) and the MF of the LT was fair (ICC?=?0.76, %SEM?=?5.71, %CV?=?2.9). Conclusion. Peak rms and MF from the MVIC normalization method can be measured with sufficient repeatability in symptomatic office workers.