pH值与乙酸对易腐有机垃圾水解过程的抑制

通过外部添加水解酶比较和区分pH值和乙酸对水解的影响,结果表明:以固相挥发性固体和元素碳的减少以及液相有机碳的增加表征水解率,在pH=7时最大,144h的水解率可达66.9%;与pH=7相比,pH=8-9时,水解率降低8%-24%;pH=5-6,水解率降低40%-60%.20g·l-1乙酸的加入抑制了水解,在不同pH值条件下与不添加乙酸的水解相比,抑制程度为2%-35%,pH=7时乙酸的抑制最显著,可达35%.颗粒态物料的水解过程动力学符合Chen-Hashimoto公式.     

生物膜法污水处理用新型纤维素载体的制备与性能

以麦草浆粕为原料,研究开发出了一种适用于生物膜法污水处理的多孔生物膜载体.实验通过对麦草浆粕碱化、黄化制备出酯化均匀的纤维素粘胶,并在此基础上选取合适的发泡成孔技术和纤维素再生工艺得到多孔纤维素载体成品.实验考察了各制备条件对载体性能的影响,总结出了该工艺下性能最优的载体的制备条件.研究结果表明,制得载体的孔隙率可达85%,比表面积在11m2·g-1以上,孔径从100μm～800μm均可人为控制.制得的多孔纤维素载体成本低廉,用于污水处理效果十分良好.     

Process of rice straw degradation and dynamic trend of pH by the microbial community MC1

The process of the rice straw degradation in the fermentor with aeration at 290 ml/h was studied. The results of dissolved oxygen （DO） indicated that the optimum DO during cellulose degradation by microbial community MC1 ranged from 0.01 to 0.12 mg/L. The change model ofpH values was as follows： irrespective of the initial pH of the medium, pH values decreased rapidly to approximate 6.0 after being inoculated within 48 h when cellulose was strongly degraded, and then increased slowly to 8.0--9.0 until cellulose was degraded completely. During the degradation process, 15 kinds of organic compounds were checked out by GC-MS. Most of them were organic acids. Quantity analysis was carried out, and the maximum content compound was ethyl acetate which reached 13.56 g/L on the day 4. The cellulose degradation quantity and ratio analyses showed that less quantity （under batch fermentation conditions） and longer interval （under semi-fermentation conditions） of rice straw added to fermentation system were contributed to matching the change model of pH, and increasing the quantity and ratio of rice straw degradation during cellulose degrading process. The highest degradation ratio was observed under the condition office straw added one time every five days （under semi-fermentation conditions）.     

降水中甲酸、乙酸和草酸的离子色谱法测定及样品保存研究

甲酸、乙酸和草酸是降水中有机酸的主要成分。研究选用离子色谱法同时测定降水中的甲酸、乙酸和草酸,并对降水样品中3种有机酸的保存条件进行了研究。优化后的色谱条件为4. 0 mmol/L Na_2CO_3和1. 2 mmol/L NaHCO_3混合淋洗液,淋洗液流速为1. 0 m L/min,进样体积为200μL,电导池温度为30℃,柱温为室温。甲酸、乙酸和草酸的检出限分别为0. 002、0. 005、0. 005 mg/L,实际降水样品测定时平行样的相对标准偏差为1. 4%～12%,加标回收率为95%～118%。样品采集后需尽快用0. 45μm聚醚砜微孔滤膜过滤,4℃以下冷藏密封保存,2 d内测定。若用氢氧化钠溶液调节p H至8～10,样品可保存7 d。     

固相餐厨垃圾厌氧发酵特性

为了研究固相餐厨垃圾厌氧发酵产甲烷特性,对固相餐厨垃圾进行批式厌氧发酵实验,主要考察了pH、VFA、COD以及纤维素酶活的变化情况,并运用修正Gompertz模型对其产气模型进行动力学拟合.实验结果表明,缓冲溶液的添加可明显促进厌氧发酵产甲烷.在添加缓冲溶液条件下,污泥与餐厨垃圾比例为2∶1,1∶1,2∶3和1∶2时,餐厨垃圾都能很好地进行厌氧发酵产甲烷,最大产甲烷产量分别为594.66、449.74、392.93和333.36 mL/g TS.采用修正Gompertz模型分别对2∶1、1∶1、2∶3和1∶2实验组产甲烷曲线进行拟合,得到产甲烷潜力分别为567.57、437.89、381.12和305.60 mL/g TS,最大产甲烷速率分别为89.38、59.81、47.26和25.80 mL/(d·g VS).对厌氧发酵过程中纤维素酶活的变化进行了研究,结果表明,CMC酶活性在提高餐厨垃圾厌氧发酵过程中纤维素的降解起重要作用.     

Anaerobic degradation of microcrystalline cellulose: kinetics and micro-scale structure evolution

The degradation kinetics and micro-scale structure change of microcrystalline cellulose during anaerobic biodegradation were investigated. A modified Logistic model was established to properly describe the kinetics, which showed good fitness and wide applicability for cellulose degradation. A maximum degradation rate of 0.14 g L⁻¹ h⁻¹ was achieved after cultivating for 51.5 h. This result was in good agreement with the scanning electron microscope and X-ray diffraction analysis. Channels of 400-500 nm size started to occur on the crystalline surface of cellulose at around the inflexion time. Accordingly, the crystallinity significantly decreased at this point, indicating a degradation of the crystalline structure zones by anaerobic bacteria. This study offers direct morphological evidence and quantitative analysis of the biodegradation process of cellulose, and is beneficial to a better understanding of the cellulose degradation mechanism.     

纤维素降解细菌筛选及降解特性分析

基于获得高效纤维素降解细菌的目的,通过LB培养基的培养以及刚果红培养基的筛选,从牛粪堆肥中筛选获得2株高效纤维素降解细菌。经鉴定,分别为枯草芽胞杆菌(Bacillus subtilis)和地衣芽胞杆菌(Bacillus licheniformis)。所筛选得到的菌种具有很高的滤纸降解能力,可在6d内使滤纸剧烈崩溃,振摇成均匀糊状;其中,地衣芽胞杆菌的羧甲基纤维素钠酶活峰值在发酵第4天达到峰值(237U/g)。     

茅草添加与温度变化对餐厨垃圾厌氧水解产酸的影响

比较了茅草添加在温度变化条件下对餐厨垃圾厌氧水解过程小分子有机酸产量的影响,提出一种新型餐厨垃圾的资源化方式。研究结果显示,餐厨垃圾在55℃条件下厌氧水解主要产物为乳酸,达到25．7g／L,其干物质转化率可以达到32．1％（gTS）,而餐厨＋茅草处理在同样条件下的乳酸产量为20．1g／L,干物质转化率为25．1％。温度下降为37℃后继续进行的的厌氧水解,得到的主要产物是乙酸、丙酸和丁酸,餐厨处理和餐厨＋茅草处理这两者的峰值分别为6．5、2．8、8．0和6．1g／L、2．7g／L和5．9g／L。结果显示茅草添加可以在一定程度上调节水解产物的比例,而温度变化可以调控小分子有机酸的产量。本研究结果表明,厌氧水解是一种有潜力的小分子有机酸生产与餐厨垃圾资源化处理途径。     

Biodegradability and compostability of polymers—test methods and criteria for evaluation

The treatment of solid waste in controlled composting facilities is an important possibility for reducing garbage. Natural and synthetic polymeric materials can be used for many purposes, for example, as packaging materials, where compostability is required. A prerequisite for official regulations and the decision as to which materials may be composted is investigations on their biodegradability and the quality of the compost produced. Several standardization groups at the ISO, CEN, and DIN are developing definitions, test methods, and classification systems for differentiating compostable from noncompostable materials. The concept which will be standardized and used in Germany is described in detail. It includes characterization of the test material, determination of the biodegradability using laboratory tests such as simple aquatic batch tests and a controlled aerobic composting test, investigation of the disintegration of the test material in industrial or bench-scale composting facilities, and finally, chemical and ecotoxicological analysis of the compost produced.     

水体沉积物中有效砷的测试新方法研究

一种氧化铁/醋酸纤维素复合膜(FeO/CAM)被用于太湖沉积物中砷的生物有效性评估.结果发现,在水介质中,FeO/CAM对沉积物中砷的富集量随土水比增加而呈乘幂函数减少,在土水质量比为0.025(即1:40)之后趋于某一平台值;在土水比为0.025并得到充分振荡的条件下,沉积物中释放的有效砷被FeO/CAM富集至膜中,并随时间增加而增加,至24 h后逐渐趋于平衡,这一过程恰当地模拟了生物对砷的吸收.因此,FeO/CAM可以用于有效砷的体外测试.利用FeO/CAM对12个总砷含量为6.4～34.6 mg·kg-1的太湖沉积物样品中的有效砷进行了测定.结果发现,FeO/CAM提取的有效砷含量与磷酸盐缓冲液提取的有效砷含量之间显著相关.太湖沉积物中的有效砷含量与总砷、总磷、有机质和吸附磷含量以及磷吸附饱和度显著相关,说明沉积物理化属性对有效砷含量有重要影响.FeO/CAM克服了化学试剂提取过程中引起的非有效态砷释放的根本缺陷,因此,FeO/CAM方法在沉积物有效砷含量的测定时比化学试剂提取法可能更准确.