活性炭深度处理工艺用于地下回灌的水质研究

以北京高碑店污水处理厂二级生化出水为对象,研究了用于地下回灌的活性炭三级处理工艺.活性炭可有效降低DOC,UV-254和COD,部分去除可吸附有机卤化物(AOX).再经过土壤含水层处理,约90%的可吸附有机溴化物(AOBr)可被去除.Ames试验结果显示活性炭工艺可有效降低二级生化出水中的致突物.GC/MS分析表明,活性炭吸附可降低有机物含量,再经土壤含水层处理,大部分有机物及优先控制的污染物可被去除.      

城市污水地下回灌深度处理技术

以城市污水地下回灌为回用目的,研究了不同的污水深度处理工艺,并着重研究了去除二级生物处理出水中有机物的处理工艺.研究结果表明,采用臭氧氧化和粉末活性炭预处理后再经土壤渗滤回灌,可大大改善水质,水中溶解性有机碳浓度可降至3mg／L以下,通过静态吸附实验选出了适于处理二级出水的粒状活性炭,并运用ADSA软件对有机物在活性炭上的吸附行为进行分析.将活性炭的动态实验同混凝、过滤结合起来,研究不同组合工艺对有机物的去除效果,筛选出了适于城市污水处理厂二级出水地下回灌的预处理工艺,其出水溶解性有机碳浓度低达3～4．5mg／L以下.     

城市污水深度处理中有机物的去除

以城市污水地下水回灌为回用目的 ,研究不同的污水深度处理工艺及对二级生物处理出水中有机物的去除 .研究结果表明 ,原水若未经深度处理 ,直接由土壤含水层处理的出水不能满足推荐的回灌水水质要求 .对原水分别采用混凝沉淀、过滤、臭氧氧化、粉末活性炭和粒状活性炭吸附等处理单元及组合工艺进行深度处理效果的对比 ,最终选用由混凝沉淀 ,砂滤 ,粒状活性炭过滤与土壤含水层处理相结合的工艺流程 .城市污水处理厂的二级出水经该工艺处理后 ,出水中的 DOC可降至 3mg/L以下 ,且活性炭柱的产水床体积可达 350 0 BV.     

臭氧/活性炭协同作用去除二级出水中DON

为探讨臭氧氧化和活性炭吸附对城市污水厂二级出水中溶解性有机氮(DON)的去除机制,首先测定二级出水DON、溶解性有机炭(DOC)、UV254、pH值等指标.接着通过臭氧氧化试验和活性炭吸附试验来考察二级出水中DON、DOC和UV254变化,以及DON分子量分布和DON亲疏水性变化,并应用三维荧光光谱对二级出水中DON变化进行表征.结果表明,当臭氧投加量为8mg/L,DON的去除率大约为33.9%,DOC和UV254去除率约21.2%、66.7%;当活性炭投加量为2.0g/L,DON、DOC和UV254的去除率大约为43.4%、27.6%、92.2%;臭氧氧化和活性炭吸附组合试验时,对DON的去除率大约为83.3%和81.5%;臭氧氧化提高小分子量( 20kDa)的DON所占比例;活性炭吸附降低小分子量( 20kDa)DON所占比例为;臭氧氧化和活性炭吸附都提高亲水性DON所占比例,而降低疏水性和过渡性DON所占比例;三维荧光光谱证实,二级出水中DON变化与3个主要峰有关,分别代表物质为色氨酸类蛋白质、芳香族类蛋白质和富里酸类物质.     

活性炭吸附石化二级出水有机物去除特性研究

采用活性炭对某石化二级出水进行吸附研究,考察了静态和动态试验下,活性炭对石化废水二级出水COD的去除效果,并讨论了吸附前后水中有机物的组分和相对分子质量的变化.结果表明:静态试验中,活性炭对石化废水二级出水的COD的饱和吸附量为1.1 mg·g-1,吸附速率为0.7 mg·min-1;通过动态试验得到了吸附的最佳条件,即HRT=1 h,水力负荷为0.76 m3·m-2·h-1,此时COD的去除率可达49.9%,出水COD低于50 mg·L-1.相对分子质量分级和树脂分级分析结果表明,活性炭对石化废水二级出水中相对分子质量小于5000的小分子有机物有较好的吸附效果,该组分被活性炭吸附的COD所占比例为59.72%,活性炭吸附作用对水中不同相对分子质量有机物分布影响不大;活性炭对石化废水中有机物组分的去除效果排序依次为:疏水碱性物质(HOB)疏水酸性物质(HOA)亲水中性物质(HIS)疏水中性物质(HON),对HOB和HOA的去除率可达到79%和61%,对HIS和HON的去除效果不佳.     

Kinetics and equilibrium of adsorption of dissolved organic matter fractions from secondary effluent by fly ash

Fly ash was used as a low-cost adsorbent for removing dissolved organic matter (DOM) in secondary effluent. Batch experiments were conducted under various adsorbent dosages, pH, contact time, temperatures and DOM fractional characteristics. Under the optimum conditions of fly ash dosage of 15 g/L, temperature of 303 K and contact time of 180 min, a removal of 22.5% of the dissolved organic carbon (DOC), 23.7% of UV-254, 25.9% of the trihalomethanes precursors in secondary effluent was obtained. The adsorption of DOM fractions onto fly ash all followed the pseudo second-order kinetic model, and the hydrophilic fraction adsorption by fly ash also fitted the intraparticle diffusion model quite well. Freundlich and Langmuir models were applicable to the fly ash adsorption and their constants were evaluated. The maximum adsorption capacities of the adsorptions revealed that fly ash was more effective in adsorbing hydrophilic fraction than the acidic fractions. Structure changes of the DOM fractions after fly ash adsorption were also characterized via spectrum analyzing. Those mechanisms presented critical step toward improved efficiencies of fly ash adsorption via further surface-modification.     

MIEX预处理技术对长江原水中有机物的去除效能

利用烧杯试验研究了磁性离子交换树脂（magnetic ion exchange resin,MIEX）预处理对长江原水中有机物的去除效能,以总溶解有机碳(DOC)、254 nm紫外吸收值(UV254)、有机物相对分子质量分布、有机物分级、紫外扫描以及消毒副产物生成量等指标进行表征.结果表明,长江水源水中的有机物主要为小分子亲水性有机物,其含量占有机物总量的50%以上;MIEX预处理可以有效降低水中有机物的含量,投加量为10 mL/L、接触时间为15 min时,DOC的去除率超过35%,相对分子质量和分级的测定结果表明,小分子亲水性部分有机物的去除导致了DOC去除效果的改善;从紫外扫描结果可看出,MIEX预处理对在190～250 nm波长时有强吸收的有机物去除效果非常明显,但对在高于250 nm波长处有吸收的有机物去除效果与混凝阶段的效果相近.     

炼油厂达标废水中溶解性有机物的表征

采用超滤和凝胶色谱法调查了炼油厂达标废水中溶解性有机物 (DOM)的分子量分布 ,并用树脂吸附和离子交换技术研究了该废水DOM中疏水性酸 (HoA)、碱 (HoB)及中性物 (HoN)和亲水性酸 (HiA)、碱 (HiB)及中性物 (HiN)的比例 ,用气相色谱 质谱法 (GC MS)定性分析了疏水性有机物的组成 .结果表明 ,某炼油厂达标废水的TOC为 12 0 6～ 16 80mg·L-1,其中溶解性有机碳 (DOC)为 10 15～ 14 4 4mg·L-1;分子量 <1k的DOM约为 80 % (以TOC计 ) ;DOM中HiN、HoN、HoA、HiB、HoB及HiA的含量分别为 2 9 7% ,2 6 5 % ,2 1 1% ,13 4 % ,5 1%及 4 2 % .鉴定出的HoN包括脂肪烃、苯系物、含硫化合物及邻苯二甲酸酯类化合物等 ,其中C10和C11脂肪烃、甲基亚硫酰苯及邻苯二甲酸二丁脂化合物的含量相对较高 .根据表征结果提出了回用处理建议.     

厌氧-缺氧-好氧处理出水中溶解性有机物组分的特征分析

本研究利用XAD-8大孔树脂对某城市污水处理厂的厌氧-缺氧-好氧(A2O)工艺出水中的溶解性有机物进行了组分分离,分析了各组分的溶解性有机碳(Dissolved organic carbon,DOC)、紫外-可见光谱和遗传毒性.结果表明,污水中亲水性物质和疏水酸性物质的DOC含量分别占总DOC含量的65%和24%.亲水性物质组分中的芳香族化合物含量显著高于其它组分,但是单位质量的亲水性物质、疏水酸性物质和疏水碱性物质中的芳香族化合物含量相近.污水具有一定的遗传毒性,主要遗传毒性物质为亲水性物质和疏水酸性物质,而疏水碱性物质和疏水中性物质则未检出遗传毒性.     

Effects of ozonation and coagulation on effluent organic matter characteristics and ultrafiltration membrane fouling

Effluent organic matter （EfOM） is the major cause of fouling in the low pressure membranes process for wastewater reuse. Coagulation and oxidation of biological wastewater treatment effluent have been applied for the fouling control of microfiltration membranes. However, the change in EfOM structure by pre-treatments has not been clearly identified. The changes of EfOM characteristics induced by coagulation and ozonation were investigated through size exclusion chromatography, UV/Vis spectrophotometry, fluorescence spectrophotometry and titrimetric analysis to identify the mechanisms in the reduction of ultrafiltration （UF） membrane fouling. The results indicated that reduction of flux decline by coagulation was due to modified characteristics of dissolved organic carbon （DOC） content. Total concentration of DOC was not reduced by ozonation. However, the mass fraction of the molecules with molecular weight larger than 5 kDa, fluorescence intensity, aromaticity, highly condensed chromophores, average molecular weight and soluble microbial byproducts decreased greatly after ozonation. These results indicated that EfOM was partially oxidized by ozonation to low molecular weight, highly charged compounds with abundant electron- withdrawing functional groups, which are favourable for alleviating UF membrane flux decline.     

石化污水厂二级出水溶解性有机物分级解析研究

以某石化污水处理厂二级出水为研究对象,采用大孔吸附树脂将污水中溶解性有机物分离成亲水性物质、疏水酸性物质、疏水中性物质和疏水碱性物质4个组分,分析了各组分的有机物的组成特征、三维荧光光谱特征及红外光谱特征.结果表明,亲水性物质和疏水酸性物质分别占水样中溶解性有机碳的49%和29%,是该石化污水厂二级出水中的主要物质类别.亲水性物质中含有较多的生物源腐殖质类物质,疏水中性物质含有较多的芳香族蛋白质和溶解性微生物代谢产物类物质.4种组分的红外光谱图中600~1200cm-1波数的指纹区波峰数量最多,多为芳香类同分异构体化合物.     

腈纶废水溶解性有机物的分级解析及可生化性

采用超滤膜法将腈纶废水中溶解性有机物分离为6个不同相对分子质量组分,分析不同组分的溶解性有机碳、UV₂₅₄、SUVA含量和分布情况,应用紫外吸收光谱、傅里叶变换红外光谱等光谱学分析方法对各组分物质结构进行定性分析,评价各组分的可生化性.结果表明废水中以相对分子质量< 3kDa的有机物为主,占比为（56.75±1.38）%;相对分子质量为3k~10kDa的有机物占比为（25.76±1.40）%;相对分子质量> 10kDa的有机物占比为（17.49±0.98）%,且该组分有机物的芳香度高.不同相对分子质量组分的紫外光谱和红外光谱均呈现相似吸收峰,均存在酰基、羧基、羰基及芳香族化合物和不饱和双键类有机物.各组分可生化性结果表明,废水中相对分子质量> 10kDa有机物是腈纶废水低可生化性的主要原因,可能是造成腈纶废水难以达标排放的根源.研究结果可为该废水处理工艺的开发与优化提供重要的指导.     

Comparison of different combined treatment processes to address the source water with high concentration of natural organic matter during snowmelt period

The source water in one forest region of the Northeast China had very high natural organic matter(NOM) concentration and heavy color during snowmelt period. The efficiency of five combined treatment processes was compared to address the high concentration of NOM and the mechanisms were also analyzed. Conventional treatment can hardly remove dissolved organic carbon(DOC) in the source water. KMn O4pre-oxidization could improve the DOC removal to 22.0%. Post activated carbon adsorption improved the DOC removal of conventional treatment to 28.8%. The non-sufficient NOM removal could be attributed to the dominance of large molecular weight organic matters in raw water, which cannot be adsorbed by the micropore upon activated carbon. O3+ activated carbon treatment are another available technology for eliminating the color and UV254 in water. However, its performance of DOC removal was only 36.4%, which could not satisfy the requirement for organic matter. The limited ozone dosage is not sufficient to mineralize the high concentration of NOM. Magnetic ion-exchange resin combined with conventional treatment could remove 96.2%of color, 96.0% of UV254 and 87.1% of DOC, enabling effluents to meet the drinking water quality standard. The high removal efficiency could be explained by the negative charge on the surface of NOM which benefits the static adsorption of NOM on the anion exchange resin. The results indicated that magnetic ion-exchange resin combined with conventional treatment is the best available technology to remove high concentration of NOM.     

制药废水二级出水中溶解性有机物混凝去除特性研究

制药废水二级出水中溶解性有机物(DOM)由于组成复杂、难去除、具有多异质性和分散性,是污水深度处理与回用的主要去除对象和关键限制因子.本论文以发酵制药废水二级出水的DOM为研究对象,采用投加聚合氯化铝(PAC)混凝剂去除DOM,考察混凝剂投加量和混凝pH值对去除效果的影响,并结合分子量分级、亲疏水性分级以及三维荧光光谱-平行因子分析方法等对DOM进行了系统表征和分析,进一步阐述混凝过程DOM的去除特征.结果表明,PAC投加量为250 mg·L~(-1)、pH=7时,混凝沉淀30 min对DOC、UV_(254)、色度和浊度的去除率分别为13.05%±0.29%、23.65%±0.75%、12.66%±1.34%、63.67%±0.89%;混凝对分子量10 kDa的组分和疏水中性(HON)组分去除效果分别为50.33%±0.98%、21.56%±0.42%,而对分子量1 kDa组分去除率较低为2.26%±0.12%;三维荧光光谱-平行因子分析将制药废水二级出水分为2个类腐殖质组分(C1、C3)和1个类蛋白组分(C2),混凝对类腐殖酸组分(C1)最大荧光强度去除率(F_(max))最高为46.22%,而亲水性的小分子和蛋白类物质混凝去除效果较差.     

2-丁烯醛生产废水中溶解性有机物的分级解析

采用超滤膜法将2-丁烯醛生产废水中的有机物分为相对分子质量不同的7个级分,并应用溶解性有机碳(dissolved organic carbon,DOC)、紫外吸收光谱(ultraviolet spectrum,UV)、傅里叶变换红外光谱(fourier transform infrared spectrometer,FT-IR)和气相色谱/质谱联用仪(gas chromatography with mass spectrometry,GC-MS)技术对不同相对分子质量区间的有机物所占比例及物质结构进行了研究.结果表明,废水中相对分子质量1×103的有机物所占比例最高,达到88.57%;采用GCMS对废水中相对分子质量1×103的级分进行分析,定性出27种化合物,包含醛、酮、酯、醇、酚、酸、烷烃类及其他苯系物等,其峰面积占有机物峰面积总和的比例分别为6.9%、5.3%、35.4%、13.2%、4.6%、0.4%、1.7%、16.8%,总和为84%.UV和FT-IR分析结果均显示不同相对分子质量区间的光谱吸收特征没有明显差别,级分中存在含有不饱和双键、羟基、羰基化合物及芳香族化合物,与GC-MS检测结果相吻合.研究结果为废水处理工艺的开发与优化提供了重要的指导作用.     

Comparison of different combined treatment processes to address the source water with high concentration of natural organic matter during snowmelt period

The source water in one forest region of the Northeast China had very high natural organic matter (NOM) concentration and heavy color during snowmelt period. The efficiency of five combined treatment processes was compared to address the high concentration of NOM and the mechanisms were also analyzed. Conventional treatment can hardly remove dissolved organic carbon (DOC) in the source water. KMnO₄ pre-oxidization could improve the DOC removal to 22.0%. Post activated carbon adsorption improved the DOC removal of conventional treatment to 28.8%. The non-sufficient NOM removal could be attributed to the dominance of large molecular weight organic matters in raw water, which cannot be adsorbed by the micropore upon activated carbon. O₃ + activated carbon treatment are another available technology for eliminating the color and UV₂₅₄ in water. However, its performance of DOC removal was only 36.4%, which could not satisfy the requirement for organicmatter. The limited ozone dosage is not sufficient to mineralize the high concentration of NOM. Magnetic ion-exchange resin combined with conventional treatment could remove 96.2% of color, 96.0% of UV₂₅₄ and 87.1% of DOC, enabling effluents to meet the drinking water quality standard. The high removal efficiency could be explained by the negative charge on the surface of NOM which benefits the static adsorption of NOM on the anion exchange resin. The results indicated that magnetic ion-exchange resin combined with conventional treatment is the best available technology to remove high concentration of NOM.     

Effect of different molecular weight organic components on the increase of microbial growth potential of secondary effluent by ozonation

Ozonation has been widely applied in advanced wastewater treatment. In this study, the effect of ozonation on assimilable organic carbon （AOC） levels in secondary effluents was investigated, and AOC variation of different molecular weight （MW） organic components was analyzed. Although the removal efflciencies were 47%-76% and 94%-100% for UV2s4 and color at ozone dosage of 10 mg/L, dissolved organic carbon （DOC） in secondary effluents was hardly removed by ozonation. The AOC levels increased by 70%-780% at an ozone dosage range of 1-10 mg/L. AOC increased significantly in the instantaneous ozone demand phase, and the increase in AOC was correlated to the decrease in UV254 during ozonation. The results of MW distribution showed that, ozonation led to the transformation of larger molecules into smaller ones, but the increase in low MW （〈1 kDa） fraction did not contribute much to AOC production. The change of high MW （〉100 kDa and 10-100 kDa） fractions itself during ozonation was the main reason for the increase of AOC levels. Furthermore, the oxidation of organic matters with high MWs （〉 100 kDa and 10-100 kDa） resulted in more AOC production than those with low MWs （1-10 kDa and 〈1 kDa）. The results indicated that removing large molecules in secondary effluents could limit the increase of AOC during ozonation.     

混凝沉淀-UF工艺去除二级出水中ARGs效能研究

为了研究混凝沉淀-UF工艺对城市污水处理厂二级出水中ARGs（抗生素抗性基因）去除的影响,以PACl（聚合氯化铝）和PFS（聚合硫酸铁）作为混凝剂,采用qPCR（实时荧光定量聚合酶链式反应）和EEM（三维荧光光谱）等分析混凝沉淀-UF工艺对ARGs的削减及其影响因素.结果表明:① PACl、PFS投加量（分别以Al、Fe计,下同）分别为0.85、0.50 mmol/L时,与直接UF工艺相比,混凝沉淀-UF工艺对水中各类ARGs的去除量高2~3个数量级,其中PACl-UF工艺的效果更好,去除量为2.51~3.52个数量级;对水中DOC（溶解性有机碳）、富里酸类及溶解性微生物代谢产物的去除效果更好,DOC去除率由18%升至36%.②直接UF、PACl-UF、PFS-UF 3种工艺膜进、出水的线性拟合结果显示,ARGs浓度与ρ（DOC）、16S rDNA浓度均呈显著正相关.研究显示,混凝沉淀-UF工艺可以有效去除二级出水中的ARGs,且有机物、16S rDNA的去除有助于ARGs的削减.      

印染废水RO浓水水质分析

以江苏某印染废水处理厂反渗透（RO）浓水为研究对象,采用多种分析手段分析了RO浓水的水质特征.首先采用IC和ICP-MS对水中的无机离子进行了定性和定量分析,采用GC-MS对废水中的半挥发性有机物进行定性和定量分析.结果表明,RO浓水中无机离子以Na⁺、Cl^-和SO₄^2-为主,半挥发性有机物邻苯二甲酸二（2-乙基己）酯（DEHP）为主要成分,其浓度为1.452mg/L.为分析RO浓水中的溶解性有机物（DOM）特征,进一步采用超滤膜分子量分级法和树脂亲疏水分离技术对废水中的DOM进行分离解析,分析了不同组分的溶解性有机碳（DOC）、UV₂₅₄、SUVA含量和分布情况,应用三维荧光光谱对各组分物质进行了定性分析.超滤分级表明,RO浓水中相对分子量<1k的有机物占56.98%,相对分子质量5~10k有机物仅占2.19%,但其芳香化程度较高.树脂分离结果表明,RO浓水中亲水性物质（HPI^*）、疏水性物质（HPO^*）和过渡性物质（TPI^*）的DOC含量差异不大,其中HPO^*的芳香构造化程度最高,含有较多的色氨酸类芳香族蛋白质,而HPI^*中含有较多的溶解性微生物代谢产物类物质.     

超滤工艺净化微污染原水的试验研究

采用混凝沉淀-超滤工艺对微污染原水进行试验,对组合工艺的除污染特性进行了研究。结果表明,组合工艺对浊度、颗粒物和藻类的去除效果非常好。出水浊度稳定在0.1NTU以下,水中粒径>2μm的颗粒数约19个/mL,藻类平均数量约为2.2×104个/L。在去除有机物方面,组合工艺对高锰酸盐指数、UV254和DOC的去除率分别为38.0%、15.2%和32.6%,其中对高锰酸盐指数的去除效果较为突出,出水高锰酸盐指数浓度为2.69~2.87mg/L。组合工艺去除的有机物是分子量大于3KD的大分子有机物,对小分子有机物去除效果不明显。其中,混凝沉淀主要去除了水中的疏水性有机物和亲水荷电有机物,超滤膜去除的有机物则以亲水中性有机物为主。在工艺运行期间,超滤膜的跨膜压差增加了约12.3%,跨膜压差的升高主要由被超滤膜吸附的小分子有机物产生。