SBR工艺处理晚期垃圾渗滤液的脱氮特性研究

采用有效容积为1 200 m3的SBR反应器处理晚期垃圾渗滤液,进行生物脱氮特性研究.结果表明,通过投加粪水调节进水C/N,能显著提高SBR反应器对晚期垃圾渗滤液中氮素污染物的去除效果,其中第112~136 d的TN平均去除率高达82.62%,出水TN≤190 mg.L-1,COD≤400 mg.L-1;能在反应器内达到各种生物脱氮反应的平衡状态,BOD5与TN去除量的比值稳定在1.43左右.在稳定平衡阶段,通过对反应器内氮素污染物和SO24-的含量变化进行周期跟踪监测,发现在搅拌回流阶段存在NH4+-N和SO24-的同时等比例去除现象,去除率分别为27.06%和76.17%,反应器内存在同步硝化反硝化和同步脱氮除硫(SO24-)过程;量化分析了反应器内各种生物脱氮反应,得到异养反硝化、同步硝化反硝化、同化作用、同步脱氮除硫(SO24-)和内源呼吸反硝化对TN去除量的贡献率分别为62.6%、33.8%、7.0%、26.1%和2.7%.     

稀土/Y分子筛多相催化电解氧化深度去除渗滤液中难降解有机物

采用浸渍和焙烧法制备了以Y分子筛为载体的几种稀土催化剂,并用玻璃纤维包埋催化剂形成反应床体,构建稀土多相催化电解氧化体系,探索这一体系对垃圾渗滤液中难降解有机物的去除效果.同时,以COD值为控制指标,考察了焙烧温度、浸渍液金属离子浓度、稀土元素种类对电催化活性的影响.最后,用SEM和XRD等手段对催化剂的微观结构、表面形貌进行了表征,并与稀土/γ-Al2O3催化剂的电催化活性和结构进行了比较.结果表明,Y分子筛中引入稀土元素后没有破坏Y分子筛的晶体结构,稀土/Y分子筛催化剂的表面并没有检测到稀土氧化物的物相,稀土/γ-Al2O3催化剂的表面形成了明显的稀土氧化物衍射峰;稀土/Y分子筛催化剂的最佳制备条件为焙烧温度400℃,浸渍液中金属离子质量分数1%～3%,负载金属为铈;所制备的稀土/Y分子筛催化剂具有良好的电催化活性和稳定性,其活性高于稀土/γ-Al2O3催化剂.     

DO对高氨氮渗滤液短程生物脱氮反硝化过程动力学的影响

为考察实际高氨氮垃圾渗滤液短程生物脱氮过程DO对以NO2--N为电子受体反硝化动力学的影响,本研究采用缺氧/厌氧UASB-SBR生化系统处理实际高氨氮垃圾渗滤液,在SBR系统实现稳短程生物脱氮(120d运行)的基础上,取SBR反应器内的污泥进行pH8.0条件下不同DO浓度梯度反硝化批次试验,从而确定DO对以NO2--N为电子受体的溶解氧抑制系数(K′O)的影响.试验结果表明,DO对反硝菌的NO2--N还原活性具有明显影响,与缺氧状态相比,DO为0.4和0.6mg·L-1时,其还原活性分别降低了49.0%和16.3%左右.DO与NO2--N还原速率两者呈指数负相关.DO对NO2--N为电子受体K′O具有显著影响,存在明显的分段现象,每一DO范围内,K′O恒定.     

An autotrophic nitrogen removal process：Short-cut nitrification combined with ANAMMOX for treating diluted effluent from an UASB reactor fed by landfill leachate

A combined process consisting of a short-cut nitrification (SN) reactor and an anaerobic ammonium oxidation upflow anaerobic sludge bed (ANAMMOX) reactor was developed to treat the diluted effluent from an upflow anaerobic sludge bed (UASB) reactor treating high ammonium municipal landfill leachate.The SN process was performed in an aerated upflow sludge bed (AUSB) reactor (working volume 3.05 L),treating about 50% of the diluted raw wastewater.The ammonium removal efficiency and the ratio of NO 2 N to NOx-N in the effluent were both higher than 80%,at a maximum nitrogen loading rate of 1.47 kg/(m 3 ·day).The ANAMMOX process was performed in an UASB reactor (working volume 8.5 L),using the mix of SN reactor effluent and diluted raw wastewater at a ratio of 1:1.The ammonium and nitrite removal efficiency reached over 93% and 95%,respectively,after 70-day continuous operation,at a maximum total nitrogen loading rate of 0.91 kg/(m 3 ·day),suggesting a successful operation of the combined process.The average nitrogen loading rate of the combined system was 0.56 kg/(m 3 ·day),with an average total inorganic nitrogen removal efficiency 87%.The nitrogen in the effluent was mostly nitrate.The results provided important evidence for the possibility of applying SN-ANAMMOX after UASB reactor to treat municipal landfill leachate.     

光催化降解渗滤液DOM不同组分的相对分子质量变化特征

采用凝胶色谱技术研究了光催化氧化处理过程中垃圾渗滤液DOM 6种组分的分子质量变化规律.结果表明,垃圾渗滤液DOM的相对分子质量大多在104以下,平均在104以上的大分子物质主要是HIB和HIN,仅占渗滤液DOM总量的20%左右.其余组分大多位于(1～10)×103之间,低于500的组分含量很少.说明垃圾渗滤液DOM是以中等相对分子质量的黄腐酸类物质为主,难以生物降解.光催化处理过程中渗滤液DOM的相对分子质量分布范围逐渐变宽,多分散系数D逐渐增大.HOB、HIB、HIA以及HON组分在光催化处理后,相对分子质量显著减小;其中HOB减小最为明显,由初始的(4～25)×103,减小为72 h的(0.4～1)×103之间.而HOA和HIN组分的相对分子质量呈增加趋势,其中HOA增加最为明显,在垃圾原液中分布于(2～20)×103,在72 h光催化处理液中位于(20～50)×103之间.随着处理时间延长,DOM各组分的RID信号均降低,说明其浓度下降.整体上看,渗滤液DOM各组分均发生了明显光催化转化.     

MBR＋纳滤＋反渗透工艺处理垃圾渗滤液实验研究

摘要：结合青岛市某生活垃圾处理场工程实例,介绍了MBR工艺处理垃圾渗滤液的工艺流程、原理等,分析了MBR工艺处理垃圾渗滤液的特点和优势。垃圾渗滤液经过MBR工艺处理,生化部分采用前置反硝化／硝化工艺,再经纳滤／反渗透等膜分离技术和其他方法处理,最终流出液水质可以达到《生活垃圾填埋场污染控制标准》（GB16889—2008）。     

Ammonium-dependent regulation of aerobic methane-consuming bacteria in landfill cover soil by leachate irrigation

The impacts of landfill leachate irrigation on methane oxidation activities and methane-consuming bacteria populations were studied by incubation of landfill cover soils with leachate and (NH₄)₂SO₄ solution at different ammonium concentrations. The community structures and abundances of methane-oxidizing bacteria (MOB) and ammonia-oxidizing bacteria (AOB) were examined by PCRDGGE and real-time PCR. Compared with the pure (NH₄)₂SO₄ solution, leachate addition was found to have a positive effect on methane oxidation activity. In terms of the irrigation amount, ammonium in leachate was responsible for the actual inhibition of leachate. The extent of inhibitory effect mainly depended on its ammonium concentration. The suppression of the predominant methaneconsuming bacteria, type I MOB, was responsible for the decreased methane oxidation activity by ammonium inhibition. Methaneconsuming bacteria responded diversely in abundance to ammonium. The abundance of type I MOB decreased by fivefold; type II MOB showed stimulation response of fivefold magnification upon the first addition but lessened to be lower than the original level after the second addition; the amount of AOB was stimulated to increase for 20-30 times gradually. Accumulated nitrate from nitrification strengthened the ammonium inhibition on type I and type II MOB, as a result, repetitive irrigation was unfavorable for methane oxidation.     

厌氧序批式反应器预处理垃圾渗滤液的碳平衡研究

为初步了解垃圾渗滤液中有机物降解过程的物质和能量转化,对渗滤液实际处理工程提供借鉴,在最优工艺参数条件下,分别用处于中温(35±1)℃和常温状态的厌氧序批式反应器(ASBR)对垃圾渗滤液进行预处理。通过对反应器内的液相、气相和固相碳素进行全面的分析测定,结果表明:中温(常温)条件下,整个反应周期内约有86.4%(77.6%)的碳进入气相,约有1.7%(1.4%)的碳进入固相,其余约11.7%(22.3%)的碳仍存于液相中;其中,进入气相部分的碳有77.6%(71.3%)以甲烷形式存在,8.8%(4.7%)以二氧化碳形式存在,这说明ASBR预处理垃圾渗滤液过程中产生的甲烷资源化利用潜力较大。另外,反应器在中温状态下较常温状态处理效果更佳。     

生活垃圾焚烧厂沥滤液处理技术研究进展

生活垃圾焚烧厂沥滤液污染物浓度高,水质成分复杂,是我国污水处理领域的热点和难点之一。重点介绍了生物处理技术、膜技术、物化处理技术、蒸发处理技术及其组合工艺用于垃圾焚烧厂沥滤液处理的研究进展,对现存的问题进行了分析并提出了相应的建议。     

泥炭预处理吸附垃圾渗滤液中的COD

通过对泥炭改性去除水中COD进行了试验研究。探讨了磷酸、硫酸、盐酸、硝酸和氢氧化钠对COD去除效果的影响和吸附机理。结果表明,在酸、碱改性过程中,用5%的硫酸改性的泥炭去除COD的效果最佳,改性泥炭用量为每10 g/100 mL,吸附时间为60 min,pH为10的试验条件下,COD的去除率为68.5%以上,磷酸较硫酸次之,去除率为55%左右,而盐酸和硝酸较差分别为45%和38%,氢氧化钠为40%左右。并对其吸附机理进行了研究,其吸附等温线符合Freundlich型。通过扫描电镜观察泥炭表面的结构,硫酸改性后的泥炭表面结构比较粗糙,比表面积最大,与实验结果相吻合。用原子吸收法对泥炭处理前后的水样进行比较,表明泥炭对重金属也有很好的去除率。本研究为泥炭利用提供了可借鉴的思路。