臭氧-活性炭工艺在炼化循环排污水处理中的应用＊

针对炼化企业循环排污水中有机污染物浓度不能满足脱盐处理工艺进水水质要求的问题,开展了臭氧氧化-活性炭吸附工艺去除循环排污水中有机污染物的研究。通过对两种处理工艺进行不同组合的实验结果得知:当反应时间控制在最佳值,臭氧氧化和活性炭吸附单独处理循环排污水时,COD去除率分别约为27%和20%,处理效率偏低;当两种工艺组合后,在臭氧浓度为12 mg/L、氧化时间20 min、吸附时间为10 min时,COD去除率则达到52%,组合工艺协同作用效果明显。     

DOMESTIC WASTEWATER TREATMENT BY PEATLANDS IN A NORTHERN CLIMATE: A WATER QUALITY STUDY1

ABSTRACT: The use of peatlands as the main form of wastewater treatment in a northern climate was studied for the James Bay Energy Society. The Fontanges campsite (70° 17′ 30″ W; 54° 34′ 00″ N) was chosen as the study site. In less than 1.5 km from the point of discharge BOD₅, COD, total hardness, inorganic carbon, orthophosphates, total phosphorus, ammonia and total nitrogen were reduced by at least 90 percent. The peatland treatment system studied is divided into four components, each having a specific function. The first part combines the action of microorganisms and adsorption on peat, thus reducing the organic content while increasing the inorganic constituents. The second part uses peat to adsorb the inorganic elements already present in the wastewater and those produced in the first part of the system. The third component acts as an aerator, increasing the dissolved oxygen and decreasing the BOD₅ levels of the water. The fourth part removes most of the remaining nutrients, thus acting like a tertiary treatment. Overall, peatlands seemed to be effective in treating domestic settled wastewater in a cold climate.     

EMMC process for combined removal of organics, nitrogen and an odor producing substance

In order to improve the process performance regarding the removal of organics, nitrogen, and an odor-causing compound (sulfide) contained in domestic wastewater, an entrapped-mixed-microbial cell (EMMC) with and without humic substances for both fixed and moving carrier reactors and conventional suspended growth culture (i.e. conventional activated sludge process) were investigated simultaneously. Both synthetic (simulated to the organics concentration of general domestic sewage) and actual domestic wastewater were investigated under operational conditions of 12 h of hydraulic retention time (HRT) with 1 h of aeration and 1 h of non-aeration, and 6 h of HRT with continuous aeration, at a room temperature of 25 +/- 2 degrees C. It was found that entrapping humic substances in the EMMC carriers had no impact on the removal of organics, nitrogen, and the odor-producing compound. Additionally, the performance of the EMMC moving carrier system for the removal of these pollutants is similar to that of the EMMC fixed carrier system. In general, the EMMC associated systems which provide high solids retention time achieve a better removal of chemical oxygen demand (COD), nitrogen, and the odor-producing substance than the suspended growth system for both HRTs of 6 h (continuous aeration) and 12 h (1 h of aeration and 1 h of non-aeration). Both the fixed and moving carrier EMMC processes, therefore, have the potential for improvement or replacement of the existing conventional activated sludge process with regard to improving the effluent qualities (such as COD, nitrogen and odor-producing compound) for reuse/disposal.     

GOALS IN WASTEWATER TREATMENT1

Within a few years all domestic wastewater effluents in the United States will be subjected to a minimum of a properly operated primary and secondary treatment process. This implies a very high degree of removal of the more readily biologically degradable material as measured by the BOD test. This practice will to a large degree negate the value of the BOD test as a pollution parameter. Organic carbon appears to be a more suitable means for determining the strength of a wastewater or for controlling the operation of physical and chemical treatment processes. Studies were conducted to determine the effect of time of passage on the ratio of organic carbon to BOD, COD and carbohydrate. The ratio was found to vary with both time and the state of the sample. The carbon content was reduced to a lesser degree than the other parameters. Organic carbon content appears to correlate better with COD than with BOD. The efficiency of a chemical precipitation process can be determined on the basis of organic carbon removal.     

制药废水生化处理后的深度处理方法比较研究

随着制药废水排放标准的提高,对制药废水进行深度处理是实现其达标排放的有效途径之一。试验比较了絮凝、高级氧化、吸附、超滤等方法对生化处理后的高浓度制药废水深度处理效果,结果表明:4种方法中,只有活性炭吸附对废水COD、浊度、色度、氨氮等都具有较好的去除效果,COD去除率最高能达到62%,可实现达标排放。     

Development of a novel fungal consortium for the treatment of molasses distillery wastewater

In India, cane molasses–based distilleries are major production centers of ethanol. These industries release a dark brown colored effluent known as spent wash, which even after anaerobic treatment retains the color. The commonly used practices of treatment fail to remove the color and COD. A novel fungal consortium was developed for the treatment of this recalcitrant wastewater. The consortium was run on a bioreactor with undiluted distillery effluent for 40 days. In the first 14 days, 61.5% color and 65.4% COD removal was achieved. Further, the fungi were able to use wheat straw as carbon source as evidenced by scanning electron microscopy (SEM) while treating the distillery wastewater. It is expected that such a treatment step will lead to development of a treatment technology for distillery wastewater without the need for diluting it.     

Combined chemical and biological oxidation of penicillin formulation effluent

Antibiotic formulation effluent is well known for its important contribution to environmental pollution due to its fluctuating and recalcitrant nature. In the present study, the chemical treatability of penicillin formulation effluent (average filtered COD(o)=830 mg/l; average soluble COD(o)=615 mg/l; pH(o)=6.9) bearing the active substances penicillin Amoxicillin Trihydrate (C(16)H(19)N(3)O(5)S.3H(2)O) and the beta-lactamase inhibitor Potassium Clavulanate (C(8)H(8)KNO(5)) has been investigated. For this purpose, the penicillin formulation effluent was subjected to ozonation (applied ozone dose=2500 mg/(lxh)) at varying pH (2.5-12.0) and O(3)+H(2)O(2) (perozonation) at different initial H(2)O(2) concentrations (=2-40 mM) and pH 10.5. According to the experimental results, the overall Chemical Oxygen Demand (COD) removal efficiency varied between 10 and 56% for ozonation and 30% (no H(2)O(2)) and 83% (20 mM H(2)O(2)) for the O(3)+H(2)O(2) process. The addition of H(2)O(2) improved the COD removal rates considerably even at the lowest studied H(2)O(2) concentration. An optimum H(2)O(2) concentration of 20 mM existed at which the highest COD removal efficiency and abatement kinetics were obtained. The ozone absorption rate ranged between 53% (ozonation) and 68% (perozonation). An ozone input of 800 mg/l in 20 min was sufficient to achieve the highest BOD(5)/COD (biodegradability) ratio (=0.45) and BOD(5) value (109 mg/l) for the pre-treated penicillin formulation effluent. After the establishment of optimum ozonation and perozonation conditions, mixtures of synthetic domestic wastewater+raw, ozonated and perozonated penicillin formulation effluent were subjected to biological activated sludge treatment at a food-to-microorganisms (F/M) ratio of 0.23 mg COD/(mg MLSSxd), using a consortium of acclimated microorganisms. COD removal efficiencies of the activated sludge process were 71, 81 and 72% for pharmaceutical wastewater containing synthetic domestic wastewater mixed with either raw, ozonated or perozonated formulation effluent, respectively. The ultimate COD value obtained after 24-h biotreatment of the synthetic domestic wastewater+pre-ozonated formulation effluent mixture was around 100 mg/l instead of 180 mg/l which was the final COD obtained for the wastewater mixture containing raw formulation effluent, indicating that pre-ozonation at least partially removed the non-biodegradable COD fraction of the formulation effluent.     

氧化法预处理垃圾渗滤液技术研究及应用

由于垃圾渗滤液含有多种有毒有害的难降解的有机物,影响了生物处理效果。采用Fenton氧化法、湿式催化氧化法和电解氧化法预处理,可减少渗滤液的污染负荷,提高可生化性,在实际应用中取得良好的效果。     

一种高效复合絮凝剂对多种废水的处理效果

用聚合氯化铝（PAC）和聚丙烯酰胺（PAM）复配成复合絮凝剂（PAC＋PAM）应用于污染河水、生活污水、工业废水和餐饮废水等6种废水的处理，结果表明。PAC、PAM、PAC＋PAM对污染河水的CODc。SS、浊度有显著降低作用，PAC＋PAM的净水效果明显优于PAC和PAM；PAC＋PAM对6种废水中COD的去除率为81．5％～90．4％，平均84．6％。对SS的去除率为81．9％～96．5％，平均88．9％，对浊度的去除率为91．3％-98．0％，平均95．1％；处理后悬浮物基本被絮凝沉降，水体变得较清澈透明，异味或臭味消除。说明本PAC＋PAM复合絮凝剂对各种废水均有良好的净水效果，具有重要的应用价值。     

涤沦仿真丝污水治理的研究

经实验比较了涤沦仿真丝污水治理中常见的两种工艺即“厌氧酸化＋好氧酸化”和“加酸沉淀＋好氧生化”的处理效果,提出了后一种工艺才能真正治理污染的观点。加酸沉淀可去除CODcr77％左右,同时大大提高了污水的可生化性。     

Ultrasound and enzyme assisted biodegradation of distillery wastewater

Irradiation with ultrasound (US) and use of an enzyme (E) as pretreatment techniques were carried out to treat a complex effluent (distillery wastewater). These two techniques have been used alone as well as in combination and the efficacy of these techniques was tested by subjecting the effluent to subsequent aerobic biological oxidation (AO). When used alone, US exposure for 30 min and 2 h yielded the best COD reduction during the aerobic oxidation step (US+AO). For the enzyme when used alone, a pH value of 4.8 (corresponding to the optimum pH of the enzyme), a dose of 50 U and a pretreatment time of 24 h yielded better COD removal efficiency as compared to untreated effluent (aerobic oxidation alone). When used in combination, ultrasound followed by enzymatic pretreatment (US+E+AO) yielded the best COD removal efficiencies during aerobic oxidation as compared to the other combinations tested for the treatment of the distillery wastewater. A 4-fold increase in the initial oxidation rate was observed over the untreated batch for the integrated technique (US+E+AO). On the basis of the variation in the values of the biokinetic parameters it can be concluded that the type of pretreatment scheme affects the subsequent rate of the aerobic oxidation significantly.     

内循环三相生物流化床处理生活污水的试验研究

对内循环三相生物流化床处理生活污水进行了试验研究,探讨了生物膜的形成和水力停留时间及曝气量对处理效果的影响。结果表明：在HRT为6h,曝气量为0.6m3/h,进水COD和NH4＋-N分别为240.2~298.7mg/L和29.1~68.9mg/L条件下,平均COD去除率为83%,NH4＋-N去除率为95.1%。     

陶粒-沸石-活性炭组合填料生物滤池的研究

采用陶粒、沸石、活性炭填料合理组合作为曝气生物滤池的填料对高校生活污水进行处理。研究了组合填料生物滤池生物膜的培养,不同水力负荷、容积负荷和气水比对污水处理效率的影响,以及该生物滤池对生活污水的处理效果。结果表明,采用组合填料生物滤池,接种挂膜培养周期为25d,在水力负荷为2．5m3／（m2·h）,气水比3．5：1,组合填料生物滤池出水COD、BOD5、SS、NH3-N和色度平均值达到《城市污水再生利用城市杂用水水质》GB／T18920—2002水质要求。     

WATER RECLAMATION BY PHYSICOCHEMICAL TREATMENT OF WASTEWATER1

ABSTRACT. Treatment of a high strength acidic industrial chemical waste, which had a COD of about 3000 mg/1 and a pH of 3, was attempted by activated carbon adsorption to evaluate the feasibility of yielding effluents of reusable qualities. The experimental methods which were employed in this investigation included batch and column studies. The former was used to evaluate the rate and equilibrium of carbon adsorption while the latter was used to determine treatment efficiencies and performance characteristics. Parallel operations of fixed-bed and expanded-bed adsorbers were contrasted in the column study. Results of this investication indicate that activated carbon was very efficient in removing the COD of the chemical waste. Initial pH adjustments for the wastewater to 7.0 or 11.4 did not increase the COD removal efficiency. Turbidity and nitrogen (total Kjeldahl- and ammonia-N) were removed to some extents by the carbon bed adsorbers while phosphorus (total-and ortho-P) was totally unaffected by the carbon treatment.     

含多聚甲醛类化合物高浓度COD废水处理方法研究

目标废水来自郴州某制药厂,具有COD高、可生化处理能力差的特点。本实验针对废水特点,提出了Fenton氧化、次氯酸钠氧化等高级氧化为主,活性炭吸附为辅的处理方案,同时探讨了加热回流时间、pH、Fe2＋投加量、H2O2投加量、次氯酸钠投加量分别对COD降解率的影响,得出最佳处理条件。     

IABR-IBAF工艺处理猪场稳定塘废水的实验研究

难降解有机物含量高且碳氮比失调是造成养猪场稳定塘废水难于处理的主要原因。本文采用基于固定化微生物技术的厌氧折流板（IABR）与曝气生物滤池（IBAF）组合工艺处理稳定塘废水,对比了IABR-IABF组合工艺与单一IBAF工艺的处理效果,研究了碱度和碳源对硝化反硝化过程的影响。组合工艺平均进水COD1532．6mg／L,平均出水为332．7mg／L,去除率为78％,NH3-N平均进水538．6mg／L,平均出水为12．3mg／L,去除率97．7％。以新鲜废水做反硝化阶段的碳源时TN去除率93％,可有效解决脱氮过程中的碳源成本问题。     

Treatment of domestic wastewater using an anaerobic baffled reactor followed by a duckweed pond for agricultural purposes

The treatment and reuse of domestic wastewater using an anaerobic baffled reactor (ABR) followed by a duckweed pond (DWP) were the main theme of the present study. The ABR was fed continuously with domestic wastewater at four HRTs ranging from 8 to 24 h and corresponds to organic loading rates ranging from 0.67 to 2.1 kg COD/m³/day. The ABR effluent was fed to a DWP operating at 10 and 15 days. The performance of the ABR at the four HRTs gave satisfactory results. Chemical oxygen demand (COD) removal was between 68 and 82%. Fecal coliform removal was between 1 to 2 logs. The 12- and 18-h hydraulic retention times (HRTs) gave close results, as indication of the possible selection of the 12-h HRT as the optimum operation for the ABR based on economic advantage. The ABR compartmentalized structure gave results higher than those produced by the one-stage digester and similar to those produced by the two-phase anaerobic digestion process. Duckweed ponds as post-treatment operated at 10 days and 15 days gave the best results at 15-day HRT, where it was possible to remove 73.4% of nitrogen and 65% of phosphorus and produce protein-rich dry duckweed of 105 kg/ha/day on average. The removal of fecal coliform (FC) in duckweed ponds was 3–4 logs. The final treated domestic sewage characteristics proved its compliance with the Egyptian standards for reuse in restricted irrigation.     

Nitrogen and phosphorus removal from domestic strength synthetic wastewater using an alternating pumped flow sequencing batch biofilm reactor

Nutrient removal from domestic strength synthetic wastewater by an alternating pumped flow sequencing batch biofilm reactor (APFSBBR) was investigated in this laboratory study. The APFSBBR comprised two reactor tanks (Reactors 1 and 2) with two identical biofilm modules of vertical tubular plastic media with a high specific surface area, one in each tank. The APFSBBR was operated in cycles of four phases: fill, anaerobic, aerobic, and draw. During the fill phase, Reactor 1 was half-filled with domestic strength synthetic wastewater. During the subsequent anaerobic phase, most of the phosphorus release took place from the submerged biofilm in this reactor. In the aerobic phase, the wastewater was circulated by pumps between Reactors 1 and 2, resulting in denitrification at the start of the aerobic phase due to low oxygen concentrations, followed by nitrification and luxury uptake of phosphorus when oxygen concentrations increased. During the draw phase, Reactor 2 was half-emptied of the treated water. At the chemical oxygen demand (COD), total nitrogen (TN), and total phosphorus (TP) loading rates on the total biofilm area of 3.20 g COD, 0.33 g TN, and 0.06 g TP m(-2) d(-1), the removal efficiencies were 97, 85, and 92% for COD, TN, and TP, respectively.     

农村生活污水土地处理技术

本文陈述了我国农村生活污水的特点和污水土地处理技术的研究及应用现状,认为污水土屯处理技术处理农村生活污水是可行的,对BOD,COD,氨氮,总氮和总磷有着较高的去除率,并且投资省、运行费用低、管理简单、维护方便、出水可回用,有净化污水、美化绿化环境和节约水资源的综合效果。     

Removal of organic pollutants and nutrients from olive mill wastewater by a sand filter

The aim of this work was to examine the performance of a sand filter in treating modern olive mill (OMW) effluents after dilution with domestic wastewater on a one-to-one basis. The experimental pilot consisted of a column of opaque PVC, and the sand filter was filled with 50 cm of sand and 10 cm of gravel in the top and the bottom of the filter. The alimentation (4 cm/day) was done sequentially following a 1 day wet/3 days dry cycle. The OMW effluent was very acidic with a pH of 4.12, and had high concentrations of phenolic compounds (7.2 g/L) and total chemical oxygen demand (65 g/L). The percolation of the diluted OMW through the sand filters caused an increase in pH from 4.84 to 8.25 and a 90% removal of total suspended solids. The sand filter treatment also led to important reductions in organic matter (90% of total COD, 83% of dissolved COD and 92% of phenolic compounds) and nutrients (91% of Kjeldahl-nitrogen, 97% of ammonia-nitrogen, 99% of nitrate-nitrogen and 99% of phosphates). The flow rate became very low indicating clogging of the sand pores after 10 weeks. HPLC analysis of the diluted OMW before and after passage through the sand filter showed an important reduction in the toxic monomeric compounds after the treatment.