“组合火焰型”焦炉大气主要污染物排放特征分析

为了研究"组合火焰型"焦炉对大气环境的实际影响,通过实测主要污染物排放浓度,对其排放规律及达标情况进行分析。结果表明:颗粒物有组织排放浓度特征规律为,筛焦处>备煤处>焦炉烟囱>装煤处>推焦处;SO2、NOx有组织排放浓度特征规律为,焦炉烟囱>推焦处>装煤处;BaP有组织排放浓度特征规律为,装煤处>推焦处>焦炉烟囱;装煤处、推焦处以BaP污染为主,焦炉顶以NOx污染为主。受装煤、出焦的双重影响,颗粒物无组织排放由塔南向塔北浓度逐渐降低,BaP、BSM在装煤塔两侧浓度水平相当。在生产负荷大于90%的情况下,所测污染物排放浓度均能达标且优于传统型焦炉,在BaP、BSM控制方面具有明显优势。     

现行焦炉烟气SO_2排放现状及整改措施分析

《炼焦化学工业污染物排放标准》(GB16171-2012)实施后,部分现有焦化企业焦炉烟囱二氧化硫排放浓度已不满足排放标准,本文通过对焦炉烟囱二氧化硫超标原因的分析,为现有焦化厂实现达标排放提出整改措施。     

典型焦化厂大气挥发性有机物排放表征分析

焦化行业是我国重要工业类别,但因其工艺过程复杂,所以VOCs（挥发性有机物）排放特征尚不明确.以典型机械焦化厂为研究对象,对焦炉烟囱、推焦、装煤和焦炉顶等不同排放环节进行采样,并利用GC/MS（气相色谱质谱联用仪）进行多物种分析,并对焦化厂排放VOCs的OFP（生成O₃的潜势）进行探索性研究.结果表明:①焦化厂排放的VOCs包括烷烃、烯烃、炔烃、芳香烃、卤代烃和含氧VOCs等六大类,共90多个物种.②不同环节排放的ρ（VOCs）差异显著,其中,焦炉烟囱ρ（VOCs）排放量（87.1 mg/m3）最大,其次为推焦（4.0 mg/m3）、装煤（3.3 mg/m3）和焦炉顶（1.1 mg/m3）.③不同环节排放的VOCs种类不同,但均以烷烃和烯烃为主,其中,焦炉烟囱排放的烯烃最多（占比达66%）,装煤和推焦排放的则以烷烃为主（占比分别为42%和36%）,焦炉顶排放的烷烃和烯烃相近（占比分别为31%和29%）.④基于排放特征和最大增量反应活性法研究发现,焦炉烟囱是焦化厂VOCs减排的重点环节,烯烃是重点减排的物种,特别是乙烯、丙烯、丁烯和1,3-丁二烯等,但乙醛、苯、甲苯等也不容忽视.研究显示,以乙烷/丙烷/乙烯（三者质量浓度之比）为指标,可明显区分焦炉烟囱、推焦、装煤和焦炉顶等不同环节的VOCs排放.      

有色冶炼污染源达标评估和动态管理系统开发

确保工业污染达标排放是环境管理的重要方面,达标评估工作需要采取全过程控制的思路,并进行动态跟踪。在污染物排放预测基础上,提出了有色冶炼行业污染源排放达标可行性评估方法,包括排污系数法和排放模型法。开发了有色冶炼污染源达标评估和动态管理系统,利用系统排放模型法评估了A企业阳极炉烟囱污染源排放污染物。结果表明,阳极炉烟囱SO2排放(538 mgm3)不达标,从节能降耗、开展清洁生产审核以及建立环境管理体系等方面提出优化方案,3个方案的SO2排放浓度分别为370、365和292 mgm3,可实现全部达标排放。     

焦炉烟囱废气SO2、NOx污染控制技术分析及展望

介绍了不同燃料类型焦炉的SO_2、NO_x产生特点和国外污染治理情况,详细梳理了目前国内在源头控制、过程控制和末端治理方面采取的污染治理技术,分析了现有焦炉在烟囱废气治理上存在的工艺路线选择、焦炉烟囱热备、次生污染及运行稳定性等方面的问题。对比分析了现有各种技术优缺点,提出了焦炉烟囱废气污染治理的可行技术路线。     

煤焦化过程中颗粒物和二氧化硫的释放

选择山西省某地的四个土焦炉、两个热回收焦炉和两个机焦炉开展焦炉顶空气和烟气中颗粒物和SO2研究。结果显示在正常工作条件下热回收焦炉顶空气中颗粒物和SO2浓度最小,其次是机焦炉,土焦炉顶最高。机焦炉和热回收焦炉顶污染物浓度在出焦和装煤时明显升高。土焦炉烟气中颗粒物排放浓度和排放速率明显高于热回收焦炉和机焦炉;各种炉型烟气中SO2浓度差别较小,排放速率以机焦炉最高;土焦炉的烟尘和二氧化硫吨焦排放量最高,而机焦炉和热回收焦炉由于环保设备的使用显著降低。生产过程污染物释放显示机焦炉和热回收焦炉的颗粒物和SO2释放主要来源于焦化过程和熄焦过程。由吨焦排放量估计炼焦烟尘和二氧化硫对全国的烟尘和二氧化硫排放贡献小于5%,但对山西省的贡献接近15%和30%,控制炼焦污染对当地环境改善具有重要意义。     

用焦炉废气中的二氧化碳分解酚钠

攀钢焦化厂自行设计制作了一套用二氧化碳分解酚钠的装置,已投产近一年时间。其中二氧化碳来自焦炉烟囱废气,生产能力每小时处理精制酚钠0.625吨,年产粗酚600吨,运转情况良好,产品质量符合国家标准。与传统的硫酸法相比,此法每年可节约硫酸360吨,副产品碳酸钠水溶液可用于焦油脱盐和黄血盐生产,避免了岗位上硫酸雾的污染和硫酸钠废液的产生,减少了烟囱二氧化碳放散量,实现了连续生产,劳动条件     

基于反演模型的焦炉无组织苯并[a]芘排放因子研究

由于焦炉无组织苯并[a]芘排放因子难以测量,导致了焦炉苯并[a]芘大气污染研究存在一定的不确定性.针对上述问题,本研究根据1999年~2003年上海某焦化厂的产量、空气质量监测等数据,建立了基于AERMOD(AMS/EPA REGULATORY MODEL)模型反演苯并[a]芘排放因子的方法.结果显示,企业周边3个监测点年平均浓度结果分别为0.033,0.0024,0.0031μg/m³,均超过了2012年颁布的环境空气质量标准,通过AERMOD模型反演得到该焦化厂苯并[a]芘平均排放因子为14.71mg/t焦煤, 苯并[a]芘预测浓度超标面积125km²,超标区域主要集中在焦化厂周围,超标焦炉苯并[a]芘防护距离为6300m.     

炼焦过程及周边环境颗粒物中水溶性无机离子特征

为明确炼焦过程排放颗粒物及周边环境颗粒物中水溶性无机离子的污染特征,于2012年5月利用改良的标准大体积总悬浮颗粒采样器采集燃烧室废气烟囱排放、焦炉顶无组织排放及焦炉周边环境空气TSP（total suspended particulates,总悬浮颗粒物）样品,使用Staplex234大流量采样器采集焦炉顶无组织排放及焦炉周边环境空气PM_1.4样品,采用ICS-90离子色谱仪测试样品中SO₄2-、NH₄+、Ca2+、Cl-、NO₃-、F-、Mg2+、K+、Na+共9种水溶性无机离子.结果表明:SO₄2-为炼焦过程排放的特征离子.炼焦过程燃烧室废气烟囱排放的TSP中总水溶性无机离子质量浓度最高,为（5 493±901）μg/m3;其次为焦炉顶无组织排放的TSP,其总水溶性无机离子质量浓度为（902±222）μg/m3;焦炉周边环境空气的TSP中总水溶性无机离子质量浓度最低,为（712±288）μg/m3.SO₄2-为燃烧室废气烟囱排放TSP与燃煤锅炉烟气排放颗粒物中共有的主要特征离子,但与燃煤锅炉烟气相比,燃烧室废气烟囱排放的w（SO₄2-）略低,w（F-）则相反.NH₄+较易富集于焦炉顶无组织排放的细颗粒物中,而SO₄2-则较易富集于粗颗粒物中.研究显示,炼焦过程及焦炉周边环境空气颗粒物中9种水溶性无机离子分布特征不同,SO₄2-是燃烧室废气烟囱排放、焦炉顶无组织排放的TSP中质量浓度最高的水溶性无机离子.      

焦化作业对工人脂质过氧化的影响

焦化作业接触多种有害物质,如煤粉、烟灰、SO2、CO及氮氧化物。焦炉逸散物中烟灰重量约占25%～40%,其中焦油成份中含有苯并(a)芘等多环芳烃化合物,大量流调资料证实,后者与焦炉工人肺癌高发率有关,焦炉工肺癌在我国已列为职业肿瘤。近年膜毒理学理论认为许多化学毒物都可加剧体内脂质过氧化(LPO)效应,长期作用可导致机体多种病理改变,甚至可诱发DNA突变。动物实验亦证实煤焦沥青对大鼠产生的脂质过氧化损伤效应与肺癌的形成有密切关系[1]。为了解焦化作业对工人脂质过氧化的影响,对某焦化厂作业工人有关指标进行了测定,并与对照人群进行…     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Effect of sorbed and desorbed Zn(Ⅱ) on the growth of a green alga (Chlorella pyrenoidosa)

Toxic effect of Zn(Ⅱ) on a green alga (Chlorella pyrenoidasa) in the presence of sepiolite and kaolinite was investigated.The Zn-free clays were found to have a negative impact on the growth of C.pyrenoidosa in comparison with control samples (without adding any clay or Zn(Ⅱ)).When Zn(Ⅱ) was added,the algae in the presence of clays could be better survived than the control samples,which was actually caused by a decrease in Zn(Ⅱ) concentration in the solution owing to the adsorption of Zn(Ⅱ) on the clays.When the solution system was diluted,the growth of algae could be further inhibited as compared to that in a system which had the same initial Zn(Ⅱ) concentration as in the diluted system.This in fact resulted from desorption of Zn(Ⅱ) from the zinc-contaminated clays,although the effect varied according to the different desorption capabilities of sepiolite and kaolinite.Therefore the adsorption and desorption processes of Zn(Ⅱ) played an important part in its toxicity,and adsorption and desorption of pollutants on soils/sediments should be well considered in natural eco-environmental systems before their risk of toxicity to aquatic organisms was assessed objectively.