曝气生物滤池工艺处理瓷厂污水

瓷厂污水中的污染物主要以有机物为主,可生化性较好,易于用生物法处理.采用曝气生物滤池(BIOFOR)工艺处理瓷厂污水.其污水水质:ρ(CODCr))为400mg·L-1;ρ(BOD5)为200 mg·L-1;ρ(NH3-N)为35mg·L-1;ρ(SS)为300 mg·L-1.运行结果表明,该工艺处理效率高、操作简单、运行费用低、占地面积小,出水水质达到了《污水综合排放标准》(GB 8978-1996)一级排放标准.     

浸胶废水的工艺改造

浸胶废水由于含有天然胶、丁吡胶等有机物质,ρ(CODCr)为6000mg·L-1,ρ(SS)为3000mg·L-1,经过技术改造,更改工艺,采用粉煤灰作絮凝剂,降低了运行成本,ρ(CODCr)降至123mg·L-1,ρ(SS)降至59mg·L-1,达到“增产不增污”的效果。     

粉末活性焦强化A/A/O工艺处理煤气化废水的中试研究

煤气化废水水质复杂,是一种典型的难降解工业废水,而常规A/A/O工艺生化处理效率不高,严重制约了此类废水的处理和回用.因此,试验进行了粉末活性焦强化A/A/O工艺处理煤气化废水的中试研究,向好氧池投加粉末活性焦形成生物膜-悬浮污泥复合系统,并将剩余污泥回流至系统前段对原水进行预处理.研究结果表明,在活性焦投加量为250 mg·L-1,系统总HRT为105 h的优化条件下,CODCr、氨氮、总氮的去除率分别为97.4%、98.1%和80.5%,出水浓度分别为76 mg·L-1、0.3 mg·L-1和22.4 mg·L-1,达到《循环冷却水用再生水水质标准》(HG/T3923—2007)中CODCr≤80 mg·L-1、NH3-N≤15 mg·L-1、TN≤30 mg·L-1的要求.进一步机理研究表明,向好氧池中投加的粉末活性焦可作为微生物载体和菌胶团核心,投加活性焦后,好氧池的活性污泥浓度增加了57.9%.含焦剩余污泥对原水进行吸附预处理,石油类和SS的去除率分别为34.8%和61.5%,降低了废水对生化系统的毒害作用和冲击负荷,从而提高了系统的整体效率.     

化肥污水处理工程实践

介绍了采用A/O一体生化工艺对化肥废水进行处理,设计水量720 m3/d,进水NH3-N质量浓度为300 mg/L.运行结果表明,该工艺处理效果好,出水水质为ρ(COD)≤150 mg/L,ρ(NH3-N)≤70mg/L,ρ(SS)≤100 mg/L达到了GB 13458-2001《合成氨工业水污染物排放标准》最高允许排放限值的要求.     

奶牛养殖废水处理工程分析

采用UASB-接触氧化为主体的工艺处理某奶牛养殖场废水,当原水CODCr质量浓度为3 000～4 000mg/L,NH3-N质量浓度为30～50 mg/L时,该工艺对CODCr的去除率为97%～98%,NH3-N去除率约为80%,配以化学深度处理,出水达到GB 8978-1996<污水综合排放标准>中的一级排放标准.     

利用UASB和EIC技术处理果汁废水

针对某饮料有限公司果汁生产废水,采用EIC UASB 接触氧化工艺进行处理。处理后出水水质:ρ(COD)为58mg·L-1,ρ(SS)为16mg·L-1,ρ(NH3-N)为2.65mg·L-1,ρ(BOD5)为13.5mg·L-1,ρ(TP)为0.20mg·L-1。均低于《污水综合排放标准》(GB8978—1996)中的一级标准。该系统容易控制、运行稳定且产生污泥量少。     

催化氧化-A/O工艺-生物滤池处理高浓度有机胺废水中试

试验采用催化氧化-A/O工艺-生物滤池组合工艺,以高浓度有机胺废水为研究对象,重点考察了该工艺对进水COD、氨氮和总氮的去除效果。结果表明:采用催化氧化预处理工艺,能有效降低废水中的抑制性物质,提高废水的B/C;A/O工艺能去除大量的有机物和总氮,但出水氨氮有所升高;末端采用生物滤池处理该废水,能有效降低废水中的氨氮和COD。当进水ρ(COD)为3 000～4 000 mg/L、ρ(NH3-N)为15～60 mg/L、ρ(TN)为350～450 mg/L时,出水水质可达当地环保要求的排放标准:ρ(COD)≤300 mg/L、ρ(NH3-N)≤35mg/L,表明该工艺可应用于高浓度有机胺废水的处理。     

焦化废水处理工程实例

以某焦化厂焦化废水处理工程为例,介绍预处理-A2O-后处理工艺处理焦化废水的工程应用,总结并分析了工程设计及运行经验;设计处理流量1 920 m3/d,进水COD,SS,NH3-N质量浓度分别为6 000,300,300 mg/L;运行结果表明:经该组合工艺处理后,出水COD,SS,NH3-N等水质指标均满足最初设计标准:ρ(COD)≤100 mg/L,ρ(SS)≤30 mg/L,ρ(NH3-N)≤10 mg/L,有利于企业的可持续发展.     

利蒙(LLMO)浓缩微生物菌在粘胶化纤废水治理中的应用

文中研究了利用投加利蒙菌对江西某化纤厂化纤废水的污水处理厂生化池进行改进,以期提高出水的CODCr与SS去除率,稳定出水水质。实验结果表明,利蒙菌在对粘胶化纤废水生化处理上的改进是可行的,对废水中CODCr,SS的平均去除率可比未投加提高56%,44%,其出水水质良好、稳定,其中ρ(CODCr)<40mg·L-1,ρ(SS)<50mg·L-1。     

O_3-MBR法深度处理煤气废水

以经多级生物处理后的煤气废水为原水,采用O3-MBR组合工艺对其进行深度处理,以满足回用要求.结果表明:采用臭氧氧化工艺,当废水pH为11和臭氧投加量〔ρ(臭氧)〕为189.2mg/L时,CODCr和色度的去除率分别为46.5%和80.2%,ρ(BOD5)/ρ(CODCr)由0.02升至0.29,废水的可生化性得到明显改善;臭氧氧化工艺出水再通过MBR作进一步处理,CODCr,NH3-N和色度的去除率分别达23.0%,76.3%和70.0%,且出水水质稳定;总体上,废水经O3-MBR组合工艺处理,CODCr,NH3-N,色度和浊度的平均总去除率分别达到58.7%,76.3%,88.6%和95.1%;处理后出水的ρ(CODCr)50mg/L,ρ(NH3-N)5mg/L,浊度0.2NTU,色度约为30度,出水水质满足生产工艺回用的要求.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.