酸碱度对生活垃圾焚烧厂沥滤液蒸发处理效果的影响

采用蒸发法处理城市生活垃圾焚烧厂垃圾沥滤液,着重考察了不同沥滤液初始pH值对蒸发去除COD和氨氮效果的影响,并采用GC-MS对蒸发冷凝液中有机物成分进行了分析鉴定.结果表明,生活垃圾沥滤液的初始pH对冷凝液中COD、氨氮含量及有机污染物分布产生了决定性的影响.沥滤液在酸性条件下(pH≤6)蒸发,随着pH的增加,冷凝液中COD的含量线性降低,而氨氮的含量线性增加.当沥滤液的初始pH值从6增加到11,冷凝液中COD的含量呈对数函数降低,而氨氮的含量表现出显著增加趋势.从冷凝液中鉴定出38种有机污染物,多为沸点较低的醇、酸、酚和酯类.在酸性条件下(pH=3),冷凝液中挥发性有机酸和低碳醇的相对丰度接近90％.在近中性条件下(pH=6.2),冷凝液中的有机污染物以酚、酸和杂环类化合物为主.在碱性条件下(pH =11),冷凝液中酚和杂环类化合物占比较高,而酸的含量极少.     

中和处理后的黄姜皂素水解废液污染物蒸发规律研究

采用常压蒸发法处理经中和后的黄姜皂素水解废液,通过定时分批截留冷凝液并测定其COD、氨氮和挥发性脂肪酸(VFAs)浓度,研究蒸发过程中污染物的蒸发规律。结果表明:蒸发初期(0~130 min)冷凝液中COD和氨氮浓度较高;蒸发中期(130~310min)冷凝液中COD和氨氮浓度较低,但随蒸发时间的延长缓慢升高,蒸发后期(310~400min)冷凝液中COD和氨氮快速升高;蒸发后期COD和氨氮的蒸出量占比最高,分别为78.46%、86.45%,但蒸发后期冷凝液体积仅占冷凝液总体积的28.3%。冷凝液中VFAs主要为乙酸、丙酸、丁酸和戊酸,且VFAs分子结构越复杂,蒸发性能越好;蒸发中、后期冷凝液中VFAs对COD的贡献率为50%~76%,可降低黄姜皂素水解废液后续生化处理的难度。     

低温真空蒸发处理垃圾渗滤液膜浓缩液

采用纳滤(NF)和反渗透(RO)工艺处理垃圾渗滤液会产生污染物浓度极高的膜浓缩液。膜浓缩液是一种有毒有害的高浓度有机废水,可生化性差、极难处理,需要选择一种经济有效的浓缩液处理技术。采用低温真空蒸发方法,对膜浓缩液进行蒸发处理。在膜浓缩液水质特征分析的基础上,通过改变膜浓缩液的pH、蒸发温度和蒸发率,分析冷凝液中的COD、NH_3-N、TDS和pH的变化规律。结果表明:1)膜浓缩液初始pH对冷凝液中COD和NH_3-N有较大影响。酸性条件下,冷凝液中COD的浓度相对较高,而NH_3-N的含量很低;碱性条件下,冷凝液中COD的浓度很低,而NH_3-N的含量较高;2)随着蒸发温度的升高,冷凝液的pH、TDS和NH_3-N增加,在70℃达到最大值,继而下降。冷凝液中UV254随着蒸发温度的升高而增加,COD随着蒸发温度的升高而减少;3)在蒸发初期,冷凝液中TDS与NH_3-N含量较高,进一步提高蒸发率,TDS与NH_3-N含量有所降低,至蒸发后期,两者含量略有上升;4)冷凝液中TDS主要来自蒸发进入冷凝液的NH_3-N,冷凝液的TDS浓度与NH_3-N浓度密切相关。本研究有利于拓宽浓缩液处理的途径,为实际应用蒸发处理技术提供有益指导。     

蒸发浓缩预处理黄姜皂素水解废液

针对黄姜皂素水解废液有机物浓度高、酸度高、可生化性差等特点,采用常压蒸发浓缩法预处理黄姜皂素水解废液,研究了初始pH值和浓缩倍数对废液主要污染物蒸发浓缩效果的影响。结果表明:初始pH值对蒸出液COD、氨氮、VFA浓度变化影响较大。pH7时,COD和乙酸浓度分别由4 045 mg·L~(-1)、1 742 mg·L~(-1)快速降低到980 mg·L~(-1)、82.9 mg·L~(-1);氨氮浓度在25 mg·L~(-1)处波动;pH7时,COD浓度在1 000 mg·L~(-1)处波动,乙酸由82.9 mg·L~(-1)缓慢降低到6.4 mg·L~(-1),氨氮浓度由26.2 mg·L~(-1)快速升高到207 mg·L~(-1)。浓缩倍数对蒸出液污染物浓度影响也很大。浓缩2~10倍,COD、氨氮、乙酸浓度分别由980、26.2、82.9 mg·L~(-1)升高到3 372、141、2 250 mg·L~(-1),对应占其污染物总量的百分比由0.66%、1.91%、1.46%升高到4.08%、18.5%、71.5%。考虑工艺设备耐腐蚀性、蒸发能耗、耗时和处理效果等因素,选择初始pH=7、浓缩5~7倍比较适宜。蒸出液经过适当处理可做工艺回用水,达到废水处理资源化、减量化的目的。     

直接接触式膜蒸馏工艺处理高浓度氨氮模拟废水中操作条件的影响

采用直接接触式膜蒸馏处理高浓度氨氮模拟废水。实验对初始pH值、原料液流量和渗透液流量等3项操作条件进行了比较研究。结果表明,提高原料液的初始pH值可以大幅度地提高氨氮的去除效率、传质系数和分离效率,当初始pH达到12时,30 min内氨氮去除率可达到98%以上;提高料液流量可以得到同样的规律,当初始pH值为11,料液流量由400 L/h提高至800 L/h时,氨氮去除率由79.8%提高至88%;但渗透液流量的提高对处理效果的影响并不明显。     

生活垃圾焚烧发电厂渗滤液蒸发浓缩处理

垃圾焚烧厂渗滤液因水质复杂,NH3-N、COD和电解质含量高等特点,成为一种难处理有机废水。采用负压蒸发浓缩法对渗滤液及电絮凝预处理渗滤液的处理进行了对比研究,并考查了浓缩比、pH等因素的影响。研究结果表明,电絮凝预处理不能改变渗滤液中COD、NH3-N的蒸发去除规律,即蒸发处理过程中,蒸发冷凝液中COD在蒸发前期和后期含量较高,蒸发中期较低;而NH3-N含量在蒸发处理前期较高,中后期含量较低。pH对蒸发处理影响较大,在酸性pH下COD去除率较低,但NH3-N去除率较高,可达95%以上,而在中碱性pH下,COD去除率增高,NH3-N去除率降低。渗滤液及电絮凝预处理渗滤液的一次蒸发冷凝液,经过二次蒸发处理后,冷凝液中COD和NH3-N含量均能达到一级排放标准,即分别低于100 mg/L和15 mg/L。     

高氨垃圾渗滤液的吹脱条件控制研究

采用吹脱塔处理含有高浓度氨氮的垃圾渗滤液,研究了操作参数的控制对吹脱效率的影响.结果表明,当pH≤11.0时,气水比决定了高径比对吹脱效率的影响,气水比较低时,高径比越小,吹脱效率越高;气水比较高时,高径比越大,吹脱效率越高;当pH过高时,高径比对吹脱效率没有影响.初始pH和温度相互影响,pH越低时,温度对吹脱效率的影响越显著;温度越低时,初始pH对吹脱效率的影响越显著.当pH≥10.4时,出水pH和残余氨氮浓度呈指数关系,可以作为反应吹脱运行状况的指示参数或控制参数.合理控制pH和气水比并实时监控出水pH是获得稳定、经济的吹脱效果的关键.     

"老龄期"填埋场渗滤液COD蒸发规律研究

"老龄期"填埋场渗滤液由于可生化性差而难于处理.采用常规蒸发、减压蒸发和载气蒸发处理不同pH值的"老龄期"渗滤液.实验结果表明,3种蒸发方式下,冷凝液COD下降过程中均存在明显的浓度转折点,转折点之后COD维持较低水平,为"老龄期"渗滤液的"三分处理法"提供理论依据.与常规蒸发相比,减压蒸发和载气蒸发的前期冷凝液COD较高,且浓度转折点偏后.     

HYDRUS-1D软件在地下水污染源强定量评价中的应用

以垃圾填埋场渗滤液中的氨氮为研究对象,利用HYDRUS-1D模型模拟其在包气带中的迁移转化规律,最终预测出氨氮到达地下水位处时的浓度值。引入折减系数的概念,通过改变填埋场渗滤液中氨氮的初始浓度及土壤包气带结构,计算不同输入条件下的折减系数值,用其综合反映包气带对于某一特征污染物的衰减能力,为地下水污染源强定量评价提供数据支持。     

电化学氧化法去除超高盐榨菜废水中的氨氮

采用电化学氧化法去除超高盐榨菜废水中的氨氮,阳极为Ti/RuO2-TiO2-IrO2-SnO2网状电极,阴极为网状钛电极,考察了电流密度、电解时间、极板间距、初始pH以及极水比对氨氮去除率的影响,并分析了电流密度对氨氮能耗和阳极效率的影响。结果表明,在初始氨氮浓度为472.73 mg/L,电流密度为156 mA/cm2,极板间距为1.5 cm,极水比为0.8dm2/L,原水pH为4.3～5.0时,电解30 min和60 min时氨氮的去除率分别为89.75%和99.94%,电解30 min时,氨氮能耗最低为96 kWh/kg,阳极效率最高为8.47 g/(h.m2.A)。     

Pig slurry concentration by vacuum evaporation: influence of previous mesophilic anaerobic digestion process

Water can be removed from pig slurry by evaporation, through the application of wasted heat from a power plant or from other processes. Apart from obtaining a concentrate with an obviously higher nutrient concentration than the original slurry, another objective of water removal is to obtain water as condensate, which could be reused. The objective of this work was to study the vacuum evaporation of pig slurry liquid fraction and to evaluate condensate composition as a function of both pH (4, 5, and 6) and pig slurry type (fresh slurry and anaerobically digested slurry). Batch experiments showed that condensate characteristics, total ammonia nitrogen (NH3-N), volatile fatty acids (VFA), and chemical oxygen demand were strongly dependent on initial slurry pH. In addition to producing part of the required thermal energy, previous anaerobic digestion presented several other clear advantages. The consumption of VFA and other volatile organic compounds during anaerobic digestion reduced the volatilization of organic matter in the evaporation treatment and, consequently, provided a higher quality condensate.     

污泥热干化和燃烧特性试验研究

分别在桨叶式干化机和热重仪上进行污泥干化和燃烧试验,研究了污泥干化特性和污染物排放特性,并对污泥的燃烧特性进行分析。结果表明,污泥干化过程分为黏稠区、粘滞区和颗粒区3个阶段。干化过程排放的污染气体有氨气、氯化氢、氟化氢、氰化氢、甲烷和挥发性有机酸等,其中氨气为主要污染气体。经冷凝吸收和活性炭吸附处理后,各种污染气体浓度均显著降低,其中氨气去除率最高,达97.04%。污泥干化冷凝液的BOD5和COD质量浓度分别为4 040、8 510mg/L,氨氮的质量浓度为1 025mg/L,pH为9.84,属于高浓度有机废水。污泥的燃烧过程可以分为3个失重阶段:水分析出阶段(50～150℃),挥发分燃烧阶段(150～450℃),固定碳燃烧阶段(450～650℃)。分别用Kissinger法和Ozawa法计算挥发分燃烧阶段和固定碳燃烧阶段的活化能和动力学方程,挥发分燃烧阶段的活化能低于固定碳燃烧阶段,表明挥发分燃烧阶段污泥更易燃烧。污泥的燃烧过程在650℃时基本完成,因此实际工程应用中,设计干化污泥的焚烧温度在750℃比较合理。     

青岛市菜市场垃圾的高温厌氧消化研究

在中试规模下进行菜市场垃圾高温厌氧消化试验,通过监测消化过程中的产气情况和消化液的pH、可溶解性COD(SCOD)、挥发性脂肪酸(VFA)、NH3-N、碱度等变化,确定菜市场垃圾厌氧消化的最大有机负荷,并分析对菜市场垃圾进行高温厌氧消化处理的可行性.结果表明,在中试规模下,菜市场垃圾高温厌氧消化的最高有机负荷可达6.2...     

Treatment of dairy manure using the microwave enhanced advanced oxidation process under a continuous mode operation

The microwave enhanced advanced oxidation process (MW/H(2)O(2)-AOP) was used to treat dairy manure for solubilization of nutrients and organic matters. This study investigated the effectiveness of the MW/H(2)O(2)-AOP under a continuous mode of operation, and compared the results to those of batch operations. The main factors affecting solubilization by the MW/H(2)O(2)-AOP were heating temperature and hydrogen peroxide dosage. Soluble chemical oxygen demand (SCOD) and volatile fatty acids (VFA) increased with an increase of microwave (MW) heating temperature; very high concentrations were obtained at 90°C. Insignificant amounts of ammonia and reducing sugars were released in all runs. An acidic pH condition was required for phosphorus solubilisation from dairy manure. The best yield was obtained at 90°C with an acid dosage of 1.0 %; about 92 % of total phosphorus and 90 % of total chemical oxygen demand were in the soluble forms. The MW/H(2)O(2)-AOP operated in a continuous operation mode showed pronounced synergistic effects between hydrogen peroxide and microwave irradiation when compared to a batch system under similar operating conditions, resulting in much better yields.     

Microwave enhanced advanced oxidation process for treating dairy manure at low pH

This study investigated the treatment of dairy manure using the microwave enhanced advanced oxidation process (MW-AOP) at pH 2. An experimental design was developed based on a statistical program using response surface methodology to explore the effects of temperature, hydrogen peroxide dosage and heating time on sugar production, nutrient release and solids destruction. Temperature, hydrogen peroxide dosage and acid concentration were key factors affecting reducing sugar production. The highest reducing sugar yield of 7.4% was obtained at 160°C, 0 mL, 15 min heating time, and no H(2)O(2) addition. Temperature was a dominant factor for an increase of soluble chemical oxygen demand (SCOD) in the treated dairy manure. The important factors for volatile fatty acids (VFA) production were microwave temperature and hydrogen peroxide dosage. Temperature was the most important parameter, and heating time, to a lesser extent affecting orthophosphate release. Heating time, hydrogen peroxide dosage and temperature were significant factors for ammonia release. There was a maximum of 96% and 196% increase in orthophosphate and ammonia concentration, respectively at 160°C, 0.5 mL H(2)O(2) and 15 min heating time. The MW-AOP is an effective method in dairy manure treatment for sugar production, nutrient solubilisation, and solids disintegration.     

Microwave enhanced advanced oxidation process for treating dairy manure at low pH

This study investigated the treatment of dairy manure using the microwave enhanced advanced oxidation process (MW-AOP) at pH 2. An experimental design was developed based on a statistical program using response surface methodology to explore the effects of temperature, hydrogen peroxide dosage and heating time on sugar production, nutrient release and solids destruction. Temperature, hydrogen peroxide dosage and acid concentration were key factors affecting reducing sugar production. The highest reducing sugar yield of 7.4% was obtained at 160°C, 0 mL, 15 min heating time, and no H₂O₂ addition. Temperature was a dominant factor for an increase of soluble chemical oxygen demand (SCOD) in the treated dairy manure. The important factors for volatile fatty acids (VFA) production were microwave temperature and hydrogen peroxide dosage. Temperature was the most important parameter, and heating time, to a lesser extent affecting orthophosphate release. Heating time, hydrogen peroxide dosage and temperature were significant factors for ammonia release. There was a maximum of 96% and 196% increase in orthophosphate and ammonia concentration, respectively at 160°C, 0.5 mL H₂O₂ and 15 min heating time. The MW-AOP is an effective method in dairy manure treatment for sugar production, nutrient solubilisation, and solids disintegration.     

Treatment of dairy manure using the microwave enhanced advanced oxidation process under a continuous mode operation

The microwave enhanced advanced oxidation process (MW/H₂O₂-AOP) was used to treat dairy manure for solubilization of nutrients and organic matters. This study investigated the effectiveness of the MW/H₂O₂-AOP under a continuous mode of operation, and compared the results to those of batch operations. The main factors affecting solubilization by the MW/H₂O₂-AOP were heating temperature and hydrogen peroxide dosage. Soluble chemical oxygen demand (SCOD) and volatile fatty acids (VFA) increased with an increase of microwave (MW) heating temperature; very high concentrations were obtained at 90°C. Insignificant amounts of ammonia and reducing sugars were released in all runs. An acidic pH condition was required for phosphorus solubilisation from dairy manure. The best yield was obtained at 90°C with an acid dosage of 1.0 %; about 92 % of total phosphorus and 90 % of total chemical oxygen demand were in the soluble forms. The MW/H₂O₂-AOP operated in a continuous operation mode showed pronounced synergistic effects between hydrogen peroxide and microwave irradiation when compared to a batch system under similar operating conditions, resulting in much better yields.     

Regulatory off-gas analysis from the evaporation of Hanford simulated waste spiked with organic compounds

After strontium/transuranics removal by precipitation followed by cesium/technetium removal by ion exchange, the remaining low-activity waste in the Hanford River Protection Project Waste Treatment Plant is to be concentrated by evaporation before being mixed with glass formers and vitrified. To provide a technical basis to permit the waste treatment facility, a relatively organic-rich Hanford Tank 241-AN-107 waste simulant was spiked with 14 target volatile, semi-volatile, and pesticide compounds and evaporated under vacuum in a bench-scale natural circulation evaporator fitted with an industrial stack off-gas sampler at the Savannah River National Laboratory. An evaporator material balance for the target organics was calculated by combining liquid stream mass and analytical data with off-gas emissions estimates obtained using U.S. Environmental Protection Agency (EPA) SW-846 Methods. Volatile and light semi-volatile organic compounds (<220 degrees C BP, >1 mm Hg vapor pressure) in the waste simulant were found to largely exit through the condenser vent, while heavier semi-volatiles and pesticides generally remain in the evaporator concentrate. An OLI Environmental Simulation Program (licensed by OLI Systems, Inc.) evaporator model successfully predicted operating conditions and the experimental distribution of the fed target organics exiting in the concentrate, condensate, and off-gas streams, with the exception of a few semi-volatile and pesticide compounds. Comparison with Henry's Law predictions suggests the OLI Environmental Simulation Program model is constrained by available literature data.     

含固率对牛粪常温厌氧消化的影响

在常温、pH值为7.0下,采用10 L玻璃瓶作为反应器对含固率(TS)分别为2%、6%、10%和14%的4组牛粪溶液进行厌氧消化实验,系统运行48 d,分析了厌氧消化过程中的COD(化学需氧量)、pH、VFA(挥发性脂肪酸)和产气量的变化。结果表明,进料TS是影响牛粪厌氧消化产气效果的重要因素,调节牛粪进料TS至10%,可以使其厌氧消化获得最佳的产气效果,COD去除率为24.6%,产气中甲烷含量为56.1%。