不同好氧颗粒污泥中微生物群落结构特点

为了探讨活性污泥好氧颗粒化过程对微生物种群的影响、不同底物及不同颗粒化方法培养的好氧颗粒污泥中微生物群落结构的差异,以接种污泥、模拟废水好氧颗粒污泥和分别投加粉末活性炭和硅藻土的实际生活污水好氧颗粒污泥为研究对象,利用PCR-DGGE对比分析了接种污泥和好氧颗粒污泥中的微生物群落结构.结果表明:活性污泥好氧颗粒化过程会减少微生物种群多样性,影响颗粒污泥稳定性的细菌被淘汰,而聚磷菌、反硝化菌、难降解有机物降解菌等污水处理功能微生物都在颗粒化过程中得到保留.活性污泥好氧颗粒化过程中能够实现亚硝化细菌(AOB)一定程度的富集.与接种活性污泥相比,好氧颗粒污泥中AOB的多样性指数与均匀性指数均有提高.好氧颗粒污泥中的优势菌群主要分布于变形菌门(Proteobacteria)、拟杆菌门(Bacteroidetes)和未培养菌(uncultured bacterium).其中AOB均属于β-Proteobacteria的亚硝化单胞菌属(Nitrosomonas).     

Influence of microbial community structure of seed sludge on the properties of aerobic nitrifying granules

In order to evaluate the influence of microbial community structure of seed sludge on the properties of aerobic nitrifying granules, these granules were cultivated with different seed sludge, and the variation of microbial community and dominant bacterial groups that impact the nitrogen removal efficiency of the aerobic nitrifying granules were analyzed and identified using 16s rDNA sequence and denaturing gradient gel electrophoresis (DGGE) profiles. The results presented here demonstrated that the influence of the community structure of seed sludge on the properties of aerobic nitrifying granules was remarkable, and the granules cultivated by activated sludge from a beer wastewater treatment plant showed better performance, with a stable sludge volume index (SVI) value of 20 mL/g, high extracellular polymeric substance (EPS) content of 183.3 mg/L, high NH₄⁺-N removal rate of 89.42% and abundant microbial population with 10 dominant bacterial groups. This indicated that activated sludge with abundant communities is suitable for use as seed sludge in culturing aerobic nitrifying granules.     

Effects of activated sludge flocs and pellets seeds on aerobic granule properties

Aerobic granules seeded with activated sludge flocs and pellets (obtained from activated sludge flocs) were cultivated in two sequencing batch reactors and their characteristics were compared. Compared with granules seeded with activated sludge flocs, those seeded with pellets had shorter start-up time, larger diameter, better chemical oxygen demand removal e ciency, and higher hydrophobicity, suspended solid concentration, and Mg2+ content. The di erent inocula led the granule surface with di erent microbial morphologies, but did not result in di erent distribution patterns of extracellular polymeric substances and cells. The anaerobic bacterium Anoxybacillus sp. was detected in the granules seeded with pellets. These results highlighted the advantage of pellet over activated sludge floc as the seed for aerobic granulation and wastewater treatment.     

选择压法培育好氧颗粒污泥的试验

以普通絮状活性污泥为接种污泥,葡萄糖为碳源,在序批式反应器中培育出好氧颗粒污泥增加COD负荷的同时,减少沉降时间以造成选择压,强化好氧颗粒污泥的形成根据污泥的形态变化,颗粒污泥的形成可分为3个阶段.反应器启动67d出现颗粒污泥COD负荷4.8kg/(m³·d)、表面气体流速0.0175m/s时,反应器中活性污泥完全颗粒化颗粒污泥粒径大多6～9mm,MLSS 7800mg/L,最小沉降速率32.7m/h.好氧颗粒污泥具有在高负荷下良好的COD去除率.对好氧颗粒污泥的基本性质及其形成的影响因素进行了初步分析.     

Rapid aerobic granulation in an SBR treating piggery wastewater by seeding sludge from a municipal WWTP

Aerobic sludge granulation was rapidly obtained in the erlenmeyer bottle and sequencing batch reactor (SBR) using piggery wastewater. Aerobic granulation occurred on day 3 and granules with mean diameter of 0.2 mm and SVI₃₀ of 20.3 mL/g formed in SBR on day 18. High concentrations of Ca and Fe in the raw piggery wastewater and operating mode accelerated aerobic granulation, even though the seed sludge was from a municipal wastewater treatment plant (WWTP). Alpha diversity analysis revealed Operational Taxonomic Units, Shannon, ACE and Chao 1 indexes in aerobic granules were 2013, 5.51, 4665.5 and 3734.5, which were obviously lower compared to seed sludge. The percentages of major microbial communities, such as Proteobacteria, Bacteroidetes and Firmicutes were obviously higher in aerobic granules than seed sludge. Chloroflexi, Planctomycetes, Actinobacteria, TM7 and Acidobacteria showed much higher abundances in the inoculum. The main reasons might be the characteristics of raw piggery wastewater and granule structure.     

基于反硝化聚磷菌的颗粒污泥的培养

采用SBR反应器,利用絮状污泥为接种污泥,培养反硝化聚磷菌颗粒污泥,在提高污泥氮磷去除率的同时,实现污泥的颗粒化.结果表明,经过三个阶段45d的培养,体系达到稳定状态,利用其处理模拟生活废水时,磷的去除率在90%左右,氨氮、COD的去除率在95%左右,单位硝态氮反硝化吸磷量达到0.876mg/mg,反硝化聚磷菌占聚磷菌的比例为74.36%.污泥的平均粒径在1.0~2.0mm之间,平均沉降速度为44~72m/h.由此可以看出,通过调节溶解氧,使污泥处于厌氧、缺氧及好氧状态,可以实现基于反硝化聚磷菌的污泥颗粒化.     

连续流膜生物反应器中好氧颗粒污泥的形成及机制探讨

为了探讨好氧颗粒污泥在连续流膜生物反应器(MBR)中的形成过程和机制,采用连续流试验的方法,研究了好氧颗粒污泥形成过程中膜反应器内污染物的去除效果和好氧颗粒污泥特性的变化,并对连续流MBR中好氧颗粒污泥的形成机制进行了探讨.结果显示,连续流MBR中好氧颗粒污泥的形成增强了MBR的运行稳定性和抗冲击能力.废水中微生物抑制...     

Characteristics of aerobic granules grown on glucose a sequential batch shaking reactor

Aerobic heterotrophic granular sludge was cultivated in a sequencing batch shaking reactor(SBSR) in which a synthetic wastewater containing glucose as carbon source was fed. The characteristics of the aerobic granules were investigated. Compared with the conventional activated sludge flocs, the aerobic granules exhibit excellent physical characteristics in terms of settleability, size, shape, biomass density, and physical strength.Scanning electron micrographs revealed that in mature granules little filamentous bacteria could be found, rod-shaded and coccoid bacteria were the dominant microorqanisms.     

好氧颗粒污泥耐受PFOS的结构稳定性及微生物响应

以好氧颗粒污泥为接种污泥,通过全氟辛烷磺酸(PFOS)长期驯化实现耐PFOS颗粒的培养,考察不同驯化时期的污泥基本特性,并结合微生物群落演替过程、微生物表型分布以及功能途径的变化情况,以揭示其耐受机制。结果表明,好氧颗粒污泥经历解体、再形成和成熟3个阶段后可在PFOS暴露下稳定维持。驯化成熟后的好氧颗粒污泥表面丝状菌减少,并且被大量胞外聚合物(EPS)所包裹,结构更加致密。驯化期间颗粒污泥中存在大量抗性细菌以及维持颗粒稳定相关细菌,主要包括unclassified_f__Comamonadaceae、Defluviicoccus、Dongia、Rhodoplanes、Flavobacterium、Thauera、Azospira、Candidatus_Competibacter、Azoarcus和norank_f__A4b,且部分菌属间存在显著的正相关性。群体感应途径和细菌趋化途径相关基因丰度在解体期上调,在颗粒形成和成熟期恢复至初始水平,说明细菌的群体感应效应和趋化性能够在颗粒应激过程中起重要作用。因此,好氧颗粒污泥可以通过特定菌群积极响应、促进细菌趋化作用和群体感应作用、提高EPS分泌量、增强系统抗氧化胁迫能力等多种方式耐受PFOS。采用菌胶团型好氧颗粒污泥以及向好氧颗粒污泥系统中投加上述菌剂或添加信号分子有利于处理含PFOS废水。     

Production and application of anaerobic granular sludge produced by landfill

Sludge granulation is considered to be the most critical parameter governing successful operation of an upflow anaerobic sludge blanket and expanded granular sludge bed(EGSB)reactors.Pre-granulated seeding sludge could greatly reduce the required start- up time.Two lab-scale and a pilot-scale EGSB reactors were operated to treat Shaoxing Wastewater Treatment Plant(SWWTP) containing wastewater from real engineering printing and dyeing with high pH and sulfate concentration.The microbiological structure and the particle size distribution in aerobic excess sludge,sanitary landfill sludge digested for one year,and the granular sludge of EGSB reactor after 400 d of operation were analyzed through scanning electron microscopy (SEM) and sieves.The lab-scale EGSB reactor seeded with anaerobic sludge after digestion for one year in landfill showed obviously better total chemical oxygen demand (TCOD)removal efficiency than one seeded with aerobic excess sludge after cation polyacrylamide flocculation-concentration and dehydration.The TCOD removed was 470.8 mg/L in pilot scale EGSB reactor at short hydraulic retention time of 15 h.SEM of sludge granules showed that the microbiological structure of the sludge from different sources showed some differences.SEM demonstrated that Methanobacterium sp.was present in the granules of pilot-scale EGSB and the granular sludge produced by landfill contained a mixture of anaerobic/anoxic organisms in abundance.The particle size distribution in EGSB demonstrated that using anaerobic granular sludge produced by sanitary landfill as the seeding granular sludge was feasible.     

好氧颗粒污泥培养及不同阶段除污性能的研究

以某味精污水处理厂厌氧池的厌氧颗粒污泥作为接种污泥,采用人工模拟配水,通过控制运行条件在序批式反应器(SBR)中成功培养出了好氧颗粒污泥。研究表明,该好氧颗粒污泥具有良好的沉降性能及除污性能。好氧颗粒污泥的形成阶段的粒径为0.1～0.5 mm,成熟后的平均粒径为2 mm。形成阶段SBR中MLSS为5 000～6 000 mg/L,对COD和NH3-N的去除率分别达到了88.1%和87.6%。成熟后SBR中MLSS为10 000 mg/L左右,对COD和NH3-N的去除率分别达到了94%和97.5%。通过电镜分析可知,好氧颗粒污泥表面主要聚集了球状菌,中部主要以丝状菌和杆状菌为主,内部为无机核心。这种明显的分层现象,充分说明了好氧颗粒污泥沿半径方向由于溶解氧的梯度分布,微生物呈层状分布,这种层状分布的结构为好氧颗粒污泥同步硝化反硝化提供了可能。     

处理实际生活污水短程硝化好氧颗粒污泥的快速培养

以普通序批反应器(Sequencing Batch Reactor,SBR)和气提式序批反应器(Sequencing Batch Airlift Reactor,SBAR)处理低COD/TN的实际生活污水,考察了不同沉淀时间以及反应器类型对快速培养短程硝化好氧颗粒污泥(Aerobic Granular Sludge,AGS)的影响.试验结果表明,沉淀时间为15min时,SBR和SBAR系统中均为全程硝化,当将沉淀时间分别改为5min、8min后的第17d和第16d时,两个反应器中均形成AGS,并且AGS与絮状污泥共存;此时两系统均由全程硝化转化为短程硝化,出水NO2-/(NO2- NO3-)平均值分别长期维持在98.7%和85.6%左右.本试验中以沉淀时间作为选择压,快速启动了具有短程硝化功能的序批式AGS反应器.由于AGS固有结构对氧传质的限制,使亚硝酸氮氧化受阻即抑制了亚硝酸氮氧化细菌的活性,从而产生了亚硝酸氮积累现象.DO是造成本研究中出现短程硝化的主要原因,而pH值、游离氨、温度、污泥龄等因素都不是导致短程硝化的关键因素.污泥颗粒化后,两个系统中NH4 -N降解速率分别提高了2.6倍和2.4倍.     

好氧颗粒污泥的研究进展

污泥颗粒化(granulation)是指废水生物处理系统中的微生物在适当的环境条件下,相互聚集形成一种密度较大、体积较大、体质条件较好的微生物聚集体.按照微生物代谢过程中电子受体的不同,颗粒污泥可分为好氧颗粒污泥和厌氧颗粒污泥两类.目前对污泥颗粒化的研究主要集中在两个方面:一方面是从宏观层面探讨颗粒化的形成模式,优化运行参数以达到更好的颗粒化效果;另一方面是从微观层面去研究颗粒化的机理、微生物菌群及其他化学成分在颗粒化过程中所起的作用.本文综述了好氧颗粒污泥近年来的研究进展.主要包括:好氧颗粒污泥的性质(形态及粒径、沉降性能、密度与强度、生物活性、细胞表面疏水性、胞外多聚物等)及结构,颗粒污泥的培养条件、形成机理及影响因素(有机负荷、基质成分、剪切力、沉淀时间、运行周期、进水模式、微生物饥饿期、反应器结构、溶解氧、温度等),以及颗粒污泥的应用(工业废水处理、城市污水处理、有毒污染物降解、脱氮除磷、重金属及放射性核素的去除等).此外,还介绍了全自养颗粒污泥,如硝化颗粒污泥方面的研究.分析表明,随着对好氧颗粒污泥研究的不断深入,将好氧颗粒污泥应用于实际废水处理得到越来越多的关注.好氧颗粒污泥的形成机理、颗粒污泥的微生物特性、颗粒污泥的长期运行稳定性及其工业化应用是今后需要重点关注的研究方向.     

Production and the application of anaerobic granular sludge produced by landfill

Sludge granulation is considered to be the most critical parameter governing successful operation of an upflow anaerobic sludge blanket and expanded granular sludge bed (EGSB) reactors. Pre-granulated seeding sludge could greatly reduce the required start-up time. Two lab-scale and a pilot-scale EGSB reactors were operated to treat Shaoxing Wastewater Treatment Plant containing wastewater from real engineering printing and dyeing with high pH and sulfate concentration. The microbiological structure and the particle size distribution in aerobic excess sludge, sanitary landfill sludge digested for one year, and the granular sludge of EGSB reactor after 400 d of operation were analyzed through scanning electron microscopy (SEM) and sieves. The lab-scale EGSB reactor seeded with anaerobic sludge after digestion for one year in landfill showed obviously better total chemical oxygen demand (TCOD) removal efficiency than one seeded with aerobic excess sludge after cation polyacrylamide flocculation-concentration and dehydration. The TCOD removed was 470.8 mg/L in pilot scale EGSB reactor at short hydraulic retention time of 15 h. SEM of sludge granules showed that the microbiological structure of the sludge from different sources showed some differences. SEM demonstrated that Methanobacterium sp. was present in the granules of pilot-scale EGSB and the granular sludge produced by landfill contained a mixture of anaerobic/anoxic organisms in abundance. The particle size distribution in EGSB demonstrated that using anaerobic granular sludge produced by sanitary landfill as the seeding granular sludge was feasible.     

曝气量对颗粒污泥制备生物柴油的影响

以处理葡萄糖废水的好氧颗粒污泥为研究对象,考察了不同曝气量对颗粒污泥的菌群结构以及后续制备生物柴油的影响.研究结果表明,不同曝气条件下的颗粒污泥形态以及细菌,真菌的菌群结构存在明显差异,曝气量为167L/（min·m³）时,丝状真菌比例最高（8.57%）,且单位生物量的生物柴油产量也最高,达到（48.62 ±1.36）mg/g SS.不同曝气条件下形成不同菌群结构的颗粒污泥,不仅影响了污泥制备生物柴油的产量,其组分也存在明显差异.曝气量为167L/（min·m³）条件下,亚油酸甲酯（C18：2）大幅增加,这可能与该条件下颗粒污泥中出现的酵母菌Dipodascus有关.由此可见,在实际工程中可以通过控制曝气量来提高生物柴油产量和调节其组分结构.     

好氧颗粒污泥同步脱氮除磷的常温启动和低温维持

为了考察好氧颗粒污泥(aerobic granular sludge,AGS)同步脱氮除磷(simultaneous nitrogen and phosphorus removal,SNPR)能力,以及在低温条件下的适应情况,采用2个SBR反应器(命名为A、B)以厌氧/好氧方式处理实际生活污水,历时254 d.反应器以沉淀时间为选择压,均在20 d内培养获得AGS,在第42 d加入不同附加碳源(分别为丙酸钠+乙酸钠和葡萄糖),调节COD∶N∶P的比例约为360∶60∶6,2个反应器均获得了夏秋季4个月长期稳定的SNPR效果,A的出水NH4+-N、TIN和PO43--P平均去除率分别为98.42%、74.25%和94.79%,B的出水NH4+-N、TIN和PO43--P平均去除率分别为99.45%、75.96%和95.60%;在低温的影响下,2个反应器分别经35 d4、9 d逐渐恢复了稳定的SNPR效果,之后A的出水NH4+-N、TIN和PO43--P平均去除率分别为96.33%、79.49%和99.68%,B的出水NH4+-N、TIN和PO43--P平均去除率则分别为93.85%、76.44%和98.44%....     

沉淀时间及生物膜对实际生活污水形成好氧硝化颗粒污泥的影响

利用3个间歇式活性污泥反应器（sequencing batch reactor,SBR,命名为R1、R2、R3）和1个间歇气提式内循环反应器（sequencing batch airlift reactor,SBAR,命名为R4）,处理低碳氮比实际生活污水,系统考察改变沉淀时间的方式及器壁生物膜对快速启动硝化好氧颗粒污泥（aerobic granular sludge,AGS）反应器的影响.结果表明,R1、R2、R4的沉淀时间骤降为2、4、2 min,由于一次性施加的沉速选择压过强,造成污泥大量流失,反应器崩溃,而后反应器器壁不断长出生物膜,混合液和出水中出现大量絮状、棒状、颗粒状污泥,经过35～40 d的培养,出水NH⁺₄-N小于1 mg/L,这主要是器壁生物膜的作用.反应器中的松软颗粒状污泥并非AGS,但它和AGS周围都有大量的轮虫等原生动物和后生动物,这表明生物膜和AGS同源.根据污泥沉淀的实际情况,逐步降低R3反应器的沉淀时间为8、6、5、4 min,当沉速达到10 cm/min时,污泥开始颗粒化;沉速达到12 cm/min时,污泥颗粒化基本完成,共经历了33 d.AGS与絮状污泥长期共存,以0.3 mm为界,两者质量比约为2∶1,AGS平均粒径在0.5　mm左右, NH⁺₄-N降解速率是污泥未颗粒化之前的5倍.     

表层附着累枝虫的好氧颗粒污泥特性

在序批式反应器(SBR)中处理实际生活污水,并接种城市污水处理厂活性污泥,培养出表层附着大量累枝虫的好氧颗粒污泥.运行120 d时,颗粒污泥浓度可达4482 mg·L-1,污泥容积指数(SVI)为55 m L·g-1左右,颗粒的粒径主要在1.6~2.5 mm之间,平均沉速为55.4 m·h-1,累枝虫密度可达30450 ind·m L-1.CODCr和NH+4-N的平均去除率分别为87.9%和91.8%.采用直接免疫荧光法证实累枝虫可吞食游离细菌,能有效减少出水SS,且出水SS与累枝虫的密度变化整体呈相反趋势.表层附着生长的累枝虫略微降低了颗粒污泥的沉速.结构分析可看出累枝虫根植于颗粒表层,柄的部分成为颗粒污泥的"骨架",有利于颗粒污泥结构强度和稳定性.     

处理城市污水的好氧颗粒污泥培养及形成过程

在中试序列间歇式活性污泥法(SBR)反应器中采用有机物浓度低的城市污水培养好氧颗粒污泥. 运行过程中考察了污泥性能,并通过调整、优化沉淀时间和排水比等运行参数,培养出了高性能且稳定的好氧颗粒污泥. 活性污泥接种40 d后反应器内开始出现细小颗粒,160 d后颗粒污泥趋于成熟,粒径可达0.8 mm,且其周围有大量的原生动物. 颗粒化过程中,污泥密度、沉降速率和ρ(MLSS)分别从初期的1.004 0 g/cm3,6.8 m/h和4 000 mg/L升至1.010 5 g/cm3,38.5 m/h和8 000 mg/L,污泥容积指数(SVI₃₀)则从75 mL/g降至40 mL/g. 形成后的颗粒污泥对城市污水中COD_Cr和NH₄+-N有很好的去除效果,出水中ρ(COD_Cr)和ρ(NH₄+-N)分别在50和5 mg/L以下.      

Comparison of membrane fouling during short-term filtration of aerobic granular sludge and activated sludge

Aerobic granular sludge was cultivated adopting internal-circulate sequencing batch airlift reactor.The contradistinctive experiment about short-term membrane fouling between aerobic granular sludge system and activated sludge system were investigated.The membrane foulants was also characterized by Fourier transform infrared(FTIR)spectroscopy technique.The results showed that the aerobic granular sludge had excellent denitrification ability;the removal efficiency of TN could reach 90%.The aerobic granular sludge could alleviate membrane fouling effectively.The steady membrane flux of aerobic granular sludge was twice as much as that of activated sludge system.In addition,it was found that the aerobic granular sludge could result in severe membrane pore-blocking, however,the activated sludge could cause severe cake fouling.The major components of the foulants were identified as comprising of proteins and polysaccharide materials.