应用新型好氧堆肥反应器连续投加处理人粪便的研究

针对间歇式堆肥反应器处理效率低、不便移动、单次投加所需物料量大等不足,以及为更有效地处理分散型人粪便,使人粪便资源化,开发了梨形筒式好氧堆肥反应器。在获得该反应器的最佳通风与搅拌频率分别为3.0 L/min,5 min/h以及最佳m（粪便）︰m（锯末）为1︰2.5的条件下进行连续投加人粪便好氧堆肥。在不接种微生物的30 d堆制过程中,升-降温周期为36 h,平均温度为51.44℃,第15天时COD降解率达到63.99%并趋于稳定,TN损失率第17天时达到56.68%,GI于第21天时达到106.25%,堆肥完全腐熟,稳定期处理效率为23.81 g/（L·d）。接种土著菌种时,升-降温周期缩短至24 h,平均温度为53.96℃,COD降解率8 d可达65.28%,TN 损失率仅为25.75%,GI于第8天达到108.22%,稳定期处理效率可达35.71 g/（L·d）,比不接种时提高1.5倍,同时节约能耗50%。     

SFBR中好氧颗粒污泥的培养及特性研究

接种自行培养的活性污泥,以模拟废水为基质,采用连续进水、间歇出水及厌氧/好氧交替的运行模式,尝试了在SFBR中进行好氧颗粒污泥的培养,并研究了好氧颗粒污泥的特性及反应器对污染物的去除效果.结果表明,通过逐步缩短沉降时间,28 d时成功培养出好氧颗粒污泥,所形成的好氧颗粒污泥呈黄色、形状不规则,且粒径较小(平均粒径0.56 mm),正常情况下的SVI保持在70 mL·g-1以下,EPS在59 d时达到最大值(以MLVSS计)373.24 mg·g-1,较培养初期增加了约2.5倍,运行后期由于颗粒出现解体,导致EPS急剧下降;反应器在运行过程中未能保持较高的污泥量,中后期MLSS始终在3 000mg·L-1以下;在63 d的运行时间里,除异常波动外,反应器对COD的去除率基本维持在90%左右,正常情况下出水COD小于100 mg·L-1,反应器对NH+4-N、TIN的去除效果波动较大,去除率分别为44.45%~94.72%及43.87%~93.13%,反应器对TP的去除率在44.50%~97.40%之间,正常情况下TP去除率可维持在60%以上;限于自动控制水平,夜间长时间的好氧饥饿期容易造成丝状菌过度生长,使得AGS在生长竞争中处于劣势,最终导致了AGS的解体.     

海水异养硝化-好氧反硝化芽孢杆菌SLWX2的筛选及脱氮特性

从分离自刺参养殖环境的7株候选菌株中筛选出1株具有较强异养硝化和好氧反硝化能力的菌株SLWX_2,通过形态学特征、生理生化特性和16S rRNA基因测序分析鉴定其为花津滩芽孢杆菌(Bacillus hwajinpoensis).该菌株脱氮特性研究结果表明,SLWX_224 h对氨氮、亚硝酸氮和硝酸氮的去除率分别达到100%、99.5%和85.6%;当3种无机氮源同时存在时,菌株优先利用氨氮,再利用NO_2~--N和NO_3~--N,72 h 3种无机氮的质量浓度均降至0.013 mg·L~(-1)以下,表明该菌株能同时进行异养硝化和好氧反硝化完成脱氮;在氨氮负荷500 mg·L~(-1)、亚硝酸氮负荷100 mg·L·~(-1)和硝酸氮负荷200 mg·L~(-1)范围内,该菌的脱氮能力不受明显抑制,对3种形态的氮均有良好去除效果,96 h最多可去除180 mg NH_4~+-N、30 mg NO_2~--N和120 mg NO_3~--N,并且在硝化过程中没有亚硝酸氮积累.该菌株在海水养殖和高盐高氮工业废水的脱氮处理方面具有更大潜力.     

温度对好氧颗粒污泥处理纤维素乙醇废水脱氮效能的影响

采用SBR反应器,考察了温度对好氧颗粒污泥处理纤维素乙醇废水脱氮性能的影响.研究结果表明,当进水为纤维素乙醇废水原水时,稳定阶段不同温度(10、20、30℃)条件下体系对COD的去除率分别为10.2%、12.7%、13.7%;总无机氮的去除率分别为42.8%、53.6%、70.5%,温度的升高明显地提高了硝化菌的活性和生长速率,进而促进了脱氮效果.当进水为纤维素乙醇废水经IC工艺处理后的厌氧出水时,3个温度条件下系统对废水中有机物的去除效果无较大差异,去除率均低于15%,主要因为纤维素乙醇废水的厌氧处理出水中的有机物很难被微生物利用;而温度对脱氮效果影响较大,30℃下NH_4~+-N去除率达到60.9%,分别是10℃和20℃时的2.0和1.3倍,并且,随着温度的升高总无机氮的去除率增强,NO_3~--N的去除量增加.由于体系COD去除率低说明反硝化可利用的碳源不足,因此,系统内可能存在内碳源反硝化作用,而且内碳源反硝化作用也随着温度的升高而增强.通过氮平衡计算可知,3个温度条件下氮损失分别为37.6%、45.0%、53.6%,说明温度的升高不仅提高了硝化菌活性,还促进了内碳源反硝化,进而提高了对氮素的去除.     

Chemical and spectroscopic characterization of organic matter during the anaerobic digestion and successive composting of pig slurry

In this work, anaerobic digestion of pig slurry and successive composting of the digestate after centrifugation were studied by means of chemical analysis, FTIR and fluorescence spectroscopy as excitation–emission matrix (EEM). Chemical analysis highlighted the organic matter transformation occurring during the processes. A decrease of volatile solids and total organic carbon were observed in the digestate with respect to the fresh pig slurry as a consequence of the consumption of sugars, proteins, amino acids and fatty acids used by microorganisms as a C source. Water Extractable Organic Matter (WEOM) was obtained for all samples and fractionated into a hydrophilic and a hydrophobic fraction. The highest WEOM value was found in the pig slurry indicating a high content of labile organic C. The digestate centrifuged and the digestate composted showed lower hydrophilic and higher hydrophobic contents because of the decrease of labile C. Total phenolic content was lower in the digestate with respect to fresh pig slurry sample (36.7%) as a consequence of phenolic compounds degradation. The strong decrease of total reducing sugars in the digestate (76.6%) as compared to pig slurry confirmed that anaerobic process proceed mainly through consumption of sugars which represent a readily available energy source for microbial activity. FTIR spectra of pig slurry showed bands indicative of proteins and carbohydrates. A drop of aliphatic structures and a decrease of polysaccharides was observed after the anaerobic process along with the increase of the peak in the aromatic region. The composted substrate showed an increase of aromatic and a relative decrease of polysaccharides. EEM spectra provided tryptophan:fulvic-like fluorescence ratios which increased from fresh substrate to digestate because of the OM decompostion. Composted substrate presented the lowest ratio due to the humification process.     

污泥膜覆盖好氧发酵堆体流场模拟及应用研究简

运用Gambit软件建立了污泥好氧发酵堆体的多孔介质模型，通过自行设计的实验装置获得了堆体的通风粘性阻力系数和惯性阻力系数以及功能膜压差与透气量之间的关系，用Fluent软件分析了堆体不同截面形状及底部通风管数量对堆体通风均匀性的影响，为确定合理的通风管数量及截面几何形状提供理论依据。对上海奉贤区城镇污水厂污泥处理工程发酵仓进行堆体流场模拟，确定堆体采用小拱形截面形状，堆高2 m，宽8 m，底部设置4条通风管，实际运行效果良好。     

接种微生物与人粪便同步连续投加对好氧堆肥效果的影响简

利用新型梨形筒式好氧堆肥反应器，在通风量为3.0 L/min，搅拌频率为5 min/h的条件下，就不接种微生物、接种土著菌种、枯草芽孢杆菌与酵母菌时人粪便连续投加好氧堆肥效果进行了对比。堆制20 d即2个运行周期中各堆体的温度、含水率、COD、总氮、pH值与GI等的变化表明，接种微生物可以显著提高堆体的升温速率与堆体平均温度、COD降解率、GI（P<0.01），堆肥可迅速达到完全腐熟。接种土著菌种效果最为明显（P<0.01），其后相继为枯草芽孢杆菌与酵母菌。接种土著菌种可使堆体温度在50℃以上维持18 d，第8天COD降解率达到61.17%、总氮损失率为25.75%，第6天时GI达到108.22%。     

Advantages and risks of using steel slag in preparing composts from raw organic waste

It had been reported that iron and manganese oxides in steel slag enhanced the production of humic acid (HA) from low-molecular-weight compounds, such as phenolic acids, amino acids, and saccharides. In the present study, this function of steel slag was applied to the composting of raw organic wastes (ROWs). The degree of humification of HAs is an important factor in evaluating compost quality. Thus, HAs were extracted from the prepared composts and the humification parameters were determined, in terms of elemental compositions, acidic functional group contents, molecular weights, spectroscopic parameters from UV–vis absorption and ¹³C NMR spectra. The timing for adding steel slag affected the degree of humification of HAs in the composts. The weight average molecular weight of a HA when slag was added initially (29 kDa) was significantly higher than when slag was added after elevating the temperature of the compost pile (17–18 kDa). These results show that ROWs are decomposed to low-molecular-weight compounds after the pile temperature is elevated and the presence of slag enhances the polycondensation of these compounds to produce HAs with a higher degree of humification. Because the slag used in the present study contained several-tens ng g^?1 to several μg g^?1 of toxic elements (B, Cu, Cr, and Zn), leaching tests for these elements from the prepared composts were carried out. Levels for leaching boron from composts prepared by adding slag (0.2–0.4 mg L^?1) were obviously higher than the corresponding levels without slag (0.05 mg L^?1).     

C/N和pH值对高温好氧反硝化菌产N2O的影响研究

以50℃高温、好氧条件下能进行高效好氧反硝化的菌株TAD1为研究对象,在不同C/N和pH值培养条件下,对其24 h的反硝化效率和反硝化过程中N2O的逸出量进行了研究。结果显示,C/N和pH值对菌株TAD1的反硝化效率和N2O产生量有明显影响.菌株TAD1最适宜的C/N为9,pH值为7,此时反硝化效率达到99.12%,N2O产生量仅为3.35×10-2 mg/L,N2 O转化率为0.045%,反硝化产物以氮气为主。另外,菌株TAD1不适宜在酸性条件下生长,pH值为6时反硝化效率为83.18%,N2O产生量为13.88×10-2 mg/L,是pH值为7时的4.14倍,是pH值为8时的5.07倍。     

小型好氧堆肥设备处理有机垃圾

针对我国生活垃圾的特点,提出了厨余等有机生活垃圾单独收集,在产生源头进行好氧堆肥处理。研制了好氧堆肥设备,由加热装置、通风装置、冷凝水收集和回灌装置,以及与该生物堆肥设备配套的生物过滤除臭装置、自控系统和数据采集软件几部分构成。自控系统由氧气、温度、湿度三路传感器以及2个控制器构成,并与加热装置、通风装置连接,能满足物料加热、供氧和散热的要求。本研究通过为期30 d的试运行实验表明,物料快速升温并稳定保持在高温阶段(50～60℃),物料中的氧气浓度保持在14%～16%范围内。在堆肥实验结束时,物料的含水率降至36.4%,有机质含量降至49%,另外,通过好氧速率指标也可判定物料达到腐熟。