氧化镁烟气脱硫反应特性研究

利用实验室规模的鼓泡式反应装置,对比了碳酸钙、氧化镁和氧化镁/硫酸镁脱硫剂的反应活性,证实脱硫液中高浓度硫酸镁的存在是保证镁法脱硫效率高于钙法的重要因素,并考察了硫酸镁浓度、脱硫剂(氧化镁)浓度、烟气量、SO2浓度和吸收液温度等因素对脱硫效率的影响。结果表明,脱硫反应可以根据pH分为2个不同阶段;反应过程中脱硫效率随着硫酸镁浓度的增加而显著升高;烟气量增加将会导致脱硫效率有所下降;入口SO2浓度升高,脱硫效率下降;氧化镁浓度、温度对脱硫效率影响不显著。结合实验现象进行推断,氧化镁脱硫的反应过程受SO2在气液两相界面的传质扩散和其水解产物在液相的扩散控制。     

湿法烟气脱硫反应过程的实验研究

在石灰石/石膏湿法烟气脱硫中试台上,系统开展了浆液pH值、飞灰浓度、液气比、入口SO2浓度、烟气速度和氧化方式等对脱硫反应过程影响的实验研究。实验表明,脱硫效率随着石膏浆液pH值、液气比的升高而增加,且入口SO2浓度越高,液气比越低,影响效应越明显;脱硫效率随着烟气速度、烟气温度和入口SO2浓度的增加而下降;石膏浆液中飞灰含量对系统脱硫效率具有一定的促进作用:pH值>5.6,飞灰浸出液中Fe3+含量相对较低,Fe3+对脱硫反应过渡态催化氧化影响程度较轻,不同工况脱硫效率差别不大。pH值<5.6,飞灰浸出液中Fe3+含量随pH值降低而增大,增效效果逐渐显著;氧化方式对脱硫反应过程有明显的影响,强制氧化工艺的脱硫效率比自然氧化的高5%左右。     

飞灰及其混合脱硫剂浆液脱硫特性的实验研究

从碱性物溶出率和脱硫容量两个方面，对杭州地区3种电厂飞灰和飞灰－大理石混合脱硫剂进行了实验研究。结果表明，降低pH值有利于飞灰中碱性物的溶出，pH为5－8时，飞灰中碱性物溶出率约为30％。不同电厂飞灰的脱硫容量差异较大，为0.12-0.25gSO2/g飞灰，相当于石灰石脱硫容量的23％－48％。飞灰－大理石混合脱硫剂中飞灰与大理石之间具有相互协同促进作用，对飞灰：大理石为1：1的混合脱硫剂，其脱硫容量Ws60比大理石提高了30％。当脱硫率要求不太高时，可考虑使用飞灰－大理石混合脱硫剂，以部分或全部取代石灰石脱硫剂，从而大大降低脱硫剂成本。     

喷射鼓泡法烟气脱硫工艺

对以喷射鼓泡反应器为主设备，石灰石浆液为脱硫剂的湿法烟气脱硫工艺进行了实验研究，结果表明主要参数[烟气压降Δp、ф（液气）比、吸收液pH值、进气SO2浓度]对脱硫效率均有较大的影响。     

高活性脱硫剂脱硫工艺的实验研究

对以粉煤灰为原料制备的高活性脱硫剂进行了半干法烟气脱硫实验研究,考虑添加剂、脱硫剂加入量、反应温度、烟气流量工艺因素的影响时该活性脱硫剂的脱硫性能;实验结果表明,加入添加剂后,脱硫效率提高1.5%～8.1%;当烟气流量＜2 m3/min,钙硫比取1.5～2.0范围时,脱硫效率较高;一定范围内反应温度变化对脱硫效率影响不大.     

废铅酸蓄电池铅膏铵法预脱硫过程的动力学分析

以废铅酸蓄电池中铅膏为研究对象,开展了用NH_4HCO_3为脱硫剂对铅膏进行脱硫转化的实验研究。通过分析反应过程中PbSO_4转化率随时间的变化关系,考察了搅拌速度、反应温度及NH_4HCO_3浓度对铅膏脱硫转化的影响;利用固液多相反应的收缩核模型,分析了反应的动力学过程,并计算了反应的表观活化能及表观反应级数。结果表明:在实验选取的条件范围内,提高反应温度、增大NH_4HCO_3浓度及加快搅拌速度均可以促进铅膏的脱硫转化;表观活化能为9.7 kJ·mol~(-1),表观反应级数为0.71,反应过程受内扩散步骤控制。研究结果可为铅膏铵法预脱硫技术能高效、低耗的应用提供参考。     

半干半湿法烟气脱硫主要影响因素分析

建立了半干法气流床烟气脱硫实验反应装置。实验研究了温度、绝对含湿量和飞灰对烟气脱硫的影响。烟气温度在65～130℃之间,绝对含湿量通过改变蒸汽量调节,在0%～10%之间,并且采用飞灰一次加入来模拟返灰,石灰与粉煤灰的比例分别为1∶3,1∶5和1∶8。结果表明,没有水蒸气加入时,温度的升高对脱硫效率影响不大,加入水蒸气后温度为68℃左右时,脱硫效率最高;65℃时,绝对含湿量在73%时脱硫效率最高;在T=68℃、Ca/S=12时,与不加粉煤灰的脱硫剂相比,利用石灰/粉煤灰=1∶8的混合脱硫剂时,脱硫效率提高了128%。     

双循环垂直筛板喷射鼓泡脱硫塔的吸收性能

设计了一种中试规模的双循环垂直筛板喷射鼓泡脱硫塔,该塔由直径分别为600 mm和150 mm的两套垂直筛板结构组成双循环。一级循环采用了一块下端开有栅孔的大直径垂直筛板,二级循环则采用了上端开有栅孔的小直径垂直筛板。两级垂直筛板上的布气栅孔均可埋入吸收液下,使塔内的气液混合处于喷射鼓泡吸收状态。研究了小直径垂直筛板埋入深度分别对单独采用二级循环和采用双循环时装置脱硫效率的影响。单独采用二级循环,在保持脱硫液pH值和烟气SO2浓度一致的情况下,小直径垂直筛板的液位高度为220 mm时(喷射鼓泡操作方式)比液位高度为80 mm时(即典型小直径垂直筛板操作方式)的脱硫效率高40%左右。采用双循环操作模式时,小直径垂直筛板液位高度为220 mm时(喷射鼓泡操作方式)比液位高度为80 mm时(即典型小垂直筛板操作方式)的总脱硫效率高30%左右。     

高活性脱硫剂脱硫工艺的实验研究

对以粉煤灰为原料制备的高活性脱硫剂进行了半干法烟气脱硫实验研究，考虑添加剂、脱硫剂加入量、反应温度、烟气流量工艺因素的影响时该活性脱硫剂的脱硫性能；实验结果表明，加入添加剂后，脱硫效率提高1．5％～8．1％；当烟气流量〈2m^3／min，钙硫比取1．5—2．0范围时，脱硫效率较高；一定范围内反应温度变化对脱硫效率影响不大。     

炼铁烧结除尘灰湿法脱除模拟烟气中的SO2

为了考察炼铁烧结除尘灰作为脱硫剂的效果,研究了湿法脱硫过程中固液比、氧气含量、吸收剂温度、气体流速、进口SO_2质量浓度、搅拌强度等影响因素对脱除效率的影响规律。结果表明,最佳反应温度为25℃;随着温度升高,SO_2溶解度降低,吸收液对SO_2吸收能力降低;气体流量增加,SO_2在吸收剂中停留时间变短,导致脱除率降低;固液比增加,气固接触概率也随之增大,SO_2脱除率也增大;进口SO_2质量浓度的提高导致液相中氢氧根消耗加剧,使反应速率减慢,不利于对SO_2的去除。同时发现,SO_2浓度增加则溶解分数减小,吸收率也会随之降低;搅拌速率的增加使得气泡破碎加剧,增大气液接触面积,使除尘灰充分悬浮在液相中,与溶液中的SO_2迅速反应,有利于SO_2的吸收。O_2含量增加,有利于O_2的溶解,增加了化学反应的推动力,有利于SO_2吸收反应的进行。除尘灰对含二氧化硫气体具有较好的脱硫效果,有一定的应用前景。     

Optimization of Height of Release of Air Pollutants

A number of key projects in the Environmental Protection Agency (EPA) particulate R&;D program having applicability to industry are presented. For electrostatic precipitators (ESP) there is presented the result of work on large diameter discharge electrodes which provide a decrease in penetration of up to a factor of 4 when compared to conventional small diameter electrodes. Also discussed is the multistage ESP which provides a collection efficiency that would require a collecting plate area 4 or 5 times larger with conventional ESP technology. The E-SOX technology makes use of the multistage concept to free up space in the ESP for SO₂ removals of up to 90%. Electrostatically augmented fabric filtration provides a reduction in pressure drop of about 5 0% as compared to conventional fabric filtration. Wind tunnel modeling of windbreaks for material storage piles indicates a potential for providing engineering design data that would allow significant emission reduction caused by wind erosion     

Investigation of the characteristics of the reflectivity of clouds

This paper investigates some of the reflectivity characteristics that clouds (when modelled as solid bodies) must exhibit to be compatible with observations that the reflecting surface of a cloud (i) appears almost equally bright across its face, (ii) is brightest when the cloud is opposite to the Sun but decreases in brightness as the cloud moves to other positions and (iii) increases in brightness with increasing optical thickness of the cloud in the observer's line of sight. These observations, respectively, are shown to imply that the peak value of the bidirectional total reflectivity from a cloud surface (i) increases in inverse proportion to the cosine of the angle between the Sun and the normal to the cloud surface, as the incident angle increases, (ii) appears to be directed back in the direction of the incident radiation, and (iii) increases as optical thickness of the cloud in the observer's line of sight increases. The results could have application in many fields (e.g. modelling diffuse radiance distributions for cloudy skies).     

次氯酸钠发生器的研制

介绍了电解法生产次氯酸钠的原理 ,并在原有生产工艺的基础上进行了重新设计和对设备的重新选择、改造 ,得出了各个工艺参数的最佳值 ,生产出高品质的次氯酸钠     

Estimation of uncertainty of sampling for analysis of pesticide residues

Abstract

A computer model was used to take random samples from primary sample populations obtained from field trials to simulate the uncertainty of sampling for residue analysis of plant commodities and soil. The results indicate about 40%, 30% and 20% relative uncertainty when random samples of size 5, 10 and 25 are taken respectively, from a single lot. Therefore the sample size should be the same for establishing and enforcing legal limits.     

扬中生态环境建设的思考与实践

结合扬中生态环境的基本情况和存在的不足，进行了具体分析，对扬中未来生态建设的发展方向提出了建议及实施措施。     

实验室质量管理体系内部审核的策划

在实施ISO／IEC 17025：1999标准《检测和校准实验室能力的通用要求》过程中，通过实验室质量管理体系内部审核的实践与系统分析，识别出内部审核策划阶段的关键环节，提出审核范围确定、审核计划和抽样方案制订的质量控制要求，为有序高效地实施内部审核提供了技术方法。     

An application of the theory of kinematics of mixing to the study of tropospheric dispersion

The most common technique used for numerical simulations of tracer mixing is that of the numerical solution of the advection–diffusion equation with the unresolved fluxes parameterized using the similarity theory. Despite correct predictions of the overall directions of transport, models based on a numerical solution of the advection–diffusion equation lack sufficient accuracy to correctly reproduce the coupling of mixing with small scale processes which are sensitive to the microstructure of the tracer distribution. The objective of this paper is to revisit the basic formalism employed in numerical models used to investigate atmospheric tracers. The main mathematical method proposed here is the theory of kinematics of mixing which could be applied effectively for simulations of atmospheric transport processes. At the beginning of the paper, we introduce simple mathematical transformations in order to demonstrate how complex topological structures are created by mixing processes. These idealistic flow systems are essential to explain transport properties of much more complex three-dimensional geophysical flows. An example of the application of the kinematics of mixing to the analysis of tracer transport on a planetary scale is presented in the following sections. The complex filamentary structures simulated in the numerical experiment are evaluated using some commonly applied statistical measures in order to compare the results with the data published in the literature. The results of the experiment are also analysed with the help of simple conceptual models of fluid filaments. The microstructure of the tracer distribution introduced in the paper is essential to increase our understanding of atmospheric transport and to develop more realistic parameterizations of small-scale mixing. The presented results could also be used to improve calculations of the coupling between microphysical processes and tracer mixing.     

Comparison of methods for evaluation of activity of photocatalytic films

Objective

This work aims to investigate the correlation between the photocatalytic activity determined by methylene blue bleaching (DIN 52980), stearic acid degradation, and degradation of acetone in gas phase.

Method

The photocatalytic TiO₂ coatings included in this investigation ranged from thin commercially available coatings (Activ^TM and BioClean^TM) and ready to use suspensions (Nano-X PK1245) to lab-produced PVD and sol?Cgel coatings. XRD analysis of the photocatalytic coatings showed that all the coatings consisted of nanocrystalline anatase, although the thickness and porosity varied considerably.

Results

The study showed that the reproducibility of the activity measurements was good. However, more importantly, the investigation showed that there is a good correlation between the activities determined by the different methods even though the characteristics of the photocatalytic coatings and the organic probe molecules varied considerably.

Conclusion

The overall findings of this work suggest that there is a good correlation between the investigated methods. These results are promising for the future work concerning standardization of methods for determination of the activity of photocatalytic films.     

Impact of overexploitation of shellfish: northeastern coast of India

India has a very extensive coastline of about 7515 km, rich in diverse living resources. These resources continue to deteriorate with rampant harvesting or are altered for other uses such as aquaculture and fisheries. The present paper deals with degrading coastal habitats in northeastern India, and projects the intensity of the stress arising from the collection of tiger prawn seeds (Penaeus monodon) for aquacultural farms and molluskan shells for poultry feed and edible lime. Indiscriminate exploitation of these resources leads to a heavy reduction of the species concerned and other associated marine communities. The magnitude of such destruction has been quantified. The impacts of biodiversity loss and their after-effects on the ecobalance of this coastal system have become a matter of great concern to ecologists to maintain security and sustainability. The authors propose a public awareness program on themes relating to the importance of biodiversity for human livelihoods.