三维电极电Fenton氧化法处理染料废水

采用三维电极电Fenton氧化法处理实际染料废水,探究了染料废水处理效果的影响因素。实验结果表明：以钌铱镀层钛电极为阳极、不锈钢板为阴极、粉末活性炭为颗粒电极,在粉末活性炭投加量为2.0 g/L、电流密度为0.5 mA/mm²、极板间距为3 cm、pH为2.0、硫酸亚铁投加量为0.50 g/L的最优工艺条件下,反应2 h后COD、TOC、氨氮、色度的去除率达到最大,分别为62.80%、41.15%、42.48%和95.00%;粉末活性炭作为颗粒电极可使染料废水COD去除率提高18个百分点;重复使用10次的处理效果与第2次基本持平。     

官厅水库底泥对染料的吸附特征研究

采用静态吸附法研究了北京官厅水库底泥对亚甲基蓝、孔雀石绿和刚果红3种染料化合物的吸附行为,探讨了pH值、离子强度、温度等因素对吸附的影响,测定了染料的吸附等温线.结果表明,3种染料的吸附等温线都很好地符合Freundlich方程,底泥对孔雀石绿的吸附量最大.吸附染料过程是在分形表面上发生的反应.不同染料吸附时计算出的分形维数不同,底泥的表面分形维数均处于2～3之间.pH值是影响吸附的主要因素,刚果红和亚甲基蓝受离子强度影响较大.吸附动力学研究表明,吸附分为快速吸附和慢速吸附两个阶段.     

Catalytic bubble-free hydrogenation reduction of azo dye by porous membranes loaded with palladium nanoparticles

Catalytic bubble-free hydrogenation reduction of azo dye by porous membranes loaded with palladium （Pd） nanoparticles was studied for the first time. The effects of Pd loading, dye concentration and reuse repetitions of membranes were investigated. In reduction, the dye concentration decreased whereas the pH rose gradually. An optimal Pd loading was found. The catalytic membranes were able to be reused more than 3 times.     

Dyes adsorption using a synthetic carboxymethyl cellulose-acrylic acid adsorbent

Removal of noxious dyes is gaining public and technological attention. Herein grafting polymerization was employed to produce a novel adsorbent using acrylic acid and carboxymethyl cellulose for dye removal. Scanning electron microscopy and Fourier-transform infrared spectroscopy verified the adsorbent formed under optimized reaction conditions. The removal ratio of adsorbent to Methyl Orange, Disperse Blue 2BLN and malachite green chloride reached to 84.2%, 79.6% and 99.9%, respectively. The greater agreement between the calculated and experimental results suggested that pseudo second-order kinetic model better represents the kinetic adsorption data. Equilibrium adsorptions of dyes were better explained by the Temkin isotherm. The results implied that this new cellulose-based absorbent had the universaiity for removal of dyes through the chemical adsorption mechanism.     

Evaluating the effectiveness of marine actinobacterial extract and its mediated titanium dioxide nanoparticles in the degradation of azo dyes

Aim of the present study was to synthesize titanium dioxide nanoparticles （YiO2 NPs） from marine actinobacteria and to develop an eco-friendly azo-dye degradation method. A total of five actinobacterial isolates were isolated from Chennai marine sediments, Tamilnadu, India and analyzed for the synthesis of TiO2 NPs using titanium hydroxide. Among these, the isolate PSV 3 showed positive results for the synthesis of TiO2 NPs, which was confirmed by UV analysis. Further characterization of the synthesized TiO2 NPs was done using XRD, AFM and FI＇-IR analysis. Actinobacterial crude extract and synthesized TiO2 NPs was found efficient in degrading azo dye such as Acid Red 79 （AR-79） and Acid Red 80 （AR-80）. Degradation percentage was found to be 81% for AR-79, 83% for AR-80 using actinobacterial crude extract and 84% for AR-79, 85% for AR-80 using TiO2 NPs. Immobilized actinobacterial ceils showed 88% for AR-79 and 81% for AR- 80, dye degrading capacity. Degraded components were characterized by FT-IR and GC-MS analysis. The phytotoxicity test with 500 μg/mL of untreated dye showed remarkable phenotypic as well as cellular damage to Tagetes erecta plant. Comparatively no such damage was observed on plants by degraded dye components. In biotoxicity assay, treated dyes showed less toxic effect as compared to the untreated dyes.     

孔雀石绿高效脱色菌株的筛选、鉴定与脱色特性研究

孔雀石绿应用广泛,但难以降解且对许多生物都具有致癌致畸性.从浙江温州皮革厂污泥中分离筛选到1株孔雀石绿高效脱色菌株DH-9,16S rRNA基因序列分析表明,该菌株属于Enterabacter sp.属.单因素实验结果表明:当pH值在3.0~9.0时,培养24 h以后,该菌株对孔雀石绿的脱色率均在90%以上;脱色的最适温度范围为30~40℃;多数所测试碳源对脱色没有显著影响,而多数所测试氮源则对脱色有显著的促进作用;所测金属离子中,仅Cu2+和Fe3+对脱色有显著的抑制效应;此外,当接种量达到3%(V∶V,菌体干重约0.23 g·L-1)以后,12 h的脱色率即可达到90%以上.响应面设计实验结果显示,菌株DH-9对孔雀石绿脱色的最优操作条件为:pH 6.0、1.0 g·L-1的半乳糖、1.0 g·L-1的酵母粉、3.0 mmol·L-1的氯化钙以及培养温度为34.5℃.验证实验结果表明:在最优条件下,该菌株在8 h内对孔雀石绿的脱色率可达99.4%.总体而言,菌株DH-9在孔雀石绿脱色中的实际应用潜能较大.     

Aureobasidium pullulans UVMU3-1产耐热性胞外漆酶活性物质培养基优化及其对染料脱色作用

对出芽短梗霉无色素突变株Aureobasidium pullulans UVMU3-1产耐热性胞外漆酶活性物质培养基进行优化,并研究其分子量大小、热稳定性及对三苯甲烷类染料孔雀石绿和结晶紫的脱色作用.结果表明:蔗糖、NaNO_3为UVMU3-1产耐热性胞外漆酶活性物质的最佳碳源和氮源,产酶优化培养基配方为:蔗糖66.5 g·L~(-1),NaNO_338.4 g·L~(-1),NaCl 1.08 g·L~(-1),酵母浸粉0.2 g·L~(-1),KH_2PO_41 g·L~(-1),pH=6.0.影响UVMU3-1产耐热性胞外漆酶活性物质的因素依次为:起始pH蔗糖NaClNaNO_3,培养7 d时产生最大酶活(94.81 U·L~(-1)),比对照提高3.85倍.其分子量小于1000 D,具有良好的热稳定性,煮沸30 min后高温酶活仍残留72.50%.粗酶液(7.5 U·L~(-1))与三苯甲烷类代表性染料孔雀石绿和结晶紫75℃反应5 min后,脱色率分别为76.3%、77.5%,反应35 min后脱色率分别达到96.3%、95.3%.     

生物活性炭法深度处理印染废水及其生物毒性的表征

采用负载经驯化后微生物的活性炭深度处理实际印染废水,研究生物活性炭系统中存在的生物相及其降解有机污染物的作用,并表征了处理后印染废水的生物毒性.结果表明,生物相中含有草履虫、轮虫及钟虫等原生动物.随着运行次数的增加,活性炭反应器在运行5次后出水的COD、NH3-N及色度去除率骤降,但是生物活性炭处理后出水的COD、NH3-N及色度去除率缓慢下降.生物活性炭能很好地降解印染废水中的苯酚类和稠环芳烃污染物.本研究中生物活性炭反应器对氨氮和COD的去除符合一级动力学方程,去除动力学常数分别为1.02和0.96.经过生物活性炭的处理可以将印染废水的生物毒性降到适于小球藻生长的水平.     

A study on genotoxicity of textile dyeing industry effluents from Rajshahi,Bangladesh, by the Allium cepa test

Textile dye effluents are believed to be toxic as they might exert various harmful effects on living organisms including genotoxicity. These effluents are the main source of direct and continuous input of pollutants into the aquatic ecosystems. In this study, dye effluents from a local silk dyeing industry were analysed for their genotoxic potential by the Allium cepa genotoxicity test. The A. cepa test is characterised as a genotoxicity test where the roots of A. cepa are grown in different concentrations of the test material. The macroscopic results clearly showed that the toxicity of the dye effluents prompted A. cepa root growth inhibition, and this effect increased with higher concentrations of the effluents. At the cellular level, no dividing cells were found at higher concentrations such as 60%, 80% and 100% of the effluents. However, at a lower concentration of 20%, dividing cells were identified, although the mitotic index was much lower than that of the control. Microscopic analysis showed that the dye effluents induced chromosomal aberrations at significant levels. Taken together, these results revealed that the textile dyeing industry effluents are toxic to eukaryotic cells and these dyes have genotoxic properties that can potentially lead to cancer development and adverse health conditions.     

高压脉冲放电等离子体处理活性红X-3B染料废水

采用高压脉冲放电等离子体技术对活性红X-3B染料废水进行处理,考察了废水电导率、脉冲电压、脉冲频率、针板间距以及曝气量对处理效果的影响。实验结果表明,当废水电导率为200μS/cm、脉冲电压为34kV、脉冲频率为60Hz、针板间距为15mm、曝气量为12L/h、处理时间为60m in时,活性红X-3B染料废水脱色率能达到98.6%。