电路板环境应力筛选方法效能分析

论述了对设计、工艺成熟电路板组件的环境应力筛选方法,对比恒定高温、温度循环、温度冲击、振动及其组合筛选的筛选度,并进行效能比分析。通过对比各种应力对有较大共性的电路板组件筛选的分析,对GJB 1032进行适当裁减,提出了不少于10个温度循环加随机振动的筛选组合,以适应电路板板级筛选要求,提高效能比。     

蛭石吸附及解吸锌离子特性研究

用蛭石对锌离子的吸附解吸进行了实验研究,初步探讨了其对锌离子吸附解吸的机理。研究结果表明：蛭石对Zn^2＋具有较强的吸附能力,吸附在8h左右接近平衡。随着锌离子浓度的增加,蛭石的吸附量也在逐渐增加,当锌离子浓度达到400mg／L时,吸附量趋于平稳。在完成吸附实验的基础上,分别采用过滤和取上清液的方法解吸,实验证明静置平衡后,取出上清液50ml,再加入50ml解吸剂的方法解吸效果较好;解吸时间在0h到12h,蛭石的解吸量呈现递增的趋势,且达到1．070mg／g;在12h到48h内,解吸量基本没有增加,其中在24h时达到最大解吸量1．074mg／g。不同的解吸剂对蛭石解吸锌离子影响效果不同：蒸馏水不能使锌离子解吸;K^＋的影响作用相对于Na^＋更明显,随着两种阳离子浓度的增加,蛭石的解吸量逐渐增加。     

天然沸石吸附低浓度氨氮废水的研究

采用浙江某地天然沸石吸附废水中低浓度氨氮,研究了pH、天然沸石投加量对吸附的影响,分析了吸附等温线和吸附动力学,并进行了动态吸附和脱附研究。结果表明,pH对天然沸石吸附有较大影响,吸附的最佳pH为8.0;随着天然沸石投加量的增加,氨氮的去除率逐渐增大,但吸附量随之减小。Freundlich方程比Langmuir方程更好地描述氨氮在天然沸石上的吸附行为,且此吸附是优惠吸附。假二级方程很好地拟合吸附动力学实验数据,吸附速率常数k2随着天然沸石投加量的增大而增大。装填105g天然沸石吸附柱处理含氨氮20mg/L废水的水量为15L,出水氨氮浓度小于5mg/L。用含氯化钠和氢氧化钠的溶液作为脱附剂,脱附率为95.5%。     

Enhanced and irreversible sorption of pesticide pyrimethanil by soil amended with biochars

Biochar derived from partial combustion of vegetation is ubiquitous and potentially effective in sequestration of environmental contaminants.Biochars were prepared by burning of red gum(Eucalyptus spp.) woodchips at 450 and 850°C(labeled as BC450 and BC850).These two biochars were found to possess markedly different properties in terms of surface area and porosity.Short-term equilibration tests(24 hr) were conducted to assess the sorption-desorption behavior of pyrimethanil in the soil amended with various amounts of biochar of each type,with a special focus on the desorption behavior of the sorbed pesticide through four times successive desorption by dilution.Sorption coefficient and isotherm nonlinearity of the amended soils progressively increased with the content of biochar in the soil.Biochar BC850 with higher surface area and microporosity showed a stronger effect on the reversibility of sorption pesticide.The soils amended with 5% BC450 and 1% BC850 had nearly the same sorption capacity for pyrimethanil;however,their desorption processes were very different with 13.65% and 1.49% of the sorbed pesticide being released,respectively.This study suggested that biochar in soil could be an important factor for immobilization of a pesticide and thus affecting its environment fate in soil.     

Thermal stabilization of chromium slag by sewage sludge: Effects of sludge quantity and temperature

To investigate the feasibility of detoxifying chromium slag by sewage sludge,synthetic chromium slag containing 3% of Cr(VI) was mixed with sewage sludge followed by thermal treatment in nitrogen gas for stabilizing chromium.The effects of slag to sludge ratio(0.5,1 and 2) and temperature(200,300,500,700 and 900°C) on treatment efficiency were investigated.During the mixing process before thermal treatment,59.8%-99.7% of Cr(VI) was reduced,but Cr could be easily leached from the reduction product.Increasing heating temperature and decreasing slag to sludge ratio strengthened the reduction and stabilization of Cr(VI).When the slag to sludge ratio was 0.5 and thermal treatment temperature was 300°C,the total leached Cr and Cr(VI) declined to 0.55 mg/L and 0.17 mg/L respectively,and 45.5% of Cr in the thermally treated residue existed as residual fraction.A two-stage mechanism was proposed for the reduction and stabilization of Cr.     

苯噻草胺在土壤中的吸附与解吸行为研究

采用批量平衡实验方法,研究了除草剂苯噻草胺在5种不同性质土壤中的吸附与解吸行为,并探讨了土壤有机质及溶液pH值对吸附的影响.结果表明,线性方程与Freundlich方程均能较好地拟合苯噻草胺在土壤中的吸附等温线.计算得到苯噻草胺在5种土壤中的碳标化分配系数K_oc在849.5～1?818.8 L·kg^-1之间,说明土壤对苯噻草胺有较强的吸附能力.苯噻草胺在土壤中的分配系数K_d、Freundlich常数K_f以及K_f(1/n)与土壤有机质含量均呈显著正相关.通过过氧化氢去除有机质后,土壤对苯噻草胺的吸附大大降低,说明土壤有机质是影响苯噻草胺在土壤中吸附的主要因素.对于同种土壤而言,苯噻草胺的吸附量随pH值的增大而减小.解吸实验表明,苯噻草胺在土壤中的解吸过程具有一定的滞后性,推测其在土壤中的迁移能力较差.     

受限空间环境压力对三元锂离子电池热失控影响*

为研究三元锂离子电池在空运低压环境中的安全性,通过自主设计搭建的封闭式变压实验舱开展相关实验,对不同荷电状态（SOC）下的三元锂离子电池在不同压力环境（101,80,60,40 kPa）下的热失控特性进行研究,采集电池热失控过程中的温度以及实验舱内的压力变化,并对热失控后实验舱内的气体成分进行分析。结果表明:三元锂离子电池热稳定性随着SOC的升高而下降,常压下100%SOC的电池热失控温度可达650.8 ℃,初始环境压力越低,相同SOC的电池热失控最高温度越低。随着环境压力的降低,相同SOC的电池在热失控后会生成更多CO,且电解液占比升高。研究结果可为锂离子电池空运安全性研究提供理论依据。     

基于热线法的不同水分含量松散煤体热物性实验与模拟研究*

为解决松散煤体热物性参数的测试周期长与实验误差大等问题,构建测试装置实验平台,结合交叉热线法和平行热线法,对松散煤体热物性参数进行准确测量与计算,对1～2 mm,0.5～0.6 mm和0.2～0.3 mm 3种不同粒径煤样在不同水分含量下的热物性参数的变化规律进行研究,利用Fluent数值模拟软件对松散煤体温度场进行模拟研究,并对比模拟结果与实验结果的差异性。结果表明:在所测粒径范围里,同等水分含量下的松散煤体粒径越大,导热系数越小,热扩散率与比热容越大;松散煤体的导热系数随水分含量的增加而增加,但增加趋势渐缓;松散煤体的热扩散率随着水分含量的增加而增大,当水分含量达到11.73～13.88%后热扩散率开始逐渐下降,而比热容随着水分含量的增加逐渐增大。     

加氢站用45 MPa高压储氢瓶式容器火烧试验模拟*

为研究加氢站用高压储氢容器在火灾下的安全性能,采用计算流体力学（CFD）方法对45 MPa高压储氢瓶式容器火烧试验过程进行模拟研究,结合气瓶火烧试验,分析高压储氢容器火灾下的热响应过程,研究不同因素对储氢容器压力泄放装置动作时间的影响。结果表明:613 s以内试验压力与模拟数据的最大相对误差为3.9%,模型误差在可接受范围;不同充装介质对安全泄放装置动作时间影响不大;不同充装压力对容器内介质压升速率影响较大,充装水平较高时压力泄放装置更快动作,较低的充装压力下容器内介质温升较快;不同环境温度对介质温升影响较小。     

Use of artificial roughness for performance enhancement of solar air heaters—a review

The performance characteristics of a solar air heater can effectively be improved by providing artificial roughness in the form of protrusions and dimples of various shapes, sizes, and orientations on the underside of heated surface. An extensive literature review on artificial roughness elements has been carried and the correlations developed for heat transfer and friction factor for roughened solar air collector have been discussed and presented in this paper. The performance parameter has also been computed and compared with various kinds and shapes of roughness geometries using correlations developed by various investigators. The optimum values of the roughness parameters obtained by several investigators have also been discussed.