蚯蚓-稻壳炭联合堆肥对工业污泥中重金属的影响研究

蚯蚓堆肥相关研究多集中在生活污泥方面,对工业污泥的探索较少。该研究以马鞍山某钢铁污水处理站污泥为例,添加不同比例稻壳炭(2%、4%、8%),设置污泥单独堆肥、稻壳炭与污泥堆肥以及蚯蚓-稻壳炭联合污泥堆肥试验,探索蚯蚓与稻壳炭联合堆肥对工业污泥中重金属形态和生物有效性的影响。研究表明,(1)相比污泥单独堆肥,稻壳炭联合污泥堆肥能增加污泥pH、EC、TP和降低TOC、TN,而蚯蚓联合稻壳炭堆肥污泥可增加TN,并进一步增加污泥EC、TP,显著降低污泥的pH、TOC。(2)稻壳炭堆肥中重金属Zn、Cu、Pb、Cd含量因浓缩效应而上升;而蚯蚓联合稻壳炭堆肥,重金属含量显著下降,添加4%稻壳炭时,重金属Zn、Cu、Pb、Cd质量分数达到最小值,分别为856.64、137.10、158.92、15.48mg·kg-1。(3)重金属形态分析表明,随着稻壳炭比例增加,稻壳炭堆肥中重金属Zn、Cu、Pb、Cd的交换态和碳酸盐结合态转化为残渣态及铁锰氧化态的比例增大,添加8%稻壳炭时DTPA提取的有效态重金属质量分数最低,分别为705.72、47.95、50.43、4.47 mg·kg-1;蚯蚓-稻壳炭联合堆肥会使得污泥中重金属交换态、碳酸盐结合态、铁锰结合态和有机结合态均向残渣态转化,添加4%稻壳炭与蚯蚓的协同转化能力最大,Zn、Cu、Pb、Cd有效态重金属质量分数分别为629.84、38.63、36.76、1.63mg·kg-1,说明稻壳炭添加入蚯蚓堆肥可进一步降低工业污泥中重金属有效性,使重金属钝化。本研究可为稻壳炭联合蚯蚓堆肥处理工业污泥提供参考和科学依据。     

Identification of rice cultivars with low brown rice mixed cadmium and lead contents and their interactions with the micronutrients iron, zinc, nickel and manganese

Paddy fields in mining areas are usually co-contaminated by a cocktail of mixed toxic heavy metals (e.g., Cd and Pb in Pb/Zn mines). However, previous studies on rice cultivars screened for effective metal exclusion have mostly focused on individual metals, and have been conducted under pot-trial or hydroponic solution conditions. This study identified rice cultivars with both low Cd and Pb accumulation under Cd-and Pb-contaminated field conditions, and the interactions of the toxic elements Cd and Pb with the micronutrient elements Fe, Zn, Mn and Ni were also studied. Among 32 rice cultivars tested, there were significant differences in Cd (0.06-0.59 mg/kg) and Pb (0.25-3.15 mg/kg) levels in their brown rice, and similar results were also found for the micronutrient elements. Significant decreases in concentrations of Fe and Mn were detected with increasing Cd concentrations and a significant elevation in Fe, Mn and Ni with increasing Pb concentrations. A similar result was also shown by Cd and Ni. Three cultivars were identified with a combination of low brown rice Cd and Pb, high micronutrient and grain yield (Wufengyou 2168, Tianyou 196 and Guinongzhan). Present results suggest that it is possible to breed rice cultivars with low mixed toxic element (Cd, Pb) and high micronutrient contents along with high grain yields, thus ensuring food safety and quality.     

水稻重金属生态毒性诊断研究进展

从植物生态毒理学的角度,结合国内外研究成果,阐述了单一重金属和复合重金属在水稻中的生态毒性诊断研究进展,提出今后可以考虑追踪重金属在水稻中的运动规律,探讨复合污染对水稻的生态毒性.     

微波诱导热解制备小麦秸秆吸附剂及响应面优化工艺研究

以氯化锌为活化剂,通过微波诱导热解法制备小麦秸秆吸附剂,并以微波功率、热解时间和氯化锌质量分数为影响因素,碘吸附值为响应值,采用响应面法对小麦秸秆吸附剂的制备工艺进行优化。结果表明,热解时间和微波功率对碘吸附值的交互作用明显。响应面优化工艺分析,发现当热解时间4.03 min、微波功率569.0 W,氯化锌质量分数为31.24%时,碘吸附值最大,为643.33 mg/g。另外,小麦秸秆吸附等温线与I型相似,吸附剂的微孔容积为0.238 4cm³/g,吸附剂的BJH孔径分布表现窄小,最高峰出现在2.1nm左右。处理Cr(VI)废水的吸附试验,发现Cr(VI)的去除率可以达到70%以上。研究表明,微波诱导热解法及响应面优化工艺制备的小麦秸秆吸附剂技术可行且具有良好的重金属废水处理应用前景。     

湖南市场和污染区稻米中As、Pb、Cd污染及其健康风险评价

为了更好地了解和评价湖南大米中As、Pb和Cd含量及其对人体的健康影响,在对湖南矿区和冶炼区水稻土壤重金属污染调查的基础上,分别以湖南各地市场大米和污染区当地生产的稻谷样品为例,对其进行重金属含量分析及对人体的健康风险评价.结果表明,湖南各地市场大米样品中As、Pb和Cd的平均含量分别是0.20、0.20和0.28mg·kg-1,其中,衡阳市场大米中的As、Pb和Cd含量最高,其次是株洲和湘潭市场的大米.污染区稻谷中As、Pb和Cd含量分布均为:谷壳糙米精米,污染区精米中As、Pb和Cd的含量分别是0.24、0.21和0.65mg·kg-1,其中,来自衡阳常宁市水口山铅/锌矿区的稻谷样品中的As、Pb和Cd含量最高,其次是株洲清水塘冶炼区和湘潭锰矿区的稻谷.与市场大米样品相比,污染区精米中As、Pb和Cd的平均含量比市场大米样品高.无论是市场大米样品,还是从污染区稻田采集的稻米,均以衡阳地区稻米中的As、Pb和Cd污染最为严重,其次为株洲和湘潭地区.在As、Pb和Cd的健康风险评价中,Cd是湖南各地稻米中影响人体健康的主要因子,株洲和湘潭的Cd污染区达到90%以上,其次是As和Pb.     

不同土壤耕作方式下秸秆还田量对晚稻土壤养分与微生物的影响

在耕翻、少耕和免耕条件下研究了早稻秸秆还田量对晚稻土壤养分与微生物的影响,结果表明,①秸秆还田显著提高土壤有效磷和速效钾含量,对土壤碱解氮含量的提高体现在水稻生育后期;秸秆还田对土壤碱解氮和有效磷含量的提高效果在免耕条件下最好,而对速效钾含量的提高效果在少耕条件下最好;②不同耕作方式下宜实行不同秸秆还田量,就提高有效磷和速效钾含量而言,耕翻和少耕条件下宜实行全部秸秆还田,而免耕条件下宜实行2/3秸秆还田;③秸秆还田使土壤真菌和嫌气性细菌数量减少,放线菌和好气性细菌数量增加;耕翻使土壤真菌和嫌气性细菌数量减少,好气性细菌数量增加;④土壤耕作有利于晚稻生育前期与后期土壤微生物活度的提高,秸秆还田量对土壤微生物活度的影响在不同耕作方式下表现不同,耕翻条件下以2/3还田量处理的土壤微生物活度最高,而少免耕条件下1/3还田量处理最高.     

Enhanced and irreversible sorption of pesticide pyrimethanil by soil amended with biochars

Biochar derived from partial combustion of vegetation is ubiquitous and potentially effective in sequestration of environmental contaminants.Biochars were prepared by burning of red gum(Eucalyptus spp.) woodchips at 450 and 850°C(labeled as BC450 and BC850).These two biochars were found to possess markedly different properties in terms of surface area and porosity.Short-term equilibration tests(24 hr) were conducted to assess the sorption-desorption behavior of pyrimethanil in the soil amended with various amounts of biochar of each type,with a special focus on the desorption behavior of the sorbed pesticide through four times successive desorption by dilution.Sorption coefficient and isotherm nonlinearity of the amended soils progressively increased with the content of biochar in the soil.Biochar BC850 with higher surface area and microporosity showed a stronger effect on the reversibility of sorption pesticide.The soils amended with 5% BC450 and 1% BC850 had nearly the same sorption capacity for pyrimethanil;however,their desorption processes were very different with 13.65% and 1.49% of the sorbed pesticide being released,respectively.This study suggested that biochar in soil could be an important factor for immobilization of a pesticide and thus affecting its environment fate in soil.     

Effect of chemical and thermal activations on the properties of rice husk ash-based solidified wastes

Strength development,leachability and microstructure of heavy metals from the solidified waste using synthesis rice husk ash (sRHA) and lime blended at the weight ratio of 1:1 were used as binders.The heavy metal-containing sludge was used at the level of 0 wt.%,30 wt.%,and 50 wt.% dry weight,respectively.The sample specimens with and without 1.5 wt.% of sodium silicate (SiO 2 /Na 2 O=1.0) were cured under the ambient condition and elevated temperature curing at 50°C for 24 hr.Experimental results showed that the introduction of sodium silicate solution and elevated temperature curing to sRHA-based solidified waste containing 30 wt.% of heavy metal sludge gave one day strength of 20 kg/cm 2 compared to 0.9 kg/cm2 for the control sample.XRD patterns indicated that most metal-sulfides present in the sludge were appeared in the solidified waste and SEM coupled with EDX techniques reveal these metal-sulfide particles were trapped within the lime-sRHA matrices.In addition,cumulative leaching behavior by tank test (EA NEN 7375:2004) showed that solidified waste containing up to 30 wt.% of heavy metal sludge was suitable to dispose in a secured landfill.     

Variations between rice cultivars in iron and manganese plaque on roots and the relation with plant cadmium uptake

To understand certain mechanisms causing variations between rice cultivars with regard to cadmium uptake and tolerance, pot soil experiments were conducted with two rice cultivars of di erent genotypes under di erent soil Cd levels. The relationships between plant Cd uptake and iron/manganese (Fe/Mn) plaque formation on roots were investigated. The results showed that rice cultivars di ered markedly in Cd uptake and tolerance. Under soil Cd treatments, Cd concentrations and accumulations in the cultivar Shanyou 63 (the genotype indica) were significantly higher than those in the cultivar Wuyunjing 7 (the genotype japonica) (P < 0.01, or P < 0.05), and Shanyou 63 was more sensitive to Cd toxicity than Wuyunjing 7. The di erences between the rice cultivars were the largest at relatively low soil Cd level (i.e., 10 mg/kg). Fe concentrations in dithionite-citrate-bicarbonate root extracts of Shanyou 63 were generally lower than that of Wuyunjing 7, and the di erence was the most significant under the treatment of 10 mg Cd/kg soil. The results indicated that the formation of iron plaque on rice roots could act as a barrier to soil Cd toxicity, and may be a “bu er” or a “reservoir” which could reduce Cd uptake into rice roots. And the plaque may contribute, to some extent, to the genotypic di erences of rice cultivars in Cd uptake and tolerance.     

一组小麦秸秆好氧分解菌系的构建及组成多样性

采用"外淘汰法"在常温、好氧条件下构建了一组稳定、有效降解小麦秸秆的复合系.复合系分解能力的研究表明,在100mL改良CMC培养基(液面深度2 cm和直径9 cm)中,分解的前6 d复合系保持较高分解能力,减重率达到66.1%,6 d后复合系分解能力逐渐减弱,到第10 d时减重率达到77.0%.1.86 g秸秆各成分中,纤维素分解0.78 g,半纤维素分解0.16 g,木质素分解0.24 g.复合系组成多样性的研究表明,通过克隆文库构建和单菌株分离共确定出13个菌属的微生物,优势菌属有Hydrogenophaga、Pseudomonas、Bacteroides和Clostridium,占100个阳性克隆子的78%.系统发育关系表明,克隆文库和单菌分离技术分别所确定的微生物种类及亲缘关系存在一定的差异;Isolated 7(FJ439527)和Clone 86(EU834839)与假单胞菌属中的厦门藻(Pseudomonas xiamenensis)亲缘关系较近.