钢渣脱除烧结烟气中二氧化硫的实验研究

通过对钢渣的分析,确定了其作为脱硫剂的可能性.从钢渣在不同操作条件下脱硫的实验研究看,钢渣能有效地脱除烟气中的SO2,在湿润状态、低流速条件下,微细钢渣的脱硫能力较强,钢渣作为脱硫剂使用将具有良好的经济效益和环境效益.     

相对湿度对钙基脱硫剂干法烟气脱硫效率的影响

为得到干法烟气脱硫较优的相对湿度,并验证钙基脱硫剂在干法烟气脱硫中的可行性,在模拟干法烟气脱硫实验台上,研究了钙基脱硫剂在不同相对湿度(0～45%)条件下,脱硫剂的出口浓度、脱硫效率和固硫量。结果表明,在相对湿度从0变化至45%时,可以稳定运行的穿透时间由160 min增加到720 min,可达100%脱硫效率的运行时间由0增至580 min,脱硫剂的固硫量从43.37 mg增加到332.09 mg;增加相对湿度能显著提高烟气脱硫效率,在保证烟气不穿透物料且不出现黏壁现象的条件下,较优的相对湿度为45%。研究明确了在低相对湿度条件下此种脱硫剂的可行性并确定了较优化的干法脱硫湿度,为干法脱硫条件的选择提供了参考。     

粗媒体颗粒流化床半干法烟气脱硫

开发了粗媒体颗粒流化床半干法烟气脱硫技术。在流化床内加入惰性粗媒体颗粒，改善脱硫剂与烟气的接触。延长脱硫剂在床内的停留时间，促进脱硫反应进行，提高脱硫效率和脱硫剂利用率。以工业用石灰石为脱硫剂，实验研究了粗媒体颗粒的加入量及其他操作条件对此过程脱硫效率的影响。结果表明：随着粗媒体颗粒粒径减小及床内加入量增加，烟气脱硫效率提高；随着Ca／S增大、饱和接近度降低、空速及脱硫剂颗粒粒径减小，脱硫效率提高。当粗媒体颗粒的静止床高为122mm，饱和接近度为15～18℃、空速为2850h^-1、钙硫比为1．0—1．1、脱硫剂粒径为64μm时，脱硫效率可达90％以上。     

含钒钢渣低温钠化焙烧钒浸出效果及其焙砂湿法脱硫作用

含钒钢渣钠化焙烧过程中添加CaF_2等助剂以降低提钒工艺的能耗,分析了不同因素对低温钠化焙烧后钒浸出效果的影响,并将含钒钢渣焙砂配制成吸收浆液以净化烟气中的SO_2。在浸出钒实现其资源化利用的同时,也探索出一种高效烟气脱硫的新方法。添加3.0%CaF_2作为助剂,温度为700℃、焙烧时间为1 h的条件下,所得焙砂中钒浸出率可达68.1%。X射线衍射(XRD)与热重(TG)分析表明,混合物料中添加CaF_2助剂能促进焙烧过程物相的改变,白云母、钛铁矿等衍射峰明显减弱,含钒钢渣混合料在700℃条件下便呈现明显的热失重,在较低温度条件下即可实现钠化焙烧。以此含钒焙砂配制脱硫吸收浆液,脱硫率不低于95%的穿透时间可达125 min,而同样条件下磷矿浆脱硫系统仅为35 min。     

氢氧化钠-钢渣双碱法烧结烟气脱硫工艺

在鼓泡反应器中考察了氢氧化钠-钢渣双碱法烧结烟气脱硫的主要影响因素。结果表明,在温度为常温,钢渣反应时间为2 h,钢渣加入量为40 g,SO2进口浓度为2 400 mg/m3,钢渣粒径为200目以上,烟气流量为0.05 m3/h,循环液pH保持在7～8,Na+浓度为0.5 mol/L,循环液为500 mL的条件下,脱硫率可长时间保持在80%以上。同时,对钢渣-氢氧化钠双碱法烧结烟气脱硫机理进行了探讨。     

粗媒体颗粒流化床半干法烟气脱硫

开发了粗媒体颗粒流化床半干法烟气脱硫技术.在流化床内加入惰性粗媒体颗粒,改善脱硫剂与烟气的接触,延长脱硫剂在床内的停留时间,促进脱硫反应进行,提高脱硫效率和脱硫剂利用率.以工业用石灰石为脱硫剂,实验研究了粗媒体颗粒的加入量及其他操作条件对此过程脱硫效率的影响.结果表明:随着粗媒体颗粒粒径减小及床内加入量增加,烟气脱硫效率提高;随着Ca/S增大、饱和接近度降低、空速及脱硫剂颗粒粒径减小,脱硫效率提高.当粗媒体颗粒的静止床高为122 mm,饱和接近度为15～18℃、空速为2850 h-1、钙硫比为1.0～1.1、脱硫剂粒径为64μm时,脱硫效率可达90%以上.     

飞灰/水菱镁石新型复合脱硫剂的性能研究

采用飞灰和水菱镁石水合搅拌制备飞灰/水菱镁石新型复合脱硫剂,模拟湿法烟气脱硫过程,采用正交实验分析法探讨了液固比(质量比)、反应温度、搅拌速度以及鼓泡深度4个因素对脱硫效率的影响。结果发现:复合脱硫剂的比表面积增大,这有利于该复合脱硫剂与气相SO2的接触和反应,因而提高了脱硫效率。复合脱硫剂的最佳反应组合:液固比为15.0∶1.0、反应温度为常温(20℃)、搅拌速度为150r/min、鼓泡深度为2.0cm,该条件下脱硫效率为98.58%。     

石灰石高温煤气脱硫的试验研究

采用天然石灰石做脱硫剂，在固定床上进行硫化氢高温脱除的试验研究，考察了脱硫剂粒径、反应温度、气速及高温煤气中H2对石灰石脱硫性能的影响，同时还用热重分析(TG)、扫描电镜(SEM)、X-射线衍射(XRD)等测试手段对脱硫剂的物相组成和结构等进行了表征。结果表明，脱硫剂的粒径对脱硫效果的影响很大，0.38～0.83 mm的石灰石脱硫效果最佳；温度对脱硫效果的影响比较复杂，最佳的操作温度为850℃；气速对脱硫效果的影响较明显，脱硫剂的穿透时间随气速的减小而加长；H₂对脱硫过程起阻碍作用，气速越小，这种阻碍作用越明显。     

飞灰及其混合脱硫剂浆液脱硫特性的实验研究

从碱性物溶出率和脱硫容量两个方面，对杭州地区3种电厂飞灰和飞灰－大理石混合脱硫剂进行了实验研究。结果表明，降低pH值有利于飞灰中碱性物的溶出，pH为5－8时，飞灰中碱性物溶出率约为30％。不同电厂飞灰的脱硫容量差异较大，为0.12-0.25gSO2/g飞灰，相当于石灰石脱硫容量的23％－48％。飞灰－大理石混合脱硫剂中飞灰与大理石之间具有相互协同促进作用，对飞灰：大理石为1：1的混合脱硫剂，其脱硫容量Ws60比大理石提高了30％。当脱硫率要求不太高时，可考虑使用飞灰－大理石混合脱硫剂，以部分或全部取代石灰石脱硫剂，从而大大降低脱硫剂成本。     

不锈钢钢渣单颗粒成分分析及用于烟气脱硫的模拟试验

为研究不锈钢钢渣化学成分及用于烟气脱硫的可行性,采用电子探针微区分析技术对太原钢铁(集团)有限公司不锈钢钢渣进行单颗粒形貌和组分分析,然后测定钢渣中游离氧化钙含量和浆液的pH,在此基础上,开展了将其用于烟气脱硫的模拟试验,研究了钢渣干湿状态、粒径对脱硫效率和失效时间的影响。结果表明,不锈钢钢渣颗粒呈不规则形状,主要成分包括CaO、MgO、Al2O3、SiO2等,其中游离氧化钙占4%~7%;钢渣浆液呈碱性。浸湿状态下80目以上钢渣脱硫率大于60%,失效时间170min。表明不锈钢钢渣具备一定的烟气脱硫潜力,可以考虑用来"以废治废"。     

钙基脱硫剂高温固硫性能的影响因素试验分析

对含硫量为1．51％的大同煤，在不同的气氛和工况下加入钙基脱硫剂，并辅以添加剂，在800—1200℃的高温下开展了较为系统的试验和分析。与CaCO3和CaO相比，Ca（OH）2具有更好的高温固硫性能；Ca（OH）2、CaCO3和CaO在900℃左右均表现出很好的固硫率；氧化气氛较适用于1000℃以下固硫；高温取Ca／S比为2．0～2．5时较适合；按一定比例添加Fe2O3、SiO2和Al2O3配置的复合脱硫剂脱硫效率更高（试验值66．67％），复合添加剂能提高1000℃以上的固硫率，加宽了最佳固硫温度范围，且能维持比较稳定的高温固硫效果；不同条件下，CaSO4分解特性不同。     

钙质煤渣吸附剂脱除烟气中二氧化硫的实验研究

利用锅炉本身排出的煤渣作脱硫剂的基本核粒,配人少量的石灰,加水搅拌均匀,使石灰裹覆在煤渣颗粒表面,制成具有较大比表面积的钙质煤渣脱硫剂,用于烟气脱硫实验研究.实验结果表明,钙制煤渣脱硫剂比未经处理的煤渣脱硫率高,在一定的石灰添加范围内(10%～20%),脱硫率随石灰添加量的增加而增加,并存在一最佳用量.     

烟道式脱硫装置处理冶炼厂高浓度SO2烟气的工程实践

本文介绍了烟道式脱硫装置的特点及工艺原理 ,采用该装置处理某冶炼厂高浓度SO2 烟气 ,其脱硫率达 90 %以上 ,净化后的烟气可直接达标排放 ,并年产合格脱硫石膏近万吨。烟道式脱硫装置解决了常规脱硫除尘装置共同存在的结垢和堵塞问题 ,在冶炼烟气治理方面具有一定的推广应用价值。     

Chloroaromatic pollutants in mussels incubated in two finnish watercourses polluted by industry

Concentrations of different chlorinated compounds were measured in mussels incubated in two polluted watercourses, a river (the River Kymijoki) and a lake (Lake Vanaja) for four weeks in summer 1995. The sum concentrations of polychlorinated phenols (PCP) and biphenyls (PCB) were both about 1 μg/g lipid weight (lw) in Lake Vanaja mussels, while in the River Kymijoki mussels PCPs were non-detectable and PCBs were measured 120 ng/g lIw. The concentrations of toxic polychlorinated dibenzo-p-dioxin (PCDD) and dibenzofuran (PCDF) congeners ranged between <17 and 370 pg/g Iw in Lake Vanaja mussels and between <38 and 11,000 pg/g lw in the River Kymijoki mussels. Polychlorinated diphenyl ethers (PCDE) were detected in the mussels incubated in the River Kymijoki (0.4–1.1 ng/g Iw), but not in those incubated in Lake Vanaja. Polychlorinated phenoxyanisoles (PCPA) were measured 33 ng/g lw and polychlorinated phenoxyphenols (PCPP) 300 ng/g lw in the mussels incubated in the River Kymijoki. PCPAs were also detected in reference samples, which were sediment and pike from the River Kymijoki and Baltic salmon, seal and white-tailed sea eagle.     

Book review

The Pesticide Manual ‐ A World Compendium, 8th Edition, C.R. Worthing, Editor and S.B. Walker, Assistant Editor, British Crop Protection Council, BCPC Publications Sales, Bear Farm, Binfield, Bracknell, Berkshire RG12 5QE, England. 1987, 1100 pp., UK £50; Overseas £56. ISBN 0–948404–01–9.     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

The chemical stability of formulations of some hydrolyzable insecticides in aqueous mixtures with hydrolysis catalysts

Abstract

The active ingredients in commercial formulations of malathion, oxamyl, carbaryl, diazinon, and chlorpyrifos diluted to “spray tank”; concentrations with buffered distilled or natural water of pH 4–9 were stable for at least 24 hr. Formulations of trichlorfon were not stable at pH 7 or above but disappearance rates were slower than for the pure chemical in homogeneous solution. Cupric ion was observed to be an effective catalyst for the hydrolysis of a variety of pure organophosphorus insecticides but did not catalyze hydrolysis of the active ingredients of the formulations examined. Increasing the dilution of the formulation increased the susceptibility of malathion, oxamyl, and carbaryl to hydrolysis.     

Organochlorine compounds in a three-step terrestrial food chain

The concentrations of 15 organochlorine chemicals (PCBs and pesticides) were studied in a Central European oak wood food chain system: Great tit (Parus major), caterpillars (Tortrix viridana, Operophtera brumata, Erannis defoliaria), and oak-leaves (Quercus robur). Juvenile tits receive organochlorines from the mother via egg transfer and, eventually to a greater extent, from the caterpillar food source during nestling period. The concentrations of PCB 153 (2,2′,4,4′,5,5′-hexachlorobiphenyl, the most abundant in this study) was found in leaf material at ca. 1 ng/g, in caterpillars 10 ng/g, and in bird eggs 170 ng/g on an average and on a dry mass basis.     

Radionuclides and trace elements in fish collected upstream and downstream of Los Alamos national laboratory and the doses to humans from the consumption of muscle and bone

Abstract

The purpose of this study was to determine radionuclide and trace element concentrations in bottom‐feeding fish (catfish, carp, and suckers) collected from the confluences of some of the major canyons that cross Los Alamos National Laboratory (LANL) lands with the Rio Grande (RG) and the potential radiological doses from the ingestion of these fish. Samples of muscle and bone (and viscera in some cases) were analyzed for ³H, ⁹⁰Sr, ¹³⁷Cs, ^totU, ²³⁸Pu, ^239,240Pu, and ²⁴¹Am and Ag, As, Ba, Be, Cr, Cd, Cu, Hg, Ni, Pb, Sb, Se, and Tl. Most radionuclides, with the exception of ⁹⁰Sr, in the muscle plus bone portions of fish collected from LANL canyons/RG were not significantly (p<0.05) higher from fish collected upstream (San Ildefonso/background) of LANL. Strontium‐90 in fish muscle plus bone tissue significantly (p<0.05) increases in concentration starting from Los Alamos Canyon, the most upstream confluence (fish contained 3.4E‐02 pCi g^‐1 [126E‐02 Bq kg^‐1]), to Frijoles Canyon, the most downstream confluence (fish contained 14E‐02 pCi g^‐1 [518E‐02 Bq kg^‐1]). The differences in ⁹⁰Sr concentrations in fish collected downstream and upstream (background) of LANL, however, were very small. Based on the average concentrations (±2SD) of radionuclides in fish tissue from the four LANL confluences, the committed effective dose equivalent from the ingestion of 46 lb (21 kg) (maximum ingestion rate per person per year) of fish muscle plus bone, after the subtraction of background, was 0.1 ± 0.1 mrem y^‐1 (1.0 ± 1.0 μSv y^‐1), and was far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem y^‐1 (1000 μSv y^‐1). Of the trace elements that were found above the limits of detection (Ba, Cu, and Hg) in fish muscle collected from the confluences of canyons that cross LANL and the RG, none were in significantly higher (p<0.05) concentrations than in muscle of fish collected from background locations.