反应萃取处理染料中间体H酸和DSD酸工业废水

分别采用三烷基胺(Alamine 336)和氯化季铵盐(Aliquat 336)为萃取剂,正辛醇为助溶剂,煤油为稀释剂,进行H酸、DSD酸及其工业废水反应萃取的实验研究结果表明,萃取率与溶液的pH值有关,Alamine 336体系适于酸性较强废水的处理,Aliquat 336体系适于中性废水的处理;采用多级错流萃取能有效地去除废水中两性官能团化合物和色度,去除率达99%以上,反萃率可达100%,工艺简单易行,溶剂可再生使用.     

采用萃取——反萃取技术回收废水中的醋酸

用N235-正辛醇-磺化煤油混合溶剂为萃取剂，用35％氢氧化钠反萃取，对于6．8％的醋酸废水进行萃取试验。试验结果表明：混合溶剂对废水中的醋酸有较高的萃取率，反萃取效果为98．4％。采用萃取-反萃取工艺处理稀醋酸废水，不但有明显的环境效益，而且还可以回收醋酸制备醋酸钠，获得良好的经济效益。     

氨基苯酚类废水的络合萃取

以P2 0 4 (二 (2 乙基己基 )磷酸 )为络合剂 ,煤油为稀释剂 ,正辛醇为助溶剂 ,通过萃取 反萃取的方式 ,对氨基苯酚类废水进行处理。研究了萃取剂浓度、废水pH值和油水比O/W ,以及反萃剂浓度、反萃油水比和反萃温度对萃取效率的影响。结果表明可将原废水的CODcr值降低至 1 / 7,使之满足其它末端处理的要求 ,而且反萃工艺简单易行 ,溶剂可重复使用     

络合萃取法处理H酸、T酸生产废水

采用络合萃取法,以三辛胺为萃取剂、正辛醇为助溶剂及煤油为稀释剂处理H酸、T酸工业废水。正交实验表明:溶液pH对萃取率影响最大。H酸最适宜的萃取条件是:萃取剂浓度25.9%、相比5∶1、pH 2.0,经一级萃取COD去除率可达88.4%,T酸最适宜的萃取条件是:萃取剂浓度50%、相比4∶1、pH 1.5,经两级逆流萃取,萃取率可达97.2%。用20%的NaOH溶液对萃取相进行反萃取,回收得到的萃取剂可循环使用,为工业上H酸、T酸废水预处理提供了可行途径。     

中和-络合萃取-双极膜电渗析处理金刚烷胺制药废水

采用中和沉淀-络合萃取-双极膜电渗析组合工艺协同处理金刚烷胺制药胺化废水与溴化废水.结果表明,通过胺化废水与溴化废水的中和反应,可以大幅消减废水中溶解性固体和有机污染物,避免后续萃取过程中的乳化现象.在pH值为8.0、油/水相比为1∶1的条件下,P204∶正辛醇=3∶2的复配萃取剂对废水中TOC和TN的萃取效率分别为56.9%和20.6%,金刚烷胺及其衍生物几乎被完全萃取.以2.0 mol·L-1的HCl溶液为反萃取剂,可以将47.5%的金刚烷胺从负载有机相中反萃分离,再生后的萃取剂可以多次重复使用.对萃余液采用双极膜电渗析进行处理,可以去除64.2%的无机盐和部分有机物,同时还能回收到较高浓度的酸,但由于氢离子的渗漏难以回收高浓度的碱.     

络合萃取法处理甲苯二异氰酸酯氢化废水的试验研究

研究络合萃取处理甲苯二异氰酸酯（TDI）生产氢化废水的工艺过程,考察了pH值、萃取相比、萃取温度、萃取时间等因素对萃取效果的影响,并通过正交试验对工艺条件进行优化,结果表明：采用酸性含磷类萃取剂,煤油为稀释剂,在pH值为8.0、萃取温度为25℃、萃取时间为3 min、萃取相比为1.5︰1优化条件下,对氢化废水中苯胺类的萃取率大于97％。负载萃取剂以31%的盐酸作反萃剂,反萃取相比为20︰1条件下可实现完全再生,反萃液经处理可回收2,4-二氨基甲苯和2,6-二氨基甲苯。     

金刚烷胺制药胺化废水与溴化废水的中和-络合萃取处理

考察了两种废水中和反应过程对污染物的去除效果,然后采用P204/正辛醇复配萃取剂对废水进行络合萃取处理.结果表明,采用溴化废水中和滴定胺化废水可以大幅消减废水中污染物,避免后续萃取过程中的乳化现象;在pH值为8.0,油/水相比为1:1的条件下,P204:正辛醇=3:2的复配萃取剂对废水中TOC和金刚烷胺的单级萃取效率分别为49.6%和99.5%;多级萃取对TOC去除率没有明显提高;以2.0mol/L的HCl溶液为反萃取剂,在水/油相比为1:1条件下,可以将47.5%的金刚烷胺从负载有机相中反萃分离,回收得到的金刚烷胺盐酸溶液可以回用,再生后的萃取剂可以多次重复使用.     

络合萃取法处理金刚烷胺制药废水

采用络合萃取法处理金刚烷胺制药废水,考察了初始pH、络合剂种类、稀释剂配比、油/水相比和反应温度等对废水中金刚烷胺萃取效率的影响,并对萃取剂中金刚烷胺进行了反萃取分离回收. 结果表明:采用V(P₂₀₄)〔P₂₀₄为二(2-乙基己基磷酸)〕∶V(正辛醇)为3∶2的复配萃取剂处理金刚烷胺制药废水,在初始pH为8.0、油/水相比为1∶1和温度为25 ℃的条件下,能够去除废水中99.7%以上的金刚烷胺;在反萃取过程中,V(P₂₀₄)∶V(正辛醇)为1∶4的复配萃取剂可以获得更高的反萃取效率,以1.0 mol/L的HCl溶液为反萃取剂,当油/水相比为1∶1时,可将51.7%的金刚烷胺从萃取剂中反萃分离,回收得到的金刚烷胺盐酸盐溶液可以回用到生产工艺中,P₂₀₄-正辛醇复配萃取剂可在萃取和反萃取过程中多次重复使用.      

萃取法处理DSD酸氧化工序废水的研究

本文对萃取法处理ＤＳＤ 酸氧化工序废水进行了研究，确定了废水Ｈ２ＳＯ４三辛胺（ＴＯＡ） － 煤油的萃取体系，并探讨了萃取相比、水相酸度、稀释比、萃取温度、反应搅拌时间、搅拌强度和反萃投碱浓度、反萃温度等一系列处理参数。实验结果表明，经萃取处理后ＤＳＤ 酸氧化工序废水中的ＣＯＤ 及色度去除率分别达９４ ．３ ％ 和９９ ．６ ％ 。     

CLT酸废母液资源化萃取工艺

研究 N₂₃₅溶剂萃取体系综合处理 CLT酸废母液工艺 ,以实现资源回收 .结果表明 ,在萃取剂浓度为 40% ,酸化率为 50% ,相比 1∶1时 ,萃取效果最佳 ,此时废母液 COD去除率达 97% ,萃余液 COD低于 200 mg/L ,COD指标达到国家综合排放标准( GB8978-1996) ;Na₂CO₃和 NaOH混合水溶液作反萃剂 ,能够完全反萃 ,浓缩倍数达 9.4倍 ;浓缩液经蒸浓酸析 ,得到固体产品 ,产率 8.34g/L(废母液 ) ,主要有机成分为 CLT酸及其硝基衍生物 .     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Evaluation of phytoextracting cadmium and lead by sunflower, ricinus, alfalfa and mustard in hydroponic culture

Soil contaminated with heavy metals cadmium(Cd)and lead(Pb)is hard to be remediated.Phytoremediation may be a feasible method to remove toxic metals from soil,but there are few suitable plants which can hyperaccumulate metals.In this study,Cd and Pb accumulation by four plants including sunflower(Helianthus annuus L.),mustard(Brassica juncea L.),alfalfa(Medicago sativa L.), ricinus(Ricinus communis L.)in hydroponic cultures was compared.Results showed that these plants could phytocxtract heavy metals, the ability of accumulation differed with species,concentrations and categories of heavy metals.Values of BCF(bioconcentration factor)and TF(translocation factor)indicated that four species had dissimilar abilities of phytoextraction and transportation of heavy metals.Changes on the biomass of plants,pH and Eh at different treatments revealed that these four plants had distinct responses to Cd and Pb in cultures.Measurements should be taken to improve the phytoremediation of sites contaminated with heavy metals,such as pH and Eh regulations,and so forth.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.