Lower flammability limits of flammable ternary organic mixtures: Synergistic behavior

Organic flammable liquids and their mixtures, which possess high risk of combustion and explosion, are widely used as raw materials and solvents in chemical and pharmaceutical industries. Lower flammability limits (LFL) is one of the most important parameters to characterize the combustion and explosion hazards of combustible gases and liquid vapors. The LFL of various ternary organic mixtures consist of ketone (acetone and butanone), ester (ethyl acetate) and alcohol (ethanol and isopropanol) were tested at 25 °C and atmospheric pressure. The results showed that resulted LFL values of the experiment were always lower than those calculated by volume fraction weighting method when the volume fraction of alcohol was less than 20 vol% but more than 10 vol%. The co-existence of alcohol and ethyl acetate had synergistic effect on reducing the LFL values of ternary organic mixtures and thus increased their explosive risk. The mechanism of synergistic effect was analyzed, and the results showed that the OH· and H· radicals produced by the oxidation decomposition of alcohols and esters accelerated the oxidation process of ternary organic mixtures, which led to the decrease of experimental LFL values and thus corresponding increased of their explosive risk. This study would be expected to provide some guidance for designing or choosing safer and more suitable ternary organic mixtures prior to their applications for engineering.     

混合气体直接吸附分离回收过程研究

以精密陶瓷制造过程中排放的甲苯和异丙醇混合气体为目标气体,采用4段活性炭吸附柱串联吸附实验方式研究了混合组分气体直接吸附分离回收的可行性.结果表明,异丙醇和甲苯这2种物性具有一定差异的物质在吸附床的长度方向存在明显的分层吸附现象.在表观气速0.42 m·s-1、异丙醇与甲苯入口浓度分别为477 mg·m-3和746 mg·m-3、吸附柱总长为26cm条件下,通气吸附798 min时,0～10 cm长度段炭层吸附甲苯量为184.5 mg·g-1,吸附异丙醇量为0 mg·g-1,而21～26 cm长度段炭层吸附甲苯量为0.92 mg·g-1,吸附异丙醇量为91.2 mg·g-1,通过分段再生回收分别得到了纯度99%以上的甲苯和异丙醇回收液.弱吸附质异丙醇在吸附过程中存在气相浓度增浓现象,该现象导致实验条件下部分活性炭层区域对异丙醇的吸附量提高了27%以上.通过多段串联吸附、分段再生回收的方式可以实现混合气体的直接吸附分离回收.     

Minimum ignition energy of LDPE dust/ethylene hybrid mixture

An experimental device for evaluating the minimum ignition energy (MIE) of LDPE dust/ethylene hybrid mixture was built with the innovative mixing mode. The MIE of the hybrid mixture that contained ethylene below its lower explosive limit (LEL) was studied. The result indicated that adding a small amount of ethylene significantly reduced the MIE of the original dust cloud. All the MIEs with five different particle sizes were found to show similar trends of exponential attenuation with the increase of ethylene concentration; such attenuating effect grew as the dust particle size rose. When ethylene concentration increased and approached to its LEL, the reaction mechanism dominated by combustible dust turned into one dominated by combustible gas. The MIE decreased first and then increased with the dust mass and increased with the dust particle size. A multifactor mathematical correlation model of the MIE with the dust particle size and ethylene concentration was developed.     

基于光谱混合分析和反照率-植被盖度特征空间的土地荒漠化遥感评价

采用线性光谱混合分析模型对Landsat TM遥感影像进行混合像元分解,获取植被、裸土和水体组分的相对丰度分布;在反演地表反照率的基础上,构建了基于Albedo-Vegetation特征空间的土地荒漠化遥感监测模型;以黑河中游部分区域为例,进行了实证研究,并利用实地调查数据进行精度验证。结果表明:此方法充分利用了多维遥感信息,反映了荒漠化土地地表覆盖、水热组合及其变化,具有明确的生物物理意义,而且指标简单、易于获取,精度较高,有利于荒漠化的定量分析与监测。     

火焰原子吸收法测定苹果中波尔多液的农药残留

通过原子吸收法测定苹果果皮、果肉上波尔多液的农药残留铜的含量,结果表明:喷洒了波尔多液的苹果果皮上铜含量明显大于果肉,在果皮上有一定的农药残留;而未喷洒波尔多液的苹果果皮和果肉中铜的含量的差异很小。     

Dynamic pressure induced by a methane–air explosion in a coal mine

The hazardous effect of dynamic pressure and strong gas flows induced by a methane–air mixture explosion in underground coal mines is studied. The dynamic pressure effect of a methane–air explosion was analyzed by numerical simulation, in a duct and tunnel. Compared to the overpressure generated by an explosion that can act on a body, the dynamic pressure caused by the high-speed flow of the gaseous combustion products can cause serious damage as well. At the structural opening of a coal mine, the destruction caused by the dynamic pressure induced by a methane–air explosion is more serious than the overpressure. For a tube or tunnel partially filled by a methane–air mixture, the dynamic pressure is lower than the overpressure in the region occupied by the flammable mixture. Beyond the premixed region, the dynamic pressure is of the same order of magnitude as the overpressure.     

高岭石、针铁矿及其二元体对胡敏酸的吸附特性

研究了高岭石、针铁矿及其混合物(KGM)和复合物(KGC)的表面性质及吸附胡敏酸的特性.结果表明,4种物质的比表面积(SSA)表现为针铁矿KGCKGM高岭石,KGM的SSA接近两种纯物质的平均值,而KGC的SSA明显升高.高岭石、针铁矿、KGM和KGC的等电点(IEP)分别为3.2、7.9、6.1和6.7;初始p H=5.0时,其表面Zeta电位分别为-13.9、38.2、14.3和19.7 m V.4种样品对胡敏酸的动力学吸附过程适合用准二级动力学模型描述,表明化学吸附是主要作用机制.一、二位Langmuir模型可较好地拟合等温吸附数据(R~2为0.962~0.993),其中二位Langmuir模型对KGM和KGC吸附数据的拟合度R~2分别为0.989和0.993;Freundlich模型对等温吸附数据的拟合度较低,但两种二元体的拟合度高于两种纯物质.初始p H=5.0时,高岭石、针铁矿、KGM和KGC对胡敏酸的吸附容量(q_(max))分别为6.02、61.83、35.13和42.10 mg·g~(-1);两种二元体的q_(max)都高于两种纯物质q_(max)的平均值,其中KGC的q_(max)明显升高.热力学参数表明,4种样品对胡敏酸的吸附均属于吸热反应,其中高岭石的吸附为非自发过程,其余样品的吸附为自发过程.     

Flame regime estimations of gasoline explosion in a tube

Flame regime of gasoline-air mixture explosion is related to chemical reaction, turbulent flow and heat and mass transfer. Experimental data of gas velocity, pressure and flame temperature of gasoline-air mixture explosion in a tube at the equivalence ratio of 0.72, 1.00 and 1.28 were preliminarily acquired. Then, fluctuating velocities, overpressures, and burned and unburned gas temperatures at early stage (50 ms), intermediate stage (150 ms) and last stage (250 ms) in three explosions were determined through the analysis of the experimental data. Finally, the Damköhler number and Reynolds number of the early, intermediate and late stage were calculated respectively, and the flame regimes for each stage were estimated through the Damköhler number vs. Reynolds number diagram. Results show that all the flames at early, intermediate and late stage of the three explosions have the same regime of flamelets-in-eddies. The conclusions can provide some useful references for further study of the flame regime and the numerical analysis model selection of gasoline-air mixture explosion.     

Oxidative stress and biochemical perturbations induced by insecticides mixture in rat testes

The joint action of pyrethroids, lambda-cyhalothrin (LC) in combination with organophosphates, fenitrothione (FNT) on antioxidant defense system and lipid peroxidation biomarkers in rat testes was studied. The results suggest that incubation of testes homogenate with different concentrations of insecticide mixture for different time intervals significantly decreased the activity of antioxidant enzymes, like glutathione S-transferase (GST), superoxide dismutase (SOD) and catalase (CAT), and the level of reduced glutathione (GSH). In addition, a significant inhibition in transaminases (AST, ALT), phosphatases (AcP, AlP) activity and protein content were observed. On the other hand, FNT plus LC increased the cellular lipid peroxidation (LPO) level and the activity of lactate dehydrogenase (LDH). In conclusion, the use of insecticides mixture might cause marked oxidative damage in a concentration and time-dependent manner.     

Evaluation of protective effects of sulforaphane on DNA damage caused by exposure to low levels of pesticide mixture using comet assay

The objective of the study was to evaluate the potential risk of DNA damage due to exposure to a mixture of the most widely used pesticides, namely endosulfan, chlorpyriphos and thiram at an environmentally relevant concentration (5 μM each) and the DNA protective capacity of sulforaphane (SFN) (10–30 μg/mL). DNA damage in human lymphocytes was ascertained with Single Cell Gel Electrophoresis (SCGE), also called Comet Assay. For positive control, H₂O₂ at 100 mM was used. The pesticide mixture produced DNA damage at the concentration used in the lymphocytes. SFN was able to offer a statistically significant (P < 0.01), concentration-dependant protection to DNA damage between 10–20 μg/mL in both the pre-incubation and co-incubation strategies. The results indicate that exposure to low levels of these pesticide mixtures can induce DNA damage, and the presence of SFN in diet may reduce the incidence of genetic damage, especially in farm workers. However, it is not clear whether SFN is involved in quenching of the free radicals generated by the pesticide mixture or it is involved in DNA repair mechanism.