人工煤气管道萘颗粒沉积规律研究

针对萘在人工煤气管道中沉积会造成管道堵塞，影响管道的安全运行的这一问题，以昆明人工煤气管道为例，运用计算流体动力学软件Fluent，选用离散相模型和雷诺应力模型，对水平直管、水平弯管和三通管进行萘颗粒沉积的数值模拟，对于不同的管径、弯曲比、管径比，分别分析萘颗粒直径、入口速度、温度及压力对萘颗粒沉积的影响。研究结果表明:水平直管、水平弯管、三通管中的萘颗粒沉积率与颗粒粒径成正相关关系，而与气流入口速度、压力成负相关关系；萘颗粒在人工煤气管道中的沉积率主要受颗粒直径、气流入口速度的影响；萘颗粒的沉积率随着水平直管的管径增大而增大，随着水平弯管的弯曲比增大而增大，随着三通管的管径比增大而先增大后减小；可通过适当增大管内煤气输送速度、压力，降低温度来降低萘颗粒在人工煤气管道中的沉积速度，进而减少萘颗粒沉积的发生。     

Enzymatic hydrolysis of banana stems (Musa acuminata): Optimization of process parameters and inhibition characterization

In current work, an optimum solid loading (solid: liquid = 1:20), pH (4.8), temperature (50°C), and enzyme dosing of 20 filter paper unit (amount of enzyme required to release 1 µmol of glucose as reducing sugar from filter paper in per mL per minute) were enumerated for enzymatic hydrolysis of banana stem using cellulase from Trichoderma reesei. Further, inhibition study on enzymatic hydrolysis of banana stem was investigated by the supplementation of monosaccharides (glucose, galactose, mannose, xylose, and arabinose), disaccharide (cellobiose), and inhibitors (acetic acid and furfural obtained from pre-enzymatic hydrolysis steps). Glucose and cellobiose showed inhibitory effect on enzymatic hydrolysis of pretreated banana stem at or above 8 g/L while galactose, mannose, and xylose showed a significant inhibitory effect at or above 4 g/L. Instead of inhibition, arabinose enhanced the enzymatic hydrolysis with increase in total reducing sugars. Acetic acid did not show any significant inhibition while furfural inhibited the system at a comparative low concentration of 2 g/L. Further, scanning electron microscopy analysis was performed to investigate the difference in ultra-structural morphology of raw biomass, pretreated biomass, and biomass obtained after enzymatic hydrolysis.     

Rapid estimation of compost enzymatic activity by spectral analysis method combined with machine learning

The aim of this study was to investigate the feasibility of using visible near-infrared (VisNIR) diffuse reflectance spectroscopy (DRS) as an easy, inexpensive, and rapid method to predict compost enzymatic activity, which traditionally measured by fluorescein diacetate hydrolysis (FDA-HR) assay. Compost samples representative of five different compost facilities were scanned by DRS, and the raw reflectance spectra were preprocessed using seven spectral transformations for predicting compost FDA-HR with six multivariate algorithms. Although principal component analysis for all spectral pretreatments satisfactorily identified the clusters by compost types, it could not separate different FDA contents. Furthermore, the artificial neural network multilayer perceptron (residual prediction deviation = 3.2, validation r² = 0.91 and RMSE = 13.38 μg g^?1 h^?1) outperformed other multivariate models to capture the highly non-linear relationships between compost enzymatic activity and VisNIR reflectance spectra after Savitzky–Golay first derivative pretreatment. This work demonstrates the efficiency of VisNIR DRS for predicting compost enzymatic as well as microbial activity.     

包埋氨氧化细菌处理合成氨工业废水

以聚乙烯醇与海藻酸钠为载体,包埋固定氨氧化细菌(AOB),研究温度、DO、初始游离氨(FA)、有机物等影响因素对其短程硝化稳定性的影响。结果表明,25~30℃时载体中氨氧化细菌占优势;DO宜控制在4.0~5.5 mg/L之间,既能满足细菌生长所需,又不至过度曝气,造成载体间的摩擦增大,减少其使用寿命;载体耐氨氮负荷能力强,同时可以抵御有机物对氨氧化细菌的伤害;当初始FA>6.5 mg/L时,氨氧化细菌的活性将受到抑制;富集氨氧化细菌的污泥包埋后氨氮去除率降低了7.5%;包埋载体在确保短程硝化作用的同时,在内部形成的缺氧区可实现反硝化脱氮,提高了系统氨氮的处理能力。     

Experimental investigation on engine performances,combustion characteristics and emission of exhaust gases of VCR engine fuelled with cottonseed oil methyl ester blended with diesel

This research work investigates the engine performances, combustion characteristics, and emission of exhaust gases of variable compression ratio engine fuelled with cottonseed oil methyl ester (COME) and diesel at different blends. The analysis showed that heat release rate and cylinder pressure is higher for diesel than COME blends. Higher BTE is obtained at the maximum load condition. The higher BTE and lower SFC are obtained for blend B15 as 42.17% and 0.2 kg/kW-hr at brake mean effective pressure (BMEP) of 4.64 bar. Also it is found that the peak cylinder gas pressure and combustion duration increases when the BMEP increases. At the BMEP of 3.51 bar, higher HRR is observed as 18.12 J/deg. Increase in HRR is obtained as 6.07% for B30 at BMEP of 4.64 bar when compared to diesel. Ignition delay decreased by 13.16% for B100, by the increment of blend proportions when compared to diesel, at BMEP of 4.64 bar. Lower smoke, HC and CO emissions are observed when increasing the blend proportions, whereas the nitric oxide emissions increases due to the better combustion resulted in higher temperatures. At BMEP of 4.64 bar, the CO emissions are reduced to 25.24% for neat biodiesel when compared with the diesel.     

汽车修理养护企业挥发性有机物排放控制标准探讨

通过对汽车修理养护企业喷烤漆废气排放现状进行调查分析,指出中国目前适用于控制汽车修理养护企业废气排放的标准《大气污染物综合排放标准》(GB 16297-1996)在实际运用中存在的问题。依据《制定地方大气污染物排放标准的技术方法》(GB/T 3840-1991)《大气污染物综合排放标准详解》《工作场所有害因素职业接触限值化学有害因素》(GBZ 2.1-2007)《工业企业设计卫生标准》(TJ 36-1979)、美国环保局多介质环境模型等,用不同方法计算汽车修理养护企业排放的废气中几种挥发性有机物的排放浓度和排放速率限值,并对监测结果进行评价分析,提出编制汽车修理养护企业废气排放控制标准的建议。     

膨化预处理玉米秸秆的还原糖酶解工艺

应用膨化技术对玉米秸秆进行预处理.在单因素实验基础上,以还原糖转化率为影响值设计正交实验,研究温度、pH、液固比、酶浓度及酶解时间五因素对纤维素酶解过程的影响.得出玉米秸秆糖化酶解最佳工艺条件为:温度48℃,pH 4.5,液固比8:1,酶浓度36.0 U/g,酶解时间25 h；在此工艺条件下还原糖转化率达到28.98％.扫描电镜表征对比观察可看出,膨化后玉米秸秆纤维素酶解充分；结合红外光谱对各组分特征基团分析表明,膨化后的玉米秸秆酶解的纤维素基团特征峰变化更为明显.     

基于RS/GIS的伊犁河谷生态环境模糊综合评价

土地利用/土地覆盖是生态环境系统的组成部分,它的变化是区域生态环境演变的直接反映和结果,它是区域生态环境演变的一个重要因素。运用RS/GIS技术,采用土地利用类型覆盖率作为评价因子,参考国际和国内各省的土地利用类型覆盖率制定评价标准,对伊犁河谷生态环境进行模糊综合评价。得出伊犁河谷生态环境质量属"优"的面积覆盖率占伊犁河谷总面积的73.2%;生态环境质量为"良"的县市面积覆盖率占伊犁河谷的26.3%。伊犁河谷生态环境总体较好,局部较差。伊犁河谷各县市的耕地面积覆盖率、建设用地覆盖率和草地面积覆盖率是各县市生态环境状况差异的主要原因。该方法与其他方法比较,所得的评价结果比较一致,结论符合实际状况,且有计算简便快捷等优点,方法可行,具有一定的可靠性和理论价值。     

鸟粪石循环利用处理高氨氮废水的热解行为

为了循环利用鸟粪石处理高氨氮废水,探讨了鸟粪石煅烧与加碱热解的脱氮率,利用电镜扫描(SEM)和X射线衍射(XRD)对2种热解产物进行了分析。鸟粪石煅烧条件为:温度100～225℃,时间1～5 h;加碱热解条件为:温度60～95℃,时间0.5～4 h,加碱量OH-∶NH4+摩尔比值0.4～1.5。结果表明,虽然XRD分析显示2种热解产物都已失去鸟粪石的特征峰,但是鸟粪石加碱热解效果更好,最佳热解条件为:加碱量OH-∶NH4+摩尔比值1,温度90℃,时间2 h,鸟粪石脱氮率95%以上;加碱热解产物表面为多孔状,完全失去了晶体结构;煅烧热解鸟粪石脱氮率仅为80%左右,热解产物晶体结构破坏不完全。鸟粪石在最佳条件下热解循环处理高氨氮废水,可循环使用6次,氨氮去除率80%以上,出水磷浓度小于8 mg/L。     

四环素高效降解酵母菌Trichosporon mycotoxinivoransXPY-10降解特性

Trichosporon mycotoxinivorans XPY-10是一株分离自抗生素制药厂的高效四环素降解酵母菌。为了建立该菌株降解四环素的适宜条件，分别研究了碳源、有机氮源、金属离子等营养物质及初始底物浓度、接种量、pH、温度、装液量、摇床转速等理化因素对菌体生长及四环素降解效率的影响。结果表明，菌株XPY-10生长的最适碳源和氮源分别为蔗糖和蛋白胨。在含有0.05% FeSO₄的培养基中，菌株XPY-10降解四环素的适宜条件为：接种量2%，pH 8，温度34℃，装液量100 mL（250 mL 三角瓶），摇床转速180 r/min。在此条件下，菌株XPY-10在7 d内对初始浓度为600 mg/L的四环素降解率为83.63%。本菌株对养殖废水及制药废水中四环素的污染治理有一定的应用前景。