Anaerobic digestion of a mixture of cheese whey, poultry waste and cattle dung: a study of the use of adsorbents to improve digester performance

This paper-describes the results of a study aimed at improving the efficiency of anaerobic digestion of a mixture of cattle dung, poultry waste and cheese whey at a ratio of 2 : 1 : 3 (w/w on dry weight basis) in terms of total gas production, methane content and process stability by adding various adsorbents. The adsorbents appeared to improve the digester performance, for example about a two-fold enhancement in total gas production with 17% enriched methane content were achieved with the addition of 4 g litre(-1) of silica gel.     

Biomethanation of tobacco waste

Tobacco is an important cash crop produced in considerable quantities in India. During cigarette manufacturing large quantities of tobacco waste are produced annually and its disposal is a serious ecological problem. In the present study a process for the biodegradation of tobacco waste, under methanogenic conditions, was developed so that environmental pollution can be reduced while producing biogas as a useful energy source. The methanogenic bacterial consortium developed for the anaerobic degradation of tobacco waste without any chemical pretreatment in a single stage digester at 15 days HRT (hydraulic retention time) has been successfully scaled-up to install a 10 m(3) biogas plant. The gas yields (1 kg(-1 TS fed) day(-1)) varied from 169 to 282 depending on the ambient temperatures. The methane content in the biogas produced was 60%. The pH and VFA content of the digested slurry were 6.8 +/- 0.1 and 599 mg litre(-1), respectively. Nicotine, COD and BOD reductions were 75, 60 and 80%, respectively.     

A kinetic study of anaerobic digestion of olive mill wastewater at mesophilic and thermophilic temperatures

The kinetics of the anaerobic digestion of olive mill wastewater (OMW) was studied in the mesophilic and thermophilic ranges of temperature. Two completely mixed continuous flow bioreactors operating at 35 degrees C and 55 degrees C and with an average biomass concentration of 5.45 g VSS litre(-1) were used. The thermophilic reactor worked satisfactorily between hydraulic retention times (HRT) of 10 to 40 days, removing between 94.6 and 84.4% of the initial chemical oxygen demand (COD). In contrast, the mesophilic reactor showed a marked decrease in substrate utilization and methane production at a HRT of 10 days. TVFA levels and the TVFA/alkalinity ratio were higher and close to the suggested limits for digester failure. The yield coefficient for methane production (1 CH(4) STP g(-1) COD(added)) was 28% higher in the thermophilic process than in the mesophilic one. Macroenergetic parameters, calculated using Guiot's kinetic model, gave yield coefficients for the biomass (Y) of 0.18 (mesophilic) and 0.06 g VSS g(-1) COD (thermophilic) and specific rates of substrate uptake for cell maintenance (m) of 0.12 (mesophilic) and 0.27 g COD g(-1) VSS.day(-1) (thermophilic). The experimental results showed the rate of substrate uptake (R(s); g COD g(-1) VSS.day(-1)), correlated with the concentration of biodegradable substrate (S(b); g COD litre(-1)), through an equation of the Michaelis-Menten type for the two temperatures used.     

Combined anaerobic/aerobic digestion: effect of aerobic retention time on nitrogen and solids removal

A combined anaerobic/aerobic sludge digestion system was studied to determine the effect of aerobic solids retention time (SRT) on its solids and nitrogen removal efficiencies. After the anaerobic digester reached steady state, effluent from the anaerobic digester was fed to aerobic digesters that were operated at 2- to 5-day SRTs. The anaerobic system was fed with a mixture of primary and secondary sludge from a local municipal wastewater treatment plant. Both systems were fed once per a day. The aerobic reactor was continuously aerated with ambient air, maintaining dissolved oxygen level at 1.1 +/- 0.3 mg/L. At a 4-day or longer SRT, more than 11% additional volatile solids and 90% or greater ammonia were removed in the aerobic digester, while 32.8 mg-N/L or more nitrite/nitrate also was measured. Most total Kjeldahl nitrogen removal was via ammonia removal, while little organic nitrogen was removed in the aerobic digester.     

An activated sludge process to reduce the pollution load of a dye-industry waste

A laboratory-scale activated sludge process was developed to reduce the pollution load of a dye-industry waste, containing aniline, phenol, methyl violet and rhodamine B as its major components. The waste exerted an organic load of 5576 mg litre(-1) as the chemical oxygen demand (COD), of 896 mg litre(-1) as total organic carbon (TOC), and had a 31.5 mg litre(-1) phenol content. A microbial sludge, capable of growing on the waste, was developed from cattle dung, adapted to the waste and used as a bioinoculum for the process. This resulted in reductions of 60% in COD, 37% in TOC, and 92% in phenol content, and a decrease in optical density of the colour of the waste from an initial 0.915 to 0.360 at 580 nm. Microorganisms isolated from sludge were identified as Pseudomonas alcaligenes and P. mendocina.     

Removal of TNT and RDX from water and soil using iron metal

Contaminated water and soil at active or abandoned munitions plants is a serious problem since these compounds pose risks to human health and can be toxic to aquatic and terrestrial life. Our objective was to determine if zero-valent iron (Fe(0)) could be used to promote remediation of water and soil contaminated with 2,4,6-trinitrotoluene (TNT) and hexahydro-1,3,5-trinitro-1,3,5-triazine (RDX). As little as 1% Fe(0) (w/v) removed 70 mg TNT litre(-1) from aqueous solution within 8 h and removed 32 mg RDX litre(-1) within 96 h. Treating slurries (1:5 soil:water) of highly contaminated soil (5200 mg TNT and 6400 mg RDX kg(-1) soil) from the former Nebraska Ordnance Plant (NOP) with 10% Fe(0) (w/w soil) reduced CH(3)CN-extractable TNT and RDX concentrations below USEPA remediation goals (17.2 mg TNT and 5.8 mg RDX kg(-1)). Sequential treatment of a TNT-contaminated solution (70 mg TNT litre(-1) spiked with (14)C-TNT) with Fe(0) (5% w/v) followed by H(2)O(2) (1% v/v) completely destroyed TNT and removed about 94% of the (14)C from solution, 48% of which was mineralized to (14)CO(2) within 8 h. Fe(0)-treated TNT also was more susceptible to biological mineralization. Our observations indicate that Fe(0) alone, Fe(0) followed by H(2)O(2), or Fe(0) in combination with biotic treatment can be used for effective remediation of munitions-contaminated water and soil.     

Responses of bean (Phaseolus vulgaris L. cv. Pros) to chronic ozone exposure at two levels of atmospheric ammonia

Plants of bean (Phaseolus vulgaris cv. Pros) were exposed to a range of O3 concentrations up to 70 nl litre(-1) for 9 h day(-1) in the presence (45 nl litre(-1)) and absence (21 nl litre(-1)) of enhanced NH3 in 12 open-top chambers. Treatment effects on visible injury, growth and yield were assessed after 49 (intermediate harvest) and 62 days of exposure (final harvest). The proportion of leaves with visible injury at final harvest increased with increasing concentrations of O3. Enhanced NH3 did not cause any symptoms and did not affect injury by O3. The estimated seasonal mean concentration corresponding with 5% injury was circa 23 nl litre(-1) O3. Biomass production and green pod yield decreased with increasing concentrations of O3 and were generally stimulated by enhanced NH3 at both harvests. Adverse effects of O3 on biomass and pod yield did not depend on the NH3 level. Relative yield response to increasing 9-h daily mean O3 concentrations was nonlinear and yield losses of 5 and 10% were calculated to occur at seasonal daytime mean concentrations of 27 and 33 nl litre(-1) O3, respectively. Linear regression showed that the Accumulated exposures Over a Threshold of 30 (AOT30) and 40 nl litre(-1) (AOT40) O3 performed equally well. The estimated accumulated O3 exposures corresponding with a yield loss of 5% were 1600 nl litre(-1) h for AOT30 and 400 nl litre(-1) h for AOT40. The results are discussed in relation to the long-term critical level that is used as a guideline to protect crops against adverse effects by O3.     

Reproductive status, blood chemistry, gill histology and growth of perch (Perca fluviatilis) in three acidic lakes

Perch (Perca fluviatilis L.) were sampled soon after spawning in three small acidic lakes (pH 4.3-6.1, Al(lab) 5-106 microg litre(-1), Ca2+ 0.01-0.08 mmol litre(-1)) and in one circumneutral lake (pH 5.9-6.4, Al(lab) 4-12 microg litre(-1), Ca2+ 0.06-0.07 mmol litre(-1)) in southern Finland. Due to the delayed spawning of perch in the acidic lakes, sampling in those lakes was performed later than in the reference lake. In spite of that, the gonadosomatic index (GSI) of males in all the acidic lakes was significantly greater than in the reference lake. Of the two lakes with similar low water pH, the effects on reproduction were more prominent in the lake with higher water Al content. The plasma Ca2+ concentrations of females in the acidic lakes were significantly smaller than in the females of the reference lake. The low female:male plasma Ca2+ ratio (1.0-1.32) depicted delay of spawning. Stress in perch in acidic water was also seen in elevated blood haematocrit values, especially in females. On the other hand, a low plasma Cl- level, a common response to acidic water in salmonids, was not detected in perch in the most acidic lakes. The amount of Al accumulated in the gill epithelium was highest in the most acidified lake with high Al concentration, but was also pronounced in a lake with low pH and low Al concentration.     

Chemistry of soil solutions under different kinds of vegetation in the vicinity of a thermal power station

The influence of atmospheric deposition on the chemical characteristics of soil solutions in a small catchment area in NW Spain was studied. The soils, developed from slates, were sampled from seven sites supporting different forms of vegetation (deciduous and pine forest and heath). Soil solutions were extracted, by the column displacement method, from soil samples collected monthly from March 1992 until November 1993. The solutions were acidic with a low content of basic cations. The most common ions in all horizons were Cl(-) and Na(+), due to marine influence. In the surface horizons (0-10 cm), relatively high concentrations of SO(2-)4 (150-380 micromol litre(-1)) and Zn (approximately 2 micromol litre(-1)) were obtained, with good correlation between the two ions. These results, along with the prevalence of inorganic forms of Al (50-90% of total Al), were related to the effects of acidic deposition in the catchment area. The more rapid breakdown of litter in the soils under deciduous forest explains the greater ionic concentrations obtained in these solutions.     

The effectiveness of lime-based amendments and bauxite residues at removing phosphorus from piggery effluent

Piggery effluent may contribute to the eutrophication of waterways, if it is not treated before disposal, because of high levels of phosphorus. Limes and red muds (a residue from bauxite refining) were used to remove phosphorus from piggery effluent (41 mg litre(-1) total P). Lime-based amendments were more effective than the red muds at removing phosphorus when compared at the same liquid: solid ratios. Based on laboratory data, the cost of treating effluent increased rapidly as the final required phosphorus concentration decreased to less than 4 mg litre(-1). Kiln dust was the cheapest amendment tested down to 2 mg litre(-1). Hydrated lime was able to clarify and flocculate the effluent to 1 mg litre(-1) within 60 min. The re-useability of all limes may be determined by a simple pH test. Red mud could be used to remove phosphorus when its pH was lowered to 6.0-6.5 and it is used at liquid:solid ratios <20:1.     

Fluoride induced changes in protein metabolism in the tissues of freshwater crab Barytelphusa guerini

Exposure of the freshwater field crab Barytelphusa guerini to a sublethal concentration of NaF (30 mg litre(-1)) caused significant alterations in protein metabolism. After an exposure time of 15 days, the crab was found to have a marked depletion of total protein and free amino acid content. A significant elevation in transaminases, Aspartate aminotransferase (AAT) and Alanine aminotransferase (ALAT), and Glutamate dehydrogenase (GDH) activities was reflected in the free amino acid levels of the tissues.     

Sulphite and sulphate concentrations in weathering products of sandy limestone and in deposition samples

The sulphite and sulphate concentrations in weathering products of limestone and in wet and total deposition samples were measured by the modified West-Gaeke method and by ion chromatography. The sulphite content in the weathering crust and in the runoff rainwater of two historical buildings in Belgium, was always much lower than the sulphate content. The maximum sulphite to sulphate ratio was 2.5%. The sulphite concentration in wet and total deposition samples was in the low or sub ppm range except during two misty periods when the sulphite concentration was 6.8 and 21 mg litre(-1). In those samples a high sulphate concentration was also found (nl. 57 and 137 mg litre(-1), respectively).     

Content, distribution and fate of 33 elements in sediments of rivers receiving wastewater in Hanoi, Vietnam

Untreated industrial and domestic wastewater from Hanoi city is discharged into rivers that supply water for various agricultural and aqua-cultural food production systems. The aim of this study was to assess the content, distribution and fate of 33 elements in the sediment and pore water of the main wastewater receiving rivers. The sediment was polluted with potentially toxic elements (PTEs) with maximum concentrations of 73 As, 427 Cd, 281 Cr, 240 Cu, 218 Ni, 363 Pb, 12.5 Sb and 1240 Zn mg kg(-1) d.w. Observed distribution coefficients (log(10) K(d,obs)) were calculated as the ratio between sediment (mg kg(-1) d.w.) and pore water (mg L(-1)) concentrations. Maxima log(10) K(d,obs) were >4.26 Cd, >6.60 Cu, 4.78 Ni, 7.01 Pb and 6.62 Zn. The high values show a strong PTE retention and indicate the importance of both sorption and precipitation as retention mechanisms. Sulphide precipitation was a likely mechanism due to highly reduced conditions.     

Bioaccumulation of cadmium by the freshwater isopod Asellus aquaticus (L.) from aqueous and dietary sources

Experiments were conducted to determine the kinetics and relative importance of aqueous and dietary uptake of cadmium by the freshwater isopod Asellus aquaticus (L.). Test animals were exposed during 30 days to aqueous Cd in a continuous flow system (exposure levels: 0.2 - 10 microg litre(-1)) and kept on a diet of previously contaminated Elodea sp. (range of Cd concentrations: 2-350 microg g(-1), dry weight). Preceding semi-static experiments on dosage-control of the dietary factor revealed a rapid uptake of Cd by Elodea, with relatively high concentration factors (CF), which ranged from 4.8 to 5.5 (dry weight log (CF) after 16 days). For Asellus uptake from water appeared to be the predominant route. Highly significant bioconcentration of cadmium from water was observed in the animals, even at exposure levels below 1.0 microg litre(-1). In the various treatments, direct uptake from water accounted for 50-98% of the body burdens after 30 days exposure. The experimental results were described with a first order one-compartment bioaccumulation model. Model parameter estimates (mean +/- standard error) were obtained for rate constant of uptake (560 +/- 110 day(-1)), rate constant of elimination (0.032 +/- 0.017 day(-1)) and assimilation efficiency of Cd uptake from food (1.1 +/- 0.7%). The (dry weight) bioconcentration factor (BCF) and bioaccumulation factor (BAF) for extrapolated steady state conditions were estimated at 18 000 (BCF) and 0.08 (BAF). Experiments conducted at two different pH levels (5.9 versus 7.6) revealed no significant effects of pH on the uptake of aqueous Cd by the isopods. The results are discussed in relation to their potential significance to the field situation.     

Whole-plant growth and leaf formation in ozonated hybrid poplar (Populus x euramericana)

Seasonal growth was studied in potted cuttings of hybrid poplar (one clone of Populus x euramericana) either exposed to ozone in filtered air (0 = control, 0.05, 0.10 microl litre(-1)) or in ambient air (mean = 0.03 microl litre(-1)). Only at 0.10 microl litre(-1) was biomass production reduced and related to leaf loss rather than leaf formation, since the latter was similar in all treatments. Stem length at 0.10 microl litre(-1) approached that of the control, whereas starch concentration in the green stem bark tended to be reduced, as were the ratios of stem weight/length and root/shoot biomass. The changes in carbon allocation and biomass production gradually became established during the second half of the growing season. At the altered carbon allocation at 0.10 microl litre(-1), the ratio of whole-plant production/attached foliage area resembled that of the other O(3) regimes. However, the latter ratio was strongly reduced at 0.10 microl litre(-1) when calculated on the basis of the potential foliage area, as compensated for the O(3)-induced leaf loss. Thus the carbon return/cost balance of the totally formed foliage was low, although the relative-growth rate of ozonated plants temporarily reached that of the control. The relation between leaf differentiation under ozonation (lowered stomatal density) and whole-plant production remains uncertain. The plant behavior found is discussed in terms of passive response or acclimatization to O(3) stress.     

Trout farm effluents: characterization and impact on the receiving streams

Effluents from three rainbow trout (Oncorhynchus mykiss) farms located in Northern Portugal were characterized and their impact on the receiving streams was evaluated. Mean fish productions in the studied fish farms were 15, 55 and 500 t of trout per year, respectively. The feeding water was abstracted from Fornelo, Inha and Coura Rivers, at flow rates ranging from 1.2 (15 t year(-1) fish farm) to 4.8 litre s(-1) per ton annual fish production (500 t year(-1) fish farm). As the water flows through the farms, net variations in the chemical characteristics were observed: a mean reduction in the dissolved oxygen (DO) concentration between 0.7 and 2.4 mg litre(-1); mean increases between 1.9 and 3.2 mg CaCO3 litre(-1) for total alkalinity, between 0.9 and 14 mg litre(-1) for BOD5, between 0.27 and 1.46 mg litre(-1) for ammonia nitrogen (NH4-N), between 0.060 and 0.579 mg litre(-1) for soluble phosphorus (PO4-P) and less than 16 mg litre(-1) for suspended solids; variations in the pH value and nitrate nitrogen concentration were not statistically significant (p<0.05). At the 500 t year(-1) fish farm it was also possible to detect net increases of total hardness (3.2 mg CaCO3 litre(-1)), electric conductivity (19 mS cm(-1)) and permanganate value (3.6 mgO2 litre(-1)). At the other farms net variations in these parameters were not significant. Net mass flow variations reported to the annual fish production are presented. The DO mass flow decreased, on average, between 255 and 549 g t(-1) of fish per day. The mean daily BOD5 increase ranged from 353 to 1510 g t(-1) of fish. The corresponding ranges for the other parameters were 105-157 g t(-1) for NH4-N, 24-62 g t(-1) for PO4-P, 348-1035 g CaCO3 t(-1) for total alkalinity and 224 x 10(6)-506 x 10(6) t(-1) for mesophilic bacteria. Daily net variations of suspended solids, total hardness, electric conductivity and permanganate value were below 1753 g t(-1), 342 g CaCO3 t(-1), 2081 mS cm t(-1) and 392 gO2 t(-1), respectively. Longitudinal concentration profiles for the most relevant parameters show the impact of the effluent discharges on the physico-chemical and bacteriological river water quality downstream from the trout farms. Analyzing the situations from a purely chemical point of view, the polluted stretches were 3, 5 and 12 km long downstream from the effluent discharges, respectively. The microbiological contamination extended over longer distances.     

Environmental tritium of the Danube basin in Yugoslavia

An overview of environmental distribution of tritium in the Danube basin in Yugoslavia during the period 1976-1990 is presented. Temporal and regional variations of environmental tritium in the Danube along its flow (1425-847 km from the confluence) and its tributaries (the Sava, the Tisa, the Velika Morava and the Timok) at various locations, as well as in alluvial groundwaters, are given. In Belgrade, monthly values of tritium in rainfall ranged from 1.1 to 18.3 Bq litre(-1), with a maximum in the late spring and early summer months. The half-life for decline in concentration was estimated as 8.3+/-1.0 years. The total amount of tritium deposited in the first 6 months during 1976-90 was 35% larger than in the second 6 months for the same period. Seasonal variations were noticeable in rivers and groundwaters, but these were greatly attenuated and smoothed for the latter. Tritium content in the monthly composite samples from the river in the Belgrade region varied between 2.5 and 18.2 Bq litre(-1) for the Danube and from 1.5 to 16.8 Bq litre(-1) for the Sava. The yearly mean values along the Danube and its tributaries ranged from 2.4 to 15.9 Bq litre(-1) with individual measurements 1.0-30.2 Bq litre(-1). The half-lives were between 6.9+/-1.7 for the Velika Morava and 9.4+/-0.9 for the Danube. Groundwaters, particularly ones in the Ranney wells, followed changes of tritium content in the rivers with a time lag from a few days to a month. During the period of observation, tritium content decreased in alluvial waters with half-lives from 9.9+/-1.6 (Belgrade area) to 7.3+/-1.8 (the Velika Morava).     

Acceleration of catalase and peroxidase activities in Lemna minor L. and Allium cepa L. in response to low levels of aquatic mercury

The purpose of this study was to assess certain physiological responses of Lemna minor L. (duckweed) and Allium cepa L. (onion) to aquatic mercury at low concentrations. Following a 96-h exposure of plants to nutrient medium contaminated with known levels of mercuric chloride (HgCl(2)), 0.001 to 4 mg litre(-1) (0.0007 to 2.95 mg Hg litre(-1)) or methyl mercuric chloride (MeHgCl(2)), 0.0001 to 0.1 mg litre(-1) (0.0007 to 0.07 mg Hg litre(-1)), the physiological endpoints measured were the growth of fronds (Lemna minor) or roots (Allium cepa), and catalase and peroxidase activities in both plant assays. The EC(50) for HgCl(2) on the basis of the growth curve of Lemna minor was found to be 2.1 mg litre(-1). HgCl(2) and MeHgCl(2) were lethal to L. minor at concentrations of 4 and 0.01 mg litre(-1), respectively. The range of low concentrations that accelerated growth as well as enzymic activities in L. minor was 0.004 to 0.04 mg litre(-1) for HgCl(2) and 0.001 mg litre(-1) for MeHgCl(2). HgCl(2) and MeHgCl(2) induced maximum enzymic activity in Lemna fronds at concentrations of 0.008 and 0.0005 mg litre(-1), respectively. In Allium roots, catalase activity was accelerated at all the concentrations of HgCl(2) (0.001-2 mg litre(-1)) and MeHgCl(2) (0.0001-0.1 mg litre(-1)) tested. The activity of peroxidase was, however, accelerated by HgCl(2) at concentration range 0.01-1.0 mg litre(-1), or by MeHgCl(2) at 0.001 mg litre(-1). The concentrations of HgCl(2) and MeHgCl(2) that induced the highest enzymic activity in Allium roots were 0.05 mg litre(-1) and 0.001 mg litre(-1), respectively.     

Aluminium speciation in surface waters from a Welsh upland area

The complete aluminium speciation of surface waters from an acidified catchment, during dry weather and during storm episodes, is obtained. For the first time, estimates of adsorbed aluminium (Al(ad)) are reported together with other aluminium species. Al(ad) is calculated from the difference between monomeric aluminium content before and after separation of suspended solids by filtration (0.015 microm pore diameter). This fraction was very significant (Al(ad) >; 40 microg litre(-1)) for samples with high suspended solids content (ss >; 20 mg litre(-1)) collected during storm episodes. Plots of pAl(3+) versus pH for samples collected during dry weather are approximated by a straight line, close to the solubility line of synthetic gibbsite, and have a slope of 2.5, which suggests that these samples were saturated with respect to gibbsite. The cloud of pAl(3+) versus pH points for samples from storm episodes has a near zero slope, and shows a significant degree of undersaturation with respect to synthetic gibbsite. Various mechanisms of aluminium mobilisation are discussed.     

Effects of sludge recirculation rate and mixing time on performance of a prototype single-stage anaerobic digester for conversion of food wastes to biogas and energy recovery

Food wastes have been recognized as the largest waste stream and accounts for 39.25 % of total municipal solid waste in Thailand. Chulalongkorn University has participated in the program of in situ energy recovery from food wastes under the Ministry of Energy (MOE), Thailand. This research aims to develop a prototype single-stage anaerobic digestion system for biogas production and energy recovery from food wastes inside Chulalongkorn University. Here, the effects of sludge recirculation rate and mixing time were investigated as the main key parameters for the system design and operation. From the results obtained in this study, it was found that the sludge recirculation rate of 100 % and the mixing time of 60 min per day were the most suitable design parameters to achieve high efficiencies in terms of chemical oxygen demand (COD), total solids (TS), and total volatile solid (TVS) removal and also biogas production by this prototype anaerobic digester. The obtained biogas production was found to be 0.71 m³/kg COD and the composition of methane was 61.6 %. Moreover, the efficiencies of COD removal were as high as 82.9 % and TVS removal could reach 83.9 % at the optimal condition. Therefore, the developed prototype single-stage anaerobic digester can be highly promising for university canteen application to recover energy from food wastes via biogas production.