城市污泥发酵物土地利用重金属迁移变化研究

文章针对污泥发酵物开展替代草坪基质的规模化应用,对其重金属迁移风险进行了分析,通过对重金属在纵向和横向水平上的迁移量变化进行比较的结果表明,与常规对照相比,随污泥发酵物施用量(45~75 t/hm2)提高,重金属(As、Cd、Ni、Pb、Cu、Zn)在地下纵向和地表横向水平上的迁移量无显著性增加.结果表明污泥发酵物应用于草坪基质,在短期(两年)内,由地下渗流和地表径流引起的重金属迁移量甚微,施用区域内地下水和周边土壤的环境安全性较高.     

Influences of adding easily degradable organic waste on the minimization and humification of organic matter during straw composting

To find a better composting process with low greenhouse gas emission and high humus production, the effect of adding kitchen waste on reduction and humification of organic matter during straw composting was studied. Three processes were compared, consisting of different ratios of straw and kitchen waste (1:2, 1:1, and 2:1). At four time points over a 62-d incubation, the reduction and humification of compost was evaluated by measuring the total mass, carbon content, and humic material content of the compost. Treatment 1 (straw/kitchen waste ratio of 1:2) reduced the total mass of compost the most. Treatment 2 (straw/kitchen waste ratio of 1:1) reduced the total carbon content the most, reflecting the highest emission of greenhouse gas. Treatment 3 produced the most humic acid material and released the lowest amount of carbon. Hence, from the point of view of reducing greenhouse gas emissions and increasing stable organic matter such as humus and humic acid during composting, treatment #3 was optimal. The three treatments resulted in significant differences in microbial biomass and enzyme activity during composting. The highest amount of active microbial biomass was associated with the largest reduction in compost mass (treatment 1). Higher proportions of straw (treatments 2 and 3), which contains more lignin, were associated with greater β-glycosidase activity, which may generate more humus that can improve soil quality. Dehydrogenase activity seemed to be the most important microbial factor in organic carbon catabolism or humification.     

利用污泥熟肥作为高含水率污泥堆肥调理剂

采用静态强制通风好氧堆肥的方法,以木屑作为对比,考察了利用污泥熟肥作为调理剂对污泥堆肥过程的影响。结果表明,与以木屑作为调理剂的污泥堆体(对照组)相比,以污泥熟肥作为调理剂的污泥堆体(实验组)升温快,高温阶段(>50℃)持续时间长达10 d,满足粪便无害化卫生标准的要求,而对照组仅持续了2 d;实验组腐熟的堆肥含水率从60%降到39%,下降了21%,pH维持在7.5～8.5范围内,微生物活性较强,而对照组含水率仅下降15%,pH始终低于7.5;实验组种子发芽指数(GI)在第14天就回升到80%以上,基本上去除了植物毒性,而对照组GI在第22天才回升到50%。总体而言,污泥熟肥能显著改善堆肥中微生物的微环境,促进有机物的降解,缩短堆肥腐熟时间,是一种优质的调理剂。     

城市污泥重金属钝化试验研究

研究了城市污水厂污泥好氧堆肥过程中的重金属钝化规律.由蘑菇渣、磷矿粉、鸡粪、高温菌种与城市污泥组成的试验堆体在微生物作用下快速干化.经过30天的好氧堆肥,试验堆体稳定态铬的比例达到了67~80%,稳定态铜的比例达到了31~41%,稳定态镍的比例达到了49~57%,稳定态锌的比例达到了46~55%,稳定态锰的比例达到了56~64%,污泥重金属的生物活性和毒性减少.生成的复合有机肥施用于园林绿化.图5,表2,参5.     

水分调节材料对牛粪堆肥氨气挥发的影响

利用通风式堆肥发酵方式研究了牛粪堆制过程中氨气的挥发特征和锯末、稻壳、稻草等不同水分调节材料对氨气挥发的影响。结果表明,牛粪堆制过程中主要在前期,尤其是在最初的2周内释放氨气;堆肥期间挥发的氨态氮约为牛粪总含氮量的17%～50%。不同水分调节材料都可以在一定程度上抑制氨气的挥发,但锯末抑制氨气挥发效果最好,其次是稻壳,稻草抑制氨气挥发的效果较小。因此,为了减少氮素损失,应采取适当措施抑制氨挥发或回收挥发的氨气。     

人工接种堆肥和自然堆肥微生物区系与分子多态性的变化

采用传统培养方法和PCR-DGGE技术研究了人工接种堆肥和自然堆肥微生物群落的演变过程。结果表明:(1)传统培养方法显示,两种堆肥堆制过程中微生物数量均呈“升高—降低—升高—降低”变化趋势,整个堆肥过程中细菌数量占优势。(2)DGGE图谱显示,两种堆肥不同时期存在不同的细菌种群,其条带数量亦呈“升高—降低—升高—降低”变化趋势。堆肥升温期条带丰富但优势条带不明显;堆肥高温期条带数量减少但出现优势条带,表明高温阶段以嗜热菌或耐高温菌为主;堆肥降温期条带数量再次增多;堆肥腐熟期条带数量少且无优势条带,表明腐熟阶段微生物种群数量少且代谢强度趋于平缓。(3)DGGE图谱表明,人工接种菌株成为堆肥高温期优势菌株。人工接种增加了堆肥中微生物总量,提高了堆肥微生物种群多样性,并且促进了堆肥菌群演替,从而缩短堆肥腐熟时间。     

Fate of ah receptor agonists during biological treatment of an industrial sludge containing explosives and pharmaceutical residues

GOAL, SCOPE AND BACKGROUND: Sweden is meeting prohibition for deposition of organic waste from 2005. Since 1 million tons of sludge is produced every year in Sweden and the capacity for incineration does not fill the demands, other methods of sludge management have to be introduced to a higher degree. Two biological treatment alternatives are anaerobic digestion and composting. Different oxygen concentrations result in different microbial degradation pathways and, consequently, in a different quality of the digestion or composting residue, It is therefore necessary to study sludge treatment during different oxygen regimes in order to follow both degradation of compounds and change in toxicity. In this study, an industrial sludge containing explosives and pharmaceutical residues was treated with anaerobic digestion or composting, and the change in toxicity was studied. Nitroaromatic compounds, which are the main ingredients of both pharmaceutical and explosives, are well known to cause cytotoxicity and genotoxicity. However, little data are available concerning sludge with nitroaromatics and any associated dioxin-like activity. Therefore, we studied the sludge before and after the treatments in order to detect any changes in levels of Ah receptor (AhR) agonists using two bioassays for dioxin-like compounds. METHODS: An industrial sludge was treated with anaerobic digestion or composting in small reactors in a semi-continuous manner. The same volume as the feeding volume was taken out daily and stored at -20 degrees C. Sample preparation for the bioassays was done by extraction using organic solvents, followed by clean up with silica gel or sulphuric acid, yielding two fractions. The fractions were dissolved in DMSO and tested in the bioassays. The dioxin-like activity was measured using the DR-CALUX assay with transfected H4IIE rat hepatoma pGudluc cells and an EROD induction assay with RTL-W1 rainbow trout liver cells. RESULTS AND DISCUSSION: The bioassays showed that the sludge contained AhR agonists at levels of TCDD equivalents (TEQs) higher than other sludge types in Sweden. In addition, the TEQ values for the acid resistant fractions increased considerably after anaerobic digestion, resulting in an apparent formation of acid resistant TEQs in the anaerobic reactors. Similar results have been reported from studies of fermented household waste. There was a large difference in effects between the two bioassays, with higher TEQ levels in the RTL-W1 EROD assay than in the DR-CALUX assay. This is possibly due to a more rapid metabolism in rat hepatocytes than in trout hepatocytes or to differences in sensitivities for the AhR agonists in the sludge. It was also demonstrated by GC/FID analysis that the sludge contained high concentrations of nitroaromatics. It is suggested that nitroaromatic metabolites, such as aromatic amines and nitroanilines, are possible candidates for the observed bioassay effects. It was also found that the AhR agonists in the sludge samples were volatile. CONCLUSIONS: The sludge contained fairly high concentrations of volatile AhR agonists. The increase of acid resistant AhR agonist after anaerobic digestion warrants further investigations of the chemical and toxic properties of these compounds and of the mechanisms behind this observation. RECOMMENDATION AND OUTLOOK: This study has pointed out the benefits of using different types of mechanism-specific bioassays when evaluating the change in toxicity by sludge treatment, in which measurement of dioxin-like activity can be a valuable tool. In order to study the recalcitrant properties of the compounds in the sludge using the DR-CALUX assay, the exposure time can be varied between 6 and 24 hours. The properties of the acid-resistant AhR agonists formed in the anaerobic treatment have to be investigated in order to choose the most appropriate method for sludge management.     

油泥废弃物的生物修复技术研究

本文利用正交试验 ,探讨了堆腐法处理油泥废弃物过程中调控因子 (肥料、客土、水分和 pH)的影响。结果发现 ,投加一定量的客土是影响处理效果的重要因子。通过正交试验选择和确定的最佳处理条件为 :在自然温度 >2 0℃的情况下 ,客土投加量 2 0 %、肥料 10 %、菌剂 5 %、控制水分 30 % (烘干基 )和pH 7。优化条件的建立为油泥废弃物的深度处理提供了理论依据     

堆肥法处理含油污泥研究进展

含油污泥是炼油厂和石油化工厂的日产固体废弃物 ,是当前石化行业所面临的污染问题。本文给出了近期国内外对含油污泥的处理方法 ,并对堆肥法处理含油污泥进行了综述。含油污泥的堆肥处理需提供氧气、菌种和营养 ,为保持油泥的疏松状态 ,还需加入填充剂。本文对高速生物反应器的结构、运行、调控进行了详细介绍 ,并从经济核算角度指出了其运营可行性     

农业蔬菜废物处理方法研究进展和探讨

目前我国农业蔬菜废物污染问题正日益加重 ,蔬菜废物和其他固体废物相比具有高含水率、高营养成分和基本无毒害的特性 ,适宜于单独收集处理。本文介绍了国内外蔬菜废物处理方法的研究进展 ,包括好氧堆肥法、厌氧消化法、好氧 -厌氧联合处理法 ,并对这些方法的适用条件进行了论述。同时 ,探讨了接种微生物自然堆沤法的初步研究结果