铬渣浸出毒性试验研究

铬渣给环境带来的危害一直困扰着铬盐行业的发展 ,其浸出毒性研究有利于对铬渣危害的监测评估、治理及综合利用。本试验对新渣和陈渣的浸出毒性进行了探讨 ,同时对铬渣中Cr(Ⅵ )进行全量溶取 ,并分析铬渣中主要阴、阳离子的浸出行为。从而提出适宜于评价铬渣浸出毒性的试验方法 ,即 :液固比 2 0∶1,浸取时间 8h、提取剂为HAC NaAC(pH5 0± 0 2 ) ,粒径为 12 0目的浸出体系     

湿法解毒还原工艺对铬渣中Cr(Ⅵ)的治理特性

以治理铬渣中的Cr(Ⅵ)污染为目的,提出了硫酸浸出-硫酸亚铁还原的铬渣湿法解毒工艺,在对铬渣处理前后的表面形貌进行表征的基础上,探究了不同处理条件下铬渣中Cr(Ⅵ)的处理效果及其修复机理。结果表明:铬渣湿法球磨时间为20 min时,铬渣颗粒98.68%过200目筛,水溶性Cr(Ⅵ)的浸出率可达40.96%;铬渣硫酸添加量为60%,液固比为4∶1,酸溶时间为2.5 h时,Cr(Ⅵ)浸出趋于饱和,此时浸出终点pH为5.8,水溶性和酸溶性Cr(Ⅵ)总浸出率为95.38%;硫酸亚铁添加量为40%时,铬渣中Cr(Ⅵ)含量下降为1.38 mg/kg。铬渣中Cr(Ⅵ)的去除主要与硫酸对含Cr(Ⅵ)矿物的溶解、SO₄2-和CrO₄2-的离子交换以及Fe(Ⅱ)对溶液中Cr(Ⅵ)的还原作用有关。     

高温自蔓延还原解毒固化铬渣技术研究

采用高温自蔓延技术处置铬渣,探讨了高温自蔓延技术还原解毒固化铬渣的机制。以铝粉和三氧化二铁作铝热剂,与铬渣充分混合,用镁条点燃引发自蔓延反应,最终得到铬渣固化体。实验结果表明:高温自蔓延技术能有效固化铬渣,铬渣的掺渣率高达44.94%。浸出实验结果表明:A组(铬渣原样)铬渣固化体总铬浸出浓度未检出;B组(铬渣原样+重铬酸钾)铬渣固化体总铬浸出浓度为0.117 76 mg/L,远远低于国标(GB 5085.3-2007)限值15 mg/L,六价铬浸出浓度未检出。XRD分析表明:铬渣还原解毒固化机制主要是六价铬在自蔓延反应中被还原为三价铬,再与其他金属化合物在高温熔融状态下生成含铬尖晶石,铬以离子键Cr—O的形式参与尖晶石的晶格形成。     

“Achromobacter sp. CH-1-Cr(Ⅵ)-H2O”体系Cr(Ⅵ)还原的电化学行为

采用循环伏安法探明了"Achromobacter sp.CH-1-Cr(Ⅵ)-水"体系的电化学行为.结果表明:循环伏安曲线上-0.62V(相对于SCE)的电流峰对应的反应为Cr(Ⅵ)还原成Cr(Ⅲ)的反应,在电势为-0.82V时Cr(Ⅲ)开始还原为零价铬.体系中的电极反应为不可逆过程,阳极扫描时Cr(Ⅲ)不会被重新氧化为Cr(Ⅵ).细菌的存在使Cr(Ⅵ)的还原更容易进行,其还原峰电势正移约0.2 V,细菌对体系中的电化学反应起了催化作用.随细菌量的增加,氢气的析出、六价铬还原为三价铬及三价铬进一步还原为零价铬的电势均发生了正移,过高的细菌量主要影响三价铬还原沉积为金属铬的过程.铬浓度对细菌还原Cr(Ⅵ)溶液的循环伏安曲线的影响不大.初始pH值为10是细菌还原Cr(Ⅵ)的最佳pH值.     

米糠在微波条件下解毒铬渣中六价铬的研究

铬渣中含有毒性较强的六价铬化合物,其严重污染环境。为探讨米糠解毒铬渣的可行性,以米糠作为解毒铬渣的材料,在微波条件下对铬渣中的六价铬进行解毒实验研究。利用正交实验对铬渣中六价铬的去除条件进行了优化。在此基础上,开展单因素实验进一步研究确定了铬渣中六价铬去除的最佳条件,并对解毒后的含铬米糠是否具有危险废物的浸出毒性进行了探讨。实验结果表明,当米糠与铬渣质量比为2.5:1,微波作用时间为5min,微波功率为900W时铬渣中六价铬的去除率最大,为72.2%,且解毒后米糠中六价铬的浸出较小,低于国家最高允许浓度标准。     

两段式还原铬渣中Cr(Ⅵ)的试验研究

比对了多种还原剂处理六价铬的解毒效果,确定了焦亚硫酸钠、硫酸亚铁两段式还原处理铬渣浸出液中六价铬和总铬的还原剂投加顺序和投加量。结果表明,该技术能使解毒后铬渣中Cr6+浓度达到0.17 mg/L,满足HJ/T 301—2007《铬渣污染治理环境保护技术规范(暂行)》解毒后铬渣六价铬≤0.5 mg/的要求,且具有较好的长期稳定性,解毒彻底,可为该技术的工程应用提供理论依据。     

铬渣浸溶Cr(Ⅵ)溶解释放规律研究-以锦州堆场铬渣为例

通过锦州地区铬渣样品静态浸溶实验,测定不同固液比、浸出时间、浸取剂pH及组成、振荡速度、铬渣粒度大小、温度等因素对铬渣中Cr(VI)溶解释放的影响,揭示铬渣中Cr(VI)析出、释放机理。结果显示,稀释作用在不同固液比浸出中起主导作用,随固液比的降低,Cr(VI)浸出浓度逐渐降低,但是Cr(VI)浸出总量却在增加;随着浸出时间的增大,浸出Cr(VI)浓度随之增大;铬渣浸出液碱性很高,在铬渣溶解释放过程中,随酸性增强Cr(VI)溶解量相应增大,体现强的酸中和能力;随着振荡速度增加,Cr(VI)溶解释放速度明显加快;粒径越小,铬酸盐的溶解释放速度越快,溶解作用越充分;铬渣的浸出为吸热反应过程,铬渣溶解度随温度升高而增大。铬渣中Cr(Vl)溶解释放速率服从菲克(Fick)扩散定律。研究结果为铬渣危害的评价、监测及铬渣污染有效防治提供参考。     

硫代硫酸钠、磷酸钠联合处理铬渣中的六价铬

以硫代硫酸钠为还原剂,将铬渣中的六价铬(Cr(VI))解毒转化为三价铬(Cr(III)),并加入磷酸盐作为稳定剂稳定解毒后的铬渣,考察不同反应时间和药剂用量对铬渣中Cr(VI)去除效果的影响.结果表明:硫代硫酸钠可以有效去除铬渣中的Cr(VI),当其与Cr(VI)的摩尔比为理论摩尔比的12倍、处理时间15d时铬渣中Cr(VI)的去除率达到最高(70%),继续增加还原剂用量或延长反应时间均不能有效提高Cr(VI)的去除率.随后加入磷酸钠作为稳定剂,当其物质的量为生成Cr(III)的4倍时,硫代硫酸钠与磷酸钠分步加入(两步法)比同时加入(一步法)处理铬渣的效果较好,处理效果最好时总铬浸出浓度为6.1mg/L,低于危险废物浸出鉴别的总铬标准(15mg/L),而且形成稳定的铬的化合物(CrPO4·6H2O).铬渣pH值变化、五态变化、XRD及XPS分析等结果表明,两步法的处理效果好于一步法.     

电炉渣铬浸出行为及资源化利用风险分析

不锈钢电炉渣含有剧毒的CaCrO4,铬的浸出行为研究,对电炉渣的处置及资源化利用过程中的风险评估具有十分重要的意义。对电炉渣中铬的浸出特征进行了分析,标准浸出程序结果表明,电炉渣Cr和Cr(Ⅵ)浸出量分别为4.68 mg/L和1.74 mg/L,高于HJ/T 301—2007规定的限值,不宜直接应用于建材领域;电炉渣铬浸出受浸提剂pH影响显著,Cr在中性环境下浸出量最少,酸性和碱性环境都有利于Cr的浸出;Cr(Ⅵ)的浸出量随pH值增大而增加。     

AOD不锈钢渣中铬的酸性淋溶特性

基于AOD渣中铬的短期淋溶特性,采用静态淋溶实验方法研究了酸性淋溶液的初始pH值和固液比对AOD渣中铬淋溶特性的影响规律。实验结果表明,初始pH值为3.0和2.0时淋溶液的pH、E和DO的变化规律与中性淋溶液相似,AOD渣中铬的淋溶均呈现快速淋溶和慢速淋溶两个阶段,其中淋溶液初始pH值降至2.0时更为显著的增加了AOD渣中铬淋溶毒性;当固液比由10∶100提高1.5倍、2倍和4倍时,初始pH值为3.0的淋溶液中铬的淋溶浓度没有成比例倍增,初始pH值为2.0时,96 h内AOD渣中铬淋溶浓度分别增加了47.3%、56.7%和75.6%。由此可见,降低酸性淋溶液的初始pH值、延长淋溶时间和增加固液比都使得淋溶液中Cr3+浓度增加,考虑到淋溶液中Cr3+的沉淀反应,采用中性淋溶液毒性测试标准可能会过低评价AOD渣中铬的淋溶毒性。     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.