生物质锅炉羰基化合物排放特征分析

为了探讨生物质锅炉羰基化合物的排放特征,采用气袋采样-PFPH衍生-GC/MS分析的方法测量了6台生物质锅炉排放烟气中的21种羰基化合物.结果表明,这些生物质锅炉的烟气中羰基化合物排放特征存在明显差异,总体而言,己醛和丙醛浓度在测定的21种目标化合物中比重最高,分别占总量的29%~47%和19%~31%,其次为甲醛和丙酮,乙醛和壬醛.通过羰基化合物排放量与消耗的燃料质量比值估算了排放因子,6台锅炉羰基化合物排放因子介于3.06~18.29mg/kg之间,平均为9.45±6.05mg/kg.采用最大增量反应活性法（MIR）评价了羰基化合物的化学反应活性及臭氧生成潜势（OFP）,平均总的臭氧生成潜势（以O₃计）为5.97gO₃/gVOCs;己醛、丙醛、甲醛对OFP的贡献尤为明显,丙酮虽然占有较高的质量浓度,但对OFP的贡献较低.     

循环流化床锅炉脱硫效率分析及监测实例

分析总结了循环流化床（CFB）锅炉的脱硫机理以及影响其脱硫效率的各种因素,对某燃煤热电厂和某生物质环保热电厂的循环流化床锅炉脱硫效果（加石灰石前后二氧化硫的排放情况）进行了实测,结果表明：采用循环流化床添加石灰石炉内脱硫后的烟气排放完全满足中国相关排放标准的要求。通过加强对循环流化床锅炉运行的管理,可具有广阔的应用前景。     

"负压干法除尘和正压湿法脱硫"工艺在燃煤锅炉烟气治理中的应用

介绍了“负压干法除尘和正压湿法脱硫”工艺在20t／h燃煤锅炉烟气脱硫除尘中的应用,及该工艺的设计过程、实际运行中的问题和达到的效果。     

大型CFB锅炉安全问题与对策

根据CFB锅炉运行的特点,重点分析了大型CFB锅炉存在的锅炉磨损、冷渣器故障、给煤系统故障、浇注料破坏脱落以及锅炉膨胀等安全问题,提出对策措施。     

蒸汽锅炉爆炸危险性分析及预防措施

简要叙述了锅炉爆炸机理及爆炸冲击波的破坏、伤害作用,采用TNT当量法对中国石化胜利油田石化总厂动力蒸汽锅炉爆炸事故后果进行了预测计算,分析了导致锅炉爆炸事故发生的原因,并给出了应对措施。     

Sustainable global energy supply based on lignocellulosic biomass from afforestation of degraded areas

An important aspect of present global energy scenarios is the assumption that the amount of biomass that can be grown on the available area is so limited that a scenario based on biomass as the major source of energy should be unrealistic. We have been investigating the question whether a Biomass Scenario may be realistic. We found that the global energy demand projected by the International Energy Agency in the Reference Scenario for the year 2030 could be provided sustainably and economically primarily from lignocellulosic biomass grown on areas which have been degraded by human activities in historical times. Moreover, other renewable energies will contribute to the energy mix. There would be no competition with increasing food demand for existing arable land. Afforestation of degraded areas and investment for energy and fuel usage of the biomass are not more expensive than investment in energy infrastructure necessary up to 2030 assumed in the fossil energy based Reference Scenario, probably much cheaper considering the additional advantages such as stopping the increase of and even slowly reducing the CO₂ content of the atmosphere, soil, and water conservation and desertification control. Most importantly, investment for a Biomass Scenario would be actually sustainable, in contrast to investment in energy-supply infrastructure of the Reference Scenario. Methods of afforestation of degraded areas, cultivation, and energetic usage of lignocellulosic biomass are available but have to be further improved. Afforestation can be started immediately, has an impact in some few years, and may be realized in some decades. Electronic supplementary material  The online version of this article (doi:) contains supplementary material, which is available to authorized users.

Experimental investigation of open core downdraft biomass gasifier for food processing industry

This paper deals with field related experience of a low temperature industrial heat application through biomass gasification. The gasification system is essentially consists of an open top down draft reactor lined with ceramic. The experiment reveals that 6.5 kg of liquefy petroleum gas (LPG) is fully replaced by 38 kg of sized wood on hourly basis. The maximum temperature attained was 367°C in 130 min at 100.7 Nm³ h⁻¹ gas flow rate. This system has resulted a saving of about 19.5 tons of LPG over 3,000 h of operation, implying a saving of about 33 tons of CO₂ emission, thus a promising candidate for clean development mechanism. Fuel economic analysis of gasifier system showed that the saving was about 13,850 US$ for 3,000 h of baking operation.     

工业燃煤链条炉细粒子排放特征研究

链条燃煤锅炉是当前我国工业锅炉的最主要应用炉型,其容量占到了工业锅炉总容量的85%,是重要的大气污染物排放源之一.本研究在3个地区选取了5种典型容量的链条炉,应用自行设计的二级稀释系统现场测试其细粒子（PM_2.5）和各种气态污染物的排放特征.结果表明,链条炉烟气中的PM_2.5质量粒径呈单峰或双峰分布,第1个峰值在0.14 μm处,第2个峰值在1 μm后;湿法除尘和旋风除尘对PM_1.0的细粒子仍具有有效的去除效率;在相同或相似除尘控制技术的条件下,PM_2.5的排放水平随锅炉容量的增大而减小.在PM_2.5中,SO^2-₄是最丰富的离子,质量分数在20%～54%范围内;C是最丰富的元素,质量分数在7.5%～31.8%之间,其次是S,质量分数为8.4%～18.7%.采用碳平衡法计算得出PM_2.5、NO_x和SO₂的排放因子分别为0.046～0.486 　g·kg^-1、 1.63～2.47　g·kg^-1、 1.35～9.95　g·kg^-1,这为建立我国的工业锅炉排放清单及大气污染来源分析提供了必要的基础数据.     

Self-ignition tendency of solid fuels: A gas emissions approach for early detection

Self-ignition of solid fuels storage is one of the main causes of human and economic losses. Additionally, each fire caused by this phenomenon emits an amount of toxic gases that contributes on the development of climate change. Nowadays, several methodologies are used in order to detect the self-ignition tendency of solid fuels, but they have as main disadvantages the amount of money and time that they require. The aim of this study is to propose a methodology of detection of incipient self-ignition of solid fuels through the measurement of gas emissions. This study compares existing methodologies to detect self-ignition tendency, such as TG, DSC or susceptibility, and to combustion related gas emission results. Different methods have been used to evaluate the results from the gas emission test, showing that interval and inflexion methods provide early detection of the self-heating process. With this methodology, it is possible to determine this process in advance with the equipment currently available in every industrial facility, reducing costs and improving efficiency.     

Modeling and simulation of biogas-fueled power system

The main objective of this paper is to develop a complete model that fully simulate a biogas-fueled power plant which can be used to supply a rural farm with sufficient electricity. The reactor is fed with animal manure of the farm. The proposed model consists of three main parts; a biogas reactor, a microturbine (MT) coupled to a permanent magnet synchronous generator, and a storage system. The model describes the dynamics of an MT and it is suitable for both steady state and transient simulation and analysis. The volume of biogas output delivered from the Anaerobic Digester depends on the reactor volume, reactor temperature, and animal manure type. The storage system is used to store the excess value of biogas if any. It is composed of two parts: a comparator and a storage tank. The comparator compares the volume of biogas produced by the reactor with that needed to supply the load. An adaptive controller is developed to withstand the system against any transient condition such as suddenly load increase/decrease. The proposed model is implemented for chemical and physical behaviors of the biogas production process, as well as for different variables of MT-generator operations. The model is implemented in Matlab/Simulink environment and tested under different operating conditions in both steady state and transient status to study the impacts of different variables on the system output. The output results prove its applicability and effectiveness under different operating conditions.