Shifts in microbial community structure and diversity in a MBR combined with worm reactors treating synthetic wastewater

The chemical oxygen demand (COD) and NH₃-N removal, membrane fouling, sludge characteristics and microbial community structure in a membrane bioreactor (MBR) coupled with worm reactors (SSBWR) were evaluated for 210 days. The obtained results were compared to those from a conventional MBR (C-MBR) operated in parallel. The results indicated that the combined MBR (S-MBR) achieved higher COD and NH₃-N removal efficiency, slower increase in membrane fouling, better sludge settleability and higher activities of the related enzymes in the activated sludge. Denaturing gradient gel electrophoresis was used to analyze the microbial community structures in the C-MBR and the S-MBR. The microbial community structure in the S-MBR was more diverse than that in the C-MBR. Additionally, the slow-growing microbes such as Saprospiraceae, Actinomyces, Frankia, Clostridium, Comamonas, Pseudomonas, Dechloromonas and Flavobacterium were enriched in the S-MBR, further accounting for the sludge reduction, membrane fouling alleviation and wastewater treatment.     

污泥基生物炭对垃圾渗滤液的吸附性能研究

以城镇污水处理厂剩余污泥为原料制备生物炭,研究了其对垃圾渗滤液中污染物吸附性能,旨在探索市政污泥综合利用方法和"以废治废"的治理技术途径。结果表明:当生物炭投加量为20 g/L时,垃圾渗滤液的COD和TP去除效果最佳,去除率分别为36.76%和78.36%,NH_4~+-N去除率随生物炭投加量增加而增加;上述三者不同污染物去除的最佳反应接触时间分别为50 min、30 min和≥2 h;生物炭对重金属离子的吸附机理主要表现为离子交换作用。     

自养脱氮污泥的亚硝化活性恢复策略

为考察自养脱氮污泥亚硝化活性快速恢复的策略,在3个反应器内分别采用不同的方法对经过长期冷冻保存后的污泥进行了恢复活性的研究.其中R1为MBR(膜生物反应器),采用低ρ(DO)(0.30 mg/L)连续流恢复策略;R2为SBR(序批式反应器),采用低ρ(DO)(0.30 mg/L)间歇流恢复策略;R3为SBR,采用低ρ(NH₄+-N)预培养-高曝气-低ρ(DO)运行三阶段的恢复策略.结果表明,R1的恢复时间为46 d,NH₄+-N氧化速率达到4.99 mg/(h·g)(以N计),最终ρ(MLSS)达到5.43 g/L;R2的恢复时间为39 d,NH₄+-N氧化速率达到4.61 mg/(h·g),最终ρ(MLSS)达到4.47 g/L;R3的恢复时间为48 d,NH₄+-N氧化速率达到5.64 mg/(h·g),最终ρ(MLSS)达到5.16 g/L. 3个反应器均能长期抑制亚硝酸盐氧化细菌的活性,使亚硝化稳定运行. 3个反应器中,R3恢复所需时间最长,但污泥活性最好; R1中的污泥活性较低,但是膜组件有效截留了污泥,达到了最高的ρ(MLSS).研究显示,通过厌氧预培养后转为膜生物反应器连续流运行的策略,可有助于污泥的极大保留及污泥活性的最大恢复.      

盐城经济技术开发区污水处理厂提标改造工程设计研究

介绍了盐城经济技术开发区污水厂提标改造工程技术路线及方案.针对污水厂进水中工业废水含量较多的特点,增设水解酸化工艺段,将现状CAST池改造为AAO生物反应池,新建二沉池及混凝沉淀设施,使出水水质稳定达到《城镇污水处理厂污染物排放标准》(GB 18918-2002)中的一级A排放标准.同时增设污泥深度脱水设施,采用化学调理+板框压滤工艺.实际运行表明,经改造后的污水处理厂对各项污染物均取得了较好的去除效果,脱水后污泥的含水率可稳定控制在60%以下.     

厌氧-准好氧联合型生物反应器填埋场产气规律的研究

通过将厌氧型生物反应器填埋场（ANBL）和准好氧矿化垃圾生物反应床（SAARB）串联,组成新型的厌氧-准好氧联合型生物反应器填埋场（AN-SABL）,研究其产气速率、产气量以及产气组分的变化规律,以期为填埋气体的收集、利用和处理提供理论依据.实验表明,AN-SABL中的厌氧填埋单元的产气受到了抑制,其中ANBL2号单元和ANBL3号单元的产气率分别为49 L.kg-1和39 L.kg-1,仅占ANBL1号的94.2%和75.0%,但提高回灌频率,能促进厌氧填埋单元的产气,其甲烷含量最大值可达到62.67%;ANBL夏季产气速率和产气量明显高于冬季,并以12 h为周期交替出现产气高峰;此外,AN-SABL能够促进其厌氧单元的硝化和反硝化作用,N2O的含量受季节和填埋场类型影响显著,其变化范围在0.001 7%～4.017 9%之间.ANBL的累积产气量在初始调整阶段呈对数增长,过渡酸化阶段呈线性增长,酸化产甲烷阶段呈指数增长.     

膜生物反应器处理甲苯性能及机制

采用膜生物反应器处理甲苯有机废气,研究了进气浓度、停留时间、循环液喷淋密度和pH值对甲苯去除率的影响.膜生物反应器能高效净化挥发性有机废气,甲苯去除率可达99%.适宜运行条件为:pH值为7.2、停留时间为6.4 s、循环液喷淋密度为2.5 m3.(m2.h)-1.采用GC-MS分析出口气样,研究结果表明乙醛酸(C2H2O3)和乙烯基甲酸(C3H4O2)为甲苯生物降解的中间产物.膜生物反应器处理甲苯机制为甲苯气体通过中空纤维膜传质到生物膜,被生物降解为乙醛酸和乙烯基甲酸,然后继续好氧降解为最终产物二氧化碳和水.     

光催化降解渗滤液DOM不同组分的相对分子质量变化特征

采用凝胶色谱技术研究了光催化氧化处理过程中垃圾渗滤液DOM 6种组分的分子质量变化规律.结果表明,垃圾渗滤液DOM的相对分子质量大多在104以下,平均在104以上的大分子物质主要是HIB和HIN,仅占渗滤液DOM总量的20%左右.其余组分大多位于(1～10)×103之间,低于500的组分含量很少.说明垃圾渗滤液DOM是以中等相对分子质量的黄腐酸类物质为主,难以生物降解.光催化处理过程中渗滤液DOM的相对分子质量分布范围逐渐变宽,多分散系数D逐渐增大.HOB、HIB、HIA以及HON组分在光催化处理后,相对分子质量显著减小;其中HOB减小最为明显,由初始的(4～25)×103,减小为72 h的(0.4～1)×103之间.而HOA和HIN组分的相对分子质量呈增加趋势,其中HOA增加最为明显,在垃圾原液中分布于(2～20)×103,在72 h光催化处理液中位于(20～50)×103之间.随着处理时间延长,DOM各组分的RID信号均降低,说明其浓度下降.整体上看,渗滤液DOM各组分均发生了明显光催化转化.     

生活垃圾填埋过程含水率变化研究

为分析垃圾在好氧和厌氧条件下降解过程中含水率变化的规律,采用时域反射测量(time domain reflectometry,TDR)技术监测了垃圾填埋过程中含水率的变化情况.结果表明,填埋过程中垃圾体积含水率随时间逐渐增大,垃圾持水性能不断提高.好氧初期垃圾内水量变化与含水率变化正相关,好氧后期则为负相关;厌氧填埋过程中,垃圾沉降压缩是含水率变化的主要原因.垃圾TDR读数与基于物质衡算的垃圾体积含水率计算值之间有较好的相关性,好氧填埋过程两者最大偏差约为±5%,厌氧填埋过程两者最大偏差约为±2%,TDR技术适用于实际填埋工程的含水率测量.     

Quantitative analysis of microbial biomass yield in aerobic bioreactor

We have studied the integrated model of reaction rate equations with thermal energy balance in aerobic bioreactor for food waste decomposition and showed that the integrated model has the capability both of monitoring microbial activity in real time and of analyzing biodegradation kinetics and thermal-hydrodynamic properties. On the other hand, concerning microbial metabolism, it was known that balancing catabolic reactions with anabolic reactions in terms of energy and electron flow provides stoichiometric metabolic reactions and enables the estimation of microbial biomass yield (stoichiometric reaction model). We have studied a method for estimating real-time microbial biomass yield in the bioreactor during food waste decomposition by combining the integrated model with the stoichiometric reaction model. As a result, it was found that the time course of microbial biomass yield in the bioreactor during decomposition can be evaluated using the operational data of the bioreactor (weight of input food waste and bed temperature) by the combined model. The combined model can be applied to manage a food waste decomposition not only for controlling system operation to keep microbial activity stable, but also for producing value–added products such as compost on optimum condition.     

城市生活垃圾和污泥填埋场的恶臭污染问题及其控制对策探讨

本文在分析城市生活垃圾和污泥填埋场产生恶臭物质的种类与污染特点和当前恶臭污染治理的方法基础上,针对我国目前填埋场恶臭治理过程中存在的各种问题提出了综合治理思路和方向。