车辆装备涂层局部微小破损对防护性能的影响研究

目的探究车辆装备有机涂层在微小破损之后性能的变化情况,并通过完好涂层防护能力的对比分析,间接预测微小破损涂层的服役寿命。方法利用某型现役装备涂层作为试验样本,进行综合环境下的循环加速腐蚀试验,最后利用EIS分析实验数据,分析两者防护性能的差别。结果完好涂层与破损涂层的防护性能均出现了大幅度的下降,两者在经过10个周期的腐蚀试验之后,都失去了防护能力,出现了大面积锈迹。完好涂层的低频阻抗模值|Z|0.1 Hz在试验初期处于1010Ω·cm2数量级,最后下降到106Ω·cm2以下;初始状态破损涂层的低频阻抗模值|Z|0.1 Hz为1.2×105Ω·cm2,9个腐蚀周期之后下降至5.7×103Ω·cm2,下降了2个数量级。结论破损涂层在腐蚀初期更多地表现出电容性质,其试验初期的防护能力大约相当于完好涂层经历6~7次循环试验之后的防护能力,破损部分随着腐蚀周期的变化呈现“钝化—溶解—再钝化—再溶解”的周期性变化规律。     

环氧富锌-石墨烯涂层在中性盐雾和高低温循环浸泡中的失效研究

目的 研究20#钢表面环氧富锌-石墨烯涂层在中性盐雾和高低温循环浸泡(3.5％NaCl溶液,45℃12 h+RT 12 h)试验中的失效过程与行为.方法 采用电化学交流阻抗(EIS)测试、开路电位(OCP)监测、扫描电镜观察与分析(SEM/EDS)以及红外光谱(FTIR)等方法研究涂层在两种试验环境中的失效特征和对20#钢的保护作用,并探讨涂层失效的低频阻抗评价标准.结果 涂层试样分别在中性盐雾79 d和高低温循环浸泡160 d后,表面开始出现锈点,失去对基体的保护作用,此时低频阻抗(|Z|0.01 Hz)值降至7×104?·cm2左右.除了屏蔽作用以外,环氧富锌-石墨烯涂层还可为钢基体提供一定的阴极保护作用,其中高低温浸泡环境中的阴极保护作用时间略长.在两种加速试验环境中,涂层后期的失光率均处于"明显失光",色差值达到或接近"较大变色".红外光谱显示,涂层中的特征官能团未发生明显的变化.结论 通常利用低频阻抗(|Z|0.01 Hz)低于1×106?·cm2来衡量有机涂层(不含导电颗粒)失效的判据,不适用于评价碳钢表面的环氧富锌-石墨烯涂层体系,对于该体系的失效评价可能需要再降低近2个数量级,约为7×104?·cm2左右.     

沿海地区输电铁塔防护涂层耐腐蚀性能研究

目的研究沿海地区输电铁塔防护涂层体系的腐蚀失效行为,评估涂层的防护性能,为铁塔防护涂层寿命体系评定和修复提供试验依据。方法分别采用热镀锌、热镀锌/冷涂锌复合涂层、热镀锌/带锈环氧涂层三种技术方案,对铁塔角钢材料进行防腐保护,采用中性盐雾方法模拟沿海环境对试样进行耐蚀性测试,通过试样表面形貌观察、极化曲线、以及阻抗谱等电化学手段对保护效果进行评价。结果热镀锌、热镀锌/冷涂锌复合涂层在盐雾150 h出现大面积腐蚀,热镀锌/带锈环氧涂层在盐雾2000 h未发生明显腐蚀。结论热镀锌/带锈环氧涂层的耐蚀性能优于热镀锌/冷涂锌漆和热镀锌涂层。     

直升机旋翼桨叶有机涂层防护性能在户内加速试验中的变化

目的考核评价高原环境下服役的直升机旋翼桨叶典型结构及其防护体系的耐腐蚀性能。方法利用建立的模拟高原环境加速试验谱,再现直升机旋翼桨叶结构防护体系实际服役过程中出现的腐蚀损伤,采取电化学阻抗谱测试研究涂层阻抗的变化。结果经历8个周期的户内加速试验后,新修桨叶试验件表面有机涂层Bode曲线呈现小幅下降,即有机涂层防护性能下降;报废桨叶试验件表面有机涂层的特定频率电化学阻抗模值与原始情况相比仅下降了不到1个数量级。结论报废桨叶试验件表面有机涂层电化学阻抗模值曲线在8个周期后仍然小幅高于未经历户内加速试验的新修桨叶试验件。     

飞机蒙皮用含氟聚氨酯涂层老化原因分析

选用飞机蒙皮常用的含氟聚氨酯涂层体系为研究对象,结合飞机服役环境的主要特点,开展了实验室模拟加速老化试验研究,并利用电化学阻抗谱对老化试验后的涂层进行了表征.结果表明,紫外线仅对涂层的表面结构产生影响,紫外试验后的涂层电阻下降较慢.在紫外-盐雾循环试验中,紫外线引起涂层表面结构发生变化,涂层的耐水性变差,水更快地进入涂...     

2024-T62铝合金涂层外场腐蚀环境下电化学性能研究

目的评估自然暴露条件下涂层的耐蚀性能。方法选取西沙热带海洋环境作为自然暴晒场,开展2024-T62铝合金涂层(N1和N2)在湿热暴露、紫外照射、盐雾等综合腐蚀环境下的外场暴晒试验,利用电化学测试方法对暴晒后涂层在3.5%Na Cl溶液中浸泡不同时间的耐蚀性能进行研究。结果铝合金涂层外场暴晒试验后,电化学阻抗值下降,综合腐蚀环境具有显明的加速作用。随着在3.5%Na Cl溶液的浸泡时间增加,C_(coat)-T值不断增大,Rcoat值不断减小。结论 N1铝合金涂层暴晒件电化学阻抗值较高,具有较强的耐蚀性能。     

直升机蒙皮典型结构有机涂层防护性能在模拟高原大气环境中的变化

目的评价服役于高原大气环境中的直升机蒙皮典型结构及其防护体系的防护性能。方法通过模拟高原大气环境加速试验方法再现直升机蒙皮典型结构防护体系实际服役过程中出现的损伤,利用扫描电镜对表面微观形貌进行观察,采用电化学阻抗谱测试研究有机涂层阻抗的变化。结果在实验室加速试验中,蒙皮试验件螺钉周边先出现局部腐蚀,之后腐蚀产物又逐渐减少,而铆钉周边经过多个周期后腐蚀产物都没有显著增多。螺钉中间区域有机涂层电化学阻抗模值直至第8个周期后与原始情况相比才大幅度下降,而铆钉中间区域有机涂层电化学阻抗模值在试验中多次明显下降。结论铆钉周边的有机涂层经过多个周期加速试验仍具有阻挡腐蚀性介质的作用。与螺钉结构的情况相比,铆钉中间区域有机涂层防护性能退化显著。     

基于SOM-SVM组合分类器的涂层防护性能研究

目的为避免EIS,EN技术可能出现的问题,建立一个准确、高效的评价模型,以探究现役军用有机涂层防护性能。方法利用电化学阻抗谱(EIS)、电化学噪声(EN)技术分析了两种军车有机涂层在循环暴露试验中的腐蚀行为,提取低频阻抗模值|Z|_(0.1 Hz)与涂层噪声电阻R_n两种电化学评价参数作为自组织神经网络(SOM)的输入训练样本,同时结合支持向量机(SVM)方法建立涂层防护性能组合分类器。结果将涂层失效过程自适应地分为涂层防护性能良好、防护性能下降、基本失效三个阶段。结论所建立的SOM-SVM组合分类器对于辅助分析涂层防护性能具有可行性。     

环氧型防腐涂层在深海环境的电化学行为分析

目的 评价铝合金基环氧型防腐涂层在深海环境的腐蚀防护性能,为铝合金结构在深海环境下的腐蚀防护提供支撑。方法 采用近底悬浮式深海环境试验装置和深海高压模拟试验系统,分别开展环氧型防腐涂层体系实海试验与室内模拟深海试验,研究铝合金基环氧型防腐涂层在深海环境下的防护性能与电化学行为。结果 某海域实海结果显示,经历0.5 a的1 000 m深海试验后,环氧防腐涂层对铝合金基体的防护状态良好,涂层附着力强度仍旧保持在9 MPa以上。室内模拟深海试验结果显示,在5～20 d的试验周期内,试验初期涂层电阻均在10¹⁰?·cm²以上,涂层电容则在10^?10 F/cm²数量级。随着试验时间的增加,涂层电阻减小,电容增加。其中3 000 m模拟深海环境下,涂层电阻从初始的3.995×10¹⁰?·cm²锐减至3.264×10⁷?·cm²,下降了3个数量级,涂层电容则从初始的8.818×10^?10 F/cm     

添加纳米SiO2空芯微球的水性丙烯酸 涂料性能研究

目的将纳米SiO_2空芯微球加入水性丙烯酸成膜物中,制备出一种性能优异的水性丙烯酸涂料。方法采用扫描电子显微镜(SEM)、拉开法附着力测试、氙灯加速老化试验、酸性盐雾试验、电化学交流阻抗(EIS)等方法对涂层的微观形貌、常规力学及电化学性能进行系统性研究。结果 SEM形貌表明,添加的玻璃微球与成膜物之间具有良好的相容性和稳定性,改性后的涂层在常温和高温环境下具有较好的附着力。盐雾试验和氙灯加速老化试验结果进一步显示改性后的涂层具有较好的耐老化性能,在酸性环境下有着较好的耐蚀性能。从电化学交流阻抗对比结果可明显观察到添加微球的水性丙烯酸涂层耐腐蚀性能提高了50%。结论将纳米SiO_2微球加入水性丙烯酸成膜物中,可有效改善水性丙烯酸涂料的环境适应性,同时能够有效提升其防腐性能。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Effect of sorbed and desorbed Zn(Ⅱ) on the growth of a green alga (Chlorella pyrenoidosa)

Toxic effect of Zn(Ⅱ) on a green alga (Chlorella pyrenoidasa) in the presence of sepiolite and kaolinite was investigated.The Zn-free clays were found to have a negative impact on the growth of C.pyrenoidosa in comparison with control samples (without adding any clay or Zn(Ⅱ)).When Zn(Ⅱ) was added,the algae in the presence of clays could be better survived than the control samples,which was actually caused by a decrease in Zn(Ⅱ) concentration in the solution owing to the adsorption of Zn(Ⅱ) on the clays.When the solution system was diluted,the growth of algae could be further inhibited as compared to that in a system which had the same initial Zn(Ⅱ) concentration as in the diluted system.This in fact resulted from desorption of Zn(Ⅱ) from the zinc-contaminated clays,although the effect varied according to the different desorption capabilities of sepiolite and kaolinite.Therefore the adsorption and desorption processes of Zn(Ⅱ) played an important part in its toxicity,and adsorption and desorption of pollutants on soils/sediments should be well considered in natural eco-environmental systems before their risk of toxicity to aquatic organisms was assessed objectively.