蜡染印花工艺废水处理设计及运行

设计运行了整个蜡染印花废水处理工程,皂化脱蜡废水松香回收新工艺,即采用两步调pH法-周边自重力进水法,回收率可达98%以上;机械洗蜡废水分流后经双级气浮处理,蜡回收率和处理水回用率可达90%以上;洗蜡废水经蜡回收后出水与其他废水混合后经初级混凝沉淀-水解酸化-好氧生化(A/O工艺)-辐流沉淀组合工艺处理,出水ρ(COD)均值约为130 mg/L,ρ(NH3-N)为3.36 mg/L,然后进入市政管网进行深度处理。     

Preparation and assay of C-glucosyltransferase from roots of Pueraria lobata

C-glucosyltransferase (EC 2.4.1.X) is one of the key enzymes for the biosynthesis of puerarin. This paper describes the methodology in purification and assay of the enzyme for the first time in Puerarin lobata (Wild.) Ohwi. C-glucosyltransferase from roots of P. lobata was extracted and partially purified by (NH4)2SO4 saturation. The effects of pH, temperature, and substrate concentration on the activity of the enzyme were investigated. The properties of the puerarin produced by C-glucosyltransferase were studied by thin layer chromatography (TLC) and high performance liquid chromatography (HPLC). The peak activity of C-glucosyltransferase was detected in fraction of by 80% saturation of (NH4)2SO4 and the optimal conditions for enzymatic reaction were 35.5 micromol l(-1) of isoliquiritigenin and 560 micromol l(-1) of UDP-G at pH 8.1, 28 degrees C for 1 h. Mn2+ at 1 mmol l(-1) and Al3+ at 1 mmol l(-1) increased the enzyme activity, while Mg2+ inhibited its activity. The enzyme activity in Nicotiana tabacum and P. lobata were detected under the above assay conditions. Higher activity was found in roots than in leaves and stems of P. lobata, while no enzyme activity was detected in leaves of N. tabacum. It was the first time that activity of C-glucosyltransferase, which transforms isoliquiritigenin to puerarin, was detected in P. lobata.     

预处理-气浮-氧化沟工艺处理再生纸废水

介绍了预处理-气浮-氧化沟工艺在再生纸废水处理工程中的应用。运行结果表明:该工艺处理效果稳定,耐冲击负荷能力强,进水ρ(COD)、ρ(BOD5)、ρ(SS)分别为1542,654,2254mg/L时,出水分别为77,38,22mg/L,系统出水水质达GB3544-2001《造纸工业水污染物排放标准》。     

烟气脱硫设施运行及脱硫电价实时监控系统设计

由于缺乏有效监管手段,目前脱硫设施实际投运情况不理想。设计了一套B/S架构的烟气脱硫设施运行及脱硫电价实时监控系统,分为数据采集、数据通讯、数据处理及发布3个子系统。选择能全面反映脱硫设施运行状况的28个信号,采用"共享-分流"信号防伪采集技术进行采集,通过电力系统内载波电话拨号与无线GPRS两种通讯方式相互竞争、互为备用来实现可靠通讯,并经过软件防伪判别模块和统计运算后以WEB形式发布。数据以5m in的间隔实时刷新,且每小时更新脱硫投入率、脱硫电价款等报表数据。     

宜兴市清源污水处理厂升级改造工艺设计

宜兴市清源污水处理厂升级改造工程设计规模5×104m3/d,采用强化生物脱氮、机械微过滤(盘片过滤)工艺,利用现有池容进行内部改造,同时增加深度处理设施,提高出水标准,改造后出水ρ(COD)、ρ(BOD5)、ρ(SS)、ρ(NH3-N)、ρ(TN)和ρ(TP)平均值分别为34,6,5,1.3,10.3和0.36mg/L,各项水质指标均达GB18918-2002《城镇污水处理厂污染物排放标准》一级A标准。     

Bioreduction of nitrate in groundwater using a pilot-scale hydrogen-based membrane biofilm reactor

A long-term pilot-scale H₂-based membrane biofilm reactor (MBfR) was tested for removal of nitrate from actual groundwater. A key feature of this second-generation pilot MBfR is that it employed lower cost polyester hollow fibers and still achieved high loading rate. The steady-state maximum nitrate surface loading at which the effluent nitrate and nitrite concentrations were below the Maximum Contaminant Level (MCL) was at least 5.9 g·N·(m²·d)^?1, which corresponds to a maximum volumetric loading of at least 7.7 kg·N·(m³·d) ^?1. The steady-state maximum nitrate surface area loading was higher than the highest nitrate surface loading reported in the first-generation MBfRs using composite fibers (2.6 g·N·(m²·d)^?1). This work also evaluated the H₂-utilization efficiency in MBfR. The measured H₂ supply rate was only slightly higher than the stoichiometric H₂-utilization rate. Thus, H₂ utilization was controlled by diffusion and was close to 100% efficiency, as long as biofilm accumulated on the polyester-fiber surface and the fibers had no leaks.     

油气钻井作业对地下水污染治理研究＊

分析了钻井作业对地下水污染的特点、污染途径,针对性地提出了钻井作业对地下水污染的预防措施,以及污染物处理技术,其中氧化还原技术、气体抽取技术、环境生物技术主要用于有机物污染治理,SRB技术、废弃钻井液固化技术、钻井液转换为水泥浆(MTC)的固井技术可用于处理废弃钻井液。钻井引起的污染治理应以"预防为主,防治结合",切实推行清洁生产和HSE管理。     

Enhanced NOx removal from flue gas by an integrated process of chemical absorption coupled with two-stage biological reduction using immobilized microorganisms

An integrated process of metal chelate absorption coupled with two stage bio-reduction using immobilized cultures has been proposed to continuously removal of NO_x, and the effects of SO₂, NO and O₂ concentration, gas/liquid flow rate on NO_x removal efficiency were investigated. Although nitrogen-containing components, such as Fe(II)EDTA-NO, NO₂^? and NO₃^? in the scrubbing solution, inhibited the bio-reduction of Fe(III)EDTA obviously, it was feasible to abate the inhibition effect by using the two stage bio-reduction system, and thus to improve NO_x removal efficiency. The removal efficiency decreased slowly with the increase of SO₂, O₂, NO concentration and gas flow rate, and increased with the increase of liquid flow rate. Continuously operating for 18 days, a high removal efficiency around 95% was reached by using the two-stage bio-reduction system with immobilized microorganisms, while the value decreased to 85% after 5 days of operation by using the suspended microorganisms, at a constant gas flow rate of 60 L/h containing 424–450 mg/m³ NO, 2428–2532 mg/m³ SO₂ and 3% O₂.     

典型进口废物循环利用技术园区投资建设模式研究

随着社会经济的快速发展、资源及原材料需求量的不断增加,以进口废物为原料进行加工利用的循环经济园区也随之蓬勃发展。循环经济产业园区建设过程中有投资巨大、资本回收周期长、投资主体众多的特点。在考虑经济效益的同时,也要统筹考虑社会效益和环境效益,因此选择何种投资建设模式来指导园区建设具有十分重大的意义。本文通过对国内三省的四个园区投资建设模式的调查研究,分析对比了不同投资建设模式的典型特征,总结概括了不同模式之间的优缺点,为同类园区的开发建设提供了有益参考。     

解读《温室气体自愿减排交易管理暂行办法》

本文对发改委颁布的（《温室气体自愿减排交易管理暂行办法》进行了解读、分析其特点并指出尚需进一步解决的问题。