Phosphate recovery from greenhouse wastewater

A study was conducted to investigate the suitability of phosphate recovery from greenhouse wastewaters by using precipitation/crystallization process. More than 90% of the phosphate could be removed from the greenhouse wastewater. Various calcium phosphate salts were obtained in the process; hydroxyapatite [Ca5(PO4)3OH] could be the main product from the precipitates. Phosphate removal was affected by the presence of magnesium ion in wastewaters. An increase of magnesium concentrations in wastewaters decreased phosphate removal rates. The chemical contents of precipitates in terms of calcium, magnesium and phosphate were affected by calcium to magnesium molar ratio. Higher calcium contents were obtained at wastewaters with high calcium to magnesium molar ratio. An addition of magnesium did not affect the potassium contents in the precipitates. K-struvite, MgKPO4 x 6H2O, was not the major product in the precipitate, even with addition of a large quantity of magnesium.     

利用白云石回收污泥厌氧消化液中的磷

为经济有效地从污泥厌氧消化液中回收磷,构建了以白云石提供钙镁源的磷回收方法,探讨了磷回收的工艺条件与效果。通过盐酸酸化厌氧消化液以降低其碳酸盐含量,同时利用白云石溶于冷稀盐酸的特性使其钙镁缓慢释放到酸化的厌氧消化液中形成第一步磷回收体系,考察体系酸化pH、白云石与厌氧消化液的固液比以及反应pH对白云石的钙镁释放和磷回收效果的影响;第一步磷回收后的上清液为第二步厌氧消化液磷回收提供钙镁源,研究投加钙磷摩尔比对磷回收效果的影响。实验结果表明,当固液比为5.0时,在酸化pH为4.0～4.5且酸化溶出时间为10 h以及反应pH为9.0的条件下,第一步磷回收产物以磷酸钙盐沉淀为主,厌氧消化液磷回收率及回收产物含磷率（以P2O5计）分别达到99.43%和38.49%;第一步磷回收后的上清液按一定的钙磷摩尔比投加到酸化后的厌氧消化液中进行第二步磷回收,当投加钙磷摩尔比为0.20时,在反应pH为9.0的条件下,回收产物同时含有磷酸钙盐和磷酸铵镁,厌氧消化液中氮、磷回收率分别达到13.19%和90.90%,回收产物氮、磷含量（以P2O5计）分别为0.26%和39.58%;经XRD、XRF、ICP及SEM等分析表征,2步磷回收的产物以磷酸钙盐和磷酸铵镁为主要成分,杂质少。研究表明,利用白云石为钙镁源,通过分别构建不同的磷回收体系可以分步从污泥厌氧消化液中经济有效地回收磷,且磷回收率和回收产物含磷率高。     

Nutrients removal and recovery by crystallization of magnesium ammonium phosphate from synthetic swine wastewater

With synthetic swine wastewater, lab-scale batch experiments were carried out to investigate the effects of pH value, magnesium dosage, calcium and carbonate concentrations on magnesium ammonium phosphate (MAP) crystallization. The morphology of the precipitates obtained was observed by using scanning electron microscopy with energy dispersive X-ray analysis, and the composition of the precipitates was analyzed with X-ray diffraction. The results show that the optimum pH value for MAP crystallization is in the range of 9.5-10.5; the phosphorus removal efficiency increases with the increase of Mg/P molar ratio; the optimum Mg/P molar ratio is 1.4, and excessive Mg dosage does not show significant effect on the efficiency improvement of MAP crystallization; the co-existing of Ca in solution disturbs the morphology and purity of the MAP product, and amorphous calcium phosphate will form when Ca increases to a certain concentration; CO3(2-) can affect the P removal efficiency, but does not obviously affect the morphology and purity of MAP.     

The Effects of Magnesium and Ammonium Additions on Phosphate Recovery from Greenhouse Wastewater

Phosphorus recovery from greenhouse wastewater, using precipitation-crystallization, was conducted under three levels of calcium concentration, 304 mg/L (7.6 mmol/L), 384 mg/L (9.6 mmol/L), and 480 mg/L (12 mmol/L), and also with additions of ammonium and magnesium into the wastewater. Jar test results confirmed high phosphate removal, with more than 90% of the removal achieved with a pH as low as 7.7. Under the low calcium concentration, ammonium addition affected the chemical reactions at pH lower than 8.0, where struvite was produced; when the pH was raised to 8.8, other calcium compounds dominated the precipitation. Under the medium calcium concentration, ammonium and magnesium addition helped struvite precipitation in the low pH range. Hydroxyapatite (HAP) was the main product. Under the high calcium concentration, ammonium addition showed no effects on the precipitation.     

Simultaneous removal of phosphorus and potassium from synthetic urine through the precipitation of magnesium potassium phosphate hexahydrate

This study investigated the simultaneous removal of P and K from synthetic urine through the precipitation of magnesium potassium phosphate hexahydrate (MPP, MgKPO₄·6H₂O) in bench-scale experiments. Results show that the removal efficiencies of P and K are mainly determined by the solution pH and the molar ratio of Mg:K:P. Co-precipitation of struvite-type compounds, i.e., magnesium ammonium phosphate hexahydrate (MAP, MgNH₄PO₄·6H₂O), magnesium sodium phosphate heptahydrate (MSP, MgNaPO₄·7H₂O), and MPP, was confirmed by analysis of the solid precipitates using a Scanning Electron Microscope/Energy Dispersive X-ray Apparatus and an X-ray Diffractometer. The co-precipitation significantly influenced the removal of K. As much ammonium as possible should be removed prior to MPP precipitation because MAP had higher tendency to form than MPP. The inevitable co-precipitation of MPP and MSP resulted in the addition of more MgCl₂·6H₂O and Na₂HPO₄·12H₂O to obtain the high removal of K. In total, the removal efficiencies of P and K were 77% and 98%, respectively, in the absence of ammonium when pH was 10 and the molar ratio of Mg:K:P was 2:1:2. The results indicate that the MPP precipitation is an efficient method for the simultaneous removal of P and K to yield multi-nutrient products.     

Effects of acidifying reagents on microwave treatment of dairy manure

Dairy manure, acidified using organic acids (acetic, oxalic, and citric acid) were treated with microwave enhanced advanced oxidation process (MW/H₂O₂-AOP). The effect of a mixture of oxalic acid and commonly used mineral acids (sulfuric and hydrochloric acid) on MW/H₂O₂-AOP was also examined. Substantial amounts of phosphorus were released under MW/H₂O₂-AOP, regardless of organic acid or mineral acid used. All three organic acids were good acidifying reagents; however, only oxalic acid could remove free calcium ion in the solution, and improve settleability of dairy manure. The MW/H₂O₂-AOP and calcium removal process could be combined into a single-stage process, which could release phosphate, solubilize solids and remove calcium from dairy manure at the same time. A mixture of oxalic acid and mineral acid produced the maximum volume of clear supernatant and had an ideal molar ratio of calcium to magnesium for effective struvite (magnesium ammonium phosphate) crystallization process. A single-stage MW/H₂O₂-AOP would simplify the process and reduce mineral acid consumption compared to a two-stage operation. The results of a pilot scale study demonstrate that MW/H₂O₂-AOP is effective in treating manure and recovering resource from dairy farms.     

The effects of magnesium and ammonium additions on phosphate recovery from greenhouse wastewater

Phosphorus recovery from greenhouse wastewater, using precipitation-crystallization, was conducted under three levels of calcium concentration, 304 mg/L (7.6 mmol/L), 384 mg/L (9.6 mmol/L), and 480 mg/L (12 mmol/L), and also with additions of ammonium and magnesium into the wastewater. Jar test results confirmed high phosphate removal, with more than 90% of the removal achieved with a pH as low as 7.7. Under the low calcium concentration, ammonium addition affected the chemical reactions at pH lower than 8.0, where struvite was produced; when the pH was raised to 8.8, other calcium compounds dominated the precipitation. Under the medium calcium concentration, ammonium and magnesium addition helped struvite precipitation in the low pH range. Hydroxyapatite (HAP) was the main product. Under the high calcium concentration, ammonium addition showed no effects on the precipitation.     

苦土和氧化镁处理氮磷废水的对比研究

分别采用苦土、纯氧化镁为沉淀剂对模拟高浓度氮磷废水(N/P=0.8)进行了脱氮除磷研究,比较了沉淀剂投加量、pH对2种沉淀剂处理氮磷废水的影响,对沉淀产物进行XRD分析,并进行了经济效益比较。结果表明,pH是影响2种沉淀剂处理氮磷废水的主要因素,随着pH的增加,脱氮除磷效果提高,在平衡pH为9～10之间时氮磷处理效果最佳,pH继续增加,由于磷酸镁沉淀的形成使得氨氮去除率降低。此外,处理相同的废水,苦土的最佳投加量要大于纯氧化镁,但是经济效益比较结果表明,以苦土为沉淀剂处理氮磷废水可大大降低处理成本。     

不同Ca/P比下碳酸根对磷酸钙沉淀反应回收磷的影响

以模拟污水处理厂污泥厌氧消化液为处理对象,进行磷酸钙沉淀除磷小试实验,考察了不同Ca/P物质的量比下碳酸根(CO2-3)对磷酸钙沉淀反应回收磷的影响;利用扫描电镜(SEM)、X射线衍射仪(XRD)和傅里叶变换红外光谱(FTIR)对沉淀产物进行表征。结果表明,磷酸钙沉淀反应是一个快速过程,CO2-3的存在并未改变这一显著特征。磷酸钙沉淀反应过程中,CO2-3的存在降低了磷的去除率,改变了沉淀物形貌、结构和组分;实验设定范围内,磷酸钙的过饱和度越高,越难形成晶体态羟基磷灰石((Ca5(PO4)3OH,HAP);当pH值为9.0,Ca/P比为1.67时,CO2-3取代HAP晶格中的PO3-4,形成碳磷灰石(CHAP);当pH值为9.0,Ca/P比为3.33和5.01时,CO2-3和PO3-4之间竞争,形成碳酸钙(CaCO3);增大Ca/P能有效提高磷的去除率,降低CO2-3对磷酸钙沉淀反应的抑制作用,但综合考虑实际效果,选择Ca/P比为3.33作为适宜的反应条件。     

污水中磷的回收和利用途径

综述了近年来污水中磷回收的主要技术方法,重点针对磷酸铵镁结晶法,对磷酸铵镁的形成、用途及该方法的可行性做了详细的介绍与评述.同时,阐述了利用磷酸盐溶解微生物,实现磷产品肥效的回收.并对今后磷回收、回用工作的开展,提出了建议.     

诱导结晶法去除地下水中氟离子简

针对现行高氟地下水处理工艺中存在的工艺复杂、运行管理困难等问题，提出采用诱导结晶法除氟。其技术核心是在高氟水中投加氟磷灰石作为晶种，并投加磷酸盐和钙盐使水中氟离子在晶种表面生成氟磷酸钙（Ca₁₀（PO₄） ₆F₂）结晶。通过单因素实验得出最佳工艺条件：投加8g/L氟磷灰石，并投加NaH₂PO₄和CaCl₂，使钙离子、磷酸根离子和氟离子的摩尔比为10：5：1，搅拌速度为100 r/min，反应时间1 h。反应中磷酸根离子和钙离子的利用率分别达到98%和25%以上。电子扫描显微镜（SEM）表征晶种在参与反应后，表面有结晶生成。研究表明，采用诱导结晶法可将水中氟离子浓度从5~10 mg/L降至1 mg/L以下，达到饮用水水质标准。     

低浓度含砷污酸处理工艺的比较研究

比较研究了石灰中和法和石灰-铁盐法对硫化后含低浓度砷(20～50 mg/L)污酸的处理效果。结果表明,单纯采用石灰法,废水难以达标排放;而两段石灰-铁盐(氯化铁)法满足达标排放的同时,一段及二段沉淀物的浸出液中砷、镉、铜、铅和锌含量均低于危险废物鉴别标准要求(GB 5085.3-2007);其最优工艺参数为一段终了pH=2,反应时间为2 h,二段终了pH=8、Fe/As=8、反应时间为60 min、氧化剂投加量(Ca(ClO)2/As)为6∶1;正交实验结果中各参数对铁盐除砷效果影响顺序为终了pH>反应时间>Fe/As>氧化剂投加量。     

Repeated use of MAP decomposition residues for the removal of high ammonium concentration from landfill leachate

The residues of magnesium ammonium phosphate (MAP) decomposed by heating under alkali conditions were repeatedly used as the sources of phosphate and magnesium for the removal of high ammonium concentration from landfill leachate. Up to 96% of ammonium in MAP powder could be released under the following conditions: NH4(+):OH- molar ratio, 1:1; temperature, 90 degrees C; heating time, 2 h. Fourier transform infrared spectra and X-ray diffraction analysis of MAP before and after heating demonstrated that MAP was mainly transformed to amorphous magnesium sodium phosphate (MgNaPO4), which makes it possible for the NH4(+) to replace Na+ in MgNaPO4 to form more stable struvite. Successful ammonium removal was achieved by using the MAP decomposition residues as the sole phosphate and magnesium sources. The ammonium removal decreased gradually following the increase of MAP reuse cycles, and in the 6th cycle, ammonium removals of 84% and 62% were achieved for synthetic wastewater and landfill leachate, respectively. Analysis of the surfaces of MAP powders acquired at different reuse cycles using scanning electron microscopy with energy dispersive X-ray suggested that the existence of calcium, kalium and aluminum ions in landfill leachate might have inhibited the formation of MAP through competition with ammonium ions for phosphate ions. It is estimated that reuse of MAP for 3 cycles could save about 44% chemical costs.     

Removal of nitrogen and phosphate from wastewater by addition of bittern

Removal of nitrogen and phosphate through crystallization of struvite (MgNH(4)PO(4).6H(2)O) has gained increasing interest. Since wastewaters tend to be low in magnesium relative to ammonia and phosphates, addition of this mineral is usually required to effect the struvite crystallization process. The present study evaluated the feasibility of using bittern, a byproduct of salt manufacture, as a low-cost source of magnesium ions. High reaction rates were observed; the extent of nitrogen and phosphorus removals did not change beyond 10 min. Phosphorus removals from pure solutions with bittern added were equivalent to those obtained with MgCl(2) or seawater. Nitrogen removals with bittern were somewhat lower than with the alternate Mg(2+) sources, however. Application of bittern to biologically treated wastewater from a swine farm achieved high phosphate removal, but ammonia removals were limited by imbalance in the nitrogen:phosphorus ratio.     

Phosphorus removal in a sulfur–limestone autotrophic denitrification (SLAD) biofilter

The sulfur–limestone autotrophic denitrification (SLAD) biofilter was able to remove phosphorous from wastewater during autotrophic denitrification. Parameters influencing autotrophic denitrification in the SLAD biofilter, such as hydraulic retention time (HRT), influent nitrate (NO₃ ^?), and influent PO₄ ^3? concentrations, had significant effects on P removal. P removal was well correlated with total oxidized nitrogen (TON) removed in the SLAD biofilter; the more TON removed, the more efficient P removal was achieved. When treating the synthetic wastewater containing NO₃ ^?-N of 30 mg L^?1 and PO₄ ^3?-P of 15 mg L^?1, the SLAD biofilter removed phosphorus of 45 % when the HRT was 6 h, in addition with TN removal of nearly 100 %. The optimal phosphorus removal in the SLAD biofilter was around 60 %. For the synthetic wastewater containing a PO₄ ^3?-P concentration of 15 mg L^?1, the main mechanism of phosphorus removal was the formation of calcium phosphate precipitates.     

Nitrogen and phosphorus removal for swine wastewater by ammonium crystallization and intermittent aeration process

Abstract

A process on crystallized precipitation of ammonium by adding magnesium salt and phosphate was carried out to improve C/N ratio in swine wastewater. After completion of crystallized precipitation of ammonium, an intermittent aeration process with aeration and non‐aeration periods alternated at interval of 1:1 hr day^‐1 is used for the improved swine wastewater (T‐N/BOD=0.14: BOD=8200 mg/liter and T‐N=1166 mg/liter). The results obtained from the experiment show that the removal ratios of T‐N and NH₄‐N are 91% and 99%, respectively. T‐P is not removed, while the removal ratio of PO₄‐P is 60% as 3% of CaCl₂ liquid is added. The results also indicate that dilution with water is effective to improve the removal of phosphorus even if raw swine wastewater contains high concentrations of T‐N, T‐P, BOD, and TOC.     

酸性条件下剩余污泥中Ca2＋和Mg2＋溶出对磷回收的影响

为了在酸性条件下实现剩余污泥中磷的高效回收，对pH=3时剩余污泥水解酸化过程中氨氮、正磷酸盐和钙镁离子的溶出现象以及磷回收进行了研究分析。结果表明：当pH=3时，所溶出的氨氮、镁离子和钙离子与磷酸盐的摩尔比均大于1，能满足采用鸟粪石沉淀法或者羟磷灰石沉淀法回收磷的要求；但所溶出的钙镁离子的摩尔比大于1，会对鸟粪石沉淀法回收磷的顺利进行有较大影响；有无外加镁剂对磷回收率影响不大。采用改型后的镁型强酸性阳离子交换树脂进行离子交换可以得到较高纯度的鸟粪石沉淀产品，通过XRD检测其纯度为95％以上。     

污水深度处理微絮凝-D型滤池工艺运行性能与经济性分析

根据昆明市第一污水处理厂深度处理微絮凝-D型滤池工艺的运行数据,评价了工艺出水水质及总磷(TP)去除效果,同时分析了混凝剂投加量及药剂费用。结果表明,微絮凝-D型滤池工艺出水TP平均浓度为0.15 mg/L,最优水平值为0.05 mg/L,95%保证值为0.37 mg/L,TP平均去除率为63.6%。出水悬浮固体(SS)浓度95%保证值为10 mg/L。混凝剂聚合氯化铝(PAC)的投加量在1.5~4 mg Al2O3/L范围波动,去除单位TP的PAC投加量平均值为16.7 mg Al2O3/mg-P,投加比为2~8 mol-Al/mol-P。当投加比超过5时,出水TP浓度可达到0.3 mg/L以下。吨水PAC成本平均值为0.017元/t。     

Microwave Pretreatment for Enhancement of Phosphorus Release from Dairy Manure

Both the advanced oxidation process (AOP) using a combination of hydrogen peroxide addition and microwave heating (H₂O₂/microwave), and the microwave heating process were used for solubilization of phosphorus from liquid dairy manure. About 80% of total phosphate was released into the solution at a microwave heating time of 5 min at 170°C. With an addition of H₂O₂, more than 81% of total phosphate could be released over a reaction period of 49 h at ambient temperature. The AOP process could achieve up to 85% of total phosphate release at 120°C. The results indicated that both the microwave, and the AOP processes could effectively release phosphate from liquid dairy manure. These processes could serve as pretreatments for phosphorus recovery from animal wastes, and could be combined with the struvite crystallization process to provide a new approach in treating animal wastes.     

Simultaneous Sulfur Dioxide and Nitrogen Dioxide Removal by Calcium Hydroxide and Calcium Silicate Solids

ABSTRACT

At conditions typical of a bag filter exposed to a coal-fired flue gas that has been adiabatically cooled with water, calcium hydroxide and calcium silicate solids were exposed to a dilute, humidified gas stream of nitrogen dioxide (NO₂) and sulfur dioxide (SO₂) in a packed-bed reactor. A prior study found that NO₂ reacted readily with surface water of alkaline and non-alkaline solids to produce nitrate, nitrite, and nitric oxide (NO). With SO₂ present in the gas stream, NO₂ also reacted with S(IV), a product of SO₂ removal, on the exterior of an alkaline solid. The oxidation of S(IV) to S(VI) by oxygen reduced the availability of S(IV) and lowered removal of NO₂. Subsequent acidification of the sorbent by the removal of NO₂ and SO₂ facilitated the production of NO. However, the conversion of nitrous acid to sulfur-nitrogen compounds reduced NO production and enhanced SO₂ removal. A reactor model based on empirical and semi-empirical rate expressions predicted rates of SO₂ removal, NO₂ removal, and NO production by calcium silicate solids. Rate expressions from the reactor model were inserted into a second program, which predicted the removal of SO₂ and NO_x by a continuous process, such as the collection of alkaline solids in a baghouse. The continuous process model, depending upon inlet conditions, predicted 30-40% removal for NO and 50-90% removal for SO₂. These x 2 results are relevant to dry scrubbing technology for combined SO₂ and NO_x removal that first oxidizes NO to NO₂ by the addition of methanol into the flue duct.