垃圾衍生燃料两段式化学链气化特性

提出了一种两段式化学链反应方式,并以Fe₂O₃为载氧体对生活垃圾衍生燃料（Refuse-Derived Fuel RDF）的化学链气化开展试验研究,分析了反应温度、载氧体含量、CaO的添加对载氧体气化性能的影响.结果表明,载氧体可以显著提高产气率,气化过程中产气率、碳转化率等均随着温度的升高而增大;随着载氧体含量的增加,CO、H₂的含量先增大后减小,在850 ℃、Fe₂O₃/C=0.15（物质的量比）时,含量最高.CaO的加入更进一步促进了焦油的裂解,提升产气率的同时,也起到了吸收CO₂的作用,改善了合成气的品质.通过X射线衍射（XRD）对反应后载氧体的组分进行了分析,结果发现,随着温度的提高,载氧体的释氧能力逐渐增强,850 ℃时,载氧体反应后被还原为FeO.     

阳离子型聚丙烯酰胺絮凝剂的开发与煤气化黑水处理

煤气化过程产生的黑水通常采用絮凝处理去除悬浮物及部分有机物后循环使用。以丙烯酰氧乙基三甲基氯化铵为阳离子单体,以氧化还原类和偶氮类引发剂为复合引发剂,采用水溶液自由基共聚法制备了一种适用于黑水絮凝处理的阳离子型聚丙烯酰胺。实验结果表明：引发温度为15~20 ℃时,聚合反应较为平稳,1 h后聚合反应结束,于60~80 ℃干燥,得到产品相对分子质量较高,达（734~1 086）×10⁴;采用该絮凝剂絮凝处理黑水时,絮体大、沉降速率快,絮凝沉降效果佳;在煤气化装置黑水工况温度下,絮凝剂投加量为3 mg/L时,黑水中悬浮物质量浓度可从114 mg/L降至30 mg/L以下,满足现场使用要求。     

焦炉煤气的净化和有效利用途径

随着我国钢铁工业的发展，焦化行业进入到一个大发展时期。大量焦炉煤气的产生，为焦炉煤气的合理开发利用提出了新的课题。焦炉煤气的有效利用可产生巨大的经济效益，并且可避免环境污染和二次能源的浪费。     

Enhanced anaerobic biodegradability of real coal gasification wastewater with methanol addition

Coal gasification effluent is a typical refractory industrial wastewater with a very poor anaerobic biodegradability due to its toxicity.Methanol was introduced to improve anaerobic biodegradability of real coal gasification wastewater,and the effect of methanol addition on the performance was investigated in a mesophilic upflow anaerobic sludge bed reactor with a hydraulic retention time of 24 hr.Experimental results indicated that anaerobic treatment of coal gasification wastewater was feasible with the addition of methanol.The corresponding maximum COD and phenol removal rates were 71% and 75%,respectively,with methanol concentration of 500 mg COD/L for a total organic loading rate of 3.5 kg COD/(m3 ·day) and a phenol loading rate of 0.6 kg/(m3 ·day).The phenol removal rate was not improved with a higher methanol concentration of 1000 mg COD/L.Substrate utilization rate (SUR) tests indicated that the SURs of phenol were 106,132,and 83 mg phenol/(g VSS·day) at methanol concentrations of 250,500,and 1000 mg COD/L,respectively,and only 45 mg phenol/(g VSS·day) in the control reactor.The presence of methanol could reduce the toxicity of coal gasification wastewater and increase the biodegradation of phenolic compounds.     

垃圾热化学转化利用过程中碳排放的两种计算方法

为了明确城市生活垃圾焚烧和热解两种热化学方式处理过程中温室气体的排放量(简称"碳排放"或GHG),分别采用生命周期评价方法(LCA)和政府间气候变化专门委员会(IPCC)制定的2006国家温室气体排放清单指南(简称"IPCC2006指南")进行了核算,并计算了两种垃圾热化学处理方式相对于填埋处理的GHG减排量.结果表明,两种核算方法计算所得的不同垃圾处理方式的碳排放趋势基本一致,但基于IPCC2006指南计算出的GHG减排量高于LCA方法的计算结果.相对填埋处理而言,焚烧处理的GHG减排量从LCA法的597～660kg(以CO2当量计,下同)提高到IPCC2006指南法的648～747kg;垃圾热解发电的GHG减排量从LCA法的535kg提高到IPCC2006指南法的589kg.同时,对这两种核算方法的特点及在我国的适用性进行了分析,研究认为LCA法和IPCC2006指南可以结合使用以促进我国GHG核算机制的完善.     

煤炭气化常压高温蒸汽锅炉的测试与分析

以洗浴行业为例,通过对煤炭气化高温蒸汽锅炉的节能、环保及安全指标的测试与分析,表明这种新型的锅炉可以在常压下产生150℃的高温蒸汽,在燃烧未经洗选的散煤的情况下,其排放的SO2和烟尘都达到国家一级排放标准,锅炉平均热效率可达78.05%,比同类大烟煤锅炉节省约30%,比型煤锅炉节省约50%,比燃油锅炉、燃气锅炉、电锅炉节省60%以上。     

Inhibition and recovery of nitrification in treating real coal gasification wastewater with moving bed biofilm reactor

Moving bed biofilm reactor (MBBR) was used to treat real coal gasification wastewater. Nitrification of the MBBR was inhibited almost completely during start-up period. Sudden increase of influent total NH3 concentration was the main factor inducing nitrification inhibition. Increasing DO concentration in the bulk liquid (from 2 to 3 mg/L) had little e ect on nitrification recovery. Nitrification of the MBBR recovered partially by the addition of nitrifying sludge into the reactor and almost ceased within 5 days. Nitrification ratio of the MBBR achieved 65% within 12 days by increasing dilute ratio of the influent wastewater with tap water. The ratio of nitrification decreased to 25% when influent COD concentration increased from 650 to 1000 mg/L after nitrification recovery and recovered 70% for another 4 days.     

Inhibitory effect of high phenol concentration in treating coal gasification wastewater in anaerobic biofilter

In this paper, the inhibition of methanogens by phenol in coal gasification wastewater(CGW)was investigated by both anaerobic toxicity tests and a lab-scale anaerobic biofilter reactor(AF). The anaerobic toxicity tests indicated that keeping the phenol concentration in the influent under 280 mg/L could maintain the methanogenic activity. In the AF treating CGW,the result showed that adding glucose solution as co-substrate could be beneficial for the quick start-up of the reactor. The effluent chemical oxygen demand(COD) and total phenol reached1200 and 100 mg/L, respectively, and the methane production rate was 175 m L CH4/g COD/day.However, if the concentration of phenol was increased, the inhibition of anaerobic micro-organisms was irreversible. The threshold of total phenol for AF operation was 200–250 mg/L. The extracellular polymeric substances(EPS) and particle size distribution of anaerobic granular sludge in the different stages were also examined, and the results indicated that the influence of toxicity in the system was more serious than its effect on flocculation of EPS. Moreover, the proportion of small size anaerobic granular sludge gradually increased from10.2% to 34.6%. The results of high through-put sequencing indicated that the abundance of the Chloroflexi and Planctomycetes was inhibited by the toxicity of the CGW, and some shifts in the microbial community were observed at different stages.     

白云石的硫化氢高温脱除性能研究

用天然白云石制备了半焙烧白云石和全焙烧白云石，并在固定床上对这些白云石进行硫化氢的高温脱除性能研究，同时考察了反应温度、空速、粒子粒径对白云石脱硫性能的影响。用X射线衍射（XRD）、热重分析（TG）和气体吸附等测试手段，对脱硫剂的物相组成、结构、比表面积和孔容进行了表征。结果表明，白云石是一种很好的吸硫剂。在同样条件下，3种白云石中半焙烧白云石具有最好的脱硫效果；而对于同一种白云石，反应条件的差异也会导致其脱硫效果的变化。白云石的脱硫性能与其微观结构有密切关系。