螺旋式旋流器的切向速度分析

借助CFD软件,采用RSM模型对螺旋式旋流器内的切向速度场进行了数值模拟。模拟结果表明:旋流器内部的流场分为螺旋通道内的准自由涡和内筒区域的准强制涡;在柱锥交界区域的内筒外壁附近有一低速区,易导致颗粒富集而出现高浓度区进而影响分离效率;此外通过改变入口速度和螺旋通道的螺距,研究对旋流器切向速度的影响。通过对流场特性的研究,为进一步充分认识此类旋流器的分离机理提供了依据。     

气浮旋流一体化油水分离器结构选型模拟研究

采用FLUENT模拟技术,应用可靠的物理模型、划分结构化网格,选用合理的模拟方法,对两种不同结构分离器单相流场和油气水三相分离效率开展了模拟研究,结果表明:两种结构分离器切向速度流场衰减速度均较慢,采用渐缩式内筒结构的"2"型分离器切向速度对称性、极大值均优于"1"型分离器;两种结构分离器均存在两组"零轴速包络面",不利于分离器收油操作,需设计特殊的收油装置、收油结构;两种结构分离器分离效率均随处理量、溶气水量、分流比以及溶气比的增加而增加,但"2"型分离器分离效率明显高于"1"型,"2"型分离器溶气水量、分流比最优值明显小于"1"型分离器。     

浓缩型入口下排气旋风分离器流场和性能的数值计算

运用CFD方法,对浓缩型入口下排气旋风分离器内的气固两相流动进行了研究。计算中气相采用RNGk-ε湍流模型,颗粒相采用拉格朗日坐标系下的离散相模型。重点计算了分离器流场、分离效率及其阻力特性,结果表明,采用浓缩入口后分离器内流场发生明显改变,分离器上部切向速度明显提高,有利于大颗粒的分离。同时通过对不同浓缩结构旋风分离器的分离效率和阻力特性进行分析比较,为工程设计提供了依据。     

旋风分离器内压力损失的计算

旋风分离器的压力损失包括入口损失，边壁摩擦损失，灰斗损失，本体内动压损失及出口损失五部分。本文在推导得出粘性流体切向速度计算公式的基础上，给出了各部分压力损失的计算方法，并使得总压力损失的计算结果与实验结果达到了很好的吻合。     

一、二次风配比对75t/h循环流化床的影响

本文利用FLUENT模拟软件对75t/h循环流化床进行数值模拟,研究了一、二次风配比(5∶5、5.5∶4.5和6∶4)对炉内温度场、速度场和CO2分布的影响,发现一、二次风配比为5.5∶4.5时,循环流化床运行较优,炉内温度场较均匀,且基本能达到规定运行温度,速度分布均匀,炉内烟气流速较高,出口烟气速度分别比1、3#工况要高33.42％和13.70％,炉内CO2分布较优,旋风分离器具有很高的工作效率.     

旋风分离器内流场的数值模拟及方法分析

基于交错网格的SIMPLE方法对切向入口旋风分离器内的流场进行了数值模拟 ,为了分析验证不同湍流模型的适用效果 ,分别选用了标准的k -ε模型、Smith修正的模型和Chen Kim修正的模型。通过对同一工况模拟结果与实验数据的比较 ,发现Smith修正的湍流模型更适合于预报像旋风分离器内这种具有返转流动的强旋流场     

Fluent在城区内流场及污染扩散模拟的适用性检验

基于榆中污染扩散实验翔实的观测资料,使用计算流体力学软件Fluent开展了城区内流场及污染物传输扩散的数值模拟研究,并将模拟值与外场实验观测值对比,以此检验Fluent软件的适用性。结果表明,Fluent能较好地模拟城区内流场,风场的模拟值能反应实际风场的变化趋势,风向平均绝对误差为32.18°,风速平均相对误差为35.63%;且模拟效果随风速的增大而逐步提高;城区建筑物对流场拖曳作用明显,街区分布对流场的影响较大;以SF6为示踪物,Fluent软件能模拟出与观测污染物扩散相似的形态,表明Fluent软件对污染物传输和扩散的较好模拟能力。该研究加深了对城区内流场复杂性的认识,并为了解城区内污染物传输扩散过程、做好空气污染事故灾害防治和救援以及事故后灾害评估等提供科学依据。     

二段往复炉排焚烧炉炉拱的优化辅助设计

为实现二段往复炉排焚烧炉炉拱的优化设计 ,运用PHOENICS软件进行炉内流场的模拟 ,研究炉拱形状和尺寸对流场的影响。通过模拟发现 ,后拱后移可以避免压火现象 ,保证炉膛空间良好的火焰充满度 ,但存在最佳后移尺度 ,以同时保证喉口位置烟气湍流效果强烈 ,充分发挥炉膛后拱和前拱的辐射及对流传热的效果。根据炉内气流湍动情况以及风速的范围 ,确定在原设计基础上将后拱后移 0 5m为最佳炉膛尺寸     

旋风分离器内滚场的数值模拟及方法分析

基于交错网格的SIMPLE方法对切向入口旋风分离器内的流场进行了数值模拟，为了分析验证不同湍流模型的适用效果，分别选用了标准的κ—ε模型、Smith修正的模型和Chen—Kim修正的模型。通过对同一工况模拟结果与实验数据的比较，发现Smith修正的湍流模型更适合干预报像旋风分离器内这种具有返转流动的强旋流场。     

带内锥的方形扩散式分离器壁面磨损的数值分析

运用数值模拟方法对带内锥的方形扩散式旋风分离器壁面关键部位的磨损情况进行了数值模拟。气固相研究分别采用雷诺应力模型和随机轨道模型。计算结果显示,分离器内磨损比较严重的部位主要有：分离器顶盖、圆筒段、方形扩散段下部、反射锥外壁面、反射锥内壁面下部、灰斗及灰斗上部方形段。最严重的是反射锥外壁面、灰斗及灰斗上部方形段等几个部位。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.