MAP晶体捕集反应器回收猪场厌氧消化液中磷的研究

研究了磷酸铵镁(MAP)结晶法晶体捕集反应器在曝气条件下回收猪场厌氧消化液中磷元素的能力.结果表明,利用曝气方式提高猪场厌氧消化液的p H值,进行MAP结晶回收磷完全可行.MAP的饱和度指数(SI)与废水p H值呈多项式函数关系,结晶反应的最佳p H值为8.5~9.0;随着曝气时间延长至180 min,反应器内废水p H值可提高至8.5;常温下(25℃),反应器内MAP回收磷的反应动力学的反应级数(n)为1.98,速率常数(K25)为7.04×10-4L·mg-1·min-1;反应器单个运行周期为270 min;磷的平均去除率为82%左右.MAP晶体捕集反应器上的晶体在一个反应周期内即可成形,随着反应周期的增加,晶体颗粒逐渐增大.利用扫描电镜和X射线衍射仪对捕集器所捕集的晶体进行了表征,证实晶体为高纯度的MAP.     

磷酸铵镁法回收污泥上清液中磷元素的最优条件探究

污泥中含有一定量的磷,污泥在储泥池中停留一定时间将会释放大量的磷到上清液中,因此采用磷酸铵镁法对储泥池污泥上清液中磷元素进行回收,可有效回收磷,提高资源利用。研究中探究了磷回收的最优条件。结果表明,镁磷摩尔比为1.2、终点p H为8.3~9.0时,磷元素的回收率维持在80%以上,可作为实际生产的控制条件,而继续增大镁磷摩尔比和提高终点p H,对磷的回收率提高较小。同时分析反应生成沉淀物发现,磷酸铵镁含量接近50%左右,且以Mg NH4PO4·H2O单晶体为主要成分。     

垃圾衍生燃料灰渣中主要元素变化的研究

以垃圾衍生燃料(RDF)为研究对象,在600~1100℃条件下灼烧RDF灰渣,对灰渣中的主要元素变化情况进行分析.研究结果表明,RDF灰渣中主要元素包括硅、氧、铝、钙、镁、钾、钠、碳、硫、氯、磷、钛、锌等;灰渣中的可溶盐倾向富集在≤0.3 mm的灰渣颗粒上;在600~1000℃范围内,其总量处于动态平衡,在1100℃则大幅度减少.随着温度的上升,碳转化为二氧化碳气体;硫元素转化为硫酸盐,随后部分再转化为二氧化硫气体;氯元素转化为以氯化钠和氯化钾为主的氯化盐,在达到一定温度时发生相变转化为气体.硅、氧、铝、钙、镁、磷等元素留存于废渣中,随着温度提高,发生复合化学反应,相互键接形成复合硅酸盐物质.     

赤泥诱导磷酸钙结晶法回收废水中的磷

为获取适用的废水磷回收工艺,以赤泥为晶种,诱导磷酸钙(HAP)结晶法回收模拟废水中的磷,研究工艺条件对回收效果的影响;运用扫描电子显微镜(SEM)、X-射线能谱仪(EDS)和X-射线衍射仪(XRD)对最优工艺条件下的结晶产物进行了表征。结果表明,当搅拌速度为180 rmin,搅拌时间为30 min,沉淀30 min后,在赤泥投加量为8 gL,赤泥粒径为40~60目(250~380μm),初始磷酸盐浓度为60 mgL时,磷的回收率可达74.1%。不同初始磷酸盐浓度下,随pH升高,磷酸根离子、钙离子的回收率均增大,但增大速率随初始磷酸盐浓度的提高而减缓。磷酸根离子的回收率随着Ca与P物质的量比的增大而增大;而钙离子的回收率随Ca与P物质的量比的增大达到一个最大值,但随初始磷酸盐浓度不同,出现回收率最大值的Ca与P物质的量比也不同。赤泥晶种重复使用不宜超过3次。废水中的磷主要以磷酸钙形态被回收。     

二乙烯三胺五甲叉膦酸酸解磷尾矿的实验探究

为减少磷尾矿堆积带来的环境污染问题,实现磷尾矿的钙、镁、磷元素的分离,以高镁磷尾矿为原料,采用二乙烯三胺五甲叉膦酸(DTPMP)进行酸解,探究磷尾矿中主要物相在DTPMP中的分解机制,并通过单因素实验探究pH、反应时间、反应温度及投料比对磷尾矿中MgO、CaO和P_2O_5分解率的影响。实验结果表明:pH对P_2O_5的分解率影响较大,高温更有利于尾矿中镁的溶出,在pH为2. 5,反应时间为60 min,反应温度为80℃,投料比为1. 56时,MgO、CaO和P_2O_5的分解率分别达到61. 05%、38. 23%和9. 67%。     

强化磷酸铵镁法回收源分离黄水中氮磷的试验研究

为强化氮磷的回收与资源化利用,采用磷酸铵镁法处理源分离黄水。分析了p H值、Mg∶N∶P(摩尔比)、搅拌时间、搅拌速度、温度等因素对氮磷回收效果的影响,考察了p H值调节方式对氮磷回收的强化作用。结果表明:p H值调节方式和Mg∶N∶P是影响氮磷回收效果的主要因素;改善pH值的调节方式可以提高氮磷回收率并节省镁源和磷源的投加;在初始pH值为9且首次反应结束后pH值回调至9、Mg∶N∶P=1.1∶1∶1的条件下,氮、磷回收率分别达到82.6%和94.5%,获得的沉淀晶体呈斜方晶型且杂质较少。     

加碱处理PAC污泥的释磷机理及磷回收研究

以加碱处理PAC污泥,考察了不同p H条件下污泥破解情况,研究了污泥中磷和铝的释放以及磷形态分布与变化以分析污泥释磷机理,最后对释放的磷进行回收.结果表明,相比于p H=11、12,p H=13更有效地促使污泥细胞破解和DNA释放,240min后细胞破解率达96.9%.同时,SOP(溶解性正磷酸盐,以PO_4~(3-)-P计)大量释放,其中大部分来源于磷酸铝和氢氧化铝的溶解.调节污泥初始p H=13,240min后污泥中91.2%的NAIP(非磷灰石无机磷)和69.2%的OP(有机磷)溶解释放.对加碱处理后的污泥脱水,取脱水滤液进行磷回收,p H=9.5,Ca/P=3时,30min后磷回收效果可达82.4%.研究认为,通过加碱促使PAC污泥大量释磷并回收,效果好、运行简单,具有实际应用潜力.     

MAP法沉淀回收尿液中氮磷的研究

从尿液中回收氮和磷,不但可以减少污水厂的负荷,还可以回收氮磷资源,具有较好的经济效益与环境效益。采用磷酸铵镁结晶法(MAP)去除和回收尿液中的氮和磷,并采用反渗透浓水作为沉淀镁源,达到以废治废的目的。在研究新鲜尿液水解特性的基础上,采用Mg Cl2作为尿液沉淀镁源,得出反应的最优化条件为:p H为9.5,n(Mg2+)∶n(PO3-4-P)为1.1∶1,搅拌速度为120 r/min、沉淀时间为90 min,并利用工业废水RO浓水替代Mg Cl2沉淀镁源回收废物尿液中的磷,去除率可达90%以上。     

从剩余污泥厌氧发酵上清液中以鸟粪石形式回收磷

为了实现以鸟粪石(MAP,MgNH4PO4·6H2O)的形式回收剩余污泥厌氧发酵上清液中的氮磷,研究了氮磷溶出的最佳条件及不同的反应条件对氮磷回收的影响.结果表明在p H为10. 5,温度为35℃时,发酵液中溶出的氨氮与正磷酸盐质量浓度皆在第5 d达到峰值;在添加磷源的条件下,磷回收的最佳条件为p H=9. 5、N∶P=0. 8、Mg∶P=1. 8;未添加磷源的条件下,回收磷的最佳条件为p H=9. 5、Mg∶P=1. 6、转速200 r·min-1.此外,降低N∶P摩尔比对于鸟粪石的形态和纯度均有显著影响.利用扫描电镜(SEM)、X光微区分析(EDS)、X射线衍射(XRD)和傅里叶红外光谱(FTIR)等手段对回收产物进行了表面相貌及物相组成分析,证实了沉淀物的主要成分为MAP.以鸟粪石形式回收剩余污泥中的氮磷,是实现污泥资源化的一种有效手段.     

废水中鸟粪石回收的机器学习预测和优化

基于机器学习的方法，探究了从模拟废水中以鸟粪石的形式回收氮和磷的问题。利用极限梯度提升算法(XGBoost)和随机森林(RF)模型对磷回收率和氮回收率进行单目标和多目标预测，明确了7种工艺条件对鸟粪石结晶的影响。XGBoost在单目标(R²=0.91～0.93)和多目标(R²=0.89)的预测方面表现均优于RF。此外，在P初始浓度为10 mg/L和1 000 mg/L的情况下，通过实验验证了多目标模型的优化解集，得到鸟粪石回收的最佳工艺条件为N∶P比值为1.2∶1,Mg∶P为1∶1,pH为9.5,反应时间为80 min,反应温度为25℃,搅拌速率为240 r/min。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.