基于CYCBD和麻雀搜索算法的滚动轴承故障特征提取方法

目的解决在较强的噪声环境下最大二阶循环平稳盲解卷积(MaximumSecond OrderCyclostationary Blind Deconvolution,CYCBD)算法在滚动轴承故障特征提取时效果欠佳的问题,为滚转尾翼导弹的尾翼滚动轴承故障诊断提供方法参考。方法提出一种利用麻雀搜索算法(SparrowSearchAlgorithm,SSA)优化CYCBD算法的方法,将CYCBD算法解卷积的包络谱熵作为SSA寻优的适应度函数,利用SSA高效地寻找出合适的循环频率以及滤波器长度,选择自适应参数后,再使用CYCBD算法有效解卷得到周期脉冲特征。结果同时对比SSA优化CYCBD前后进行故障特征提取的包络谱图,CYCBD的噪声幅值不超过0.13 m/s^(2),峰值不超过0.29 m/s^(2),用SSA优化CYCBD的噪声幅值不超过0.08 m/s^(2),峰值不超过0.32 m/s^(2),故障频率成分更加突显,无论是噪声幅度,还是峰值幅度特性,均较CYCBD有了较大改善。结论仿真实验验证了SSA优化CYCBD方法能够更加清晰地辨识到故障特征频率及其倍频成分,其具有良好的工程应用前景。     

低铬油套管钢材在不同工况下的腐蚀规律研究

目的 研究低铬油套管钢材在不同腐蚀环境中的腐蚀特征。方法 采用高温高压动态反应釜对1Cr、3Cr这2种常用低铬油套管钢材进行纯CO2、CO2和低浓度H2S共存条件下的腐蚀试验。结果 温度在40~80 ℃条件下,各种钢材的腐蚀速率随着温度的升高而变大。加入低浓度H2S后,可以抑制CO2腐蚀,且随着温度升高,抑制性逐渐减弱。分析认为,在单独CO2环境以及CO2和低浓度H2S共存的环境中,1Cr、3Cr钢表面出现铬富集现象,形成的Cr(OH)3膜保护基底。同时,在CO2和低浓度H2S共存的环境中,1Cr、3Cr钢表面形成致密的FeS产物膜有助于保护基底,抵抗Cl^－侵蚀。结论 低Cr钢表面因铬的富集形成钝化膜,能有效抑制油套管的腐蚀速率,以上研究成果对CO2和低浓度H2S环境中的腐蚀理论以及油田油套管材料合理选择均有一定指导意义。     

WTO规则对西部开发的影响、风险及机遇浅析

随着中国加入WTO和西部大开发战略的实施 ,依法治国无疑是改善投资环境、促进西部开发的最有效手段之一。本文根据WTO基本原则与法制经济的相互关系和影响深入浅出地论述了WTO对西部开发的影响、风险及机遇 ,并提出了针对性的策略     

外绝缘用液体硅橡胶的自然老化因素研究

近年来,液体硅橡胶(Liquid Silicone Rubber,LSR)已经在外绝缘领域得到了较为广泛的应用,但是目前对其耐老化性能的研究还不够深入。尤其是在中国南方地区使用时,高温、高湿环境更容易导致液体硅橡胶的老化。在许多地区都观察到了电流、电压互感器的液体硅橡胶绝缘外套的龟裂、老化现象,对设备的安全运行产生了影响。本文设计并实施了在光照、高温、高湿、电晕等老化因素作用下的液体硅橡胶人工老化试验,并对老化试验后的样品进行了硬度、力学性能、憎水性、光泽度以及SEM、FTIR等微观性能试验和分析。认为在光照作用下,高温、高湿环境对液体硅橡胶具有加速老化作用,表现为硬度上升、憎水性下降、光泽度下降,并且在表面出现细微裂纹。     

盐生植物种子萌发的特点及其生理基础

用NaCl和等渗PEG处理8种盐生植物和2种非盐生植物种子。结果表明：NaCl和等渗PEG对所有种子的萌发率都产生抑制作用，而且PEG（对盐生植物）的抑制程度大于等渗NaCl，NaCl对盐生植物萌发的抑制水平随处理时间延长而降低，但对非盐生植物种子萌发率的抑制程度增大到8d以后即不再增大。另外，在0．6MPaNaCl下，随处理时间延长，盐地碱蓬和琐琐种子的α－淀粉酶活性不断提高，SOD活性基本不变，但小麦和大麦种子的α－淀粉酶活性在处理8d后接近最大值，SOD活性显著下降，这些结果说明，影响盐生植物种子萌发率的因素与渗透胁迫，种子内部一些关键酶的活性及萌发过程中大量吸收和积累盐离子等都有关系。图6参19     

垂直流人工湿地水力学特性研究

通过示踪剂实验从停留时间分布（RTD）曲线及其统计特征值等方面对垂直流人工湿地的水力学特性进行了定性和定量的分析。研究表明水流在垂直流人工湿地中的流动是一种非理想的不均匀流动，存在一定的死区和水流的扩散；垂直流人工湿地较大的死区率与其表面布水的不均匀性有关，这也可能是其死区率大于表流人工湿地的最主要的原因。实验还表明，进水流量对垂直流人工湿地停留时间分布影响较大，随着进水流量的增加，平均停留时间减小，但标准平均停留时间增大，死区率减小；当进水流量为15L／h（水力负荷为620mm／d）时，水流在湿地中的散度最大，水流更接近全混流，不利于污染物的降解。     

Diversity of Soil Nematodes in Areas Polluted with Heavy Metals and Polycyclic Aromatic Hydrocarbons (PAHs) in Lanzhou,China

This study investigated the soil nematode community structure along the Yellow River in the Lanzhou area of China, and analyzed the impact of heavy metals (Cd, Pb, Cr, Cu, and Zn) and polycyclic aromatic hydrocarbons (PAHs) on the nematode community. Soil samples from five locations (named A–E), which were chosen for soil analysis, showed significant differences in their heavy metal content (p < 0.01), as well as in the variety of nematodes (up to 41 genera) and families (up to 20) that were present. The different samples also differed significantly in the total PAH content (p < 0.05), as well as the six types of PAH present. Sites A–C showed the most severe contamination with heavy metals and PAHs; these sites had the lowest abundance of fungivores and omnivore/predators, but the proportion of bacteriovores was the highest (p < 0.05). Site E, in contrast, showed only minor pollution with heavy metals and PAHs, and it contained the highest abundance of plant parasites (p < 0.05). Several nematode ecological indicators were found to correlate with concentration of soil pollutants at all the sites tested: the maturity index (MI, in addition to plant parasites), plant parasite index (PPI), ΣMI (including all the soil nematodes), Shannon-Wiener diversity index (H′′), and Wasilewska index (WI). Disturbance to the soil environment was more severe when MI, ΣMI, and H′ values were lower. The results of the study show that the abundance and structure of the soil nematode communities in the sampling locations were strongly influenced by levels of heavy metals and PAHs in the soil. They also show that the diversity index H′ and the maturity index can be valuable tools for assessing the impact of pollutants on nematodes.     

Fenton氧化法深度处理抗生素废水二级出水

采用Fenton氧化法对青霉素和土霉素混合废水二级处理出水进行深度处理,通过正交和单因素实验研究了废水初始反应pH值、H2O2投加量、Fe2+/H2O2摩尔比及反应时间等因素对废水处理效果的影响。实验结果表明,Fenton氧化法处理的最佳反应条件为:初始pH值4、H2O2(30%)投加量50 mL/L、Fe2+/H2O2摩尔比1/20和反应时间60 min,处理后出水COD小于120 mg/L,COD去除率在75%以上,急性毒性(HgCl2毒性当量)小于0.07 mg/L,满足《发酵类制药工业水污染物排放标准》(GB21903-2008)表2标准要求。     

Copper leaching of MSWI bottom ash co-disposed with refuse: Effect of short-term accelerated weathering

Co-disposal of refuse with municipal solid waste incinerator (MSWI) bottom ash (IBA) either multi-layered as landfill cover or mixed with refuse could pose additional risk to the environment because of enhanced leaching of heavy metals, especially Cu. This study applied short-term accelerated weathering to IBA, and monitored the mineralogical and chemical properties of IBA during the weathering process. Cu extractability of the weathered IBA was then evaluated using standard leaching protocols (i.e. SPLP and TCLP) and co-disposal leaching procedure. The results showed that weathering had little or no beneficial effect on Cu leaching in SPLP and TCLP, which can be explained by the adsorption and complexation of Cu with DOM. However, the Cu leaching of weathered IBA was reduced significantly when situated in fresh simulated landfill leachate. This was attributed to weakening Cu complexation with fulvic acid or hydrophilic fractions and/or intensifying Cu absorption to neoformed hydr(oxide) minerals in weathered IBA. The amount of total leaching Cu and Cu in free or labile complex fraction (the fraction with the highest mobility and bio-toxicity) of the 408-h weathered IBA were remarkably decreased by 86.3% and 97.6% in the 15-day co-disposal leaching test. Accelerated weathering of IBA may be an effective pretreatment method to decrease Cu leaching prior to its co-disposal with refuse.     

内置转盘式PVDF膜生物反应器污水处理的试验研究

对内置转盘式PVDF膜生物反应器(SRMBR)处理污水工艺及膜清洗进行了研究.SRMBR处理污水可以长期稳定运行,在实验模拟污水COD为180～368 mg/L时,出水COD在运行1d后稳定在20 mg/L以内,COD去除率>93%.增大转盘式平板膜组件转速可以增大SRMBR的平衡水通量,转速从15 r/min增大到25 r/min,平衡水通量从42.5 L/(m2·h)增大到47.5L/(m2·h).在一定自吸泵停抽时间内(0～1 min),延长停抽时间有利于减缓膜污染、提高平衡水通量.对污染的膜进行水洗、水洗 碱洗、水洗 碱洗 酸洗,3种清洗方式分别使膜平衡水通量恢复至新膜平衡水通量的48.4%、83.5%、90.2%.