唐钢2×150t转炉煤气回收系统设计及运行实践

在此较详细地介绍了唐钢一炼钢厂 2× 15 0t转炉煤气回收湿法除尘工艺和系统的技术特点。该系统设计吸收了国内外大型转炉煤气回收的经验。经近 18个月的生产实践 ;认为效果良好 ,煤气回收率近 80 % ,热值近 80 0 0kJ Nm3,放散排放浓度小于 80mg m     

冬季动态槽式堆肥温度的空间变异

以鲜鸡粪、蘑菇渣和污泥按照体积比3∶1∶1混合进行动态堆肥模拟试验.堆肥槽沿物料前进方向分为7个部分,对每个部分按等间距分别做5个水平方向上切分和5个垂直方向上切分,在形成的125个交叉点上进行温度监测.研究结果表明,第1天的混合物料温度在同一层中变异很小,不同层之间略有差异.随着动态过程的进行,同一层温度变异逐渐增大,从第一天相差1～3℃,增加到相差30～40℃,靠近墙体的堆料温度较低,远离墙体的温度较高.随着堆肥时间延长,差异增大.机械翻堆能起到通风的作用,同时使每一个堆方的堆料在纵向方向上上下混合,但达不到横向混匀,因此,靠近墙体两侧的堆料始终处于较低的温度,只有中部能达到较高的温度,以堆肥温度50℃作为无害化指标,自墙体向中心方向的1m为没有达到无害化厚度,无害化体积占堆肥总体积50%.整个动态堆肥过程符合二级动力学方程.     

Dynamic fate modeling of γ-hexachlorocyclohexane in the lower reaches of the Liao River

A QWASI model dependent on temperature is parameterized to describe the long-term fate of persistent organic pollutants (POPs) in the Liao River. The model parameters, namely fugacity capacity, degradation rate, and transfer coefficient, are profoundly affected by temperature. This model is used to simulate the fate of γ-hexachlorocyclohexane (γ-HCH) in the lower reaches of the Liao River from 1998 to 2008. Modeling results show that γ-HCH fugacity capacities in air, water, and sediment increase as temperature decreases, and the transfer and transformation rate coefficients increase as temperature increases. The variations of transfer and transformation parameter D values depend on fugacity capacities, and transfer and transformation coefficients simultaneously. The performance of the model is evaluated by comparing the predicted and observed concentrations in the water and sediment of the Liao River. The predicted values agree well with the observed value in the order of magnitude, in most cases within the factor of 3. It is believed that the model is appropriate for simulating the long term fate of POPs in the Liao River. Translated from Environmental Science, 2006, 27(1): 121–125 [译自: 环境科学]     

测空气中SO2时的主要影响因素

目前测定空气中SO2主要采用甲醛吸收-副玫瑰苯胺分光光度法。该法操作比较严格，测试结果的准确度受诸多因素的影响。因此文中对这些影响因素进行了探讨，主要为试剂质量、显色温度和显色时间、溶液加入顺序、比色皿、空气采样器流量、采样温度、导气管的吸附等因素对测定结果的影响进行了探讨。     

利用多次回归拟合水的饱和蒸气压与温度的关系表达式

在使用于湿球测定锅炉烟气含湿量的过程中,需要查找水的饱和蒸气压,非常不方便.利用D-196和<化工原理>上册中取得部分数据,用多次线性回归的方法,拟合出水在0～200℃范围内的饱和蒸气压与温度的关系表达式;并对该表达式的误差进行了分析,误差均值为0.2‰,最大值也只有0.8‰,完全可以满足环境监测中数据处理的精度要求.     

铝酸钙去除水中氟离子的条件研究

采用铝酸钙粉,进行去除模拟废水中氟离子的条件研究,并进行了pH值、温度等多项条件的系列实验。实验得出,当氟离子浓度为215mg/L,反应溶液为200mL,反应温度是影响去除率的主要因素,去除主要发生在前15min,除氟主要依靠沉淀、络合等作用。pH为11,40℃时,投加量50g/L时,去除率可以达到95.7%以上,出水可直接达标。     

景观锚链的近海大气腐蚀调查研究

在2007年3月对暴露于湛江观海长廊近8年的景观锚链进行了大气腐蚀调查和研究.现场调查结果显示,各站点锚链均受到不同程度的腐蚀,锈层呈黄褐色,站点2和站点3的锈层易剥落.锚链的扫描电镜结果表明,外表面锈层疏松多孔,并伴有大量的裂纹,内表面局部存在大量诱导腐蚀发生的微孔,表面锈层中均含有S元素和Cl元素.红外光谱分析结果显示,锚链表面锈层均有α-FeOOH.大气湿热气候、高含量的Cl-和H2S是锚链钢严重腐蚀及发生块状开裂的主要因素.     

袋式除尘器在立窑烟气除尘中的应用

对立窑烟尘排放特点与立窑除尘工艺中的问题及对策进行了讨论。分析了立窑烟尘排放特征,对几种常见的立窑除尘的设备和工艺进行了比较,指出袋式除尘器可成功地用于立窑烟气除尘。并且从滤料选择、清灰方式、烟温控制、灰斗的气密性等方面详细地完善了袋式除尘器在立窑烟气除尘中的应用。     

The effect of heating temperature of thin film transistor-liquid crystal display (TFT-LCD) optical waste glass as a partial substitute partial for clay in eco-brick

In order to fulfill the current WEEE directives, the traditional approach to manage thin film transistor-liquid crystal display (TFT-LCD) waste glass is inadequate. It is a serious opportunity to achieve resource conservation, reduction, stabilization and safety of management of TFT-LCD in the near future. To assist in achieving these goals, this study investigated the sintering characteristics and material properties of TFT-LCD waste glass, which can be pulverized and ground and subsequently blended with clay, at various substitution levels (0–40%) and finally fired from 800 °C to 1000 °C to make eco-brick. The brick thus produced was analyzed to determine variations in weight losses on ignition, 24-h absorption, bulk density, shrinkage, compressive strength and microstructure changes. The results for specific gravity, water adsorption, and compressive strength revealed that bricks made from mixtures containing TFT-LCD waste glass met the general requirements for bricks. The advantages of less water absorption, less weight loss on ignition, and a gain in compressive strength in the clay-TFT-LCD waste glass bricks should encourage the use of TFT-LCD waste glass as a brick additive.     

银的变色及抗变色研究

讨论了大气中各种腐蚀性气体对银变色的影响,以及变色膜中各种腐蚀产物的成分及状态,以硫化氢气体和硫化银为主要对象进行阐述,侧重介绍了最近30年的研究结果.总结了近年来各种银的抗变色的方法.