烧结砖生产中氟的逸出及钙基废渣固氟特性研究

砖坯烧制过程中，氟逸出的初始温度约为600℃，大部分氟在约800℃至砖坯发生明显烧结的温度内逸出，以CaO含量高的粘土原料制砖，氟逸出量相对较少。在此基础上，提出在制砖原料中添加适量钙基废渣抑制氟的逸出，并进行了详细的实验室和工业性试验；结果表明，在适宜添加量下，存氟率由约25％增至70％以下，且不影响砖制品质量。     

一种新型的电石炉炉气干法净化系统

介绍一种我国自行研制的电石炉炉气干法净化系统，由于采用了热管技术和流化床燃烧技术，使工艺流程简化，投资省，运行稳定，操作简单，安全可靠，完全避免了二次污染。运行试验表明，该系统的主要技术指标均达到或超过国外同类装置的水平。     

电石渣在煤泥水混凝中的作用机理研究

电石渣在煤泥水混凝中的作用机理 :电石渣对煤泥水混凝作用不是补给了 OH- ,而是提供了大量的 Ca2 + 。Ca2 +通过压缩双电层 ,破坏了煤泥颗粒的稳定性 ,从而使煤泥颗粒发生凝聚。OH-和 Ca( OH) 2 对煤泥水的混凝不直接起作用。     

Effect of biocides on the precipitation of calcium fluoride in the presence of anionic copolymeric inhibitors

The inhibitory efficiency of anionic copolymers and the effect of the biocides sodium hypochlorite, glutaraldehyde, and tris(hydroxymethyl)nitromethane on the precipitation behavior of calcium fluoride (CaF₂) were studied. The efficiency of polymeric inhibitors was traced from conductivity measurements by using half-life (t_1/2) method. X-ray diffraction parameters have been measured for calcium fluoride scale minerals. An anionic copolymer (K-798) acts as one of the best inhibitors for the precipitation process of the calcium fluoride in water as compared to K-775. It is assigned to the fact that the copolymer (K-798) contains both sulfonic acid and sulfonated styrene groups while the polymer (K-775) having only the sulfonic acid group. It was further observed that the biocides have no appreciable effect on the performance of the anionic polymeric inhibitors.     

固定化解脂耶氏酵母处理油脂废水研究

利用海藻酸钙包埋固定的解脂耶氏酵母(Yarrowia lipolytica)分别降解以色拉油为惟一碳源和以葡萄糖为惟一碳源的污水,结果表明,在最佳处理条件下,固定化细胞在50 h内,能较好地降解废水中浓度为2 000 mg/L的色拉油和浓度为2 000 mg/L 的COD,降解率都在80%以上;固定化细胞对色拉油、COD降解效率随着时间的延长而增加、随着底物浓度的增加而下降;与未固定菌株相比,固定化细胞有着更好的储存稳定性和可重复使用性,结果进一步提示固定化解脂耶氏酵母适于含油废水以及高COD含量的生活污水处理。     

Effects of solution conditions on the precipitation of phosphate for recovery. A thermodynamic evaluation

To understand the effects of solution conditions on the precipitation of calcium phosphates from wastewater for recovery, a computer programme PHREEQC was employed to calculate the speciation and saturation-index (SI) with respect to hydroxyapatite of a chemically defined precipitation system, which contains phosphate of 1–200 mg P/l, with Ca/P molar ratios of one to 10 times of the stoichiometric calcium to phosphorus molar ratio of hydroxyapatite, at a pH range of 7.0–11.0. The results show that the SI is respectively the logarithmic function of the phosphate concentration and the calcium concentration, increasing with the increase of either of them; the SI is a polynomial function of the solution pH value and increases with its increase, and the effect of solution pH value is due to its influence on base uptake of the precipitation reaction and the speciation of phosphate and calcium ions; the SI is also a logarithmic function of the solution ionic strength but decreases with its increase; at the temperature range of 5–30 °C the SI increases linearly with solution temperature and the effect of temperature is also due to its influence on the speciation of phosphate and calcium ions.     

Accelerated seeded precipitation pre-treatment of municipal wastewater to reduce scaling

Membrane based treatment processes are very effective in removing salt from wastewater, but are hindered by calcium scale deposit formation. This study investigates the feasibility of removing calcium from treated sewage wastewater using accelerated seeded precipitation. The rate of calcium removal was measured during bench scale batch mode seeded precipitation experiments at pH 9.5 using various quantities of calcium carbonate as seed material. The results indicate that accelerated seeded precipitation may be a feasible option for the decrease of calcium in reverse osmosis concentrate streams during the desalination of treated sewage wastewater for irrigation purposes, promising decreased incidence of scaling and the option to control the sodium adsorption ratio and nutritional properties of the desalted water. It was found that accelerated seeded precipitation of calcium from treated sewage wastewater was largely ineffective if carried out without pre-treatment of the wastewater. Evidence was presented that suggests that phosphate may be a major interfering substance for the seeded precipitation of calcium from this type of wastewater. A pH adjustment to 9.5 followed by a 1-h equilibration period was found to be an effective pre-treatment for the removal of interferences. Calcium carbonate seed addition at 10 g l⁻¹ to wastewater that had been pre-treated in this way was found to result in calcium precipitation from supersaturated level at 60 mg l⁻¹ to saturated level at 5 mg l⁻¹. Approximately 90% reduction of the calcium level occurred 5 min after seed addition. A further 10% reduction was achieved 30 min after seed addition.     

Microbial response to CaCO3 application in an acid soil in southern China

Calcium carbonate (CaCO₃) application is widely used to ameliorate soil acidification. To counteract soil and bacterial community response to CaCO₃ application in an acidic paddy soil in southern China, a field experiment was conducted with four different dosages of CaCO₃ addition, 0, 2.25, 4.5 and 7.5?tons/ha, respectively. After one seasonal growth of rice, soil physicochemical properties, soil respiration and bacterial communities were investigated. Results showed that soil pH increased accordingly with increasing dose of CaCO₃ addition, and 7.5?tons/ha addition increased soil pH to neutral condition. Moderate dose of CaCO₃ application (4.5?tons/ha) significantly increased soil dissolved organic carbon (DOC) and dissolved organic nitrogen (DON) content, enhanced soil respiration, while the excessive CaCO₃ application (7.5?tons/ha) decreased these soil properties. High-throughput sequencing results illustrated that moderate dose of CaCO₃ application increased the richness and alpha diversity of soil bacterial community. Compared with control, the relative abundance of Anaerolineaceae family belonging to Chloroflexi phylum increased by 38.7%, 35.4% and 24.5% under 2.25, 4.5 and 7.5?tons/ha treatments, respectively. Redundancy analysis (RDA) showed that soil pH was the most important factor shaping soil bacterial community. The results of this study suggest that proper dose of CaCO₃ additions to acid paddy soil in southern China could have positive effects on soil properties and bacterial community.     

改良型固定化Pseudomonas oleovorans DT4降解四氢呋喃的研究

成功构建出了新型的海藻酸钠-活性炭纤维复合固定化Pseudomonas oleovorans DT4来去除四氢呋喃,并优化了该复合固定化载体组分的含量,发现在海藻酸钠含量为3%,活性炭纤维含量为1.5%条件下,制备成细胞浓度为6×109g-1的协同固定化细胞在初始THF浓度为360 mg·L-1时的降解速率达到最大为24.0 mg·(L.h)-1,同时其机械强度也得到了显著的提升.此外与游离菌体相比,该固定化细胞在不同温度和pH条件下的降解速率表现得更加稳定,且去除效果均能稳定在80%以上.在改进的反应体系中,协同固定化小球高效降解THF的重复利用次数达到80批以上,显示出该载体良好的可行性.     

Removal of copper ions from aqueous solution by calcium alginate immobilized kaolin

Kaolin has been widely used as an adsorbent to remove heavy metal ions from aqueous solutions. However, the lower heavy metal adsorption capacity of kaolin limits its practical application. A novel environmental friendly material, calcium alginate immobilized kaolin (kaolin/CA), was prepared using a sol-gel method. The e ects of contact time, pH, adsorbent dose, and temperature on Cu2+ adsorption by kaolin/CA were investigated. The Langmuir isotherm was used to describe the experimental adsorption, the maximum Cu2+ adsorption capacity of the kaolin/CA reached up to 53.63 mg/g. The thermodynamic studies showed that the adsorption reaction was a spontaneous and endothermic process.