Experimental study on explosion inhibition by heptafluoropropane and its synergy with inert gas

The inhibition effect of heptafluoropropane (CF₃CHFCF₃) on methane explosions under different inhibitor concentrations in a closed vessel was studied. A high-speed camera and a pressure sensor were adopted respectively to record flame propagation characteristics and pressure data. Results indicate that the relationship between flame propagation and pressure rising was correlated. As the equivalent ratio (ϕ)≤1, the pressure presented a trend of rising firstly and then decreasing with increasing CF₃CHFCF₃ concentration, and it was found that there existed a critical concentration for pressure decrease. As ϕ > 1, the pressure exhibited a decreasing trend. Although the pressure appeared to seemingly increase, the moment that the pressure began to rise (t_rise) and the moment that the maximum explosion overpressure appeared (t_Pmax) were obviously delayed. The average rate of pressure rise ((dP/dt)_ave) was decreased as the concentration of CF3CHFCF3 increased. It indicates that CF₃CHFCF₃ can effectively reduce the explosion reaction rate. The critical concentration of CF₃CHFCF₃ for complete inhibition was determined. Meanwhile, the synergy of CF₃CHFCF₃-inert gas can improve the inhibition effect. Compared with CF₃CHFCF₃–N₂, the synergy of CF₃CHFCF₃–CO₂ presented a better inhibition effect, and the inhibition effect was increased with increasing inert gas concentration. And the mechanisms of physical and chemical effects on explosion inhibition were analyzed.     

水平管内不同煤质煤尘爆炸火焰传播特性实验研究

为研究水平管道空间不同煤质煤尘爆炸火焰传播特性，选取褐煤、长焰煤、不粘煤、气煤4种煤尘，对爆炸火焰焰峰特性、火焰加速传播特性、火焰传播距离与持续时间展开研究。研究结果表明:褐煤在500 ms内焰峰的形状由尖锐向平滑再向钝化不断演变，长焰煤与不粘煤在375 ms时焰峰前端出现明显焰体分离现象，分析认为这与管体冷壁效应、空间尺度效应及空间氧气消耗直接相关；气煤在375 ms时焰峰出现大面积火焰碎纹，说明气煤爆炸火焰猛烈传播的持续时间相对较短，整体爆炸强度相对较弱；褐煤与长焰煤爆炸火焰存在2次间断性加速，分析认为这与管体空间受限、常温管壁散热、局部助燃氧气瞬间不足等因素有关；褐煤在爆炸后400～600 ms内火焰2次加速完全，火焰传播距离达740 mm，明显大于长焰煤、不粘煤与气煤，说明低变质褐煤爆炸火焰持续时间更长，火焰传播距离更远且传播更剧烈；虽然气煤火焰最远传播距离比长焰煤大30 mm，但由于气煤火焰在375 ms左右出现大片火焰碎纹，因此气煤整体的爆炸强度小于长焰煤。     

Large eddy simulation and experimental study of the effect of wire mesh on flame behaviours of methane/air explosions in a semi-confined pipe

Preventing the propagation of flames in a pipeline is an effective measure for avoiding gas explosion accidents and reducing losses. To evaluate the effect of wire mesh, acting as a porous media, experimental and simulation studies are conducted to determine the influence of the wire mesh on the dynamics of premixed methane/air flame propagation in a semi-closed pipe. Four different kinds of wire mesh with different numbers of layers are chosen in the experiments and simulation, and the mechanism of wire mesh quenching of the flame is investigated. The experimental and simulation results are consistent. Flames are quenched when 4 layers of 40-mesh or 3 layers of 60-mesh wire mesh are used; however, once the flame propagates through the wire mesh, the risk of methane combustion may increase. The wire mesh becomes the key factor causing flame folds and acceleration, and the greater the number of layers or the larger the mesh size is, the more obvious the folds after the flame passes through the wire mesh. Moreover, the combination of heat absorption and disruption of the continuous flame surface by the mesh causes flame quenching. Wire mesh can effectively attenuate the flame temperature during premixed flame propagation in a pipe, and the attenuated maximum rate reaches approximately 79% in the case of adding 3 layers of 60-mesh wire mesh.     

Numerical study on premixing characteristics and explosion process of starch in a vertical pipe under turbulent flow

Fire and explosion accidents are frequently caused by combustible dust, which has led to increased interest in this area of research. Although scholars have performed some research in this field, they often ignored interesting phenomena in their experiments. In this paper, we established a 2D numerical method to thoroughly investigate the particle motion and distribution before ignition. The optimal time for the corn starch dust cloud to ignite was determined in a semi-closed tube, and the characteristics of the flame propagation and temperature field were investigated after ignition inside and outside the tube. From the simulation, certain unexpected phenomena that occurred in the experiment were explained, and some suggestions were proposed for future experiments. The results from the simulation showed that 60–70 ms was the best time for the dust cloud to ignite. The local high-temperature flame clusters were caused by the agglomeration of high-temperature particles, and there were no flames near the wall of the tube due to particles gathering and attaching to the wall. Vortices formed around the nozzle, where the particle concentration was low and the flame spread slowly. During the explosion venting, particles flew out of the tube before the flame. The venting flame exhibited a “mushroom cloud” shape due to interactions with the vortex, and the flame maintained this shape as it was driven upward by the vortex.     

金属丝网对甲烷/空气预混火焰管道内传播的影响

为研究管道内金属丝网对甲烷/空气预混火焰传播的影响，通过实验和三维数值模拟研究安装金属丝网的管道内火焰传播特性以及流场、温度场的变化。结果表明:40目4层的金属丝网可以使火焰淬熄，30目4层的金属丝网无法淬熄，但可以使火焰停滞3 ms；大涡模型可以很好地对管道内火焰淬熄现象进行模拟；当火焰穿过30目4层金属丝网时，速度增大，在Kelvin Helmholtz不稳定和Rayleigh Taylor不稳定的耦合作用下形成湍流；金属丝网的目数会影响热量在丝网层中的扩散，当金属丝网为30目4层时，火焰热量扩散快，而当金属丝网为40目4层时，火焰热量扩散慢且温度大幅度衰减，衰减率达到83%。     

基于ANFIS模型的基坑工程位移反分析

在软土地基深基坑开挖支护工程的设计与施工中,岩土体力学参数的取值问题是关键。基于MATLAB(R2007a)模糊工具箱中的自适应神经模糊推理系统(ANFIS)对基坑岩土体力学参数进行了位移反演分析,并结合汉口火车站出站厅基坑工程实例,动态反演了具体参数,检验了反演精度,从而验证了该方法用于基坑工程位移反分析的可行性及工程适用性。     

上海市大气总汞季节变化特征及与气象条件的关系

2008年到2010年对上海市西南部大气中总汞(TGM———Total Gaseous Mercury)的污染水平进行监测,结果表明TGM日均浓度为ND~57.23ng/m(3(7.79±3.29)ng/m)3。TGM呈现出一定的季节性变化特征,浓度最高的是秋季,然后依次是冬季、春季、夏季,平均浓度分别为(9.30±2.48)、(8.32±2.79)、(7.78±2.33)、(2.16±3.29)ng/m3。TGM浓度受东南风向影响最大,其次为西北和东北风向。在置信水平为95%的情况下,TGM浓度与日平均温度呈正相关性,而与日温差、相对湿度、日相对湿度差、风速无显著相关性。但TGM浓度分别与日均O3浓度和NO2浓度均呈显著正相关。利用HYSPLIT_4模型对TGM浓度高值与低值几天的空气气团来源轨迹进行反演,结果发现高低浓度日的气团来源略有差别,总体上看,冬季、春季和秋季受北方气团影响较大,夏季则受我国东部海域影响,具体的局部和长距离输送的贡献需要进一步研究。     

浅海跃层底质对水下声的影响研究

本文针对海底底质对水下噪声传播具有显著影响的现象,选取典型负梯度温度跃层,加载三个典型海底底质,即细砂底质、粉砂底质及黏土-粉砂底质,声波参数为固定值。试验定性分析了浅海海底底质对水下声传播的影响,仿真计算了海底底质对声传播的影响,比较分析了不同底质条件下声波的衰减差异,总结了不同底质对水下声传播影响的特点,并同行参考。     

南京市夏季大气气溶胶新粒子生成事件分析

研究了南京市夏季大气气溶胶数浓度的基本特征和气溶胶新粒子生成事件的形成条件及其影响因子.应用宽范围颗粒粒径谱仪(WPS)和双光路差分吸收光谱仪(DOAS)对南京市2010年7月大气气溶胶数浓度谱分布和污染气体(O3、SO2和NO2)进行了观测,并结合气象要素观测数据和后向轨迹模式模拟,探讨了南京市夏季大气气溶胶新粒子生成的条件及其影响因子.结果表明,南京市夏季10～500nm气溶胶平均数浓度为1.7×104cm-3,与北美和欧洲的一些典型城市观测值相近;10～25 nm气溶胶粒子数浓度占总数浓度的比例为25%.观测期间共出现6次新粒子生成事件,通过分析发现比较稳定的风速风向、较强的太阳辐射有利于南京夏季新粒子的形成.南京夏季新粒子生成事件的相对湿度条件在50%～70%,通过后向轨迹模式模拟的结果发现偏东风或偏南风带来的海洋性洁净气团有利于新粒子的生成.南京夏季新粒子生成事件发生时,10～25 nm气溶胶数浓度与SO2的浓度呈正相关,与O3的浓度呈负相关,而与NO2的浓度相关性较差.     

Experimental study on the competing effect of ceramic pellets on premixed methane-air flame propagation in a duct

It is urgent to explore effective suppression methods for gas fires and explosions to ensure the safe utilizations of combustible gases in industrial processes. In this work, experiments are performed to study the effect of spherical ceramic pellets on premixed methane-air flame propagation in a closed duct. High-speed schlieren photography and pressure transducers are used to record the flame propagation and pressure transient, respectively. Behaviors of the flame propagating through a section of the duct filled with ceramic pellets in mixtures at different equivalence ratios are scrutinized. Three different diameters of pellets are considered in the experiments. The result shows that the flame can be quenched in the case with a smaller pellet diameter (3 mm) for a wide range of equivalence ratios from fuel-lean to fuel-rich mixture. For larger pellet diameter (5 or 10 mm), flame extinction occurs in fuel-rich mixtures (e.g. Φ = 1.1, 1.2). For the cases of flame surviving through the pellets bed, the pellets show a significant influence on the flame structure and behavior. The flame propagation depends on the porosity and the mean void diameter of the porous media in the pellets bed. Small void diameter is beneficial to flame quenching, while large porosity can accelerate the flame propagation. The pressure dynamics evolution is closely related to the interaction of flame with the pellets, and it depends on whether the flame quenches in the pellets bed. Overall, d = 3 mm ceramic pellets display the best suppression effect on flame propagation and pressure buildup in this study. The results of this study are of great significance to guide the safety design of spherical suppression materials in engineering applications for process safety researchers and engineers.