7A52铝合金及25CrMnSiA钢焊接件海洋大气应力腐蚀试验研究

目的研究7A52铝对接焊拉伸试样、25CrMnSiA钢对接焊拉伸试样的海洋大气应力腐蚀行为。方法利用自行设计制作的恒载荷大气应力腐蚀试验装置,在海南万宁站海洋大气环境中,分别采用7A52铝对接焊拉伸试样、25CrMnSiA钢对接焊拉伸试样进行海洋大气应力腐蚀试验研究。对试验中断裂的试样和未断裂的试样,进行表面腐蚀形貌、断口形貌、显微组织、显微硬度分布等分析。结果 7A52铝焊接件断裂在焊接部位,Cl-富集于SCC部分的含钙或含硫的第二相质点,促进了7A52铝焊接件应力腐蚀开裂。海洋大气应力腐蚀试验的25CrMnSiA钢焊接件断裂在母材部位,而实验室拉伸试验断裂在焊接部位。结论两种焊接件在海南海洋大气环境下均存在应力腐蚀开裂,裂纹萌生、扩展于朝向海洋方向的试样表面,存在"风脆"现象。     

海洋大气对TA15钛合金应力腐蚀影响研究

采用恒位移WOL试样测定KISCC的原理对已在海洋平台户外和海水飞溅区暴露2a的TA15钛合金样及原始TA15钛合金样进行了应力腐蚀行为研究。探讨了TA15钛合金预制裂纹的条件,并用裂纹终止法测量应力腐蚀临界应力场强度因子,确立了应力场强度因子KISCC与裂纹瞬时扩展速率da/dt之间的联系,并绘制了lg （da/dt）-KI曲线。通过扫描电镜对试件断面进行了分析,对其断裂特征进行了描述。     

海洋大气对TA15钛合金应力腐蚀影响研究

采用恒位移WOL试样测定KISCC的原理对已在海洋平台户外和海水飞溅区暴露2a的TA15钛合金样及原始TA15钛合金样进行了应力腐蚀行为研究。探讨了TA15钛合金预制裂纹的条件,并用裂纹终止法测量应力腐蚀临界应力场强度因子,确立了应力场强度因子KISCC与裂纹瞬时扩展速率da1dt-C间的联系,并绘制了lg（da／dt）-K1曲线。通过扫描电镜对试件断面进行了分析,对其断裂特征进行了描述。     

30CrMnSiA高强钢在工业和海洋大气环境中的腐蚀行为研究

目的为30CrMnSiA高强钢的大气腐蚀防护设计、应用范围扩展和开发新钢种提供有益的借鉴和参考。方法采用腐蚀质量损失、XRD和SEM研究了30CrMnSiA高强钢在工业和海洋大气环境暴露60个月的大气腐蚀行为。结果 30CrMnSiA高强钢在工业和海洋大气环境中腐蚀质量损失随暴露时间变化的双对数函数分别是lgΔw=2.245+0.387lg t和lgΔw=2.822+0.637lg t。纤铁矿和针铁矿是两种大气环境中形成的腐蚀锈层的主要成分,除了纤铁矿和针铁矿外,在海洋大气环境形成的锈层中还发现了四方纤铁矿。随着暴露时间的延长,在海洋大气环境中形成的锈层呈现逐渐剥落的趋势。结论 30CrMnSiA高强钢在海洋大气环境中表现出较高的腐蚀敏感性,在工业大气环境中表现出较低的腐蚀敏感性。     

电镀Cd层在海洋大气环境中的腐蚀行为研究

通过自然暴露试验,研究了航空钢结构常用的电镀Cd层在我国南部热带海洋大气环境中的腐蚀行为。采用扫描电子显微镜(SEM)观察了电镀Cd层的表面微观结构和腐蚀形貌;采用电化学交流阻抗谱(EIS)表征了电镀Cd层在腐蚀介质中的表面细微结构及其在自然暴露过程中的变化规律,分析了镀Cd层在海洋大气环境中的腐蚀过程和腐蚀机理。研究发现,电镀Cd层在海洋大气环境中的腐蚀主要包括含Cr钝化膜的局部破损和镀层本身的腐蚀两个方面,电镀Cd层的腐蚀产物膜能够有效抑制腐蚀扩展。相对于近海户外大气环境,海洋平台户外的高湿度和高盐分大气环境对含Cr钝化膜的穿透性更强,对镀Cd层的腐蚀更加严重。     

SO2在碳钢初期大气腐蚀中的作用

通过自建的模拟大气腐蚀系统,借助金相显微镜、扫描电镜(SEM/EDX)、X-射线衍射(XRD)和x-射线光电子能谱(XPS),研究了SO2对碳钢初期大气腐蚀行为的影响,并进一步用原子力显微镜从更微观的角度观察了在SO2环境中初期阶段腐蚀形貌变化.研究结果表明:在SO2污染大气环境中,随SO2浓度的升高碳钢腐蚀加快.在体积分数为5×10(-6)SO2的大气环境中,碳钢和耐候钢表面腐蚀主要以条状物生长,随着SO2浓度的升高,腐蚀产物的形貌发生改变,在体积分数为5×10(-5)SO2的大气环境中,条状锈和胞状锈同时生长.在锈层中S元素以FeSO4·4H2O的形式存在,腐蚀产物中还有γ-FeOOH.SO2在初期阶段加速了碳钢的腐蚀,降低了碳钢的耐蚀性.     

严酷海洋大气环境下玻璃纤维复合材料腐蚀老化规律研究

目的 研究严酷海洋大气环境下,玻璃纤维增强树脂基复合材料的腐蚀老化规律.方法 通过实海大气环境试验,分析了南海岛礁大气环境下,复合材料暴露不同周期后的腐蚀形貌特征以及力学性能变化规律,建立了腐蚀老化性能预测灰色模型GM(1,1),并与青岛、厦门和三亚等典型海洋大气环境进行对比研究.结果 随暴露时间的增长,南海岛礁大气环境下的复合材料发生严重的纤维裸露,其弯曲强度呈下降趋势,基于弯曲强度建立的灰色模型GM(1,1)精度达到1级;与其他典型海洋大气环境相比,随着纬度的降低,复合材料的弯曲强度呈下降趋势.结论 灰色模型GM(1,1)对复合材料在岛礁等严酷海洋大气环境下的腐蚀老化性能预测精度较高.影响复合材料性能的最主要环境因素为辐照,其次为相对湿度和温度.     

Release kinetics of vanadium from vanadium titano-magnetite: The effects of pH, dissolved oxygen, temperature andforeign ions

As part of a broader study of the environmental geochemistry behavior of vanadium(V), the release kinetics of V from the dissolution of natural vanadium titano-magnetite under environmentally relevant conditions was investigated. In both the acidic and basic domains, the V release rate was found to be proportional to fractional powers of hydrogen ion and dissolved oxygen activities. The dependence of the rate on dissolved oxygen can also be described in terms of the Langmuir adsorption model. The empirical rate equation is given by: r= k′α(H~+)~α(Kα(O_2))/(1+Kα(O_2)) where, α = 0.099–0.265, k′ = 3.2 × 10~(-6)–1.7 × 10~(-5), K =2.7 × 10~4–3.9 × 10~4 mol/L in acid solution(pH 4.1), and α =-0.494-(-0.527), k′ = 2.0 × 10~4–2.5 × 10~(-11), and K = 4.1 × 10~3–6.5 × 10~3 mol/L in basic solution(pH 8.8) at 20°C. Based on the effect of temperature on the release rate of V, the activation energies of minerals at p H 8.8 were determined to be 148–235 k J/mol, suggesting that the dissolution of vanadium titano-magnetite is a surface-controlled process. The presence of Na~+, Ca~(2+), Mg~(2+), K~+, NO_3~-, Cl~-, SO_4~(2-)and CO_3~(2-)was found to accelerate the V release rates. This study improves the understanding of both the V pollution risk in some mine areas and the fate of V in the environment.     

涂漆铝合金铆接件在美济礁大气环境中初期失效行为

目的研究铆接结构件在南海热带岛礁海洋大气环境暴露初期的失效行为。方法通过对在热带岛礁大气环境中暴露初期的试样进行外观拍照、光泽度测试、色差测试、光学显微拍照、以及电化学阻抗测试(EIS),描述相关变化过程。结果试样暴露1 a后,失光率和色差分别达到67.0%和10.67,平面位置呈现出沟壑状形貌特征,连接缝隙底部和铆钉顶部存在明显的涂层缺陷。平面位置0.01 Hz处的阻抗模值由初始的2.81×10~(10)?降低为8.19×10~8?,而铆钉位置0.01 Hz处的阻抗模值由初始的1.09×10~9?降低为2.92×10~6?。结论试样在热带岛礁大气环境暴露初期的外观变化主要表现为失光和变色,平面位置、连接缝隙底部及铆钉顶部均存在一定程度的微观形貌变化。随暴露时间的增加,电化学阻抗呈下降趋势,且铆钉位置的下降幅度相对更大。     

7050高强铝合金在我国四种典型大气环境下腐蚀行为研究

目的研究海洋大气、干热沙漠、寒冷低温和高原低气压四种典型大气环境对7050高强铝合金腐蚀行为的影响。方法通过在万宁、敦煌、漠河、拉萨四种典型环境中开展7050高强铝合金大气暴露试验,利用腐蚀质量损失、力学性能、腐蚀形貌、金相显微分析7050高强铝合金在我国四种典型大气环境中的腐蚀规律和行为。结果暴露1年,海洋大气环境对7050高强铝合金的腐蚀质量损失、力学性能、腐蚀形貌和金相显微组织有明显影响,干热沙漠环境对铝合金的腐蚀形貌和金相显微组织有一定影响,铝合金对寒冷低温和高原低气压大气环境腐蚀不敏感。结论四种典型大气环境对7050高强铝合金腐蚀影响大小的顺序为万宁>敦煌>漠河和拉萨。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.