碱改性活性炭对VOCs的吸附性能

选用3种经氢氧化钠改性的活性炭,研究了其对4种代表性VOCs(丁酮、乙酸乙酯、甲苯和四氯化碳)的吸附规律。结果表明:活性炭经碱改性后吸附性能有较大改善,吸附量的大小与其比表面积呈正相关性,而其比表面积多为微孔提供;改性活性炭对有机气体的吸附以物理吸附为主;吸附质的相对分子质量、密度、熔点与其在改性活性炭上的吸附量具有线性相关性,而沸点、饱和蒸气压、分子动力学直径则与吸附量无明显相关性;对于同一吸附剂,170℃再生时的性能最好,130℃次之,210℃最差。     

轻烃类VOCs在活性炭上的动态吸附行为

采用BET,XRD,FTIR技术对两类椰壳活性炭进行了表征,考察了空速和吸附温度对正戊烷和正己烷动态吸附穿透容量(DPC)及穿透时间的影响,并对正戊烷和正己烷的二元竞争吸附过程进行了研究。结果表明:两类活性炭材料的组成和官能团结构相似,具有大量微孔的片状活性炭(FAC)有利于轻烃类VOCs的吸附;采用FAC吸附正己烷时,DPC对空速和温度变化不敏感;二元竞争吸附过程中,开始阶段正戊烷和正己烷同时被吸附,随后已被吸附的正戊烷被强吸附质正己烷部分置换,直至正己烷吸附饱和,与一元吸附相比,正己烷的DPC和饱和吸附容量略有增加,正戊烷的DPC和饱和吸附容量大幅降低。     

活性炭吸附回收挥发性有机物的研究进展

活性炭吸附法是目前使用范围最为广范、技术最为成熟的回收挥发性有机物（VOCs）的方法。该法与冷凝法联用，可达到经济、高效回收VOCs的目的。介绍了变压吸附和变温吸附等常见的活性炭吸附回收VOCs的工艺，分析比较了各工艺的特点，并指出了存在的问题。在总结现有研究进展的基础上，预测了活性炭吸附回收VOCs技术的发展趋势。     

超临界二氧化碳萃取再生吸苯活性炭的研究

以工业废水中的典型污染物苯作为单一吸附质,进行了超临界二氧化碳萃取再生活性炭研究,探讨了操作温度、操作压力、CO2流速、活性炭粒度、循环再生次数等因素对再生效率及再生速率的影响。试验结果表明,超临界CO2对活性炭中的苯具有良好的再生效果。     

活性炭对气体中二硫化碳吸附性能的研究

研究了４种不同活性炭的孔结构及对二硫化碳的平衡吸附性能,并对４种活性炭床层的穿透性进行了考察,为选择吸附净化废气中低浓度二硫化碳的吸附剂奠定了基础。     

活性炭纤维对气体中醋酸丁酯吸附性能的研究

通过试验选择活性炭纤维作为吸附剂,吸气气体中醋酸丁酯。对影响其吸附性能的主要因素进行了研究。     

多孔CO2吸附剂研究进展

CO2吸附分为物理吸附和化学吸附。物理吸附主要发生在微孔内，常见的物理吸附剂包括活性炭、沸石、硅胶等。调整多孔材料的结构可以改变吸附性能。通过在多孔材料尤其是介孔材料孔表面接枝或浸渍胺类等碱性物质，将物理吸附转化为新化学吸附，是提高多孔吸附剂吸附性能的有效方法。综述了活性炭、沸石、硅胶和改性介孔材料等多种多孔CO2吸附剂的研究进展，指出了研究和改进的方向。     

沸石和糠醛渣对硝酸盐吸附性影响的研究

利用沸石和糠醛渣改性制得硝酸盐吸附剂,研究吸附剂的饱和吸附能力和各种影响因子(温度、pH值、吸附时间、吸附质浓度、吸附剂用量和干扰离子)对硝酸盐吸附性能的影响。结果表明,改性沸石和糠醛渣的硝酸盐吸附能力大大增强;影响因子对吸附剂吸附硝酸盐能力的影响很大,其中升温有利于解吸、在中性pH值附近脱除率较高、干扰离子可降低吸附剂的硝酸盐脱除率;影响因子对改性糠醛渣MF的吸附影响要比对改性沸石的影响大。因此,改性沸石在实际应用中比改性糠醛渣MF的硝酸盐吸附能力强,具有更好的应用前景。     

氯化锌活化法制备甘蔗渣活性炭吸附剂

采用氯化锌活化法制备了甘蔗渣活性炭吸附剂，并考察了活化剂氯化锌溶液浓度、活化温度和活化时间对吸附剂吸附性能的影响。实验结果表明，氯化锌活化法制备甘蔗渣活性炭吸附剂的最佳工艺条件为：活化温度800℃、氯化锌溶液质量浓度190g／L、活化时间60min。所得甘蔗渣活性炭吸附剂的得率为30．3％，碘吸附值为1070mg／g，亚甲基蓝吸附值（以0．1g吸附剂吸附的亚甲基蓝体积计）为15．0mL，达到了GB／T13803．2—1999《木质净水用活性炭》一级品标准（碘吸附值1000mg／g，亚甲基蓝吸附值9mL）。     

氯甲烷废气处理方法的选择

根据柔软剂生产中季胺化反应过程所排氯甲烷废气的具体情况,对它的处理选择了吸附处理工艺。同时,对两种吸附剂——活性炭和活性炭纤维进行了分析、比较,选择了活性炭纤维作为本处理工艺的吸附剂。     

响应面法优化阴阳极同时作用电化学法处理染料废水

在自制电化学反应器中,以甲基橙模拟染料废水为处理对象,采用Box-Behnken Design响应面法研究了影响阴阳极同时作用电化学法处理染料废水的因素及其交互作用。实验得出各因素对废水脱色率影响的大小顺序为：电流密度> Fe³⁺浓度>Cl^-浓度。各因素之间的交互作用对废水脱色率影响的大小顺序为：电流密度和Fe³⁺浓度>电流密度和Cl^-浓度>Fe³⁺浓度和Cl^-浓度。优化结果表明：Fe³⁺浓度为1.02 mmol/L、Cl^-浓度为10.96 mmol/L、电流密度为11.52 mA/cm²时,最佳脱色率为94.67%。阴阳极同时作用电化学法对甲基橙去除效果显著。     

Agricultural solid waste for the removal of organics: adsorption of phenol from water and wastewater by palm seed coat activated carbon

Adsorption studies for phenol removal from aqueous solution on activated palm seed coat carbon (PSCC) were carried out under varying experimental conditions of contact time, phenol concentration, adsorbent dose and pH. Adsorption equilibrium was reached within 3 h for phenolic concentrations 10-60 mg l(-1). Kinetics of adsorption obeyed a first order rate equation. The percent removal remained constant over the pH range 4-9 for a phenolic concentration of 25 mg (l-1). The equilibrium data could be described well by the Freundlich isotherm equation. The adsorption of phenol on PSCC follows the film diffusion process. A comparative study with a commercial activated carbon showed that PSCC is two times more effective than commercial activated carbon. The studies showed that the palm seed coat carbon can be used as an efficient adsorbent material for the removal of phenolics from water and wastewater.     

ACF床动态吸附及脱附性能试验研究

利用活性炭纤维(ACF)床在热态下进行动态吸附及脱附性能试验,研究了W/Q、水蒸汽含量对ACF吸附性能的影响,并利用ACF的选择性吸附性能,采用分段吸附,以达到同时高效吸附SO2和NOx.对ACF床进行了水洗脱附与负吸热空气法脱附试验.     

黑索金废水的处理

以球形活性炭为吸附剂，用吸附法处理黑索金（ＲＤＸ）废水，出水能够达到国家排放标准，球形活性炭的动态饱和吸附量为０．１２３－０．１４０ｇ／ｇ，吸附带长为２ｍ。吸附饱和的球形活性炭，可用碱液以复再生。笔者还提出了数学模型，导出了处理实验数据公式，此公式可推广应用于同类吸附实验数据处理。     

Removal of PCDD/F from flue gases in fixed or moving bed adsorbers

Whereas the PCDD/F-abatement in MSWIs is mostly achieved through entrained-phase adsorption upon activated carbon, the other thermal processes are more bending towards fixed/moving bed adsorption or catalytic destruction. The treatment of entrained-phase adsorption has been previously dealt with. The present paper focuses upon fixed/moving bed adsorption as abatement alternative. The characteristics of granular carbonaceous adsorbents are reviewed and commented upon, and stress some advantages of the fixed/moving bed operation. The equilibrium adsorption characteristics are expressed in terms of the number of active sites of the adsorbent and its saturation capacity. The breakthrough calculations for a fixed/moving bed adsorber are based upon these adsorption characteristics and expressed in terms of the relevant operating parameters of the flue gases to be treated. Although detailed literature data on these adsorbers are scarce, application of the design equations predicts meaningful results, thus demonstrating the predictive capacity of the design method.     

Experimental and Modeling Studies for the Removal of Crystal Violet Dye from Aqueous Solutions using Eco-friendly <Emphasis Type="Italic">Gracilaria corticata</Emphasis> Seaweed Activated Carbon/Zn/Alginate Polymeric Composite Beads

This research article describes, an eco-friendly activated carbon prepared from the Gracilaria corticata seaweeds which was employed for the preparation of biodegradable polymeric beads for the efficient removal of crystal violet dye in an aqueous solution. The presence of chemical functional groups in the adsorbent material was detected using FTIR spectroscopy. The morphology and physical phases of the adsorbent materials were analyzed using SEM and XRD studies respectively. Batch mode dye adsorption behavior of the activated carbon/Zn/alginate polymeric beads was investigated as a function of dosage, solution pH, contact time, initial dye concentration and temperature. Maximum dye removal was observed at a pH of 5.0, 1 g of adsorbent dosage with 60 mg/L dye concentration, 50 min of contact time and at 30 °C. The equilibrium modeling studies were analyzed with Freundlich and Langmuir adsorption isotherms and the adsorption dynamics was predicted with Lagergren’s pseudo-first order, pseudo-second order equations and intra particle diffusion models. The process of dye removal followed a pseudo second-order kinetics rather than pseudo first order. The thermodynamic parameters like standard Gibbs free energy change (ΔG°), enthalpy change (ΔH°) and entropy change (ΔS°) were determined and the results imply that the adsorption process was spontaneous, endothermic and increases the randomness between the adsorbent and adsorbate. The results from the experimental and correlation data reveal that the Gracilaria corticata activated carbon/Zn/alginate polymeric beads have proved to be an excellent adsorbent material for the removal of CV dye.     

颗粒状污泥活性炭流化床吸附处理含铜矿山废水

以城市污水处理厂活性污泥为原料，通过高温热解制备了颗粒状污泥活性炭吸附剂。在自制的流化床吸附装置上研究了该吸附剂对含铜矿山废水的吸附处理效果。实验结果表明：在初始废水pH6、吸附剂加入量15g/L、废水循环流量6.0L/min、吸附时间120min的最佳吸附条件下，废水中Cu²⁺去除率达98.2%。