催化氧化去除黄磷尾气中的H2S

黄磷尾气的主要成分是CO,其中含硫杂质主要以还原性气体--硫化氢的形式存在,采用催化氧化法净化黄磷尾气,利用吸附工艺净化硫化氢.通过常温吸附和变温吸附的比较来找出最佳的吸附方法.     

催化氧化法脱除黄磷尾气中的磷化氢和硫化氢

在常压、温度60~100℃、气体流量0.375~0.875 m3/h的条件下,利用自制的JC-4型催化剂可以深度脱除黄磷尾气中的磷化氢和硫化氢,使它们在产品气中的体积分数小于1×10-6,净化效率接近100%。该催化剂寿命长达6 000 m in,处理黄磷尾气能力为300 m3/kg。在36~50 m3/h黄磷尾气净化中试试验中,取得了同样的效果。     

电炉法生产黄磷的工艺和装置

该发明公开了一种采用电炉法生产黄磷的工艺和装置，特别涉及电炉法生产黄磷排放物综合利用的工艺和装置。电炉法生产黄磷产生的尾气通过黄磷尾气净化装置净化，并在蓄热换热器内燃烧将热量传递给换热介质，换热后的热介质送至经过改进后的循环流化床锅炉装置烟气喷嘴进入循环流化床锅炉燃烧室，     

国外动态

克劳斯装置尾气催化脱硫新工艺CEN,65[19],29(1987) 西德莫比尔石油公司开发出一种催化脱硫新工艺,称作MODOP,并已实现工业化应用。这种工艺主要是用于克劳斯尾气的脱硫,也可用于其它含低浓度硫化氢气体的脱硫,目前该公司正研究将其用于天然气的脱硫。这种新工艺的优点是不产生有害的副产物,也没有废水处置问题,且其能耗费用要比一般的尾气     

液相同时脱硫脱硝技术研究

综述了国内外目前开发的液相同时脱硫脱硝技术,包括湿式洗涤并脱硝(WSA-SNOx)工艺、氯酸氧化工艺(Tri NOx-NOxSorb)、湿式络合吸收(Fe-EDTA金属螯合物联合脱硫脱硝)工艺、乳化黄磷法脱硫脱硝工艺、尿素和添加剂液相脱硫脱硝工艺等新方法.分析了各种工艺的特点及存在问题,并对其应用前景进行了预测.     

次氯酸钠氧化脱除黄磷尾气中的硫、磷杂质

采用次氯酸钠氧化工艺净化黄磷尾气，在次氯酸钠溶液中有效氯的质量分数为0．65％，PH为9、反应温度为285K，气体流速为0．6-0.8L/min的条件下，对尾气中H2S、PH3的脱除率分别达到99．9％，和99．8％，出口含量分别小于0.2mg/m^3和7mg/m^3，对有机硫也有30％的脱除能力。     

气相色谱法测定黄磷生产尾气中的CO_2

针对黄磷生产尾气具有强化学活性和腐蚀性的特点,选择了TDX-01型碳分子筛色谱柱,采用气相色谱法测定黄磷尾气中的CO2。实验结果表明:黄磷尾气中高浓度的CO2用TCD检测器检测,CO2体积分数在0.1%~10%时,检测下限可达到0.05%,方法的平均回收率为93.6%~104.1%,相对标准偏差为2.1%~3.2%;净化后黄磷尾气中的微量CO2经Ni催化甲烷化转化后用FID检测器测定,CO2体积分数在1.0×10-7~1.0×10-4时,方法的检测下限可达到5.0×10-8,相对标准偏差为1.63%。     

新型湿式电除雾（尘）器在脱硫脱硝尾气深度净化工程的实践应用

通过新型湿式电除雾（尘）器器应用于脱硫脱硝尾气深度净化工程的成功案例，介绍新型湿式电除雾（尘）器器研制的技术优势及其应用领域，旨在为脱硫脱硝尾气中夹带的雾滴、PM2.5微粉尘等气溶胶污染物，提供一种有效可行的深度净化治理新途径，以应对日趋严格的环保政策及排放标准。     

焦炉煤气净化工艺研究进展

阐述了国内外焦炉煤气净化工艺的发展与研究现状，介绍了几种典型的焦炉煤气净化工艺，重点说明了湿式氧化工艺中的FRC法和湿式吸收工艺中的Sulfiban法，比较了几种有代表性的焦炉煤气净化工艺的脱硫脱氰效果，工艺特点以及运转费用，同时介绍了美国研究开发的LO－CAT法和我国东北师范大学研究开发的PDS法，并提同了几点建议。     

用废气中的硫化氢制硫化锌

在以重晶石（ＢａＳＯ４）为原料、用碳化法生产碳酸钡的过程中,排放含硫化氢的尾气。硫化氢是一种具有恶臭的有毒气体,在我国工业企业设计卫生标准中规定居住区大气中硫化氢最高容许浓度为００１ｍｇ／ｍ３。我们进行了以氧化锌为原料制成吸收液吸收尾气中的硫化氢,制造ＺｎＳ的试验研究。ＺｎＳ可用于生产锌钡白。１　试验１１　主要仪器、试剂与材料ＰＨＳ４型酸度计,ＷＺＧ２００型光电光谱仪。氧化锌矿粉（ＺｎＯ质量分数８６８％）,硫酸（化学纯）,氢氧化钠（化学纯）。１２　试验方法１２１　氧化锌的溶解将氧…     

Distribution of Cd,Ck, Pb and Zn in Soil and Vegetation Compartments in Stands of Five Boreal Tree Species in N.E. Sweden

Concentrations and total quantity of cadmium (Cd), cupper (Cu),lead (Pb) and zink (Zn) were determined in biomass and soil compartments in a replicated tree species experiment with 27-yr-old stands growing on former farmland in N.E. Sweden. Sequentialextractions of soil samples were performed in order to estimate the exchangeable and an organically bound fraction of each element. The tree species included were Picea abies (L.)H. Karst., Pinus sylvestris L., Pinus contorta Dougl., Larix sibirica Ledeb., and Betula pendula Roth.Tree species influenced the rate of removal of Cu, Pb and Zn incase of stemwood harvesting, and of Cd, Cu and Zn in the case ofwhole-tree harvesting. B. pendula and P. abies had higher quantities and average concentrations of Zn in the biomass. For all species, >50% of the Zn in the stems was found in the bark. P. abies and L. sibirica had higher quantities of Cu in the biomass than the other species.P. abies and P. contorta had high quantities of Cd inthe biomass in relation to the other species. Branches and stembark contained high concentrations of Cd and Pb in relation to foliage and stemwood. Dead branches had especially high concentrations of Pb. The high accumulation rate of Zn in thebiomass of B. pendula was related to a low exchangeable amount of Zn in the A horizon. In the superficial centimeters ofthe A horizon, a depletion similar to that found for Zn was detected for Cu, whereas for Cd and Pb, no correlations were found between quantities of elements in the trees and element pools in the soil.     

Programs assessing implementation and effectiveness of state forest practice rules and BMPs in the West

The major forest nonpoint source control programs in the West are largely regulatory, either under forest practices acts (California, Idaho, New Mexico, Nevada, Oregon, and Washington) or a streamside management act (Montana). These programs and the specific rules they enforce continue to undergo intensive scrutiny. Still, the questions are the same for these regulatory programs as for states that base nonpoint source control on voluntary BMPs (Arizona, Colorado, Utah, Wyoming). Are the rules or BMPs being applied, and are they effective in reducing nonpoint source pollution to levels that protect beneficial uses of water? The level of debate about forestry in the West has resulted in detailed monitoring and research to answer these questions. In the past, state agencies have assumed levels of BMP compliance based on the percent of operations without enforcement actions. These estimates are being replaced by statistically valid and reproducible monitoring of forest practices rules and BMP compliance levels. BMP effectiveness is being assessed using both qualitative and quantitative methods. This can involve field assessments, process-based research, and control watershed studies. Some trend monitoring is also beginning. With the regional implementation rate for forestry BMPs at about 94% and rising, it is likely that effectiveness testing will continue to be a priority and consume the majority of assessment resources for this region.     

Starch-plastic materials—Preparation,physical properties,and biodegradability (a review of recent USDA research)

Recent starch-plastic research at the National Center for Agricultural Utilization Research is reviewed and related worldwide efforts are noted. Properties of starch that influence its formulation and performance in plastics are discussed. Methods are given for preparation of starch-poly(methyl acrylate) graft copolymer, starch-poly(ethylene-co-acrylic acid), and starch-poly(ethylene-co-acrylic acid)-polyethylene plastics. Their physical properties are discussed, as is degradability by enzymes or amylolytic organisms from soil, ponds, and streams.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

High Immobilization of NH4+ in Danish Heath Soil Related to Succession,Soil and Nutrients: Implications for Critical Loads of N

During recent decades heathlands havechanged into grasslands in regions with high atmosphericnitrogen deposition. In regions with intermediatedeposition level (e.g., Denmark) changes have been lesspronounced which may be due to delay or decrease inresponse of the ecosystem. The mor layer (O horizon) mayplay an important role for this delay due to high sinkstrength for N. In this study, the capacity for netNH₄ ⁺ immobilization and mineralization wasstudied during short- and long-term incubations (2–36 days)of mor samples from Danish dry inland heaths. High short-term capacity for net NH₄ ⁺ immobilization wasfound to be a general characteristic of Danish heath morlayers both under heather (Calluna vulgaris) andcrowberry (Empetrum nigrum ssp nigrum), the latterdominating late stages in heathland succession. The netNH₄ ⁺ immobilization was higher under youngcompared to old or dead vegetation, and higher on lessnutrient poor soils than on extremely nutrient poor soils.The addition of N, P and C stimulated CO₂ productionand net NH₄ ⁺ immobilization, but not net Nmineralization. The immobilization of ¹⁵NH₄ ⁺caused release of dissolved organic N, increased N anddecreased C/N ratio in the microbial biomass, and indicatedgrowth of microorganisms with other metabolic abilitiesthan the indigenous population. No evidence was obtained ofstabilization of immobilized ¹⁵NH₄ ⁺ intosoil organic matter during the experiment. On background ofthe results and current knowledge it was concluded that therecognition of the high capacity for net NH₄ ⁺immobilization in mor layers does not allow for a raiseof critical loads for N for northern dry inland heaths.     

四氮唑废水处理工艺设计

高浓度、高盐分的四氮唑生产废水通过三效蒸发浓缩，馏出液经铁炭氧微电解和混凝预处理，再采用水解酸化一接触氧化一反应二沉主体组合工艺进行处理。研究了该工艺所需构筑物和设备的设计与选型。该工艺在正常运行条件下，处理后出水pH6～9，COD 302mg／L，BOD5 108mg／L，SS30mg／L，色度36倍，水质达到GB8978--1996（污水综合排放标准》三级标准。     

Application of Cellulose Microfibrils in Polymer Nanocomposites

Cellulose microfibrils obtained by the acid hydrolysis of cellulose fibers were added at low concentrations (2–10% w/w) to polymer gels and films as reinforcing agents. Significant changes in mechanical properties, especially maximum load and tensile strength, were obtained for fibrils derived from several cellulosic sources, including cotton, softwood, and bacterial cellulose. For extruded starch plastics, the addition of cotton-derived microfibrils at 10.3% (w/w) concentration increased Young’s modulus by 5-fold relative to a control sample with no cellulose reinforcement. Preliminary data suggests that shear alignment significantly improves tensile strength. Addition of microfibrils does not always change mechanical properties in a predictable direction. Whereas tensile strength and modulus were shown to increase during addition of microfibrils to an extruded starch thermoplastic and a cast latex film, these parameters decreased when microfibrils were added to a starch–pectin blend, implying that complex interactions are involved in the application of these reinforcing agents.     

Hysteresis in Reversal of Central European Mountain Lakes from Atmospheric Acidification

Extremely high emissions of S and N compounds in Central Europe (both 280 mmol m^-2 yr^-1) declined by 70and 35%, respectively, during the last decade. Decreaseddeposition rates of SO₄ ^-2, NO₃ ^-, and NH₄ ⁺ in the region paralleled emission declines. The reduction in atmospheric inputs of S and N to mountain ecosystemshas resulted in a pronounced reversal of acidification in the Tatra Mountains and Bohemian Forest lakes. Between the 1987–1990and 1997–1999 periods, concentrations of SO₄ ^-2 and NO₃ ^- decreased (average ± standard deviation) by 22±7 and 12±7 mol L^-1, respectively, in theTatra Mountains, and by 19±7 and 15±10 mol L^-1, respectively, in the Bohemian Forest. Their decrease was compensated in part (1) by a decrease in Ca²⁺ + Mg²⁺ (17±7 mol L^-1) and H⁺ (4±6 mol L^-1), and an increase in HCO₃ ^-(10±10 mol L^-1) in the Tatra Mountains lakes, and (2) by a decrease in Al (7±4 mol L^-1), Ca²⁺ + Mg²⁺ (9±6 mol L^-1), and H⁺ (6±5 mol L^-1), in Bohemian Forest lakes. Despite the rapid decline in lake water concentrations of SO₄ ^-2 and NO₃ ^- in response to reduced S and N emissions, their present concentrations in some lakes are higher than predictionsbased on observed concentrations at comparable emission rates during development of acidification. This hysteresis in chemical reversal from acidification has delayed biological recovery of the lakes. The only unequivocal sign of biological recovery hasbeen observed in erné Lake (Bohemian Forest) where a cladoceran species Ceriodaphnia quadrangular has recentlyreached its pre-acidification abundance.     

Reconstruction of Long-Term Changes in Lake water Chemistry,Zooplankton and Benthos of a Small,Acidified High-Mountain Lake: Magic Modelling and Palaeolimnogical Analysis

Starolesnianske pleso is a small and shallow acid lake in the High Tatra Mountains, situated at 2000 m above sea level, on granitic bedrock, with sparse and thin soil cover. When detailed measurements began in the 1980s Starolesnianske pleso had pH below 5 and only one species of cladoceran zooplankton, the ubiquitous Chydorus sphaericusPalaeolimnological investigations show changes in cladoceran zooplankton and chironomid zoobenthic assemblages since about 1920 and a major change in 1970–1980. The dynamic acidification model MAGIC was used to reconstruct changes in water chemistry over the past 150 years. The results from MAGIC agree well with the sediment record; pH levels gradually decreased from 6.5 in the mid-1800s to about 5.6 in 1920 (first response in biota) to below 5.0 by 1970, and concentrations of inorganic aluminium rose dramatically beginning about 1960. In the 1990s the lake water chemistry showed clear signs of reversal in acidification brought about by a major decline in S deposition.     

Does Soil Acidification Affect Spruce Needle Chemical Composition and Tree Growth?

In 1994, a large survey of soil chemistry was undertaken in thecounty of Värmland in central Sweden (Lundström et al., 1998).The southern part of the county was affected by soilacidification whereas there were no such indications in thenorthern part. To investigate the influence of soil chemistryon the trees at the specific sites, the survey was continued byan analysis of needle chemistry (Norway spruce) which wasundertaken at 150 of the 180 sites, and of tree growth at 65 ofthe 180 sites. Growth was expressed as a ratio between expectedgrowth, estimated with a national, empirical growth model, andthe growth observed in the field. In statistical analyses,using rank correlation, PCA and PLS, there were only weakindications of an influence of soil chemistry on needlechemistry and on tree growth. A moderate correlation betweennitrogen and sulphur in needles was found, which wasinterpreted as an effect of deposition and of processes in thetree canopy. No obvious regional pattern of the growth ratiowas found, in contrast to the clear pattern of soilacidification. The statistical analysis could not with anycertainty point out any of the soil chemistry variables asespecially important for the tree growth ratio.     

Bioassessment of silvicultural impacts in streams and wetlands of the Eastern United States

Bioassessment is a useful tool to determine the impact of logging practices on the biological integrity of streams and wetlands. Measuring biota directly has an intuitive appeal for impact assessment, and biota can be superior indicators to physical or chemical characteristics because they can reflect cumulative impacts over time. Logging can affect stream and wetland biota by increasing sedimentation rates, altering hydrologic, thermal, and chemical regimes, and changing the base of food webs. Biotic impacts of logging on streams compared to wetlands probably differ, and in this paper we review some of those differences. In streams, invertebrates, fishes, amphibians, algae, and macrophytes have been used as indicators of logging impacts. In wetlands, bioassessment is just beginning to be used, and plants and birds are the most promising indicator taxa. Various best management practices (BMPs) have been developed to reduce the impacts of logging on stream and wetland biota, and we review quantitative studies that have evaluated the efficacy of some of these techniques in streams and wetlands in the eastern United States. Remarkably few studies that address the overall efficacy of BMPs in limiting biotic changes in streams and wetlands after BMP implementation have been published in scientific journals, although some work exists in reports or is unpublished. We review these works, and compile conclusions about BMP efficacy for biota from this body of research.