煤气脱硫废料综合利用新工艺

针对煤气脱硫废料（简称废料）的成分（硫、碳、萘及少量其他有机物），提出了一种处理废料的新工艺，先用乙酸乙酯提取废料中的萘和少量其他有机物，再用复合溶剂B加热溶解废料，热过滤得碳粉，最后将溶液冷却结晶分离出硫。实验结果表明：在乙酸乙酯与废料的质量比（R1）为3.75，提取温度为60℃，提取时间为4h的条件下，萘回收率为98%，纯度大于等于70%，在复合溶剂B与提取剩余物的质量比（R2）为2.69，过滤温度为100℃的条件下，硫回收率接近100%，纯度大于等于99%，碳回收率和纯度为100%。     

Experimental investigation of the performance of modified expanded graphite powder doped with zinc borate in extinguishing sodium fires

Sodium is the main cooling medium in the circuit of fourth-generation nuclear reactors, and its leakage constitutes a severe fire hazard because of its high chemical activity. In this study, expandable graphite (EG), which is a traditional sodium fire-extinguishing agent, was modified with zinc borate (ZB) as an intercalator, and the modified EG_ZB was characterized. Moreover, the effectiveness of the modified EG_ZB in extinguishing sodium fires was tested using a self-developed fire-extinguishing experimental device. This study's results indicated that EG, EG_ZB had a smaller particle size, higher thermal stability, higher fire-extinguishing speed, and lower powder mass consumption than EG. During the fire-extinguishing process, ZnO decomposed by ZB captured free radicals and inhibited the combustion reaction. Furthermore, B₂O₃ was adsorbed on the surface of the EG layer, which strengthened covering and asphyxiation. The findings of this study provide crucial information for effectively controlling fires caused by active metals and metallo-organic compounds.     

微生物光电还原CO2合成乙酸对外电压的响应机制

以TiO₂光阳极结合自养型生物阴极,构建双室微生物光电合成（MPES）系统,以光能作为主要的能量来源,探究MPES还原CO₂合成乙酸的性能及其限制因素.结果表明,光阳极取代纯电化学阳极显著降低了MPES生物阴极对外电压的需求.MPES能持续稳定运行,平均产乙酸速率为（1.18 ±0.11） mmol/（L·d）,法拉第效率为45.75%±3.97%.光阳极驱动阴极产生氢气,推测阴极微生物倾向于利用氢转移的方式来进行电子传递.外加电压通过影响光阳极的给电子能力从而对MPES的性能产生显著的影响,当外电压从0.4V升高至0.6V时,MPES的电流,乙酸产量和法拉第效率都显著提高,系统的性能主要受限于阳极.当外电压高于0.6V,系统电流,乙酸产量的增速减缓,法拉第效率在外加电压0.8V时达到最大值,随后下降,表明生物阴极的得电子能力已经达到饱和,此时MPES的性能主要受限于阴极.作为电子传递中间体,H₂的不完全利用是法拉第效率没有随着外电压的增加进一步提升的原因.     

不同类型填料的三维电极/Fenton试剂法处理苯酚废水

采用不同类型填料对三维电极/Fenton试剂法处理苯酚模拟废水进行研究.结果表明.不同类型活性炭填料对苯酚去除率有很大影响,粒炭不适合做粒子电极,采用5.0 mm柱炭处理效果较好;采用石英砂与活性炭混合填料的处理效果比单一活性炭填料好,但苯酚去除率提高不明显;电解槽反应器中按比例投加涂膜活性炭和活性炭混合填料能明显提高苯酚去除率;当涂膜活性炭与活性炭体积比为1,2时,苯酚去除率最高,达96.8%.     

Na_2CO_3对回填材料膨润土的改型效果分析

以新疆柯尔碱膨润土为原料,加入不同比例的Na2CO3改型剂,研究改型剂添加对膨润土胶质价、膨胀容和pH值的影响。另外,考虑到压实膨润土的非饱和渗透特性对于评价缓冲回填材料性能具有重要意义,故采用压力膜仪测量压实Na2CO3改型膨润土和原土的土水特征曲线,分析研究二者基质吸力随体积含水率变化的相关关系。实验结果显示,添加Na2CO3改型剂可以增大膨润土的胶质价、膨胀容和pH值,成功地将膨润土中的钙蒙脱石转化为钠蒙脱石,其对柯尔碱膨润土pH值的作用效果满足地质处置库对缓冲回填材料的要求;改型后膨润土的持水能力明显大于原土。     

COD组分分析的实验条件及结果可靠性分析

本研究尝试用SF(OURmax/OURen)代替S(0)/X(0)来作为呼吸法确定COD组分最优实验条件的参数,从而简化测量过程且可实现自动化操作.另外由生长消耗COD与生物量的比值来判断测量结果的可靠性.结果表明,获得可靠的RBCOD组分分析结果的实验条件为:1对于易生物降解含量较高的水质(如由乙酸钠配制的污水),SF在2.8~5.3范围内,生长消耗COD与生物量比值在30%以内;2对于易生物降解和难生物降解物质适中的水质(如典型生活污水),SF应在5.8~6.4左右,生长消耗COD与生物量比值在30%以内;3而对于含有大量难生物降解物质的工业废水(垃圾渗滤液),SF在15以下,且生长消耗COD与生物量的比值在40%以内.由此可见,采用呼吸法确定COD组分,其最优条件SF范围随碳源的复杂程度的上升而上升.     

针铁矿强化剩余污泥与烟草废弃物厌氧发酵的研究

以剩余污泥和烟草废弃物为研究对象,探究了针铁矿对有机物厌氧消化产甲烷的影响.针铁矿投加能提高消化产气率至359.4mL/g,显著高于空白对照组.针铁矿有助于混合气体中甲烷含量的升高并减少CO₂的体积分数.针铁矿利于剩余污泥和烟草废弃物共消化过程有机物溶出,纤维素减量,从而为产甲烷古菌提供充足的消化底物.针铁矿利于酸化代谢过程,在针铁矿投加组中挥发性脂肪酸的最大产量仅为56.2mg/g,显著低于空白组,此外针铁矿促进丙酸的合成.针铁矿促进乙酸降解,在消化第1d,针铁矿投加实验组中乙酸降解率高达65.5%,较高于空白组中的56.6%.酶活性分析表明针铁矿促进水解,酸化及产甲烷过程关键酶.Methanothrix和Methanobacterium是产甲烷阶段重要微生物,454高通量测序表明针铁矿提高Methanothrix和Methanobacterium的相对丰度至59.6%和23.5%,显著高于空白对照组.     

Female sex pheromone of Ostrinia orientalis – throwing a light on the relationship between O. orientalis and the European corn borer, O. nubilalis

Summary. The sex pheromone of Ostrinia orientalis (Lepidoptera: Crambidae) was analyzed by gas chromatography–electroantennographic detection (GC–EAD), GC–mass spectrometry and a series of bioassays. Three EAD-active compounds were detected in the female sex pheromone gland extract, and identified as tetradecyl acetate (14:OAc), (Z)-11-tetradecenyl acetate (Z11-14:OAc) and (E)-11-tetradecenyl acetate (E11-14:OAc). The titers (ratio) of 14:OAc, Z11-14:OAc and E11-14:OAc in 3-day-old virgin females were 0.49 ng (10), 4.86 ng (98) and 0.10 ng (2), respectively. In a wind-tunnel bioassay, the 98:2 blend of Z11- and E11-14:OAc, but not Z11-14:OAc alone, elicited the same male behavioral responses as virgin females and crude gland extracts. 14:OAc was inactive by itself, and did not show any synergistic effect on the binary blend. Field trapping experiments also confirmed the attractiveness of the binary blend to O. orientalis males. Based on these results, we concluded that the sex pheromone of O. orientalis is a 98:2 mixture of Z11-14:OAc and E11-14:OAc. This sex pheromone is very similar to that of the Z-type European corn borer, O. nubilalis. The present finding raises the question of whether O. orientalis , which is indistinguishable from O. nubilalis based on external morphology, is a biologically distinct species independent from O. nubilalis.     

煤燃烧过程中有机钙固氟效果研究

选择醋酸钙镁、醋酸钙2种有机钙为固氟剂,在固定床管式炉上对它们的固氟效果进行了初步研究,并分析了粒径、温度、钙硫比等对试验结果的影响.通过与传统固氟剂碳酸钙的固氟效果进行比较发现:在相同实验条件下,这2种有机钙具有良好的固氟效果,高温阶段效果更加明显,温度为1 000～1 100℃时,醋酸钙镁的固氟率是碳酸钙的1.68～1.74倍,醋酸钙的固氟率为碳酸钙的1.28～1.37倍.     

氯化钠/纳米疏水二氧化硅超细干粉制备及灭火性能研究

选用氯化钠为基体制备金属火灾超细干粉灭火剂。应用反溶剂法对其改性,使纳米疏水二氧化硅吸附在氯化钠晶体表面,其中分散剂为PEG-1000。结果表明,纳米疏水二氧化硅的添加有利于细化氯化钠颗粒,但过量的添加会起反作用,最佳用量为3 wt%左右,平均粒径为2.18μm。镁片灭火实验证明超细复合干粉的灭火性能明显好于传统氯化钠灭火剂(商用D类灭火剂),纳米疏水二氧化硅最佳添加量为3 wt%,此时灭火时间仅需传统灭火剂的一半。最后利用FDS5.0模拟干粉颗粒与燃烧火焰作用过程,模拟结果表明干粉覆盖对火焰具有一定的抑制效果,并分析了复合干粉灭火机理。