真菌和细菌对染料吸附脱色的高效共培养体系研究

在含有真菌G－1培养液中加入染料厂污水排放口的污泥样品，从发生快速脱色降解染料的混合培养液中分离出2株染料脱色细菌L－1和L－2，经API鉴定系统鉴定，确定菌株L－1为Enterobacter sp.，菌株L－2为Pseudomonas sp.,研究比较了单一和不同组合混合的真菌G－1菌株（Penicillium sp.)，细菌L－1菌株（Enterobacter sp.)和L－2菌株（Pseudomonas sp.)对偶氮染料红M－3BE（C.I.Reactive Red 241)和蒽醌染料艳蓝KN－R（C.I.Reactive Blue 19)的去除情况，发现G－1真菌和2种细菌组合的共培养体系对50mg/L红M－3BE和艳蓝KN－R处理5h去除率达100％和97．9％，并且是以脱色降解作用为主，建立了染料脱色降解菌的最佳组合，进一步测定了此最佳共培养体系对另外13种不同结构染料的脱色降解，结果表明，除对蒽醌染料R－478脱色降解较差外，对其他染料均可在1h-3d被完全脱色降解，表现出脱色降解染料的广谱性，向培养4d的共培养体系中依次加入8种染料，菌体可对染料连续脱色，维持脱色能力达8d左右。     

真菌和细菌对染料吸附脱色的高效共培养体系研究

在含有真菌G 1培养液中加入染料厂污水排放口的污泥样品 ,从发生快速脱色降解染料的混合培养液中分离出 2株染料脱色细菌L_1和L_2 ,经API鉴定系统鉴定 ,确定菌株L_1为Enterobactersp .,菌株L_2为Peudomonassp .。研究比较了单一和不同组合混合的真菌G_1菌株 (Penicilliumsp .)、细菌L_1菌株 (Enterobactersp .)和L_2菌株 (Pseu domonassp .)对偶氮染料红M - 3BE(C .I .ReactiveRed 2 41)和蒽醌染料艳蓝KN -R(C .1.ReactiveBlue 19)的去除情况 ,发现G - 1真菌和 2种细菌组合的共培养体系对 5 0mg/L红M - 3BE和艳蓝KN -R处理 5h去除率达 10 0 %和 97.9% ,并且是以脱色降解作用为主 ,建立了染料脱色降解菌的最佳组合 ;进一步测定了此最佳共培养体系对另外 13种不同结构染料的脱色降解 ,结果表明 ,除对蒽醌染料R - 478脱色降解较差外 ,对其他染料均可在lh— 3d被完全脱色降解 ,表现出脱色降解染料的广谱性 ;向培养 4d的共培养体系中依次加入 8种染料 ,菌体可对染料连续脱色 ,维持脱色能力达 8d左右     

优势菌处理印染废水的工艺及脱色机理研究

采用不完全厌氧－好氧工艺处理印染废水,工程运行前在水解池中投入了主要用于脱色的优势菌群,经３年多的运行,系统的脱色率均稳定在９０％以上。从池中取菌进行分离鉴定,并进行各单株菌脱色能力实验,对其中具有最佳脱色能力的菌株进行偶氮染料活性黑ＫＮＢ的脱色产物的化学分析,从而探讨水解池中染料的脱色机理。结果发现：分离到的１０株菌对试验染料有较好脱色效果,高效液相色谱检测发现产物只有苯胺类物质的存在。该菌的脱色作用主要是破坏了染料的发色基团——偶氮双键。     

喷射环流三相光催化反应器可见光下降解酸性湖兰A的研究

设计了一种喷射环流三相光催化反应器。用该反应器在可见光下,对染料酸性湖兰A在不同初始浓度、催化剂浓度、pH、光照时间下光催化降解脱色率的影响进行了研究。实验结果表明,反应最佳pH为6,反应最佳时间为20min,催化剂最佳投加量为8g／L。在最优条件下,染料脱色率达90％以上。     

活性染料K-2BP在环境水体中的光解效应

研究了活性染料K－2BP在TiO2存在下的光催化氧化分解。结果表明,影响光解过程的主要因素是染料浓度、催化剂TiO2的用量和pH。实验条件下,染料样液脱色率可达90％以上,将该法用于实际印染废水的处理,光照6h,脱色率可达70％以上。     

偶氮染料脱色菌Lysinibacillus sp.FS1的脱色性能

从佛山某工业园印染废水处理厂曝气池中,经梯度驯化筛选出一株对多种染料具有较强脱色能力的菌株FS1,通过16S r DNA基因序列分析初步鉴定为Lysinibacillus sp.,研究了该菌株在不同营养条件(氮源、碳源、碳源浓度),不同培养条件(p H、温度、供氧条件),不同染料(甲基橙、亚甲基蓝、中性红、酸性红B)和染料浓度下的脱色性能。结果表明,该菌株的最佳脱色条件:温度30~40℃,p H 7~9,氯化铵1 g/L,葡萄糖2 g/L的厌氧条件下培养脱色效果最好,10 h时对酸性红B脱色率可达98.73%左右,且脱色过程符合一级反应动力学方程:-ln(At/A0)=0.0588t-0.0448。该菌株可降解多种染料,脱色率均随污染强度的升高先增大后减小,对高浓度染料和混合染料也表现出很好的脱色效果,是一株高效广谱的染料降解菌,具有处理印染废水的开发应用价值。     

植物载体固定化无花果曲霉对直接冻黄G的脱色研究

利用植物载体丝瓜瓤对无花果曲霉进行固定，并对直接冻黄G进行脱色研究。同时考察了不同因素如菌龄、温度、pH、转速对直接冻黄G的脱色影响。试验结果表明：三龄菌丝脱色效果最佳，该菌在30℃、pH6．0．90r／min的振荡条件下，经12h它对直接冻黄G的脱色达到最佳效果。固定化细胞经8次脱色后，脱色率仍达94％以上。因此用丝瓜瓤固定无花果曲霉对处理染料污染废水具有较好的应用前景。     

Phanerochaete chrysosporium吸附载体的选择及染料降解研究

研究了游离细胞与载体吸附培养、不同载体材料对Phanerochaete chrysosporium进行连续染料脱色及产酶能力的影响。结果表明,P.chrysosporium可在载体上良好生长,甚至生长到载体内部。木屑、玉米芯、花生壳3种载体材料中,以木屑载体吸附培养物的持续脱色和产酶效果最佳,该培养物经三轮连续脱色后对染料RB5仍能达到最高95%的脱色率,并产生596 U/L锰依赖过氧化物酶（MnP）和1 326 U/L木质素过氧化物酶（LiP）,对染料的持续脱色和产酶能力明显优于游离细胞培养物。     

染料废水的脱色研究

模拟中温(35℃左右)厌氧消化条件,以葡萄糖为共基质,对模拟染料废水的厌氧生物脱色进行了研究.结果表明对可溶性的活性染料处理效果,脱色率和COD去除率可分别达到90%和70%左右.特别是对红、紫、橙三色染料处理效果好,如活性红KD-8B、活性艳兰KGL、活性金黄MG、活性红紫KN-2R、活性艳橙KGN等.当染料浓度在1.0 g/L以下,都没有抑制;脱色在22 h就可达90%的脱色率;污泥负荷在2～4 g/L时,处理效果最佳.实验亦证实,在厌氧处理过程中,染料分子结构发生了明显的变化.     

丝瓜瓤固定化脱色菌Enterobactor sp.S8 对活性黑5的脱色

利用植物载体丝瓜瓤对肠杆菌(Enterobactor sp.S8)进行固定,并对活性黑5进行脱色研究.探讨了固定化菌体的菌龄、菌量、pH、温度对染料脱色的影响.研究了该固定化菌体的重复利用和动力学实验.结果表明,最佳脱色条件为:菌龄3d、接菌量2％、温度30℃、pH 6.0.该固定化菌体对不同初始浓度活性黑5的脱色符合二级反应动力学方程.经9次重复利用后的该固定化菌体,其脱色率仍达76.8％.在优化实验条件下,根据降解3d前后的紫外-可见光谱图分析可知,活性黑5并非完全被降解为CO2和H2O,而是生成一些小分子有机中间体.     

Decolourization of synthetic dyes by Trametes hirsuta in expanded-bed reactors

The present paper studies the decolourization of different synthetic dyes (Indigo Carmine, Bromophenol Blue, Methyl Orange and Poly R-478) by the white-rot fungus Trametes hirsuta at bioreactor scale under solid-state conditions, operating with ground orange peelings as a support-substrate. Dye decolourization was performed in both batch and continuous mode. Batch cultivation led to high decolourization percentages in a short time (100% for Indigo Carmine in 3h and 85% for Bromophenol Blue in 7 h). As for continuous cultivation, different hydraulic retention times (HRT) were studied (0.8, 1, 1.5 and 3d). The highest decolourization percentages were obtained operating at a HRT of 3d, especially for the dyes Methyl Orange and Poly R-478 (81.4% and 46.9%, respectively). This is a very interesting result, since there are few studies dealing with the continuous decolourization of dyes at bioreactor scale by fungal laccases.     

基于Ti/SnO_2阳极氧化法的典型染料废水电化学氧化规律

采用Ti/SnO2电极间接阳极氧化法处理直接深棕M和活性艳蓝KNR模拟染料废水,研究电解质种类、pH、电压、NaCl投加量及电解时间对其降解效果的影响;在最佳组合条件下,通过分析UV-Vis光谱以及降解过程中氮元素的存在形式,研究上述2种染料的降解规律。结果表明,在pH为3,电压20 V,NaCl投加量为2.5 g/L的条件下,电解30 min后,直接深棕M和活性艳蓝KNR的脱色率分别达到80%和95%,60 min后直接深棕M的COD去除率可达75%,活性艳蓝KNR的COD去除率达到90%;电解60 min后,直接深棕M的偶氮双键完全破坏,萘环和苯环结构被逐步降解,活性艳蓝KNR溶液电解2 min,其分子结构中的蒽醌共轭体系被破坏,随反应的进行,蒽醌结构逐渐被破坏,染料逐步降解。     

基于Ti/SnO2阳极氧化法的典型染料废水电化学氧化规律

采用Ti／SnO2电极间接阳极氧化法处理直接深棕M和活性艳蓝KNR模拟染料废水，研究电解质种类、pH、电压、NaCl投加量及电解时间对其降解效果的影响；在最佳组合条件下，通过分析uV—Vis光谱以及降解过程中氮元素的存在形式，研究上述2种染料的降解规律。结果表明，在pH为3，电压20V，NaCl投加量为2．5g／L的条件下，电解30min后，直接深棕M和活性艳蓝KNR的脱色率分别达到80％和95％，60min后直接深棕M的COD去除率可达75％，活性艳蓝KNR的COD去除率达到90％；电解60min后，直接深棕M的偶氮双键完全破坏，萘环和苯环结构被逐步降解，活性艳蓝KNR溶液电解2min，其分子结构中的蒽醌共轭体系被破坏，随反应的进行，蒽醌结构逐渐被破坏，染料逐步降解。     

The effect of pre-ozonation on the biocompatibility of reactive dye hydrolysates

Pre-ozonation of 14 different reactive dyestuff hydrolysates at alkaline pH was investigated to assess possible relationships between ozone transfer efficiency, first order decolourization kinetics, release of initially complexed heavy metals and relative changes in the biodegradability of the partially oxidized dye waste samples. Biocompatibility of the raw (untreated) and ozonated dye hydrolysates was comparatively tracked through specific oxygen uptake rate measurements from which the respirometric inhibition of biological activated sludge imparted by raw and ozonated reactive dye wastewater with respect to synthetic domestic wastewater was determined. It could be demonstrated that preliminary ozonation of reactive azo dyes increases their biological compatibility more significantly than formazan copper complex, copper complex azo and phythalocyanine dyes as a consequence of heavy metal release associated with the cleavage of associated chromophoric groupings right at the initial stages of pre-ozonation.     

Degradation and toxicity reduction of textile effluent by combined photocatalytic and ozonation processes

To minimize the environmental impact of textile effluents, mainly related to their high coloration and the presence of toxic or carcinogenic reactive dyes, the efficiency of photochemical and ozonation processes, applied in the form of isolated and combined procedures, were evaluated. The investigation was focused on the reduction of total organic carbon content (TOC), color and acute toxicity (monitoring by inhibition of Escherichia coli respiration). For a reaction time of 60 min, the anatase TiO2-assisted photocatalytic process produces color and TOC reduction of about 90% and 50%, respectively. Meanwhile, the ozonation process gives a decolorization of about 60% but negligible TOC reduction. When the processes were applied in a simultaneous form, the decolorization was almost complete and the TOC reduction was higher than 60%. The three treatments studied yield an acute toxicity reduction of around 50%.     

隔膜槽中ACF电极成对电解脱色活性艳蓝KN-R

同时以活性炭纤维(ACF)为阳极和阴极,在隔膜电解槽中研究了不同电流密度下蒽醌染料活性艳蓝KN-R的电化学脱色.考察了ACF阳极和ACF阴极各自对染料的脱色性能.结果表明,当电流密度为1.0～1.5 mA/cm2时,电解槽中发生阳极电氧化和阴极电还原同时进行的成对电解脱色.在ACF电极上,活性艳蓝KN-R的电氧化脱色比电还原脱色容易进行,1.0 mA/cm2时,阴阳两极室脱色率分别为69%和93%,而1.5 mA/cm2时,阳极室脱色率保持在93%,阴极室脱色率达到79%.     

高铁酸盐对活性及分散染料的脱色研究

采用湿法制备了高铁酸钾(K₂FeO₄)氧化剂，研究了其对染料活性艳红X-3B(X-3B) 和分散蓝2BLN(2BLN)在不同pH条件下的脱色效果，并对Al₂ (SO₄)₃、K₂FeO₄及O₃对活性及分散染料的脱色效果进行了比较。结果表明：高铁酸钾对活性及分散染料的脱色效果明显， X-3B脱色率随pH的增加不断提高，2BLN脱色率在pH 6～10范围内无明显变化，在pH＝5时达到最大值。在X-3B及2BLN浓度同为100 mg／L，pH分别为10、5， K₂FeO₄浓度分别为100 mg／L和200 mg／L时，BLN及X-3B的脱色率分别达到92.3％和87.3％。在相同条件下，K₂FeO₄对活性艳红X-3B的脱色效果好于Al₂(SO₄)₃和O₃； 而K₂FeO₄对分散蓝2BLN的脱色效果虽比Al₂ (SO₄)₃稍差，但比臭氧的脱色效果要好。同时还研究了K₂FeO₄对活性及分散染料的脱色机理，结果表明： 高铁酸钾对X-3B的脱色依赖于K₂FeO₄的氧化作用，而对的2BLN的脱色则以絮凝为主。     

铁屑法处理活性染料废水的实验研究

研究了反应时间、染料浓度、进水pH以及不同的废铸铁屑投加量的条件下，废铸铁屑内电解法处理模拟印染废水的脱色能力。并采用铁屑滤床强化厌氧一好氧膜生物反应器（A／OMBR）处理含活性染料的模拟废水。研究结果表明，铁屑对模拟印染废水的最佳脱色时间为12min，酸性条件下铁屑的脱色率优于碱性条件．随铁屑投加量的增加，系统对印染废水的脱色率提高，铁屑滤床强化A／OMBR处理可以提高组合工艺出水色度和COD的去除率。     

Photocatalytic degradation of azo dyes by nitrogen-doped TiO2 nanocatalysts

This study examined the photocatalytic degradation of three azo dyes, acid orange 7 (AO7), procion red MX-5B (MX-5B) and reactive black 5 (RB5) using a new type of nitrogen-doped TiO2 nanocrystals. These newly developed doped titania nanocatalysts demonstrated high reactivity under visible light (lambda>390 nm), allowing more efficient usage of solar light. The doped titania were characterized by X-ray diffraction (XRD) and transmission electron microscopy (TEM). Experiments were conducted to compare the photocatalytic activities of nitrogen-doped TiO2 nanocatalysts and commercially available Degussa P25 powder using both UV illumination and solar light. It is shown that nitrogen-doped TiO2 after calcination had the highest photocatalytic activity among all three catalysts tested, with 95% of AO7 decolorized in 1 h under UV illumination. The doped TiO2 also exhibited substantial photocatalytic activity under direct sunlight irradiation, with 70% of the dye color removed in 1h and complete decolorization within 3 h. Degussa P25 did not cause detectable dye decolorization under identical experimental conditions using solar light. The decrease of total organic carbon (TOC) and evolution of inorganic sulfate (SO4(2-)) ions in dye solutions were measured to monitor the dye mineralization process.     

Characterisation and optimisation of three potential aerobic bacterial strains for kraft lignin degradation from pulp paper waste

Eight aerobic bacterial strains were isolated from pulp paper mill effluent sludge. Out of eight through nutrient enrichment technique three potential aerobic bacterial strains ITRC S(6), ITRC S(7) and ITRC S(8) were found capable to effectively degrade the kraft lignin (KL), a major byproduct of the chemical pulping process and main contributor to the colour and toxicity of effluent. Further, these potential strains (ITRC S(6), ITRC S(7) and ITRC S(8)) were biochemically characterised as Gram variable small rod, Gram negative rod and Gram positive rod respectively. Subsequently, 16S rRNA sequencing showed 95% base sequence homology and it was identified as Paenibacillus sp. (AY952466), Aneurinibacillus aneurinilyticus (AY856831), Bacillus sp. (AY952465) for ITRC S(6), IITRC S(7) and ITRC S(8), respectively. In batch decolourization experiments Bacillus sp. ITRC S(8) reduced the colour of lignin amended mineral salt medium, pH 7.6 by 65% after 6th d, at 30 degrees C, A. aneurinilyticus ITRC S(7) by 56% and Paenibacillus ITRC S(6) 43%. Under these conditions the three strains degraded the KL by 37%, 33% and 30%, respectively while the mixed culture of these three bacteria reduced colour by 69%, lignin by 40% and total substrate by 50% under same conditions. Biodegradation of the KL was not affected by low (<0.2 mg l(-1)) dissolved oxygen content; thus oxygen inhibition is more likely to be a metabolism-dependent event. Initially with 48 h incubation the decolourization was slow with decreased pH. Further incubation there was rapid decolourization with slight increase in pH at 6d compared with initial pH by increasing culture optical density. The lignin analysis from medium with HPLC indicated complete degradation rather than biotransformation with complete loss of absorbance peak at 280 nm.