袋式除尘器进气均布板结构参数对气流分布的影响分析

针对袋式除尘器的进气均布板主要结构参数对气流分布影响的问题,采用正交试验方法进行CFD模拟试验设计,并以气流速度相对均方根σ值作为气流均匀性的评价指标。研究结果给出了σ与板数n、板长L、挡板上端距灰斗顶部截面高度ΔH、挡板前后偏角θ及过滤风速v之间的函数关系式。表明适当增加n、增大ΔH和θ、减小L、降低v,可以提高进气流分布均匀程度,影响进气均匀分布程度的排序为L>θ>n>ΔH>ΔL。     

厌氧生物滴滤法脱除冷煤气中硫化氢的研究

水煤气中硫化氢在燃烧时会转变成二氧化硫,对环境产生污染。文章采用厌氧生物滴滤塔法对冷煤气进行脱硫处理。因煤气对氧的严格限制,通过设计生物滴滤塔,经挂膜驯化后在厌氧条件下对浓度在1~5 g/m3左右的硫化氢进行脱除处理,考察滴滤塔运行条件对脱除效果的影响。结果表明,生物挂膜25 d后,生物滴滤塔达到稳定,喷淋液pH值为2.23,ORP值为283 mV,溶解氧为0.4 mg/L,对溶液中硫离子氧化效率达到94%。滴滤塔在液气比0.15,空塔气速0.088 m/s,pH值5.0~7.0,填料高度为82 cm,塔温为25~30℃左右时,达到较优的运行条件,此时该滴滤塔对以CO、CO2、H2和1 940 mg/m3H2S组成的模拟水煤气的脱硫效率达91.2%。     

某海洋平台上海水篮式过滤器事故分析

目的研究分析东海某一海上平台海水用篮式过滤器发生的腐蚀和堵塞事故原因。方法从海洋平台海水系统用篮式过滤器的原理、工艺流程、材料选择、滤网精度,滤芯设计、人工操作等多方面进行分析。结果受内压滤芯结构要优于受外压滤芯结构,如果过滤精度选择过高,会增加压差,造成滤芯堵塞。结论篮式过滤器滤芯单元应采用多滤芯的受内压结构,过滤精度应根据下游用户要求来确定。     

PPS滤料在SO2气体作用下的耐腐蚀性研究

采用气体实验法对PPS滤料在SO2气体中腐蚀失效的过程进行了研究.通过实验前后PPS滤料的机械特性、微观特征和化学结构的分析,认为PPS对SO2气体具有良好的耐腐蚀性.但是,随着SO2气体温度的升高,时间的延长及气体体积比提高,PPS 针刺毡滤料的性能有所下降,尤其是高温能加快腐蚀效果.为了延长使用寿命,应使其工作参数在限定的范围内: 在SO2体积比高于700 mL/m3时,应对烟气进行预处理使其体积比低于实验值,或者使烟气的温度控制在170 ℃以下; 如果烟气中SO2体积比超过预定值,烟气温度又高于170 ℃,则PPS针刺毡滤料连续使用时间应不超过96 h.     

Wastewater management in small- and medium-size enterprises: case studies

Wastewater management in small and medium-sized enterprises representing the chemical and food industries was investigated. The results showed that wastewater discharged from an ink-production factory was highly contaminated with organic pollutants. Anaerobic biological treatment followed by chemical coagulation using ferric chloride aided with lime proved to be very effective and produced an effluent that complied with national regulatory standard for wastewater discharge into public sewage network. Also, management of wastewater from a confectionery factory representing the food sector was carried out. Aerobic biological treatment using plastic-packed trickling filter proved to be an effective treatment method. However, application of in-plant control measures alleviated the requirement for the construction of a wastewater treatment plant. The applied pollution prevention and cleaner production measures involved good housekeeping, recovery of spent chocolate, modification of floor cleaning and installation of suction devices for the removal of sugar and starch powders. All improvement measures were documented by cost/benefit analysis.     

Performance of a novel vertical-flow settler: a comparative study

By increasing particle concentration and G value （root-mean-square velocity gradient） to enhance flocculation, a novel vertical-flow settler was designed to increase sedimentation effectiveness, and to simultaneously improve operational stabilization. Due to the gradual decrease in upward flow-rate of raw water, a floes blanket would form and suspend in the middle section of the settler, not at the bottom as in a conventional clarifier. Enough large floes, resulted from flocculation or fltration, would continuously settle out of the floes blanket, and simultaneously, the floes in raw water or those forming above the blanket would ceaselessly enter the floes blanket. As a result, the floes concentration in the blanket could keep a dynamic balance. The hydrodynamic shear in the blanket was improved by flow separation, which was induced by the abrupt change in flow channel. Due to the floes blanket and improved hydrodynamic shear, flocculation would be enhanced, which was helpful for removing fine particles in raw water. A comparative study showed that the novel vertical-flow settler had a much better performance in the removal of the particles in raw water than a conventional one, when they treated kaolin suspensions of different concentrations （500, 100 and 50 mg/L, respectively） coagulated by polyaluminum chloride（PAC1） at the up-flow rates of 1 and 2 mm/s, respectively.     

Concentrations of inorganic elements in 20 municipal waters in Sweden before and after treatment – links to human health

The water chemistry of 20 municipal water treatment plants in southern Sweden, representing various bedrock situations, and water qualities, were investigated. Four water samples, raw and treated, were collected from each plant and analyzed by predominantly ICP-OES and ICP-MS at four occasions from June to December, 2001. The concentrations of Ca, Mg, K, Na, HCO₃ and a number of micronutrients, varied considerably in treated waters from the studied plants (ranges; Ca: 9.1–53.7 mg L⁻¹, Mg: 1.4–10.9 mg L⁻¹, K: 1.1–4.8 mg L⁻¹, Na; 5.4–75.6 mg L⁻¹, HCO₃: 27–217 mg L⁻¹). The elimination of Fe and Mn from raw water was efficient in all treatments investigated, giving concentrations in treated waters below the detection limits at some plants. Softening filters gave waters with Ca-concentrations comparable to the softest waters in this study. Adjustment of pH by use of chemicals like lye, soda or lime, modified the consumer water composition significantly, besides raising the pH. It was estimated that drinking water contributed to approximately 2.2–13% of the daily Ca uptake, if the gastrointestinal uptake efficiency from food and water was estimated to be around 50%. The corresponding figures for Mg was 1.0–7% and for F 0–59%. None of the studied elements showed any significant time trends in raw or treated waters during the follow-up period. The concentrations of potentially toxic metals such as Al, Pb and U were low and did not indicate risks for adverse health effects (ranges; Al: 0.5–2.3 μg L⁻¹, Pb: 0–0.3 μg L⁻¹, U: 0.2.5 μg L⁻¹).     

新型聚乙烯填料生物滴滤床净化硫化氢气体的启动研究

研究了新型高密度聚乙烯改良型拉西环填料生物滴滤床净化硫化氢气体的启动过程,重点比较了启动过程中不同的挂膜方式对启动时间及效能的影响.结果表明,采用液相连续流强化挂膜法成膜时间短,在环境温度20～28℃时7 d可以挂膜成功.在启动过程中,随着工艺参数的突然改变(GRT缩短)和入口浓度波动,液相连续流强化挂膜后反应器的硫化氢去除率更稳定.在进气浓度最高为343 mg/m³时硫化氢去除率稳定在95%以上.试验过程中还发现,将SO₄^2-浓度作为活性污泥驯化完成的监测指标、液相S^2-去除率作为挂膜完成的监测指标更合理.启动结束后,通过2种途径减去喷淋液中的碳源并未影响硫化氢的去除率,这进一步表明生物滴滤床中硫化氢的净化主要由自养菌完成.     

造纸中段废水与生活污水合并深度处理工艺

采用水解酸化 CAST 混凝 复合滤池与水解酸化 接触氧化 混凝 复合滤池2种组合工艺对造纸中段废水与生活污水进行合并处理对照试验.结果表明,两种工艺都是切实可行的,二级出水均可达到<污水综合排放标准>(GB8978-1996)二级标准,深度处理出水可达中水水质要求.其中以水解酸化 CAST 混凝 复合滤池组合工艺效果最好.     

鱼体甲基汞的萃取富集和测定

研究了苯萃取和半胱氨酸滤纸富集再用苯洗脱的方法,使鱼肉中甲基汞得到富集和提取。建立了气相色谱测定甲基汞的方法并对所建立的方法进行评价。结果表明:加标回收率为87.10%～105.69%;变异系数为2.93%。符合要求,大量样品实验表明,该方法适用于痕量甲基汞的提取和分析。