Combustion performance and emission characteristics on HCCI engine of waste plastic pyrolysis oil biodiesel blends with external PFI and vaporiser

ABSTRACT

Analysis of plastic oil obtained from waste plastic through pyrolysis process, as an alternative to biodiesel is presented in this paper. The HCCI engine is considered for experimental validation of combustion performance and emission characteristics. To accumulate pyrolysis oil as fuel, the design modifications were made in external mixture formation on the existing computerised 4-stroke, single cylinder, water cooled, direct injection kirloskar diesel engine connected with eddy current dynamometer to satisfy HCCI conditions. HCCI engine can be worked on wide assortment of fuels beginning from diesel to different blends (WPPO 5%,10%,15% and 20% by volume) of biodiesel .The designed additional device connected to the engine is utilised for fuel vaporisation and mixture arrangement. In the experimental study, the combustion results were initiate to be of 39.69 % higher Rate of Heat Release (RoHR) for biodiesel HCCI as compared with diesel HCCI. Higher brake thermal efficiency (BTE) was found 37 % without exhaust gas recirculation (EGR) at WPPO 20 % biodiesel blend. And also found 50 % and 65 % reduction in NOx emission and 18 % and 28 % reduction in smoke opacity are obtained for biodiesel vapour induction without EGR and biodiesel vapour induction with 15 % EGR as compared with diesel fuel. The CO (0.34 %), and UHC (2.15 %) emissions are increases with 15 % EGR, but the emissions are within the standard limits specified by the emissions standards.     

注水采油对中原油田生态环境的影响分析

随着近30年来中原油田高强度、大面积的石油开采，高强度注水采油和超采地下水造成的负面效应日益凸现。通过地下水位下降，地下漏斗面积增大，地面沉降，地裂缝，土壤、水体污染五个方面阐述了注水采油带来的生态环境问题，以及由此导致的对公共设施和建筑物的破坏、水土污染等严重后果。     

流动注射-氢化物发生-原子吸收法测定土壤中微量砷

用混酸消解土壤试样，用体积分数为20％的盐酸作酸介质，质量分数为1．5％的硼氢化钾作还原剂，体积分数为1％的盐酸作载液，采用流动注射-氢化物发生三-原子吸收法定量测定土壤中的微劈砷。通过实验确定，在原子化温度为920℃、土壤中共存元素含量低于5mg／kg时对测定无干扰。该方法的榆出限为0．5μg/L，线性范嘲为5～100μg/L．相对标准偏差为0．89％，平均回收率达98．99％：     

含硫低浊度采油污水絮凝处理技术的研究

中原油田明二污属含硫低浊度污水,处理后水主要用于回注。文章通过pH调节剂的优选、除硫剂优选并与絮凝药剂联合,对明二污含硫低浊度污水进行了絮凝处理。结果表明:当pH值为7.5、2#絮凝剂加量为50mg/L、有机絮凝剂加量为0.5mg/L、除硫剂加量为20mg/L时,处理后水中的悬浮物、总铁和含油量分别达到1.9mg/L、0.43mg/L和0mg/L;SRB、TGB均为102个/mL;腐蚀速率及结垢量分别降到0.062mm/a和1.9mg/L;污泥产生量降低到0.23～0.26mg/L;在90℃时的结垢量由地层水的23.3mg/L降低到1.9mg/L,处理后的水达到中原油田回注水的水质标准,并且水质稳定。     

Injection Molded Biocomposites from Soy Protein Based Bioplastic and Short Industrial Hemp Fiber

Biocomposites from soy based bioplastic and chopped industrial hemp fiber were fabricated using twin-screw extrusion and injection molding process. Soy based bioplastics were prepared through cooking with plasticizer and blending with biodegradable poly(ester amide). Mechanical, thermal properties and fracture surface morphology of the “green”/biocomposites were evaluated with universal testing system (UTS), dynamic mechanical analysis (DMA), Environmental Scanning Electron Microscopy (ESEM). It was found that the tensile strength and modulus, flexural strength and modulus, impact strength and heat deflection temperature of industrial hemp fiber reinforced biocomposites significantly improved. The fracture surfaces showed no signs of matrix on the fiber surface suggesting poor interfacial adhesion.     

在线浓缩-流动注射分光光度法测定海水中痕量的镉

本文针对海水中镉含量低、海水基体干扰严重等特点，建立了在线浓缩一流动注射分光光度法测定海水中痕量镉的新方法。优化了Cd（Ⅱ）的显色条件、浓缩条件和解吸条件，在最佳检测条件下，Cd（Ⅱ）的检出限为0．02μg/L，线性范围为0．05～2μg/L，相对标准偏差RSD为2.74％（n=g，Ccd（Ⅱ）=1μg／L）。将该方法应用于实际海水中Cd（Ⅱ）的测定。结果满意。     

新型BOD微生物传感流动注射检测仪的研制

研制采用微生物传感技术和流动分析技术来快速测定BOD的仪器。主要技术性能:测量周期为15min;误差率<5%;偏差<5%。通过对国家标准样品和不同水质污水的测试表明,其具有自动化程度高,测量周期短的优点;准确度、稳定性均达到国家标准;且具有良好的适应性。     

秸秆替代煤高炉喷吹的能源消耗及环境影响比较

以秸秆替代部分煤进行高炉喷吹,对收集、运输、破碎和喷吹等过程进行了能源消耗和环境影响的差异性比较。考虑到碱负、荷对高炉顺行的影响,秸秆在煤中的混入比最大应在10%左右。秸秆喷吹的能耗较高,与煤相比,原煤消耗量增加了1倍以上,原油消耗量增加了4倍左右。从秸秆的收集到破碎,污染物排放量都比煤高,尤其在破碎过程,各种污染物的排放量是煤的7倍左右。在高炉喷吹利用过程中,秸秆与煤的CO_2、CO和高炉渣的排放量相差不大。由于秸秆生物质的碳循环特点,冶炼1 t铁水可减少CO_2排放量23kg。根据我国排污费标准和国际CO_2排放指标交易市场价,用秸秆替代煤喷吹,生产1t铁水可降低环境成本2.23元。对于一座2 500 m³高炉,每年可减排CO_2 5.63万t,总环境成本可以降低550万元。     

基于响应面法SCR脱硝反应器喷氨格栅的优化研究

利用计算流体动力学（CFD）方法,采用k-e湍流模型和组分运输模型对SCR脱硝反应器的氨浓度场进行了数值模拟,并通过实验验证了反应器内氨浓度场数值模拟的准确性,同时,基于响应面法研究了喷氨格栅各结构参数和系统运行参数对SCR脱硝反应器内氨浓度场的影响.结果表明,喷口密度N,开孔率ψ,喷口角度α及入口风速v对氨浓度分布均匀性都存在着一定影响,其中影响的显著性为N>α>v>ψ.而且存在着一组最优的喷氨格栅结构参数和最佳的系统运行参数能够使SCR脱硝反应器内的氨浓度分布不均匀系数达到最优值.在本文研究的参数范围内,喷氨格栅最优的结构参数分别是：r=8个、d=57mm、α=90°,系统最佳的运行参数为v=8.17m/s,此时氨浓度分布不均匀系数为0.0151.     

Evidence for coupled iron and nitrate reduction in the surface waters of Jiaozhou Bay

Iron and nitrate (NO₃^?) are dominant physiologically required nutrients for phytoplankton growth, and iron may also play a key role in the marine nitrogen cycle. In this study, we investigated the temporal and spatial distributions of dissolved iron (DFe) and Fe(II) in the surface waters of Jiaozhou Bay (JZB) from April 2 to July 26, 2017. High concentrations of DFe and Fe(II) predominantly occurred in nearshore and estuarine stations and concentrations were generally higher in April and May. The highest DFe concentration was observed along the coast of Hongdao (51.55 nmol/L) in May, while the lowest concentration was observed in the western coastal region (2.88 nmol/L) in April. The highest and lowest Fe(II) concentrations were observed in the Licun estuary (22.42 nmol/L) and outer bay (0.50 nmol/L) in May, respectively. We calculated the proportions of nitrate, nitrite, and ammonium in dissolved inorganic nitrogen (DIN) as well as the ratio of Fe(II) to DFe in all four months. The mean Fe(II)/DFe ratio was 0.48 in April, 0.43 in May, 0.69 in June, and 0.32 in July. The mean ratio of NO₃^? to DIN was 0.78 in April, 0.54 in May, 0.20 in June, and 0.62 in July. NO₃^?/DIN continuously decreased in the first three months, while Fe(II)/DFe remained high, which suggests that the reduction of iron and nitrate occurred simultaneously in the surface waters of JZB.