Advanced landfill leachate treatment using a two-stage UASB-SBR system at low temperature

A two-stage upflow anaerobic sludge blanket(UASB) and sequencing batch reactor(SBR) system was introduced to treat landfill leachate for advanced removal of COD and nitrogen at low temperature.In order to improve the total nitrogen(TN) removal efficiency and to reduce the COD requirement for denitrification,the raw leachate with recycled SBR nitrification supernatant was pumped into the first-stage UASB(UASB1) to achieve simultaneous denitrification and methanogenesis.The results showed that UASB1 played an important role in COD removal and UASB2 and SBR further enhanced the nutrient removal efficiency.When the organic loading rates of UASB1,UASB2 and SBR were 11.95,1.63 and 1.29 kg COD/(m3·day),respectively,the total COD removal efficiency of the whole system reached 96.7%.The SBR acted as the real undertaker for NH4+-N removal due to aerobic nitrification.The system obtained about 99.7% of NH4+-N removal efficiency at relatively low temperature(14.9-10.9°C).More than 98.3% TN was removed through complete denitrification in UASB1 and SBR.In addition,temperature had a significant effiect on the rates of nitrification and denitrification rather than the removal of TN and NH4+-N once the complete nitrification and denitrification were achieved.     

高氮渗滤液缺氧/厌氧UASB-SBR工艺低温深度脱氮

在低温条件下,采用缺氧/厌氧UASB-SBR组合工艺处理实际垃圾填埋场渗滤液.结果表明,该工艺可实现有机物和氮的同步、深度去除.在进水COD平均为11950.2mg/L,NH4+-N为982.7mg/L的条件下,出水分别为390.1mg/L和2.9mg/L,去除率分别为96.7%和99.7%.同时,缺氧UASB1反应器的最大COD负荷达到13kg/(m3×d),最大COD去除速率为12.39 kg/(m3×d),具有高效缺氧反硝化和高效厌氧降解有机物反应的双重功效, 在SBR反应器的缺氧段和缺氧UASB,反应器内获得了99%以上的反硝化率.对于冬季水温分别为14.9,14.1,13.5,11.05℃的低温条件下,SBR反应器实现了完全硝化和反硝化,出水TN分别为4.1,5.7,14.1,16.5mg/L,达到了深度脱氮的目的.此外,在上述温度范围内,温度对反硝化速率(rN)的影响大于对硝化速率 (rDN)的影响, rN/rDN比值相对恒定.     

游离氨对城市生活垃圾渗滤液短程硝化的影响

为了考察游离氨(free ammonia,FA)对高氮城市生活垃圾渗滤液短程硝化的影响,采用“两级UASB-缺氧-好氧系统”处理实际城市生活垃圾渗滤液.首先在UASB1中实现同时反硝化与产甲烷反应,COD在UASB2中进一步去除,在A/O反应器中利用残余COD进行反硝化以及将NH⁺₄-N彻底硝化.试验共进行79 d,经历3个阶段,即稳定短程硝化(40 d)、短程硝化破坏(19 d)、短程硝化恢复(20 d).结果表明,适当的游离氨浓度（40～70 mg·L^-1）可实现稳定的短程硝化,如在阶段1中亚硝态氮积累率为97%,氨氮的去除率为99%.但游离氨浓度在160 mg·L^-1左右会抑制全部的硝化反应.在阶段3中,通过稀释原水降低了游离氨浓度,在短时间内就恢复了短程硝化.可见,游离氨是实现和维持城市生活垃圾渗滤液短程硝化的重要影响因素.     

Nitrogen removal via nitrite from municipal landfill leachate

A system consisting of a two-stage up-flow anaerobic sludge blanket (UASB), an anoxic/aerobic (A/O) reactor and a sequencing batch reactor (SBR), was used to treat landfill leachate. During operation, denitrification and methanogenesis took place simultaneously in the first stage UASB, and the e uent chemical oxygen demand (COD) was further removed in the second stage UASB. Then the denitrification of nitrite and nitrate in the returned sludge by using the residual COD was accomplished in the A/O reactor, and ammonia was removed via nitrite in it. Last but not least, the residual ammonia was removed in SBR as well as nitrite and nitrate which were produced by nitrification. The results over 120 d (60 d for phase I and 60 d for phase II) were as follows: when the total nitrogen (TN) concentration of influent leachate was about 2500 mg/L and the ammonia nitrogen concentration was about 2000 mg/L, the shortcut nitrification with 85%–90% nitrite accumulation was achieved stably in the A/O reactor. The TN and ammonia nitrogen removal e ciencies of the system were 98% and 97%, respectively. The residual ammonia, nitrite and nitrate produced during nitrification in the A/O reactor could be washed out almost completely in SBR. The TN and ammonia nitrogen concentrations of final e uent were about 39 mg/L and 12 mg/L, respectively.     

高氮渗滤液短程深度脱氮及反硝化动力学

采用单级UASB-SBR生化系统处理实际高氮晚期渗滤液,重点研究了系统的有机物和氮去除特性,同时考察了SBR短程生物脱氮系统内微生物的反硝化动力学特性.试验结果表明,该生化系统能够高效、深度去除渗滤液内高浓度有机物和氮.UASB反应器的平均COD负荷为6.5 kg/(m3.d),去除速率为5.3 kg/(m3.d).在进水COD平均为6 537 mg.L-1,NH+4-N为2 021mg.L-1的条件下,出水分别为354 mg.L-1和2.8 mg.L-1以下,去除率分别为94.6%和99.8%,尤其是该系统获得了99.2%的TN去除率,出水TN20 mg.L-1,实现了深度脱氮的目的.SBR反应器实现并维持了稳定的短程硝化,通过90%以上的亚硝化率实现高效的氨氮去除,同时SBR系统内微生物的反硝化特性符合Monod动力学方程.     

An autotrophic nitrogen removal process：Short-cut nitrification combined with ANAMMOX for treating diluted effluent from an UASB reactor fed by landfill leachate

A combined process consisting of a short-cut nitrification (SN) reactor and an anaerobic ammonium oxidation upflow anaerobic sludge bed (ANAMMOX) reactor was developed to treat the diluted effluent from an upflow anaerobic sludge bed (UASB) reactor treating high ammonium municipal landfill leachate.The SN process was performed in an aerated upflow sludge bed (AUSB) reactor (working volume 3.05 L),treating about 50% of the diluted raw wastewater.The ammonium removal efficiency and the ratio of NO 2 N to NOx-N in the effluent were both higher than 80%,at a maximum nitrogen loading rate of 1.47 kg/(m 3 ·day).The ANAMMOX process was performed in an UASB reactor (working volume 8.5 L),using the mix of SN reactor effluent and diluted raw wastewater at a ratio of 1:1.The ammonium and nitrite removal efficiency reached over 93% and 95%,respectively,after 70-day continuous operation,at a maximum total nitrogen loading rate of 0.91 kg/(m 3 ·day),suggesting a successful operation of the combined process.The average nitrogen loading rate of the combined system was 0.56 kg/(m 3 ·day),with an average total inorganic nitrogen removal efficiency 87%.The nitrogen in the effluent was mostly nitrate.The results provided important evidence for the possibility of applying SN-ANAMMOX after UASB reactor to treat municipal landfill leachate.     

序批式移动床生物膜反应器内同步短程硝化反硝化的控制

在序批式移动床生物膜反应器(SBMBBR)内,对进水COD较低的条件下,模拟生活污水的亚硝化及脱氮性能进行了研究.结果表明,缺氧时间、进水COD、NH44 -N浓度、pH值以及溶解氧对亚硝化过程有明显影响.在进水COD为100mg·L-1NH4 4-N浓度为50mg·L-1时,调控溶解氧、pH,出水的亚硝化率可到99.7%,总氮去除率可达66.4%,表明系统中发生了同步短程硝化反硝化.     

一体化厌氧氨氧化工艺处理垃圾渗滤液的性能研究

以垃圾渗滤液为研究对象,研究UASB-除碳-一体化ANAMMOX工艺的除碳脱氮特性.结果表明:该工艺可实现高效除碳脱氮;在进水COD浓度6210~16365mg/L?TN浓度为990~2100mg/L时工艺出水COD浓度最低为655mg/L,出水TN浓度最低为39.9mg/L.进水中的可降解COD主要在UASB和除碳池中去除(分别为59%和31%),进入到一体化ANAMMOX池中的多为惰性有机物质;TN的去除在除碳池和一体化ANAMMOX池中进行,其中除碳池中TN去除量占工艺TN去除量的53%,主要通过同步硝化反硝化去除;ANAMMOX池中TN去除46%,主要通过AOB和AnAOB的协同作用实现.当除碳池出水含可降解有机物时,对后续一体化ANAMMOX池的自养脱氮抑制严重;充分降解除碳池中的可降解有机物是影响系统脱氮效率的关键因素.     

UASB1-A/O-UASB2深度处理垃圾渗滤液

针对传统垃圾渗滤液生物处理TN去除率低、投加碳源成本高的问题,采用UASB1-A/O-UASB2(单级上流式厌氧污泥床+缺氧/好氧+后置上流式厌氧污泥床)工艺处理实际垃圾渗滤液,实现NH₄+-N和TN的同步深度脱除,并且定量解析了A/O反应器实现并维持稳定短程硝化的影响因素. 结果表明:以V(垃圾渗滤液)∶V(生活污水)为1∶5的混合液作为进水,其ρ(COD_Cr)、ρ(TN)和ρ(NH₄+-N)分别为1 700~1 800、660~700和650~680 mg/L,最终出水COD_Cr、TN和NH₄+-N去除率均在95%以上,出水ρ(TN)为38 mg/L,满足GB 16889—2008《生活垃圾填埋场污染控制标准》的排放要求. 在好氧反应器中,FA(游离氨)与FNA(游离亚硝酸)对NOB(硝化细菌)的联合抑制作用是实现NO₂--N积累率稳定在80%以上的主要原因,而产生的NO₂--N和NO₃--N可在UASB2中以难降解的有机物为碳源,通过反硝化途径被去除. 研究显示,组合系统可实现对TN的深度去除.      

短程硝化-厌氧氨氧化组合工艺深度处理垃圾渗滤液

为解决垃圾渗滤液中高浓度污染物对微生物的毒性抑制、生物处理出水有机物或氮不达标及投加碳源成本高的问题,采用UASB(上流式厌氧污泥床)-A/O(缺氧/好氧)反应器-ANAMMOXR(厌氧氨氧化反应器)工艺,通过短程硝化-ANAMMOX(厌氧氨氧化)深度处理实际垃圾渗滤液与生活污水混和液(体积比为1∶10),其ρ(COD_Cr)、ρ(NH₄+-N)和ρ(TN)分别为(750±30)(290±10)和(300±10)mg/L,试验共进行90 d. 结果表明:COD_Cr、NH₄+-N和TN的去除率分别为88%±1%、95%±1%和91%±1%,最终出水质量浓度分别为(67±5)(15±2)和(35±5)mg/L,满足GB 16889—2008《生活垃圾填埋场污染控制标准》的排放要求. A/O反应器中的ρ(FA)(FA为游离氨)在0.21～1.38 mg/L之间,可抑制NOB(硝酸细菌),使AOB(氨氧化细菌)成为优势菌种,从而实现并维持NO₂--N积累率(70%～96%)较高的短程硝化,继而在ANAMMOXR中通过ANAMMOX去除残余NH₄+-N和NO₂--N,实现系统对氮的深度去除.      

UASB-A/O工艺处理垃圾渗滤液短程生物脱氮的实现

应用缺氧/厌氧UASB-A/O组合工艺处理高氮晚期渗滤液,在获得稳定有机物和氮同步去除的前提下,考察了如何实现并维持A/O系统内稳定短程硝化的途径.结果表明:在单一UASB反应器内,同时发生了缺氧反硝化和厌氧产甲烷的反应,有机物和NOx--N去除速率分别为5.3,1.1kg/(m3×d).12~30.6℃时,经过54d的运行, A/O反应器实现短程硝化 (亚硝态氮积累率>50%),此后亚硝态氮积累率迅速上升,70d后,亚硝态氮积累率稳定在90%以上.在A/O反应器内,游离氨和游离亚硝酸协同作用是实现并维持稳定短程硝化的决定因素.此外,以pH值作为A/O硝化反应进行的过程控制参数,可准确把握硝化终点,避免过度曝气破坏短程硝化,为氨氧化菌的生长创造有利条件,有效抑制亚硝酸盐氧化菌的生长并逐渐从系统中淘洗出去,实现了硝化菌种群的优化,荧光原位杂交技术检测也证明这一点.     

实际垃圾渗滤液短程生物脱氮的常温实现及低温维持

采用单级UASB-SBR生化系统处理实际垃圾渗滤液,主要考察了常、低温条件下,该生化系统短程生物脱氮的长期稳定性,同时研究了SBR内短程硝化的实现机理及微生物种群特性.598d试验结果表明:单级UASB-SBR生化系统对渗滤液内COD,NH4+-N和TN的去除率分别为92.0%,99.2%和98.0%以上,实现渗滤液内有机物和氮的深度去除.经过116d运行,SBR系统实现了短程硝化,亚硝积累率(NAR)达到90%以上,此后稳定运行,成功跨越2个冬季,15℃以下共计171d,最低温度为10.2℃.游离氨(FA)和过程控制的协同作用是实现与维持SBR 内短程硝化的决定因素.荧光原位杂交(FISH)技术检测表明:氨氧化菌(AOB)已经成为SBR硝化菌群中的优势菌属.扫描电子显微镜(SEM)检测表明:AOB菌属以活椭球状亚硝化球菌属(Nitrosococcus)和杆状亚硝化单胞菌属(Nitrosomonas)为主.     

回流比对DN-PN-ANAMMOX工艺处理中晚期垃圾渗滤液的影响

为了进一步提升反硝化-部分亚硝化-厌氧氨氧化（denitrification partial nitrification and anaerobic ammonia oxidation,DN-PN-ANAMMOX）工艺处理含有高浓度NH₄+-N的中晚期渗滤液的脱氮能力,以当地垃圾填埋场的中晚期渗滤液为试验用水,考察了在不同回流比下该工艺对有机物和氮素的去除以及各功能区微生物群落的变化.结果表明:当回流比由5调至9时,COD_Cr（chemical oxygen demand）的去除率由47%逐渐升至53%,其中前置UASB（Up-flow Anaerobic Sludge Bed/Blanket,上流式厌氧污泥床反应器）去除COD_Cr的占比为41%,为后续的PN-ANAMMOX工艺提供了低碳环境.然而在回流比调至9时,由于高回流比的稀释作用使得游离氨（free ammonia,FA）的质量浓度下降〔ρ（FA） < 2 mg/L〕,导致了其无法抑制PN区NO₂--N氧化菌（nitrite oxidizing bacteria,NOB）的活性,部分亚硝化工艺的稳定性下降且NO₂--N积累率降至50%以下,对后续的ANAMMOX区脱氮性能产生不利影响,ANAMMOX区氮去除速率随之降至4.29 kg/（m3·d）.研究显示:采用具有回流的DN-PN-ANAMMOX工艺处理ρ（NH₄+-N）高达1 900 mg/L的中晚期垃圾渗滤液的最佳回流比为8,ANAMMOX区的氮去除速率达到7.41 kg/（m3·d）,出水ρ（TN）（8.83 mg/L）更低;同时,在回流比为8时,Pseudomonas、Nitrosomonas和Candidatus_Kuenenia分别在DN-PN-ANAMMOX工艺的前置UASB、PN区及ANAMMOX区得到最优的富集.      

Three-stage aged refuse biofilter for the treatment of landfill leachate

A field-scale aged refuse(AR) biofilter constructed in Shanghai Refuse Landfill,containing about 7000 m3 aged refuse inside,was evaluated for its performance in the treatment of landfill leachate. This AR biofilter can be divided into three stages and can manage 50 m3 landfill leachate per day. The physical,chemical,and biological characteristics of AR were analyzed for evaluating the AR biofilter as leachate treatment host. The results revealed that over 87.8%-96.2% of COD and 96.9%-99.4% of ammonia nitrog...     

垃圾渗滤液配水对UASB-ANAMMOX反应器进行二次启动的研究

通过温度和进水控制对UASB-ANAMMOX反应器内的ANAMMOX菌的反应活性进行充分抑制后,采用垃圾渗滤液配水来进行二次启动.结果表明,二次启动的时间相对较快,在第21 d的 NH^＋₄-N的去除率就可以达到96 .17%,NO^-_２-Ｎ的去除率达到86 .77%;由于反硝化的协同作用降低使得COD的去除率有下降的趋势,平均去除量只有60 mg/Ｌ; 反应启动过程中的平均三氮比即去除的NH^＋₄-N∶去除的NO^-_２-Ｎ∶生成的NO^-_３-Ｎ=1∶0 .75∶0 .26; 反应成功进行二次启动后的平均三氮比即去除的NH^＋₄-N∶去除的NO^-_２-Ｎ∶生成的NO^-_３-Ｎ=1∶0 .95∶0 .26,三氮比中的亚硝氮去除比率较大幅度上升.     

电化学氧化与厌氧技术联用处理垃圾渗沥水

采用电化学氧化与上流式厌氧污泥床(UASB)结合技术,提出了处理香港垃圾渗沥水的二步法工艺.对含COD和NH₃-N分别为4750mg/L和1310mg/L的垃圾渗沥水,首先进行UASB预处理(消化温度37℃,COD负荷0.78g/(L·d),HRT为6.1d),获得了66%的COD去除率;UASB的出水被引入电化学氧化反应器进行深度处理.在外加Cl 2000mg/L,电流密度为32.3mA/cm²的条件下,经6h的电解间接氧化,COD和NH₃-N的去除率分别达到87%和100%,出水的COD为209mg/L,并且不含NH3-N,此过程的COD电能消耗＜55kW·h/kg.本文讨论了电化学氧化过程中电极反应原理,各实验参数对COD和NH₃-N去除率的影响,以及电能消耗与运行成本评估等.     

微波/活性炭强化过硫酸盐氧化处理垃圾渗滤液研究

采用微波(MW)-活性炭(AC)强化过硫酸盐(PS)氧化处理垃圾渗滤液,研究不同因素对垃圾渗滤液处理的影响,比较不同组合工艺对渗滤液处理的效果及活性炭的多次使用情况.结果表明,COD和氨氮(NH4+-N)的去除率随着AC用量、PS用量(S2O82-:12COD0)、MW功率和辐射时间的增加而增大,pH值对COD的去除影响不明显, NH4+-N在碱性条件下得到更理想的去除效果;在活性炭用量为10g/L,PS用量为S2O82-:12COD0=1.2,pH=9,MW功率和辐射时间分别为500W和10min时,垃圾渗滤液中的COD和NH4+-N去除率分别为78.2%和67.2%,BOD5/COD由0.17增至0.38;不同工艺对垃圾渗滤液处理效果显示,MW-AC-PS工艺对垃圾渗滤液中COD和氨氮去除率明显高于其他处理,且MW、AC和PS之间存在协同效应,MW热效应显著;活性炭四次实验后,COD和NH4+-N的去除率分别为61.2%和46.1%.     

COD负荷对MBSBBR脱氮除磷性能的影响研究

以模拟废水为处理对象,采用一套特定的MBSBBR系统,研究了COD负荷率对COD和NH4+-N去除率的影响,验证并分析了系统的SND现象。实验结果表明:COD负荷率为2.88～4.96kg/(m3·d)时,NH4+-N的去除率在70%左右,TP去除率在85%左右。系统对有机物具有良好的去除能力,可以承受较高的有机负荷率。系统中存在SND现象,反硝化菌大量存在,反硝化过程的碳源主要来自生物膜。系统的污泥产率较低,随着COD负荷率的增大而略有提高。     

晚期渗滤液脱氮过程中的抑制现象及其消除

对于垃圾填埋过程中高氨氮浓度、低C/N的晚期渗滤液,反硝化碳源不足会造成A/O脱氮系统的亚硝酸积累,导致对氨氧化和亚硝酸氧化过程的抑制作用.A,²/O流程中的厌氧处理对难降解有机物的水解酸化作用可为后续反硝化提供易降解有机碳源,可消除亚硝酸盐的积累及其对硝化过程的抑制.试验表明,厌氧处理可使氨氧化速率和反硝化速率提高约1倍和1.3倍,分别达0.123mgN/(mgMLSSd)和0.0675mgN/(mgMLSSd),TN去除率由8%提高到15%.使浓度高达1000mg/L的氨氮,在0.138mgN/(mgMLSSd)的进水负荷下较为彻底地氧化为安全的硝酸盐.     

A/O生物脱氮工艺处理生活污水中试(二)系统性能和SND现象的研究

应用A/O中试装置处理实际生活污水,研究了低DO浓度下系统对有机物、氨氮和总氮的去除效果.研究结果表明,低DO浓度下COD和氨氮的平均去除率分别为85%和92%.由于进水C/N比仅为2.93,总氮平均去除率仅为64%,但提高亚硝酸氮积累率可以提高总氮去除率,当亚硝化率从15%增加到85%,总氮去除率将增加12%.氨氮去除率和硝化速率、总氮去除率具有较好的相关性.维持低DO浓度可以实现亚硝酸型同步硝化反硝化反应,基于氮的物料平衡可知它占系统总氮去除率的5%～12%,增加DO浓度将破坏同步硝化反硝化(SND)现象.