Extracellular amylase(s) production by fungi Botryodiplodia theobromae and Rhizopus oryzae grown on cassava starch residue

The fungi Botryodiplodia theobromae and Rhizopus oryzae produce extracellular amylase when grown on a liquid medium containing 2% (WN) soluble starch or cassava starch residue(CSR) (as starch equivalent), a waste generated after extraction of starch from cassava, as the sole carbon source. Using CSR as the sole carbon source, the highest amylase activity of 3.25 and 3.8 units (mg, glucose released x ml(-1) x h(-1)) were obtained in shake flask cultures during the late stationary phase of growth of B. theobromae and R. oryzae, respectively. These values were slightly lower than the values obtained using soluble starch as the carbon source. Maximum enzyme synthesis in CSR incorporated medium occurred at the growth temperature of 30 degrees C and pH 6.0. Presence of inorganic NH4+ salts like ammonium acetate and ammonium nitrate in culture medium yielded more amylase than the other nitrogen sources. Amylase(s) production in the controlled environment of a Table-Top glass Jar Fermenter (2-L capacity) was 4.8 and 5.1 units for B. theobromae and R. oryzae, respectively using CSR as the carbon substrate. It is concluded that CSR, a cheap agricultural waste obtained after starch extraction from cassava could replace soluble starch as carbon substrate for commercial production of fungal amylase(s).     

Characterization and optimization of conditions for biodegradation of sella-rice mill effluent

The sella-rice mill effluent is a major environmental pollutant requiring proper treatment before disposal. The present study has been conducted to isolate and characterize micro-organisms capable of growing on sella-rice effluent and to optimize conditions for its rapid bioremediation. Using three different types of media (LB, YEPDA and PDA), a total of 139 isolates were isolated from effluent samples collected from three different locations. Out of these, 45 isolates were found to utilize starch on starch medium, eight isolates showing high efficiency. For the optimization of conditions for maximum utilization of starch by selected isolates, parameters such as effect of addition of carbon and nitrogen sources, effect of growth factors, temperature and pH were studied. Maximum growth (absorbance of 2.10) and starch-utilization (varying in the range of 2.33 to 3.62) was observed on starch medium supplemented with peptone and yeast extract at 30 degrees C with a pH of 6.0. These bacterial isolates also reduced the amount of starch (80.10%), BOD (64.24%) and COD (75.0%) of sella-rice mill effluent after 15 days of incubation. On the basis of morphological and biochemical characteristics, the selected isolates were found to belong to the genera Lactobacillus and Micrococcus.     

Influence of culture media and environmental factors on mycelial growth and sporulation of Lasiodiplodia theobromae (Pat.) Griffon and Maubl

Lasiodiplodia theobromae, a common tea (Camellia sinensis) pathogen, usually does not sporulate or sporulates poorly in common media, which makes spore production difficult. In this study the effects of culture media, carbon source, nitrogen source, temperature, pH and light on mycelial growth and sporulation were evaluated. Among several carbon sources tested, glucose and sucrose were found superior for growth. Potassium nitrate supplemented media showed maximum growth amongst the tested inorganic nitrogen sources while peptone produced maximum growth among the tested organic nitrogen sources. Tea root extract supplemented potato dextrose agar medium was found to be the most suitable for mycelial growth and sporulation of L. theobromae. The fungus grow at temperatures ranging from 40 to 36 degrees C, with optimum growth at 28 degrees C and no growth was noted at 40 degrees C. There was no significant effect of different light period on growth of L. theobromae, but light enhanced sporulation. The fungus grow at pH 3.0-8.0 and optimum growth was observed at pH 6.0. Tea root extract supplemented potato dextrose agar medium with pH 6.0 was the most suitable for production of conidia of L. theobromae at 28 degrees C. Hence this media may be recommended for inoculum production for further studies.     

Studies on influence of natural biowastes on cellulase production by Aspergillus niger

The objective of this study was to determine the influence of natural biowaste substrates such as banana peel powder and coir powder at varying environmental parameters of pH (4-9) and temperature (20-50 degrees C) on the cellulase enzyme production by Aspergillus niger. The cellulase enzyme production was analyzed by measuring the amount of glucose liberated in IU ml(-1) by using the dinitrosalicylic acid assay method. The substrates were pretreated with 1% NaOH (alkaline treatment) and autoclaved. The maximum activity of the enzyme was assayed at varying pH with temperatures being constant and varying temperatures with pH being constant. The highest activity of the enzyme at varying pH was recorded at pH 6 for banana peel powder (0.068 +/- 0.002 IU ml) and coir powder (0.049 +/- 0.002 IU ml(-1)) and the maximum activity of the enzyme at varying temperature was recorded at 35 degrees C for both banana peel powder (0.072 +/- 0.001 IU ml(-1)) and coir powder (0.046 +/- 0.003 IU ml(-1)). At varying temperatures and pH the high level of enzyme production was obtained at 35 degrees C and pH 6 by using both the substrates, respectively. However among the two substrates used for the production of cellulases by Aspergillus niger banana peel powder showed maximum enzymatic activity than coir powder as substrate.     

Biodegradation of phenol by native microorganisms isolated from coke processing wastewater

The present investigation was undertaken to assess the biodegradation of phenol by native bacteria strains isolated from coke oven processing wastewater. The strains were designated ESDSPB1, ESDSPB2 and ESDSPB3 and examined for colony morphology Gram stain characters and biochemical tests. Phenol degrading performance of all the strains was evaluated initially. One of the strains namely ESDSPB2 was found to be highly effective for the removal of phenol, which was used as sole carbon and energy source. From an initial concentration of 200 mg I(-1) it degraded to 79.84 +/- 1.23 mg l(-1). In turn the effect of temperature (20 to 45 degrees C), pH (5-10) and glucose concentration (0, 0.25 and 0.5%) on the rate of phenol degradation by that particular strain was investigated. Observations revealed that the rate of phenol biodegradation was significantly affected by pH, temperature of incubation and glucose concentration. The optimal conditions for phenol removal were found to be pH of 7 (84.63% removal), temperature, 30 degrees C (76.69% removal) and 0.25% supplemented glucose level (97.88% removal). The main significance of the study is the utilization of native bacterial strains from the waste water itself having potential of bioremediation.     

Anaerobic degradation kinetics of reactive dye with different carbon sources

This study aims to investigate the anaerobic degradation kinetics of reactive dye, C.I. Reactive Red 141 (Evercion Red H-E7B) by partially granulated anaerobic mixed culture using three carbon sources, namely modified starch (MS), polyvinyl alcohol (PVA) and acrylic size (AS) during batch incubation. There is a first-order kinetics reaction in the decolorization processes using MS and PVA as carbon sources, while a zero-order kinetics relationship describes the decolorization process for the AS carbon source. The k values and color removal rate of decolorization with MS carbon source was higher than those of PVA and AS carbon sources. This is because the MS carbon source was well degraded in comparison to AS and PVA, respectively This study also found dye reduction could be enhanced through the addition of MS as a carbon source. The decolorization rates increased with decrease in dye concentrations of RR 141. In contrast, the decolorization rates increased with increase in COD concentration.     

均匀设计法优化樟芝产三萜液体发酵条件

为在兼顾生物量的基础上提高液体发酵中三萜的百分含量,首先通过单因子试验筛选出最佳的碳源、氮源、无机盐,然后采用均匀设计(UD)对其培养基配比和培养条件进行优化试验,建立适当的数学模型,并对模型进行验证确定优化条件.单因子试验结果表明玉米淀粉既能促进菌丝体的生长,又能促进三萜的合成;麸皮虽然对菌体生长略有不利,但是对三萜的积累作用特别显著;硫酸镁对菌丝体生长效果不显著,但是对三萜的合成比较有利.均匀设计试验结果表明,菌丝体干重最大的培养条件和三萜的最优培养条件相差甚远.菌丝体干重的最优培养条件为:1 L培养液中玉米淀粉47 g,麸皮47 g,硫酸镁0.5 g,初始pH 3.0,培养7 d;三萜最佳培养基配方为:1 L培养液中玉米淀粉20 g,麸皮20 g,硫酸镁1.85 g,初始pH 3.0,培养16 d.菌丝体干重在最优条件下能达到15.58(±0.37)g L-1;三萜百分含量在最优培养条件下高达6.04(±0.03)%,三萜的百分含量比基础发酵结果和报道的最高发酵结果3.18%提高了90%,因此,均匀设计法能有效优化液体发酵培养条件     

Characterization of two metal resistant Bacillus strains isolated from slag disposal site at Burnpur, India

Two strains of Bacillus sp. resistant to arsenate and lead designated as AsSP9 and PbSP6, respectively were isolated from the slag disposal site. They were identified to be related to Bacillus cereus cluster on the basis of 16S rDNA based sequence analysis and phenotypic characteristics. Both were rod-shaped (AsSP9, 2-5 microm and PbSP6, 2-4 microm), aerobic, salt tolerant (2-8% NaCI), endospore forming bacteria with minor differences like the AsSP9 showed sporangial bulging and PbSP6 had positive lipase activity. The temperature range for their growth was 20-40 degrees C and pH range 6.0-9.0 with an optimum temperature of 37 degrees C and pH of 7 for both strains. The principal nitrogen sources forAsSP9 and PbSP6 were DL-Tryptophan and L-Phenylalanine, respectively. The suitable carbon source forAsSP9 was lactose and for PbSP6 sucrose. The heavy metal accumulation efficiency was found to be 0.0047 mg g(-1) of dry mass forAsSP9 and 0.686 mg g(-1) of dry mass for PbSP6.     

Semicontinuous production of ethanol from agricultural wastes by immobilised coculture in a two stage bioreactor

The seed testing laboratories of Maharashtra discard 10 tonnes of grains and oil seeds treated with pesticides per annum. These agricultural wastes could be converted to reducing sugar and ethanol in a two stage semicontinuous fluidised bed bioreactor containing immobilised, Bacillus sp. and Zymomonas mobilis in the 1st stage and Saccharomyces diastaticus and S. cerevisae in the 2nd stage. The optimum temperature and pH for fermentation in both the stages were 30 degrees C and 7.2 respectively. In this process 600 g (approximately 400 g starch) waste seeds could yield 402 g of reducing sugar in the 1st stage after 20 h and 205 g ethanol in the 2nd stage after 40 h incubation with a yield factor 0.51. Using these system 10 tonnes of agricultural wastes could be converted to 3.4 x 107 g of ethanol.     

Impact of Ni(II), Zn(II) and Cd(II) on biogassification of potato waste

A study was conducted on anaerobic digestion of potato waste and cattle manure mixture, inoculated with 12% inoculum and diluted to 1:1 substrate water ratio at 37 +/- 1 degrees C. Initially pH of substrate was found to be 4.5 to 5.0. Lime and sodium bicarbonate solutions were employed to adjust the pH to 7.5. Biogas production continued up to 10 and 7 days, when lime and sodium bicarbonate solutions were used to adjust the pH, respectively. Biogassification potential was studied in response to different ratio of waste and cattle manure. Biogas production rate was higher when potato waste and cattle manure were used in 50:50 ratio. Effect of two different concentrations (2.5 and 5.0 ppm) of three heavy metals viz. (Ni (II), Zn (II) and Cd (II)) on anaerobic digestion of substrate (potato waste--cattle manure, 50:50) was studied. At 2.5 ppm, all the three heavy metals increased biogas production rate over the control value. The percentage increase in biogas production over the control was highest by Cd, followed by Ni and Zn. In all the treatments, methane content of biogas increased with increase in time after feeding. Various physico-chemical parameters viz. total solids, total volatile solids, total organic carbon and chemical oxygen demand considerably declined after 7 days of digestion and decline was greater in presence of heavy metals as compared to control. The physico-chemical parameters revealed maximum decrease in the presence of 2.5-ppm concentrations of heavy metals with the substrate. Among all the three heavy metals employed in the study, Cd++ at 2.5 ppm was found to produce maximum biogas production rate. The use of three heavy metals to enhance biogas production from potato and other horticultural waste is discussed.     

Biosorption of zinc (II) using Spirogyra species from electroplating effluent

Zinc was removed from the metal plating effluent with the biosorbent consisting of filamentous algae Spirogyra sp. The sorption was pH dependent with best adsorption at pH 2.5. The metal uptake increased from 3.9% (for no dilution) to 36.8% (for 10 times dilution), indicating that sorption increased with dilution of sample. The adsorption was faster at initial contact time, gradually decreased and remains constant after certain optimum time. Percentage removal of zinc increased from 20.3% to 63.6% with increase in the temperature from 25 degrees C to 35 degrees C but further increase resulted in the decrease in adsorption. Freundlich isotherm was applied and it holds good for the adsorption data.     

Carbohydrate digestion in Penaeus monodon

Using crude homogenates from the digestive system of pond-cultured Penaeus monodon, carbohydrase activity was demonstrated toward a wide variety of substrates differing in sources and complexity. The largest concentration of this activity was found to be localised within the midgut gland. Multiple pH optima for the hydrolysis of starch suggested the presence of more than one amylase, which was confirmed by partial purification using chromatofocusing. Enzyme characterisation of the amylase activity suggested exohydrolysis in the form of a glucoamylase and possible endohydrolysis in the form of an -amylase. The complexity of the enzyme profile demonstrated in P. monodon is discussed in relation to possible sources of carbohydrate found in natural food items.     

Studies on the carbohydrases in the digestive tract of the milkfish chanos chanos

Crude extracts from various regions of the digestive tract of pond grown milkfish were tested forttheir ability to catalyze the hydrolysis of various carbohydrates. The most active carbohydrases were those involved in the hydrolysis of -glucosidic bonds. Maltose, trehalose, dextrin, starch and glycogen were rapidly hydrolyzed in the presence of crude extracts from the intestines and the pyloric caeca. High amylase activity was observed in extracts from the intestines, pancreas, pyloric caeca and liver. The intestinal amylase had optimum activity at pH 6.2 and at a temperature of about 50°C. It was active at a chloride concentration of 10 to 40 ppt. The amylase activity in the intestines consistently peaked daily at about noon when the milkfish gut was full. In contrast, enzyme activity was significantly lower at 0030 hrs when the gut was empty. These results are consistent with earlier observations that the milkfish is a daytime feeder and suggest further that intestinal amylase secretion is in phase with the feeding activity of the milkfish. Although the fishes used in this study fed mostly on the naturally occurring algae in the ponds, no cellulase activity was detected in any region of the digestive tract. Less active carbohydrases that were detected include a -glucosidase and -galactosidase, both of which were of limited substrate specificity.SEAFDEC Contribution No. 71     

A new conceptual model for the fate of lignin in decomposing plant litter

Lignin is a main component of plant litter. Its degradation is thought to be critical for litter decomposition rates and the build-up of soil organic matter. We studied the relationships between lignin degradation and the production of dissolved organic carbon (DOC) and of CO2 during litter decomposition. Needle or leaf litter of five species (Norway spruce, Scots pine, mountain ash, European beech, sycamore maple) and of different decomposition stage (freshly fallen and up to 27 months of field exposure) was incubated in the laboratory for two years. Lignin degradation was followed with the CuO method. Strong lignin degradation occurred during the first 200 incubation days, as revealed by decreasing yields of lignin-derived phenols. Thereafter lignin degradation leveled off. This pattern was similar for fresh and decomposed litter, and it stands in contrast to the common view of limited lignin degradation in fresh litter. Dissolved organic carbon and CO2 also peaked in the first period of the incubation but were not interrelated. In the later phase of incubation, CO2 production was positively correlated with DOC amounts, suggesting that bioavailable, soluble compounds became a limiting factor for CO2 production. Lignin degradation occurred only when CO2 production was high, and not limited by bioavailable carbon. Thus carbon availability was the most important control on lignin degradation. In turn, lignin degradation could not explain differences in DOC and CO2 production over the study period. Our results challenge the traditional view regarding the fate and role of lignin during litter decomposition. Lignin degradation is controlled by the availability of easily decomposable carbon sources. Consequently, it occurs particularly in the initial phase of litter decomposition and is hampered at later stages if easily decomposable resources decline.     

Temperature influences carbon accumulation in moist tropical forests

Evergreen broad-leaved tropical forests can have high rates of productivity and large accumulations of carbon in plant biomass and soils. They can therefore play an important role in the global carbon cycle, influencing atmospheric CO2 concentrations if climate warms. We applied meta-analyses to published data to evaluate the apparent effects of temperature on carbon fluxes and storages in mature, moist tropical evergreen forest ecosystems. Among forests, litter production, tree growth, and belowground carbon allocation all increased significantly with site mean annual temperature (MAT); total net primary productivity (NPP) increased by an estimated 0.2-0.7 Mg C x ha(-1) x yr(-1) x degrees C(-1). Temperature had no discernible effect on the turnover rate of aboveground forest biomass, which averaged 0.014 yr(-1) among sites. Consistent with these findings, forest biomass increased with site MAT at a rate of 5-13 Mg C x ha(-1) x degrees C(-1). Despite greater productivity in warmer forests, soil organic matter accumulations decreased with site MAT, with a slope of -8 Mg C x ha(-1) x degrees C(-1), indicating that decomposition rates of soil organic matter increased with MAT faster than did rates of NPP. Turnover rates of surface litter also increased with temperature among forests. We found no detectable effect of temperature on total carbon storage among moist-tropical evergreen forests, but rather a shift in ecosystem structure, from low-biomass forests with relatively large accumulations of detritus in cooler sites, to large-biomass forests with relatively smaller detrital stocks in warmer locations. These results imply that, in a warmer climate, conservation of forest biomass will be critical to the maintenance of carbon stocks in moist tropical forests.     

Performance of an ANAMMOX reactor treating wastewater generated by antibiotic and starch production processes

A pilot-scale anaerobic ammonia oxidation (ANAMMOX) reactor was used to treat mixed wastewater resulting from a chlortetracycline and starch production process. The results, collected over the course of 272 days, show that the ratio of influent ammonium to nitrite, pH, and temperature can all affect the efficiency of nitrogen removal. The ratio of influent ammonium to nitrite was maintained at about 1:1 at a concentration below 200 mg·L^-1 for both influent ammonium and nitrite. The total nitrogen (TN) loading rate was 0.15–0.30 kgN·m^-3·d^-1, pH remained at 7.8–8.5, and temperature was recorded at 33±1°C. The rate of removal of ammonia, nitrite, and TN were over 90%, 90%, and 80%, and the effluent ammonium, nitrite and TN concentrations were below 50, 30, and 100 mg·L^-1.     

生淀粉糖化酶产生菌Aspergillus niger(6#)的分离筛选及其产酶条件

从大曲中分离到了1株降解生淀粉能力较强的黑曲霉Aspergillusniger(6#).固体发酵酶活可达2461U/g,RDA值为21.47%;液体发酵酶活可达353U/mL,RDA值为20.30%.以6#菌为实验材料,进一步考察了氮源、碳源及pH对生淀粉糖化酶形成的影响.实验结果表明,无机氮源NaNO3较有机氮源蛋白胨更有利于生淀粉糖化酶的形成;pH是影响生淀粉糖化酶形成的重要因素,低pH会阻遏生淀粉糖化酶的形成;玉米粉和麦芽糖较其它碳源更有利于生淀粉糖化酶的形成.图4表2参12     

Modeling the seasonal autochthonous sources of dissolved organic carbon and nitrogen in the upper Chesapeake Bay

In this paper we investigate the seasonal autochthonous sources of dissolved organic carbon (DOC) and nitrogen (DON) in the euphotic zone at a station in the upper Chesapeake Bay using a new mass-based ecosystem model. Important features of the model are: (1) carbon and nitrogen are incorporated by means of a set of fixed and varying C:N ratios; (2) dissolved organic matter (DOM) is separated into labile, semi-labile, and refractory pools for both C and N; (3) the production and consumption of DOM is treated in detail; and (4) seasonal observations of light, temperature, nutrients, and surface layer circulation are used to physically force the model. The model reasonably reproduces the mean observed seasonal concentrations of nutrients, DOM, plankton biomass, and chlorophyll a. The results suggest that estuarine DOM production is intricately tied to the biomass concentration, ratio, and productivity of phytoplankton, zooplankton, viruses, and bacteria. During peak spring productivity phytoplankton exudation and zooplankton sloppy feeding are the most important autochthonous sources of DOM. In the summer when productivity peaks again, autochthonous sources of DOM are more diverse and, in addition to phytoplankton exudation, important ones include viral lysis and the decay of detritus. The potential importance of viral decay as a source of bioavailable DOM from within the bulk DOM pool is also discussed. The results also highlight the importance of some poorly constrained processes and parameters. Some potential improvements and remedies are suggested. Sensitivity studies on selected parameters are also reported and discussed.     

Wastewater-nitrogen removal using polylactic acid/starch as carbon source: Optimization of operating parameters using response surface methodology

The use of PLA/starch blends for nitrogen removal was achieved. The influence of different operating parameters on responses was verified using RSM. The conditions for desired responses were successfully optimized simultaneously. Blends material may have a promising application prospect in the future. Nitrogen removal from ammonium-containing wastewater was conducted using polylactic acid (PLA)/starch blends as carbon source and carrier for functional bacteria. The exclusive and interactive influences of operating parameters (i.e., temperature, pH, stirring rate, and PLA-to-starch ratio (PLA proportion)) on nitrification (Y₁), denitrification (Y₂), and COD release rates (Y₃) were investigated through response surface methodology. Experimental results indicated that nitrogen removal could be successfully achieved in the PLA/starch blends through simultaneous nitrification and denitrification. The carbon release rate of the blends was controllable. The sensitivity of Y₁, Y₂, and Y₃ to different operating parameters also differed. The sequence for each response was as follows: for Y₁, pH>stirring rate>PLA proportion>temperature; for Y₂, pH>PLA proportion>temperature>stirring rate; and for Y₃, stirring rate>pH>PLA proportion>temperature. In this study, the following optimum conditions were observed: temperature, 32.0°C; pH 7.7; stirring rate, 200.0 r·min^-1; and PLA proportion, 0.4. Under these conditions, Y₁, Y₂, and Y₃ were 134.0 μg-N·g-blend^-1·h^-1, 160.9 μg-N·g-blend^-1·h^-1, and 7.6 × 10³ μg-O·g-blend^-1·h^-1, respectively. These results suggested that the PLA/starch blends may be an ideal packing material for nitrogen removal.     

Growth, biomass production and photosynthesis of Cenchrus ciliaris L. under Acacia tortilis (Forssk.) Hayne based silvopastoral systems in semi arid tropics

The growth, biomass production and photosynthesis of Cenchrus ciliaris was studied under the canopies of 17 yr old Acacia tortilis trees in semi arid tropical environment. On an average the full grown canopy of A. tortilis at the spacing of 4 x 4 m allowed 55% of total Photosynthetically Active Radiation (PAR) which in turn increased Relative Humidity (RH) and reduced under canopy temperature to -1.75 degrees C over the open air temperature. C. ciliaris attained higher height under the shade of A. tortilis. The tiller production and leaf area index decreased marginally under the shade of tree canopies as compared to the open grown grasses. C. ciliaris accumulated higher chlorophyll a and b under the shade of tree canopies indicating its shade adaptation potential. The assimilatory functions such as rate of photosynthesis, transpiration, stomatal conductance, photosynthetic water use efficiency (PN/TR) and carboxylation efficiency (PN/CINT) decreased under the tree canopies due to low availability of PAR. The total biomass production in term of fresh and dry weight decreased under the tree canopies. On average of 2 yr C. ciliaris had produced 12.78 t ha(-1) green and 3.72 -t ha(-1) dry biomass under the tree canopies of A. tortilis. The dry matter yield reduced to 38% under the tree canopies over the open grown grasses. The A. tortilis + C. ciliaris maintained higher soil moisture, organic carbon content and available N P K for sustainable biomass production for the longer period. The higher accumulation of crude protein, starch, sugar and nitrogen in leaves and stem of C. ciliaris indicates that this grass species also maintained its quality under A. tortilis based silvopastoral system. The photosynthesis and dry matter accumulation are closely associated with available PAR indicating that for sustainable production of this grass species in the silvopasture systems for longer period about 55% or more PAR is required.