Experimental research of dyeing and printing wastewater treatment by flocculation-MBR combined technology

采用絮凝—膜生物反应器(MBR)组合工艺进行印染废水处理的试验研究.结果表明,调节pH至8.5、搅拌时间为30min时,COD和色度去除效果最佳；而单纯絮凝工艺对印染废水处理效果不理想,最佳运行条件为64 mg/L NaOH+75 mg/L饱和石灰水+0.2 mg/L聚丙烯酰胺(PAM)+3 mg/L硅酸钠+8 mg/L聚合氯化铝(PAC),COD和NH3-N平均去除率分别达到23.91％、31.17％.在上述最佳运行条件下,采用絮凝—MBR组合工艺处理印染废水,效果较显著；出水COD均值可达42.2mg/L,其平均去除率为91.62％;出水NH3-N均值可达6.26 mg/L,其平均去除率为92.43％,出水水质可达到《城镇污水处理厂污染物排放标准》(GB 18918-2002)一级B标准.     

混凝—水解酸化—好氧工艺处理印染废水的设计与运行

采用混凝-水解酸化-好氧工艺处理印染废水,设计规模3000m3/d.当进水C0D在571～1752 mg/L时,处理后的出水可达国家<污水综合排放标准>(GB 8978-1996),主要污染物ρ(C0D)＜100mg/L.     

臭氧-曝气生物滤池处理酸性玫瑰红染料废水

在实验室配制含酸性玫瑰红染料的印染废水,采用臭氧氧化-曝气生物滤池工艺开展处理试验.试验运行结果表明,臭氧氧化处理能提高模拟废水的可生化性,BOD/COD值由原水的0.18上升到0.36.经组合工艺处理后出水COD＜40 mg/L,色度40倍以下,SS约50 mg/L,处理效果良好.     

印染废水出水回用与实践

采用过滤-碳纤维吸附工艺对印染废水一级出水进行深度处理,废水COD可由80 mg/L降至30～40mg/L,出水水质完全满足生产工艺回用水要求.该技术具有工艺简单、投资少、运行费用低、操作简单等优点,特别适用于水资源短缺的中小印染企业.     

臭氧催化氧化工艺深度处理印染废水

采用正交实验对催化剂NiO/γ-A12O3的制备条件进行优化,并探讨臭氧催化氧化法对于印染废水的深度处理效能.结果表明,最优的催化剂制备条件为:浸渍液浓度为3％、浸渍时间为4h、灼烧温度为450℃、灼烧时间为3h.臭氧催化氧化反应15 min时,COD浓度由84.22 mg/L降低至50.00 mg/L以下;氨氮浓度由10.88 mg/L降低至5.01 mg/L;色度去除率达到69％,明显高于单纯臭氧氧化的反应效率.     

常规组合工艺-稳定塘-湿地系统处理印染废水

针对工业园区印染企业产生的印染废水和生活污水,采用独特的"常规组合工艺与‘植物稳定塘-人工湿地系统’联合工艺"对其进行集中统一处理,并考察了运行效果。数据结果表明,系统出水COD、BOD5、SS、色度、NH3-N和TP平均分别为63.2 mg/L、13.8 mg/L、5.0 mg/L、49倍、0.2 mg/L和0.4 mg/L,出水水质达到国家污水综合排放一级标准(GB8978-1996)。该工艺运行稳定,可有效去除废水中的COD、SS和色度,去除率均在90%以上。按日均处理量4×104m3计算,此工艺每年将削减COD排放近30万t。     

ClO2氧化/TiO2复合吸附剂协同体系处理印染废水的实验研究

利用ClO2 氧化/TiO2 复合吸附剂协同体系对处理实际印染废水进行了实验研究.结果表明,对于COD为750 mg/L、色度为250倍、SS为100 mg/L的1 000 mL印染废水,当溶液pH为4.0、ClO2 用量20 mg/L、TiO2 复合吸附剂用量2.5 g、反应时间和吸附时间分别为2、8 min时,处理后的废水COD＜100 mg/L、色度＜40倍、SS＜70 mg/L,达到了《纺织染整工业水污染物排放标准》(GB 4287-92)排放要求.并对两者的协同机理进行了理论上的探讨.     

水解酸化—铁炭微电解—好氧生化工艺处理印染废水

采用水解酸化-铁炭微电解-好氧生化工艺对印染废水进行了处理.COD为3 000～4 000 mg/L、BOD5为750～1 000 mg/L、色度为500～600倍、NH3-N为30～40 mg/L、SS为200～300 mg/L、pH为6～10的印染废水,经该工艺处理,后出水达到了<纺织染整工业水污染物排放标准>(GB 4287-92)的一级标准.运行结果表明,该工艺具有运行稳定、管理简单等优点.     

接触氧化-人工湿地去除印染废水中的COD

采用絮凝沉淀＋接触氧化＋人工湿地工艺处理印染废水中COD研究.结果表明,斜板沉淀池出水COD平均值为1322 mg/L,此间COD去除率为38.6%;二沉池出水COD平均值为71 mg/L,此段COD去除率达94.6%;人工湿地出水COD平均值为37 mg/L,人工湿地COD去除率为48.0%.处理设施COD总去除率98.3%.     

微电解反应器应用于印染废水深度处理的小试研究

利用铁炭微电解反应器对印染废水的深度处理进行了实验研究，检验了微电解设备的性能，确定了其设备的最大负荷、反冲洗周期以及填料更换的周期，并对曝气影响反应器运行的状况进行了研究。该工艺对COD的去除率均达到70％以上，色度去除率为99％，盐度达1000mg／L以下，硬度达220mg／L以下，出水水质达到印染废水的回用水质标准。     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

Radionuclides and trace elements in fish collected upstream and downstream of Los Alamos national laboratory and the doses to humans from the consumption of muscle and bone

Abstract

The purpose of this study was to determine radionuclide and trace element concentrations in bottom‐feeding fish (catfish, carp, and suckers) collected from the confluences of some of the major canyons that cross Los Alamos National Laboratory (LANL) lands with the Rio Grande (RG) and the potential radiological doses from the ingestion of these fish. Samples of muscle and bone (and viscera in some cases) were analyzed for ³H, ⁹⁰Sr, ¹³⁷Cs, ^totU, ²³⁸Pu, ^239,240Pu, and ²⁴¹Am and Ag, As, Ba, Be, Cr, Cd, Cu, Hg, Ni, Pb, Sb, Se, and Tl. Most radionuclides, with the exception of ⁹⁰Sr, in the muscle plus bone portions of fish collected from LANL canyons/RG were not significantly (p<0.05) higher from fish collected upstream (San Ildefonso/background) of LANL. Strontium‐90 in fish muscle plus bone tissue significantly (p<0.05) increases in concentration starting from Los Alamos Canyon, the most upstream confluence (fish contained 3.4E‐02 pCi g^‐1 [126E‐02 Bq kg^‐1]), to Frijoles Canyon, the most downstream confluence (fish contained 14E‐02 pCi g^‐1 [518E‐02 Bq kg^‐1]). The differences in ⁹⁰Sr concentrations in fish collected downstream and upstream (background) of LANL, however, were very small. Based on the average concentrations (±2SD) of radionuclides in fish tissue from the four LANL confluences, the committed effective dose equivalent from the ingestion of 46 lb (21 kg) (maximum ingestion rate per person per year) of fish muscle plus bone, after the subtraction of background, was 0.1 ± 0.1 mrem y^‐1 (1.0 ± 1.0 μSv y^‐1), and was far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem y^‐1 (1000 μSv y^‐1). Of the trace elements that were found above the limits of detection (Ba, Cu, and Hg) in fish muscle collected from the confluences of canyons that cross LANL and the RG, none were in significantly higher (p<0.05) concentrations than in muscle of fish collected from background locations.     

A History of Dry Cleaners and Sources of Solvent Releases from Dry Cleaning Equipment

Approximately 25, 000-35, 000 dry cleaning facilities currently operate in the U.S. The release of perchloroethylene and other solvents from these establishments represents a major source of soil and groundwater contamination. The manner in which dry cleaning solvents escape from dry cleaning plants is, for all practical purposes, identical for chlorinated and petroleum hydrocarbon solvents and is related to one of the following events: the catastrophic failure of a component of the dry cleaning system, the improper installation, operation or maintenance of the dry cleaning equipment or a combination of all of these causes. Acceptable customs, codes and regulations can also dictate what is authorized for operation of a dry cleaning facility in a particular community, geographic area during a particular time frame. Environmental litigation dealing with the origin of a solvent release from dry cleaners tends to focus on the design and manufacture of dry cleaning industry machines such as washers, washer extractors, tumblers, solvent filters, water separators, stills and spotting boards. A thorough analysis of the daily operations of dry cleaners often reveals that poor maintenance, failure to follow the manufacturer's instructions and the actions of the operator are the most likely causes of soil and groundwater pollution. In order to forensically evaluate the most probable origins of a solvent release and to examine issues regarding liability, a thorough understanding of the history of dry cleaning and a detailed analysis of the operation and maintenance of the dry cleaning equipment are necessary. The discovery of solvent plumes in the vicinity of dry cleaning plants may suggest that the solvent source is the dry cleaning plant; however, the presence of these plumes does not necessarily indicate that the dry cleaning equipment was defectively designed or manufactured. A thorough review of the type of equipment used over the life of the dry cleaning plant and verifiable solvent mileage records frequently indicates that operators of the plant have disposed of solvent and contaminated solids into the municipal sewer or on ground surfaces.     

Radionuclides in deer and elk from Los Alamos national laboratory and the doses to humans from the ingestion of muscle and bone

Abstract

This paper summarizes radionuclide concentrations (³H, ⁹⁰Sr, ¹³⁷Cs, ²³⁸Pu, ^239,240Pu, ²⁴¹Am, and ^totU) in muscle and bone tissue of mule deer (Odocoileus hemionus) and Rocky Mountain elk (Cervus elaphus) collected from Los Alamos National Laboratory (LANL), Los Alamos, New Mexico, lands from 1991 through 1998. Also, the committed effective dose equivalent (CEDE) and the risk of excess cancer fatalities (RECF) to people who ingest muscle and bone from deer and elk collected from LANL lands were estimated. Most radionuclide concentrations in muscle and bone from individual deer (n = 11) and elk (n = 22) collected from LANL lands were either at less than detectable quantities (where the analytical result was smaller than two counting uncertainties) and/or within upper (95%) level background (BG) concentrations. As a group, most radionuclides in muscle and bone of deer and elk from LANL lands were not significantly higher (p<0.10) than in similar tissues from deer (n = 3) and elk (n = 7) collected from BG locations. Also, elk that had been radio collared and tracked for two years and spent an average time of 50% on LANL lands were not significantly different in most radionuclides from road kill elk that have been collected as part of the environmental surveillance program. Overall, the upper (95%) level net CEDEs (the CEDE plus two sigma for each radioisotope minus background) at the most conservative ingestion rate (50 lbs of muscle and 13 lbs of bone) were as follows: deer muscle = 0.22 mrem y^‐1 (2.2 μSv y^‐1), deer bone = 3.8 mrem y^‐1 (38 μSv y^‐1), elk muscle = 0.12 mrem y^‐1 (1.2 μSv y^‐1), and elk bone = 1.7 mrem y^‐1 (17 μSv y^‐1). All CEDEs were far below the International Commission on Radiological Protection guideline of 100 mrem y^‐1 (1000 μSv y^‐1), and the highest muscle plus bone net CEDE corresponded to a RECF of 2E‐06, which is far below the Environmental Protection Agency upper level guideline of 1E‐04.     

Leaching of seven pesticides currently used in cotton crop in Mato Grosso State—Brazil

This study aimed to evaluate the leaching of pesticides and the applicability of the Attenuation Factor (AF) Model to predict their leaching. The leaching of carbofuran, carbendazim, diuron, metolachlor, α and β endosulfan and chlorpyrifos was studied in an Oxisol using a field experiment lysimeter located in Dom Aquino – Mato Grosso. The samples of percolated water were collected by rain event and analyzed. Chemical and physical soil attributes were determined before pesticide application to the plots. The results showed that carbofuran was the pesticide that presented a higher leaching rate in the studied soil, so was the one representing the highest contamination potential. From the total carbofuran applied in the soil surface, around 6 % leached below 50 cm. The other pesticides showed lower mobility in the studied soil. The calculated values to AF were 7.06E-12 (carbendazim), 5.08E-03 (carbofuran), 3.12E-17 (diuron), 6.66E-345 (α-endosulfan), 1.47E-162 (β-endosulfan), 1.50E-06 (metolachlor), 3.51E-155 (chlorpyrifos). AF Model was useful to classify the pesticides' potential for contamination; however, that model underestimated pesticide leaching.     

Endosulfan in China 2—emissions and residues

Background, aim, and scope  Endosulfan is one of the organochlorine pesticides (OCPs) and also a candidate to be included in a group of new persistent organic pollutants (UNEP 2007). The first national endosulfan usage inventories in China with 1/4° longitude by 1/6° latitude resolution has been reported in an accompanying paper. In the second part of the paper, we compiled the gridded historical emissions and soil residues of endosulfan in China from the usage inventories. Based on the residue/emission data, gridded concentrations of endosulfan in Chinese soil and air have been calculated. These inventories will provide valuable data for the further study of endosulfan. Methods  Emission and residue of endosulfan were calculated from endosulfan usage by using a simplified gridded pesticide emission and residue model—SGPERM, which is an integrated modeling system combining mathematical model, database management system, and geographic information system. By using the emission and residue inventories, annual air and soil concentrations of endosulfan in each cell were determined. Results and discussion  Historical gridded emission and residue inventories of α- and β-endosulfan in agricultural soil in China with 1/4° longitude by 1/6° latitude resolution have been created. Total emissions were around 10,800 t, with α-endosulfan at 7,400 t and β-endosulfan at 3,400 t from 1994 to 2004. The highest residues were 140 t for α-endosulfan and 390 t for β-endosulfan, and the lowest residues were 0.7 t for α-endosulfan and 170 t for β-endosulfan in 2004 in Chinese agricultural soil where endosulfan was applied. Based on the emission and residue inventories, concentrations of α- and β-endosulfan in Chinese air and agricultural surface soil were also calculated for each grid cell. We have estimated annual averaged air concentrations and the annual minimum and maximum soil concentrations across China. The real concentrations will be different from season to season. Although our model does not consider the transport of the insecticide in the atmosphere, which could be very important in some areas during some special time, the estimated concentrations of endosulfan in Chinese air and soil derived from the endosulfan emission and residue inventories are in general consistent with the published monitoring data. Conclusions  To our knowledge, this work is the first inventory of this kind for endosulfan published on a national scale. Concentrations of the chemical in Chinese air and agricultural surface soil were calculated for each grid cell. Results show that the estimated concentrations of endosulfan in Chinese air and soil agree reasonably well with the monitoring data in general. Recommendations and perspectives  The gridded endosulfan emission/residue inventories and also the air and soil concentration inventories created in this study will be updated upon availability of new information, including usage and monitoring data. The establishment of these inventories for the OCP is important for both scientific communities and policy makers.     

Impact of spiked concentrations of Cd,Pb, As and Zn in growth medium on elemental uptake of Nasturtium officinale (Watercress)

This study is aimed at investigating the impact of water quality on the uptake and distribution of three non-essential and toxic elements, namely, As, Cd and Pb in the watercress plant to assess for metal toxicity. The plant was hydroponically cultivated under greenhouse conditions, with the growth medium being spiked with varying concentrations of As, Cd and Pb. Plants that were harvested weekly for elemental analysis showed physiological and morphological symptoms of toxicity on exposure to high concentrations of Cd and Pb. Plants exposed to high concentrations of As did not survive and the threshold for As uptake in watercress was established at 5 ppm. Translocation factors were low in all cases as the toxic elements accumulated more in the roots of the plant than the edible leaves. The impact of Zn on the uptake of toxic elements was also evaluated and Zn was found to have an antagonistic effect on uptake of both Cd and Pb with no notable effect on uptake of As. The findings indicate that phytotoxicity or death of the watercress plant would prevent it from being a route of human exposure to high concentrations of As, Cd and Pb in the environment.     

Butyltin compounds in sediment and fish from the Polish Coast of the Baltic Sea

Concentrations of mono- (MBT), di- (DBT), and tri-(TBT) butyltin compounds were measured in eggs, liver, and muscle of nine species of fish from four regions of the Baltic Sea - the Firth of Vistula, the Gulf of Gdańsk, Puck Bay, and the mouth of the Vistula River. The overall concentration ranges among all the fish sampled from the four sites were: < 7 to 79 ng/g for MBT, 6 to 1100 ng/g for DBT, 7 to 3600 ng/g for TBT, and 16 to 4800 ng/g for total BTs, on a wet wt basis. The highest concentration of total BTs was found in herring liver from the Firth of Vistula (4800 ng/g, wet wt) and in roach muscle from Puck Bay (3300 ng/g, wet wt), while the least concentration was found in burbot eggs and liver from the Vistula River (39 and 32 ng/g, wet wt, respectively). TBT was the major form of BTs present in most samples analyzed. Sediment samples collected from shipyards in the Gulf of Gdańsk contained butyltin concentrations ranging from 1.2 to 46 μg/g (dry wt) for MBT, 2.0 to 42 μg/g for DBT, and 2.6 to 40 μg/g for TBT. As with the fish, the majority of the BTs in sediment were present as TBT, which suggested recent exposure of the aquatic environment of the region to TBT.     

Malathion-induced sublethal toxicity on the hematology of cricket frog (Fejervarya limnocharis)

The effect of malathion [diethyl(dimethoxythiophosphorylthio)succinate] at sublethal concentration (0.006 ppm) on hematological parameters of the cricket frog (Fejervarya limnocharis) was studied for 24 hrs to 240 hrs of exposure and remarkable hematological alterations were observed. The study on hematological parameters revealed a highly significant decrease (P < 0.01) in the total erythrocytes count in malathion-exposed animals from 24 hours to 96 hrs of exposure as compared to control. Significant decreases (P < 0.01) of hemoglobin and packed cell volume were also observed from 48 hrs to 240 hrs. A significant increase (P < 0.01) in leucocytes count was noted throughout the exposure period. Elevated numbers of lymphocytes and eosinophils as found in the present study revealed lymphocytosis as well as eosinophilia, suggesting that this was a result of direct stimulation of the immunological defense due to the presence of a toxic substance or may be associated with tissue damage. The cytomorphological and cytopathological study of erythrocytes and leucocytes in malathion-exposed frogs at 0.006 ppm concentration revealed various cytotoxic effects at different exposure times. It was noted that the size and the shape of the erythrocytes were subjected to variation in different blood disorders.